2001 Toyota Tundra fuel system problems

FUEL/PROPULSION SYSTEM

THE FUEL TANK FELL OUT OF MY TRUCK DUE TO RUST ON THE STRAPS. I WAS TOLD THERE WAS ONCE A RECALL FOR THIS PROBLEM. I TOOK MY TRUCK TO MY LOCAL GARAGE TO GET IT FIXED BECAUSE IT WAS CLOSER. I HAD TIED THE FUEL TANK TO THE TRUCK TO GET THE TRUCK TO THE SHOP. I SUPPLIED TOYOTA WITH THE INFORMATION AND RECEIPTS. THEY ARE REFUSING TO REIMBURSE ME.

NHTSA complaint #10934093 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TOOK MY 2001 TUNDRA IN FOR THE FRAME RECALLS. I HAD 52616 MILES ON A GARAGE KEPT TRUCK. THEY SAID MY FRAME WOULD BE FINE AND WOULD HAVE A CRC COMPOUND APPLIED APR 2012. AFTER A FEW WEEKS I TOOK IT BACK IN SINCE THE COMPOUND WAS FALLING OFF, MAY 2012. THEY REAPPLIED THE CRC. I TOLD THEM I HAD CONCERNS OVER SPRAYING OVER RUST, BUT SAID THEY WERE SURE TOYOTA WOULD STAND BEHIND IT. FEB 2014 THE TECHNICIAN MADE A COMMENT ABOUT THE RUST AND LACK OF COMPOUND VISIBLE. FEB 2015 THE TECHNICIAN AGAIN SAID IT WAS CLEAR THAT THE CRC WAS ALMOST GONE. HE MADE A NOTE OF IT ON THE SERVICE REPORT. I ASKED THEM TO CONTACT THE CORP OFFICE ABOUT IT. A FEW WEEKS LATER THE DEALERSHIP SAID THAT CORP WOULDN'T SPRAY IT AGAIN, BUT THAT THE DEALERSHIP WOULD SPRAY IT. 27 JUNE 2015 DRIVING HOME FROM WORK ON INTERSTATE 41, THE FRONT STRAP HOLDING THE GAS TANK BROKE, MILEAGE 58325. I GOT THE TRUCK TO THE DEALERSHIP AND HAD NEW STRAPS INSTALLED. THE TECHNICIAN SAID THEY ACTUALLY HAD TO DRILL AND TAP AND MOUNT THE FRONT STRAP IN A DIFFERENT LOCATION DUE TO SEVERE ROTTING OF THE FRAME. AFTERWARDS I FOUND OUT THAT THE STRAPS SHOULD HAVE BEEN REPLACED DURING PHASE 2 OF SSC 90. I CALLED TOYOTA CORP CASE# 1507131315. THE FIRST CASE MANAGER GEORGE SAID RIGHT AWAY TOYOTA WOULD DO NOTHING FOR ME. THEN I TOOK MY TRUCK TO THE GAS STATION TO FILL IT UP FOR THE FIRST TIME. GAS STARTED POURING OUT ONTO THE GROUND. I BASICALLY CALLED EVERY DAY TILL I GOT JEFFERY MOORE AS MANAGER. HE GOT MY STRAPS AND TANKS REPLACED BUT SAID CORP WOULDN'T DO ANYTHING ABOUT THE FRAME. I SENT PICTURES AND EVERYTHING. NOW TOYOTA WILL NOT RESPOND TO ANY OF MY E-MAILS OR CALLS . MY FRAME HAS HOLES THAT I CAN PUT MY HAND THREW AND HAS ONLY 6000 MILES ON IT SINCE IT WAS SPRAYED. I'M AFRAID THAT THE GAS WILL BRAKE AWAY OR THE FRAME WILL SNAP AT ANY TIME. THE GOVT NEEDS TO MAKE THEM FIX THIS SAFETY ISSUE THAT WAS IN THE RECALL, NOT MASK IT.

NHTSA complaint #10760669 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TRUCK WAS PARKED IN THE DRIVE WHEN I NOTICED THAT A STRAP WAS DANGLING AND WHAT LOOKED TO BE THE TANK WAS HANGING A LITTLE LOW. AFTER CHECKING UNDER-NEATH THE TRUCK I FOUND THAT THE ONE OF THE STRAPS HAD BROKEN, RUSTED AT THE BOLT SITE AND WAS NO LONGER HOLDING THE TANK UP.

NHTSA complaint #10625841 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

THE VEHICLE WAS RECALLED FOR CORROSION ,FRAME .CROSS MEMBER AND GAS TANK STRAPS WERE REPLACED IN AUGUST 2012 03/16/2014 THE GAS TANK LEAKED APPROX. 15 GALLONS OF GAS IN MY ATTACHED GARAGE THE GAS TANK WAS PERFORATED IN THREE SPOT UNDERNEATH THE NEW TANK STRAPS THIS VEHICLE HAS 85000 MILES ON IT AND I BELIEVE THIS ISSUE COULD HAVE BEEN RESOLVED WITHOUT ENDANGERING PEOPLE IN THIS MANNER. ALSO NOW THE REAR DIFFERENTIAL HOUSING IS CORRODED SO BAD IT IS LEAKING GEAR OIL IN SEVERAL PLACES AND I AM AFRAID OF CATASTROPHIC FAILURE.

