32 of the 88 complaints filed about the Volkswagen E-Golf are about the electrical system — 36% of everything owners reported. The worst model year for it is 2015.
32
Complaints
36%
Share of all complaints
0
Crashes
2
Fires
ELECTRICAL SYSTEM
High voltage component, onboard charger, failure caused an electrical fire contained inside the case. It is available for inspection. Unclear on safety concerns. Taken to dealer and a second repair shop and they were unable to identify the issue. I opened the onboard charger and found the evidence of the fire. Has not been inspected by anyone. No warning lights were present before or after the incident.
NHTSA complaint #11735929 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
While the vehicle is attached to A/C power for charging, the forced air heating system does not warm the car. This can leave the occupants without heat for an extended period of time while charging in a remote location which could be life threatening. There used to be a "work around" using CarNET functions for this car, but that service has been discontinued for the 2016 model year. It should also be noted that other battery electric vehicles allow heating and cooling while plugged in to A/C power.
NHTSA complaint #11494331 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Two miles into my morning commute, I accelerated to 65 mph when the following message appeared on the instrument display "Error: electrical system. Stop!" At the same time, the vehicle lost all electrical motor drive and began to coast and decelerate. As I coasted there was a clicking noise in the drivetrain and remained audible while I changed lanes to the shoulder and made a safe full stop. I powered the vehicle OFF then ON three time or until the error disappeared. The vehicle was driven to a service location and scanned which revealed 14 error codes (ref. attachment) related to electric drivetrain. This error is a safety related fault and needs to be investigated by a NHTSA and a VW safety engineer.
NHTSA complaint #11489309 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:PROPULSION SYSTEM:CHARGING:CABLE/CORD:ACCESSORY
The contact owns a 2016 Volkswagen E-Golf. The contact stated that while charging the vehicle with the level 3 charger, the female connector on the vehicle became loosened due to a failure with the 4 tabs holding the connector in place on the vehicle. The level 3 charger loosened and exposed the plug with live current going to the part. The contact stated that he smelled a burnt electrical odor and the charger was now inoperable. The contact had taken the vehicle to a local dealer however, there were no trained technicians available to fix the vehicle. The manufacturer had not been informed of the failure. The failure mileage was approximately 43,000.
NHTSA complaint #11468478 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
Car computer system spontaneously crashes every few minutes. Proximity sensors, rear camera, and drive mode selector (normal, eco, eco+) stop working creating a potential driving hazard. After several crashes, the system requires a hard reboot. If a phone is connected (via bluetooth or USB cable), the handsfree car-link also stops working.
NHTSA complaint #11445625 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
CAR WAS IN MOTION ON A CITY STREET AND SUDDENLY LOST POWER. PULLED OFF ROAD, WAITED AND RESTARTED VEHICLE WITH NORMAL FUNCTION. EVALUATED AT VW DEALER AND TOLD THE DC-DC CONVERTOR IS NOT WORKING PROPERLY AND SHUTTING DOWN THE MOTOR. THIS PART WAS PART OF A PRIOR SAFETY RECALL BY NHSTA, AND THE CAR WAS EVALUATED AND SAID TO BE FIXED. CONTACTED VW OF AMERICA (CASE # 04750977) AND TOLD THERE WAS NOTHING THEY COULD DO AS THE CAR WAS OUT OF WARRANTY.
NHTSA complaint #11414340 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I WAS DRIVING DOWN THE ROAD AND THE CAR HALTED ALL OF A SUDDEN. AN ERROR APPEARED ON THE DASHBOARD THAT SAID ELECTRIC FAILURE. STOP. LUCKILY NO CARS WERE BEHIND ME OR IT WOULD HAVE BEEN AN ACCIDENT. THE CAR WOULD NOT START BACK UP FOR 30-40 MINUTES.
