10 of the
65 complaints about the 2018 Volkswagen Passat are about the
electrical system — 15% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
49,900 miles.
C
10
Complaints
1
Crashes
0
Fires
0
Injuries
Exactly what failed
Electrical System
880.0%
12V/24V/48V Battery
110.0%
Interlock/Lockout
110.0%
Electrical System across every Volkswagen Passat year
A major engineering and material design failure occurred involving internal fluid containment seals, resulting in a severe electrical safety hazard. Pressurized engine coolant breached an internal component seal and began migrating internally directly through the vehicle's engine wiring harness via capillary/siphoning action. The fluid used the sealed wiring loom as a literal pipeline, traveling inside the wire insulation to bypass all outer weather seals and completely flood the Engine Control Module (ECM) pin connectors. The vehicle's dealership service department documented extensive galvanic corrosion and shorting inside the primary vehicle computer pins due to this blue-green fluid pooling. Because the dealership has not yet completed the full repair, the exact originating component source of the leak (e.g., the engine coolant temperature sensor or the coolant expansion tank housing barrier) remains unconfirmed. However, the physical mechanism of the coolant migration through the sealed harness into the primary electrical architecture is fully verified. This defect presents a critical safety risk. The sudden flooding and short-circuiting of the Engine Control Module can cause an immediate and unexpected loss of engine propulsion, power steering assist, and electrical control while driving at highway speeds, creating an imminent risk of a high-speed collision.
NHTSA complaint #11741923 — an unverified report by a vehicle owner.
at 70,000 milesRahway, NJ
ELECTRICAL SYSTEM
The contact owns a 2018 Volkswagen Passat. The contact stated that while driving at an undisclosed speed, the infotainment screen failed to respond to touch commands, preventing the contact from viewing the GPS feature. The contact performed a hard reset on the vehicle, but the failure persisted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.
NHTSA complaint #11731417 — an unverified report by a vehicle owner.
at 136,000 milesKernersville, NC
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The contact owns a 2018 Volkswagen Passat. The contact stated that while driving at an undisclosed speed, the vehicle stalled. There was no warning light illuminated. The vehicle was unable to restart and was towed to the dealer to be diagnosed. The vehicle was diagnosed with battery failure. The contact was informed that the battery needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was then towed to a different dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 136,000.
NHTSA complaint #11715843 — an unverified report by a vehicle owner.
at 55,000 milesMckees Rocks, PA
ELECTRICAL SYSTEM
The contact owns a 2018 Volkswagen Passat. The contact stated that while driving approximately 40 MPH, the vehicle made an abnormal sound and failed to accelerate as intended. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a wiring harness failure. The vehicle was repaired. The contact had received an unknown notice, which was related to the failure. The manufacturer was contacted for reimbursement, and a case was filed. The contact sent the requested documents to the manufacturer; however, the manufacturer failed to call back as the manufacturer had stated. The failure mileage was approximately 55,000.
NHTSA complaint #11714408 — an unverified report by a vehicle owner.
at 35,000 milesRichmond, VA
ELECTRICAL SYSTEM
The contact owns a 2018 Volkswagen Passat. The contact stated while driving 35 MPH, several unknown warning lights illuminated. The contact stated that the vehicle had experienced unstated electrical failures while driving at various speeds. Additionally, the rear-view camera would activate while the vehicle was in drive(D). The contact stated that the passenger occupant air bag sensor was flashing on and off without a passenger being seated in passenger’s side seat. The contact had taken the vehicle to a local dealer, where it was determined that the failure could not be duplicated. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 35,000.
NHTSA complaint #11515663 — an unverified report by a vehicle owner.
