12 of the
76 complaints about the 1999 Volkswagen Golf are about the
electrical system — 16% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
90,000 miles.
D
12
Complaints
1
Crashes
1
Fires
0
Injuries
Exactly what failed
Electrical System
541.7%
Fuses AND Circuit Breakers
325.0%
12V/24V/48V Battery
18.3%
Ignition
18.3%
Interior/Under Dash
18.3%
Relay
18.3%
Electrical System across every Volkswagen Golf year
INSTRUMENT CLUSTER FIRE IN 1999 VW GOLF TDI: 2003-01-14, MILEAGE 88290, LIGHTS AND GAUGES ON INSTRUMENT CLUSTER WERE ACTING FLAKY AND NOT WORKING PROPERLY. SOME LIGHTS WERE DIM AND SOME WERE BURNT OUT. 2003-02-05, I BOUGHT NEW INSTRUMENT CLUSTER. PLAN WAS TO HAVE DEALERSHIP REPLACE FAULTY ONE WITH NEW ONE ON 2003-02-10. A FEW DAYS AFTER I BOUGHT NEW ONE, THE CARS EXISTING ONE SUDDENLY EMITTED SPARKS WHILE I WAS DRIVING IN A SNOW STORM, AND CAUGHT ON FIRE! THICK, ACRID SMOKE BILLOWED FROM UNDERNEATH THE DASHBOARD, FORCING ME OUT OF THE CAR. I PUT OUT THE FIRE WITH MY JACKET AND SOME SNOW. 2003-02-10, DEALERSHIP REPLACED INSTRUMENT CLUSTER. DURING THE FIRST HEAVY SNOWFALL AFTER THAT, CAR STARTED BUCKING AT LOW RPMS AND WHEN ATTEMPTING TO SHIFT GEARS. SPEEDOMETER STARTED FLUCTUATING WILDLY, SHOWING ME GOING ANYWHERE FROM 0 TO 120 MPH. TEMPERATURE GAUGE STARTED FLUCTUATING BETWEEN 0 AND DANGER ZONE, AND TEMPERATURE ALARM SOUNDED WHENEVER THE GAUGE JUMPED INTO THE DANGER ZONE. FUEL GAUGE DROPPED TO EMPTY. ODOMETER FROZE UP. 2003-04-04, MILEAGE 90906, TECHNICIAN AT DEALERSHIP FOUND 300 KILO-OHM RESISTANCE IN WIRING HARNESS GROUNDS. THE FOUR MAIN GROUND WIRE ENDS WERE HORRIBLY CORRODED. AS A RESULT, THERE WAS NO POWER GOING TO THE ENGINE COOLANT TEMPERATURE SENSOR, VEHICLE SPEED SENSOR, OR COOLANT BOTTLE SENSOR. TECHNICIAN LEFT THE EXISTING WIRING HARNESS IN PLACE, SINCE MOST OF THE HARNESS WIRES WERE WORKING FINE. HE DISCONNECTED AND CAPPED THE ENDS OF THE FOUR CORRODED WIRES. HE THEN RAN NEW WIRES TO THE AFFECTED SENSORS (CREATING AN OVERLAY HARNESS), CRIMPED NEW CONNECTORS ON THE ENDS, AND USED HEAT SHRINK ON THE CRIMPS. I HAVEN'T HAD ANY INSTRUMENT CLUSTER FIRES SINCE THEN; HOWEVER, I HAVE REPLACED THE ECT SENSOR 7 TIMES DURING THE 15 YEARS I HAVE OWNED THIS CAR, POSSIBLY BECAUSE OF LINGERING GROUNDING ISSUES. CURRENT MILEAGE IS ABOUT 392,000.
NHTSA complaint #10762026 — an unverified report by a vehicle owner.
Washington, NC
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
THE BATTERY EXPLODED WHEN I TRIED TO START THE CAR.
NHTSA complaint #764108 — an unverified report by a vehicle owner.
Greenwood Lake, NY
ELECTRICAL SYSTEM
WHILE AT HIGH SPEEDS, THE ENGINE WOULD SHUT OFF (NOT STALL), THE CAUSE WAS THE POWER SUPPLY RELAY FOR THE DIESEL ENGINE.
