15 of the 231 complaints about the 2002 Volkswagen Beetle are about the lighting — 6% of everything reported for this model year. Half of the failures with a mileage on record happened before 46,500 miles.
15
Complaints
0
Crashes
0
Fires
0
Injuries
Filed with NHTSA, in their own words.
EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE. WHILE DRIVING VARIOUS SPEEDS AT NIGHT, THE HEADLIGHTS AND TAIL LIGHTS FAILED TO WORK INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 32,000.
NHTSA complaint #10658624 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
SERIOUS ELECTRICAL LONG TERM QUALITY ISSUES, STARTING WITH UNDER HOOD WIRING FOR GLOW PLUGS MELTED AWAY, AIR BAG/SEAT BELT WIRING BROKE/FAILED, SEAT HEATER FAILED, PASSENGER DOOR SWITCH FAILED, TURN SIGNAL BULB HOLDER FAILED, REPEATED HEAD LAMP AND TAIL LIGHT FAILURES, ALTERNATOR PULLEY CLUTCH FAILED(EXPLODED) FACTORY ALARM PROBLEMS - JUST SETS OFF, AIR BACK LIGHT ON DASH ON, SERVICE ENGINE LIGHT ON.
NHTSA complaint #10370670 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
2002 VOLKSWAGEN NEW BEETLE. CONSUMER WRITES REGARDING REPLACEMENT BRAKE LIGHT SWITCH *TGW THE CONSUMER STATED THE EPC LIGHT ILLUMINATED. THE CONSUMER TOOK THE VEHICLE TO THE DEALER AND THE PROBLEM WAS DIAGNOSED AS A FAILED BRAKE LIGHT SWITCH. THE CONSUMER STATED IT WAS THE SAME SWITCH THAT WA REPLACED UNDER RECALL.
NHTSA complaint #10368931 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
EACH TIME I SELECT THE TURN SIGNAL IT NOW BLINKS A COUPLE TIMES AND THEN STOPS WORKING. THE HAZARD LIGHTS WORK FINE.
NHTSA complaint #10239564 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
I OWN TWO OF THE VW NEW BEETLES. ONE IS 2002 AND THE OTHER IS 2003. BOTH OF THEM HAVE TROUBLE WITH THE TAILLIGHT/STOPLIGHT AND TURN SIGNALS NOT WORKING DUE TO A DEFECTIVE CONTACT DESIGN IN THE BULB SOCKET. IN ORDER TO FIX THE PROBLEM YOU HAVE TO TAKE THE ASSEMBLY OUT AND BEND THE CONTACT TO PUT MORE SPRING IN THEM WHICH PUTS MORE PRESSURE AGAINST THE BULB. THIS MAY FIX THE PROBLEM FOR A TIME ( 1 TO 60 DAYS) THEN THE PROBLEM REVERTS. ALL PARTS ARE OEM EQUIPMENT. I HAVE CONTACTED VW ABOUT THIS AND THERE IS NOT A RECALL. I WOULD THINK THAT TURN SIGNALS AND TAIL LIGHTS WOULD BE CONSIDERED A SAFETY ISSUE. I KNOW I AM NOT THE ONLY PERSON TO HAVE THIS PROBLEM. I AM CONCERNED ABOUT MY FAMILIES SAFETY AND DON'T UNDERSTAND WHY A MANDATORY RECALL HAS NOT BEEN ISSUED.
NHTSA complaint #10231630 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING:BRAKE LIGHTS
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN NEW BEETLE. WHEN THE VEHICLE IS TURNED ON THE AIR BAG INDICATOR LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE DEALER STATED THAT THE AIR BAG WAS DEACTIVATED AND THE SEAT BELT LATCH SYSTEM NEEDED TO BE REPAIRED IN ORDER FOR THE AIR BAG SYSTEM TO FUNCTION PROPERLY. THE CONTACT WOULD HAVE TO PAY FOR THE REPAIR BECAUSE AIR BAG WAS NOT COVERED UNDER WARRANTY. THE VEHICLE NEEDS TO BE REPAIRED. THE FAILURE MILEAGE WAS 51,000 AND CURRENT MILEAGE WAS 52,000. UPDATED 02/14/08. *LJ THE BRAKE LIGHT BULB AND RIGHT REAR TAIL LIGHT WAS INOPERATIVE. UPDATED.
NHTSA complaint #10216400 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING:TAIL LIGHTS
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN NEW BEETLE. WHEN THE VEHICLE IS TURNED ON THE AIR BAG INDICATOR LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE DEALER STATED THAT THE AIR BAG WAS DEACTIVATED AND THE SEAT BELT LATCH SYSTEM NEEDED TO BE REPAIRED IN ORDER FOR THE AIR BAG SYSTEM TO FUNCTION PROPERLY. THE CONTACT WOULD HAVE TO PAY FOR THE REPAIR BECAUSE AIR BAG WAS NOT COVERED UNDER WARRANTY. THE VEHICLE NEEDS TO BE REPAIRED. THE FAILURE MILEAGE WAS 51,000 AND CURRENT MILEAGE WAS 52,000. UPDATED 02/14/08. *LJ THE BRAKE LIGHT BULB AND RIGHT REAR TAIL LIGHT WAS INOPERATIVE. UPDATED.