NHTSA complaint #11375152 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THE CAR WAS LAST DRIVEN 9/16/2020 AROUND 5:30PM. IT HAD APPROXIMATELY 90 MILES LEFT AS AN ESTIMATED BATTERY CHARGE. IT WAS PARKED IN MY DRIVEWAY. ON 9/17 3:20PM OR SO I WALKED OUT OF MY HOUSE AND SMELLED SOMETHING BURNING. I OPENED THE CAR DOOR AND HEARD AN ALERT AND THE DISPLAY SAID ELECTRICAL SYSTEM ERROR. I TRIED TURNING THE CAR ON AND OFF A FEW TIMES, NOTICED A LIGHT SMELL INSIDE THE CAR. I CONTINUED TO GET THE ELECTRICAL ERROR MESSAGE. I CALLED FOR VW ROADSIDE ASSISTANCE, TOOK THE CAR SEATS OUT, AND WHILE WAITING TO BE CONNECTED TO ROADSIDE ASSISTANCE I HEARD A SMALL POP SOUND AND A LITTLE SMOKE COME FROM THE HOOD AREA. MY HUSBAND CALLED 9-1-1. WITHIN ABOUT 5 MINUTES, WE HEARD MORE POPPING, SAW MORE SMOKE, AND THEN SAW FLAMES COMING FROM BENEATH THE CAR. A FIRE ENGINE ARRIVED AND WORKED ON PUTTING OUT THE FIRE. THE BATTERY HEATED/SMOKED/FLARED UP FOR ABOUT 3 HOURS UNTIL IT WAS DEEMED SAFELY OUT, AND FIREFIGHTERS LEFT. AS OF NOW, 3:30PM ON 9/18/2020, THERE ARE STILL FLARE UPS ON THE BATTERY AND IT IS UNDER THE SUPERVISION OF THE FIRE DEPARTMENT. PLEASE HELP WITH THIS INVESTIGATION AS QUICKLY AS POSSIBLE. THIS CAR IS EXTREMELY DANGEROUS.
NHTSA complaint #11359869 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THE VEHICLE INTERMITTENTLY WILL NOT UNLOCK/RELEASE THE CHARGING CONNECTOR FROM THE CONNECTION PORT. WHEN THIS OCCURS, THE EMERGENCY RELEASE PROCEDURE FOR THE VEHICLE WILL NOT RELEASE THE CHARGING CONNECTOR. THE CHARGING STATUS INDICATOR IS RED. EVENTUALLY CONNECTOR FINALLY RELEASES BUT AFTER EITHER HOURS OF WAITING OR SOMETIMES HITTTING THE CONNECTOR TO JAR IT FREE. DURING THE LOCKED CONDITION, THE VEHICLE IS NOT MOVEABLE - WILL NOT OPERATE. IF IT OCCURS AT A PUBLIC CHARGER, THE CAR IS LITERALLY TIED TO THE CHARGER AND BUILDING, UNABLE EVEN TO BE TOWED. CHARGERS CAN BE IN SOME KIND OF BLEAK, SCARY PLACES. NOT ALWAYS WHERE YOU WANT TO BE TRAPPED ALONE AT NIGHT. THERE ARE MANY REPORTS BY OTHER OWNERS/DRIVERS OF THE SAME YEAR AND MODEL, SEE: HTTPS://WWW.MYVWEGOLF.COM/FORUM/VIEWTOPIC.PHP?F=12&T=839&START=10 OR HTTPS://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?9292185-NOW-CHARGER-PORT-WON-T-RELEASE-CHARGER-CONNECTER! OR HTTPS://WWW.MYVWEGOLF.COM/FORUM/VIEWTOPIC.PHP?F=12&T=158&START=30 . THERE ARE OTHERS ALSO.
NHTSA complaint #11268374 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THE 2015 EGOLF LOCKS THE CHARGING CONNECTOR ONTO THE VEHICLE DURING CHARGING. THIS FUNCTIONALITY HAS TWO (AT LEAST) BENEFITS TO THE VEHICLE OPERATOR. ONE BENEFIT IS THAT THE (VERY EXPENSEIVE) CAR CHARGER'S POWER SUPPLY CAN'T EASILY BE STOLEN DURING CHARGING. A SECOND, SAFETY-CENTRIC, FUNCTION IS DERIVED BY NOT ALLOWING THE CHARGING PORT TO SEPARATE WHILE A CHARGE IS UNDERWAY PREVENTING POSSIBLE ELECTRICAL ARCS AND ELECTROCUTION. THE LOCKING MECHAISM INTERMITTENLY FAILS TO UNLOCK TOGETHER WITH THE REST OF THE DOORS AND FUNCTIONS ON THE VEHICLE. THIS HAS SEVERAL POTENTIAL DANGERS TO A VEHICLE OPERATOR. WHEH THE CHARGE CONNECTER WILL NOT RELEASE, THE VEHICLE WILL START AND