NHTSA complaint #564611 — an unverified report by a vehicle owner.
Greenwood Lake, NY
ELECTRICAL SYSTEM
WHILE AT HIGH SPEEDS, THE ENGINE WOULD SHUT OFF (NOT STALL), THE CAUSE WAS THE POWER SUPPLY RELAY FOR THE DIESEL ENGINE.
NHTSA complaint #564611 — an unverified report by a vehicle owner.
Richmond, ME
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
NO SUMMARY LISTED FOR ABOVE VEHICLE.
NHTSA complaint #757933 — an unverified report by a vehicle owner.
Oberlin, OH
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
RELAY QUIT WORKING AND LEFT ME STRANDED ON A 10 DEGREE MORNING.
NHTSA complaint #756630 — an unverified report by a vehicle owner.
ST. Cloud, MN
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
ENGINE SUDDENLY STOPPED RUNNING WHILE ON FREEWAY, ONLY GOOD LUCK ALLOWED ME TO GET OUT OF TRAFFIC. ENGINE RESTARTED 5 MINUTES, I CONTINUE DRIVING, NOW ONLY IN THE RIGHT HAND LANE. ALMOST MADE IT HOME, ENGINE DIES SUDDENLY AGAIN, SAME 5 MINUTE WAIT, ENGINE STARTS AND RUNS JUST FINE. I AM AN ENGINEER SO I TOOK OFF THE KICK PANEL TO HAVE ACCESS TO THE RELAY PANEL: THE NEXT TIME IT SUDDENLY STOPPED, I FELT ALL RELAYS ON THE PANEL, RELAY MARKED 109 WAS HOT TO MY TOUCH; I WOULD ESTIMATE 130 DEGREES F OR MORE. I REPLACED THE RELAY AND I FIND IT HAS BEEN REDESIGNED. THIS IS WHY I CONTACT YOU.
NHTSA complaint #752814 — an unverified report by a vehicle owner.
GIG Harbor, WA
ELECTRICAL SYSTEM
ELECTRONIC DEFECTS THAT MANUFACTER CANNOT/WILL NOT FIX. CAR WILL STOP AT CRUISE SPEEDS WITHOUT WARNING AND DURING ACCELERATION. CAR HAS BEEN TO DEALER5 TIMES SINCE MAY TO DATE. NO FIX AVAILABLE YET. EXTREMELY DANGEROUS IN MANY ROAD CONDITIONS.
NHTSA complaint #750115 — an unverified report by a vehicle owner.
GIG Harbor, WA
ELECTRICAL SYSTEM
ELECTRONIC DEFECTS THAT MANUFACTER CANNOT/WILL NOT FIX. CAR WILL STOP AT CRUISE SPEEDS WITHOUT WARNING AND DURING ACCELERATION. CAR HAS BEEN TO DEALER5 TIMES SINCE MAY TO DATE. NO FIX AVAILABLE YET. EXTREMELY DANGEROUS IN MANY ROAD CONDITIONS.
NHTSA complaint #750115 — an unverified report by a vehicle owner.
Buffalo Grove, IL
ELECTRICAL SYSTEM:IGNITION
ENGINE DIED ON HIGHWAY; RESTARTED BUT STALLED 2 MORE TIMES. REPLACED RELAY BASED ON INTERNET INPUT (SEARCH 'RELAY 109' AT WWW.TDICLUB.COM).
NHTSA complaint #740838 — an unverified report by a vehicle owner.
Buffalo Grove, IL
ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY
ENGINE DIED ON HIGHWAY; RESTARTED BUT STALLED 2 MORE TIMES. REPLACED RELAY BASED ON INTERNET INPUT (SEARCH 'RELAY 109' AT WWW.TDICLUB.COM).
NHTSA complaint #740838 — an unverified report by a vehicle owner.
Corona, CACrash
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
SEE WWW.TDICLUB.COM AND SEARCH FOR 'RELAY 109' FOR REPORTS. DEFINITELY RECALL MATERIAL, HAZARD TO DRIVERS WHEN ENGINE DIES IN TRAFFIC.
NHTSA complaint #723073 — an unverified report by a vehicle owner.