NHTSA complaint #10574515 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

I SENT IN MY TOYOTA TUNDRA FOR A SAFETY RECALL THE SSC 90-M RECALL AND THE DEALERSHIP DID NOTHING BUT SPRAY CRC OVER THE RUST WHEN I BROUGHT IT TO THERE ATTENTION THAT THE FUEL STRAPS WERE NOT CHANGED OR THE SPARE TIRE THAT HAS PREVIOUSLY DISLODGED FROM THE VEHICLE WAS STILL IN THE BED OF THE TRUCK THEY SAID IT IS NOT OUR PROBLEM . WHAT ACTION CAN I TAKE ON THIS?

NHTSA complaint #10455955 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE UNDERSIDE OF THE VEHICLE WAS COMPLETELY CORRODED. THE CONTACT ALSO MENTIONED THAT THE FUEL TANK WAS CORRODED AND AS A RESULT, THERE WAS A FUEL LEAK. IN ADDITION, THE REAR DIFFERENTIAL HOUSING WAS ALSO AFFECTED. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE DIFFERENTIAL HOUSING AND THE FUEL TANK IN ORDER TO REMEDY THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 98,000.

NHTSA complaint #10420986 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

I HAD A STRONG GASOLINE ODOR WHILE IN THE VEHICLE. I PUT THE TRUCK IN PARK, GOT OUT WHILE THE VEHICLE WAS RUNNING AND NOTICED A FUEL MIST AND FUEL STREAMING DOWN THE FUEL TANK TO THE GROUND. WHEN I SHUT OFF THE TRUCK, THE STREAM SLOWED TO A DRIP AND THEN STOPPED. FUEL HAD SPRAYED UNDER THE FRAME AND ONTO THE EXHAUST PIPE, LUCKILY IT DID NOT IGNITE. THIS OCCURRED WITHIN THE SAME DAY. TOYOTA FOUND THAT THE MAIN FUEL LINE COMING OUT OF THE FUEL TANK HAD FAILED WITH A PIN HOLE FORMING. P/N 77209-0C010 (TUBE SUB-ASSY, FUEL). IT IS A RUBBER FUEL LINE. TOYOTA DROPPED THE FUEL TANK IN ORDER TO CHANGE THE FUEL LINE. IT WAS NOT COVERED UNDER THE CORROSION RECALL SINCE IT WAS A RUBBER FUEL LINE. I FEEL THERE SHOULD BE A RECALL, IT COULD HAVE TURNED OUT TO BE A TOTAL LOSS OF THE VEHICLE AND POSSIBLE LIFE HAD THE FUEL STREAM IGNITED.

NHTSA complaint #10364977 — an unverified report by a vehicle owner.

FUEL SYSTEM, OTHER

I WAS ACCELERATING AT AROUND 20 MPH AND MY TRUCK (2001 TUNDRA V8) FELT AS IF THE FUEL CUT OUT. I LET OFF THE THROTTLE AND GOT BACK INTO IT AND THE TRUCK LEAPED FORWARD AS IF IT RECEIVED A SHOT OF GAS. IT ACCELERATED, BUT THE TRUCK WOULD STOP ACCELERATING INTERMITTENTLY AS I WAS GOING DOWN THE HIGHWAY. THE CEL CAME ON AS WELL.

NHTSA complaint #10330218 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

EXCESSIVE RUST PROBLEMS IMPACTED THE GAS TANK AND SECURING STRAPS UNDER MY 2001 TOYOTA TUNDRA. THE CORROSION CREATED SMALL PINHOLES IN THE TANKS, RESULTING IN GAS LEAKAGE AND REQUIRED THE TANK AND STRAPS TO BE REPLACED.

NHTSA complaint #10322332 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

GAS TANK HAD TO BE REPLACED DUE TO SEVERE CORROSION. THE TANK WAS LEAKING FUEL PRIOR TO REPLACEMENT. THE TOYOTA DEALER STATED THE ENTIRE UNDERCARRIAGE WAS EXTREMELY RUSTED.

NHTSA complaint #10289296 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY

CONSUMER LETTER COMPLAINT REGARDING THE AIR FUEL SENSOR ON THE 2001 TOYOTA TUNDRA.*MR THE MANUFACTURER DID NOT WARRANTY THE AIR FUEL SENSOR ON HIS V-6 ENGINE BUT THEY WARRANTED THE V-8 ENGINES UP TO 80000 MILES. THE CONSUMER HAS HAD TO REPLACE THE UPSTREAM AND DOWNSTREAM SENSORS AT HIS OWN EXPENSE. THE MANUFACTURER REFUSED TO REIMBURSE THE CONSUMER FOR THE REPAIRS.

NHTSA complaint #10125812 — an unverified report by a vehicle owner.

FUEL SYSTEM, OTHER:STORAGE

WHEN FUEL TANK IS FULL, AND VEHICLE RIDE ON AN UPWARD INCLINE PASSENGER'S COMPARTMENT FILLS UP WITH FUMES FROM GAS. THE PROBLEM COULD NOT BE DUPLICATED BY THE DEALER.

NHTSA complaint #877503 — an unverified report by a vehicle owner.