MIGHT CREATE A SITUATION OF BEING STRANDED AT NIGHT IN A PUBLC CHARGING LOCATION. TJRTRRWERT---9RR-RRWPWRHIS HAS HAPPENED TO ME. TRYING TO RELEASE THE PLUG REQUIRES A STRONG LONG NARROW OBJECT (USUALLY METAL) BE INSERTED INTO THE SHIELDED AREA OF THE LOCKING MECHANISM. THE MECHANISM CAN SOMETIMES BE OVER-RIDDEN THROUGH TRIAL AND ERROR. EVENAUALLY, THOUGH AN OOPERATOR IS GOING TO ACCIDENTALLY CONTACT ONE OF THE HIGH VOLTAGE TERMINALS.AND BE SERIOUSLY HURT OR KILLED. CLIPPERCREEK CHARGING EQUIPMENT SEEMS MORE LIKELY TO CAUSRE THIS CONDITION. OUR HSC-40 UNIT AND THE SMALLER 120V TRAVEL MODEL THESE ARE OTHER SIMILAR REPORTS FOUND ONLINE: HTTPS://WWW.MYVWEGOLF.COM/FORUM/VIEWTOPIC.PHP?F=12&T=839 ' HTTPS://WWW.MYVWEGOLF.COM/FORUM/VIEWTOPIC.PHP?F=12&T=839#P7764 ' HTTPS://WWW.MYVWEGOLF.COM/FORUM/VIEWTOPIC.PHP?F=12&T=839#P7764
NHTSA complaint #11255767 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
EV CHARGER WILL NOT DISENGAGE FROM PORT EVEN WHEN CAR IS UNLOCKED WITH REMOTE. RED LIGHT INDICATING CHARGING FAILURE REMAINS AND CHARGER MUST BE REMOVED USING EMERGENCY DISENGAGE PIN WHICH IS DIFFICULT TO ACCESS AND CAR IS IMMOBILIZED WHILE CHARGER REMAINS STUCK. ELECTRICAL ERROR MESSAGE REQUESTING SERVICE COMES UP ON DASHBOARD TWO DAYS BUT DISAPPEARS UPON RESTART OF VEHICLE.
NHTSA complaint #11241947 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
WHILE CHARGING THE CAR, AN ELECTRIC COMPONENT FAILED AND THE CARD GOT DISABLED AND WOULD NOT START ANYMORE. IT ALSO STOPPED CHARGING. THE CAR WAS THEN TOWED AWAY FROM CHARGING STATION TO THE NEAREST DEALERSHIP.
NHTSA complaint #11166367 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
MY VEHICLE IS PARKED PLUGGED INTO A 240 V CHARGING STATION IN MY GARAGE/DRIVEWAY. I CANNOT DISCONNECT THE CHARGER BECAUSE THE RED LIGHT ON MY CAR IS ON SOLID RED AND THE LOCK WILL NOT DISENGAGE. ACCORDING TO THE MANUAL, WHEN THE LIGHT COMES ON RED SOLID TO SEEK EXPERT ADVICE. HOWEVER, NO ONE AT THE VOLKSWAGEN DEALERSHIP KNOWS HOW TO FIX IT. NOW MY VEHICLE STUCK IN THE DRIVEWAY AND CAN'T EVEN BE TOWED BECAUSE IT IS ATTACHED TO MY HOUSE.
NHTSA complaint #11024860 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TODAY, WHILE DRIVING ON LOCAL ROAD, CAR STARTED TO SHAKE AND MESSAGE APPEARED "BATTERY MALFUNCTION" AND CAR JUST DIED WHILE RUNNING 40 MPH. AFTER I TURNED IT OFF AND ON AFTER FEW MINS EVERYTHING WAS FINE FOR ANOTHER COUPLE OF HUNDREDS FEET AND THEN IT REPEATED AGAIN. THIS TIME WHILE I WAS ON THE TRAFFIC LIGHT.
NHTSA complaint #11013776 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I EXPERIENCED THIS ERROR "ELECTRICAL SYSTEM FAILURE: STOP!". I COULDN'T USE MY CAR. I HAD TO WAIT FOR COUPLE OF MINUTES AND AFTER THIS EVERITHING WAS BACK TO NORMAL
NHTSA complaint #10937081 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
AFTER CHARGING TIME RESUMED, THE CAR DOESN'T RELEASE THE CHARGE PLUG . CHARGE LIGHT TURNED RED.-LOCK WON'T RELEASE.-THE CAR IS STUCK BECAUSE THE PIN IS STUCK AND IT WON'T UNLOCK. AT THE END OF THE DAY IT UNLOCKED BY ITSELF NOW IT HAPPENED FOR THE SECOND TIME AFTER ONLY 3 DAYS SINCE LAST TIME.