NHTSA complaint #10216400 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING:TURN SIGNAL:FLASHER UNIT
I HAVE THE SAME PROBLEM WITH MY 2002 VW NEW BEETLE AS IN PE 04073: TURN SIGNAL/HAZARD FLASHER FAILURE: EXTERIOR LIGHTING:TURN SIGNAL:FLASHER UNIT. THE FLASHER DOES NOT WORK CONSISTENTLY: IT STARTS, THEN STOPS AFTER ONE OR TWO BLINKS. THE TIMING OF THE BLINKS ARE ALSO ERRATIC. MY MODEL NEEDS TO BE COVERED BY THIS RECALL.
NHTSA complaint #10214044 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
DT*: THE CONTACT STATED A NHTSA RECALL LETTER WAS RECEIVED INDICATING THE BRAKE SAFETY SWITCH NEEDED TO BE REPLACED AT THE NEAREST DEALERSHIP. THE VEHICLE HAD NOT PRESENTED ANY PROBLEMS WITH THE BRAKE LIGHT SWITCH YET. THE NEAREST DEALERSHIP WAS 130 MILES FROM THE LOCALITY. THE CONTACT ASKED THE MANUFACTURER FOR THE REPLACEMENT PART TO PERFORM THE REPAIR AT AN INDEPENDENT AUTHORIZED CERTIFIED MECHANIC OR OTHER TRUSTED DEALERSHIP. THE MANUFACTURER REFUSED THE PROPOSAL. THE CONTACT EXPRESSED CONCERN BECAUSE THE MANUFACTURER SHOULD BE FLEXIBLE IN CASES WERE NO DEALERSHIP WERE PRESENT IN THE AREA.
NHTSA complaint #10176066 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
I HAVE A 2002 VW BEETLE AND THE BRAKE LIGHTS DO NOT WORK BECAUSE THE BRAKE LIGHT SWITCH FAILED. I KNOW THEY HAVE RECALLED OTHER BEETLES FOR THIS BUT WHEN I CALLED VW THEY SAID IT WAS NOT RECALLED ON MY VEHICLE.
NHTSA complaint #10166972 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
DT*: THE CONTACT STATED THE VEHICLE WAS NOT ABLE TO BE TAKEN OUT OF PARK DURING FAILURE OF THE BRAKE LIGHT SWITCH. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE BRAKE LIGHT SWITCH WAS REPLACED 4 TIMES. THERE WAS A NHTSA RECALL # 06V183000 WHICH PERTAINED TO THE BRAKE LIGHT SWITCH. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
NHTSA complaint #10165010 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
TRANSMISSION REPLACED THREE TIMES, STILL NOT WORKING PROPERLY, LUNGES INTO FORWARD AND REVERSE, AND WILL DROP INTO AND OUT OF HIGH AND LOW GEAR WHEN DRIVING. SUNROOF LEAKED BECAUSE THE DRAINAGE TUBING WAS NOT CONNECTED AT FACTORY CAUSING WATER DAMAGE TO LEATHER SEATS AND NOW MOLD IS GROWING INSIDE OF VEHICLE, MAKING IT DIFFICULT TO BE INSIDE AND HAVE HAD ONE SINUS INFECTION ALREADY.
NHTSA complaint #10153996 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING:TURN SIGNAL
THE TURN SIGNALS TO NOT WORK. CONSUMER HAS TO REMOVE THE BULB AND REPLACE THEM TO MAKE THEM WORK. VEHICLE HAS BEEN SERVICED FOR THE ONGOING PROBLEM, AND THE DEALER HAS ONLY REPLACED THE BULBS.*AK THE CONSUMER STATED THE BULBS THAT WHERE REPLACED WHERE NOT BURNT OUT AND THE PROBLEM RESIDES IN THE SOCKET. THE CONSUMER STATED THAT THE CONNECTION BETWEEN THE SOCKET AND THE BULB IS NOT SOUND AND THEREFORE THE BULB RATTLES. AFTER TIGHTENING THE BULB WILL WORK A FEW DAYS AND THEN THE PROBLEM OCCURS AGAIN. THE DEALER JUST TIGHTENS THE BULB BUT THE PROBLEM IS STILL THERE.
NHTSA complaint #10111216 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
THE EPC LIGHT COMES ON THE DASH. I WAS TOLD THIS IS DUE TO A BRAKE LIGHT SWITCH THAT WILL GO OUT. THIS CAUSES CRUISE CONTROL TO GO OUT, BRAKE LIGHTS TO NOT WORK, AND DIFFICULTY GETTING YOUR GEARSHIFT OUT OF PARK OR NEUTRAL.
NHTSA complaint #10033434 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
WHEN FOLLOWING THIS VEHICLE IN BRIGHT SUN IT IS IMPOSSIBLE TO SEE THE BRAKE LIGHTS OR THE TURN SIGNAL LIGHTS ON THE BACK OF THE VEHICLE. THE SUN JUST WASHES THEN OUT. THEY NEED TO BE MOUNTED VERTICALLY AND NOT ON A SLOPE AS THEY ARE NOW.
NHTSA complaint #764725 — an unverified report by a vehicle owner.