NHTSA complaint #10936112 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
THERE ARE MULTIPLE CONDITIONS UNDER WHICH THE CAR'S CHARGING CONNECTOR ALLOWS REMOVAL OF THE PLUG FROM THE VEHICLE WHILE POWER IS ENGAGED. THIS HAS LEAD TO SPARKS BEING GENERATED ON REMOVAL. THE CONDITIONS INVOLVE THE FAILURE OF THE PHYSICAL LOCKING PIN ON THE CHARGE PORT, AND VW'S INCOMPLETE IMPLEMENTATION OF THE J1772 CHARGING STANDARD, SPECIFICALLY AROUND THE PROXIMITY CIRCUIT.
NHTSA complaint #10926245 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
AT ABOUT 17500 MILE ON ODOMETER, I HAD JUST UNPLUGGED THIS ELECTRIC CAR FROM A PUBLIC LEVEL 2 CHARGING STATION AND SAW A WARNING "ERROR: ELECTRICAL SYSTEM. STOP!". I ASSUMED IT WAS JUST A LIGHT WHEN FIRST TURNING THE CAR ON SO SHIFTED INTO REVERSE. ( I WAS PARKED IN A STANDARD PARKING LOT, RACKING THE CHARGER. THE CAR STARTED ROLLING OUT OF THE SPOT, BUT HAD NO POWER. I WAS ABLE TO APPLY THE BRAKES AND NOT ROLL INTO TRAFFIC. THE CAR WAS TOWED TO VW AND I AM TOLD THAT TWO SEPERATE SMALL BATTERIES HAD A PROBLEM AND NEEDE TO BE REPLACED. THIS HAS OCCURRED AND THE CAR SHOULD BE RETURNED IN A FEW DAYS. I'M WORRIED ABOUT ANOTHER FAILURE HAPPENING WHEN I AM DRIVING WITH KIDS IN CAR, AS HAS BEEN REPORTED ON YOUR SITE.
NHTSA complaint #10918074 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
ON AUGUST 28 2016 PRIOR TO CHARGING E-GOLF, CHARGING SYSTEM FAILED CAUSING THE DAMAGE ON THE ELECTRICAL SYSTEM AND BATTERY. THE CAR WAS PARKED ON THE UCSD THORNTON PARKING LOT. AT THAT TIME CAR ODOMETER SHOWS 8727 MILES. VOLKSWAGEN DIDN'T (FAILED TO) INFORM ME ABOUT THE RECALL FOR THE SOFTWARE THAT CONTROL CHARGING SYSTEM AND BATTERY CHARGING. NOT SURE IF THE SOFTWARE FOR THE BATTERY/CHARGING SYSTEM IS THE ONLY PROBLEM SINCE THE VOLKSWAGEN OF AMERICA STATE THAT BATTERY NEEDS TO BE INSPECTED, TESTED AND IF BROKEN FIXED OR REPLACED. SINCE THEN THE CAR HAS BEEN UNABLE TO START OR MOVE. VOLKSWAGEN OF AMERICA TAKE THE CAR TO OXNARD THE ONLY AVAILABLE SERVICE CENTER FOR E-GOLF IN CALIFORNIA. THE CAR HAS NOT BEEN FIXED YET SINCE THE AUGUST 29TH WHEN THE CAR HAS BEEN DIAGNOSED WITH THE BATTERY AND ELECTRICAL ISSUES.
NHTSA complaint #10906064 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
VEHICLE WAS TRAVELLING ~40 MPH ON PUBLIC ROAD. REACHED DOWN TO PRESS "MODE" BUTTON TO LEFT OF SHIFTER TWICE TO SWITCH TO ECO MODE. PRESSED "POWER" BUTTON BY MISTAKE. TWO PRESSES OF POWER BUTTON CAUSES VEHICLE TO SHUT OFF, EVEN WHILE MOVING. VEHICLE SUFFERED TOTAL LOSS OF POWER. WAS ABLE TO BRING VEHICLE TO A STOP THANKS TO LIMITED TRAFFIC, ENGAGED PARK, AND PRESSED POWER BUTTON TO RESTART VEHICLE. MODE AND POWER BUTTONS ARE RIGHT NEXT TO EACH OTHER, BOTH REQUIRE TWO BUTTON PRESSES TO EITHER ENGAGE ECO MODE (MODE BUTTON), OR ACTIVATE EMERGENCY VEHICLE SHUTOFF (POWER BUTTON). NOT ENOUGH DIFFERENTIATION IN FEEL TO DETERMINE WHICH BUTTON IS BEING PRESSED WITHOUT TAKING EYES OFF ROAD AND LOOKING DOWN AT SHIFTER CONSOLE.
NHTSA complaint #10882754 — an unverified report by a vehicle owner.