Harvest, ALCrash
ELECTRICAL SYSTEM:IGNITION:INTERLOCK/LOCKOUT
The vehicle can be turned off while in drive, and gives no extra signals (beeps, flashing lights, etc.) with the exception of a brief message on the dash and single ding (same ding for door open, and other low importance messages). The vehicle will then roll until the brake is applied or it comes to a rest on a flat surface or against a pole or hard object. This is a significant safety hazard that has occurred to me 3-4 times, the most recent was today when the vehicle rolled backwards down my mothers driveway. Crossed the street, entered the neighbors driveway/yard, contacted the mail box and came to rest in the front yard. The vehicle rolled approx. 200ft. The vehicle is equipped with auto braking and parking collision warning, that are capable of sensing a collision while driving and notifying the driver of objects while parking. The same system should be able to prevent a car turned off while in drive from rolling uncontrolled and striking a person or object. In addition the car should have generate a significant audio and visual warnings to the driver, furthermore the car should not be able to be turned off while in drive. It’s a fundamental flaw that it can be turned off, drivers door opened, driver and keys step out of the vehicle with no response from the vehicle.
NHTSA complaint #11428647 — an unverified report by a vehicle owner.
at 49,900 milesBurlington, WI
ELECTRICAL SYSTEM
WHILE REVERSING IN MY DRIVEWAY, MY DASH LIGHTS UP WITH WARNING: ACC ERROR AND WARNING : AIRBAG ERROR AND STAYED WHILE I WAS PARKED AND KEPT MY CAR STATIONARY. THE NEXT DAY IT SHOWED UP AGAIN AND I AM WORRIED ABOUT MY AIRBAG DEPLOYING ON ME WHILE DRIVING AND CAUSING AN ACCIDENT. I AM WORRIED ALSO THAT MY AIRBAG MIGHT NEVER GO OFF AND THESE CODES DAMAGE SOMETHING ELSE INTERNALLY IN THE CAR.
NHTSA complaint #11387703 — an unverified report by a vehicle owner.
at 200 milesRome, NY
ELECTRICAL SYSTEM
THE RADIO/VIDEO MONITOR ON THE DASH GOES BLACK AND NO SOUND AND NO BACKUP CAMERA WILL ENGAGE AFTER DIFFERENT PERIODS OF TIME THE MONITOR COMES BACK ON THIS PROBLEM HAS NOT BEEN CORRECTED WITH DAYS OF SERVICE AT THE VW DEALERSHIP OVER TWO WEEKS AT THIS TIME
NHTSA complaint #11322383 — an unverified report by a vehicle owner.
at 11,500 milesNesconsent, NY
ELECTRICAL SYSTEM
TL* THE CONTACT LEASED A 2018 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE HORN WAS INOPERABLE WITH THE IGNITION IN THE OFF POSITION. THE CONTACT STATED THAT WHILE ANOTHER VEHICLE WAS ATTEMPTING TO PARK AND GETTING EXTREMELY CLOSE TO THE VEHICLE, THE HORN PAD WAS DEPRESSED AND FAILED TO NOTIFY THE OTHER DRIVER OF THE CLOSE PROXIMITY TO THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE ISSUE. THE CONTACT WAS INFORMED THAT THE VEHICLE FUNCTIONED AS DESIGNED. THE FAILURE MILEAGE WAS 11,500.
NHTSA complaint #11308549 — an unverified report by a vehicle owner.
Richmond, VA
ELECTRICAL SYSTEM
I HAD REPORTED THE ISSUE TO VW VERBALLY AND SERVICE DEPARTMENT BASICALLY ADVISED I WILL HAVE TO PLACE IT ON THE MACHINE TO RUN A DIAGNOSTIC TEST THAT IS NOT COVERED. I DID NOT HAVE THE FUNDS BUT THEY SAID IF IT HAPPENED AGAIN LET THEM KNOW. IT DID SEVERAL OCCASIONS AFTER THAT ALL THE WAY UP UNTIL 3 DAYS AGO AS OF 09.26.19. IT IS KINDA HARD TO REPORT THINGS TO WEST BROAD VOLKSWAGEN SERVICE DEPARTMENT WHEN THEY ARE RUDE AND UNFRIENDLY AND MAKE A CUSTOMER UNCOMFORTABLE. I LIKE ONLY SPEAKING TO MR. FRANK IN SALES WHEN I HAVE AN ISSUE BECAUSE HE GOES OVER AND BEYOND. IF IT WASN'T FOR HIM I WOULD BE VERY UNCOMFORTABLE ASKING OR GOING TO THAT DEPARTMENT. WHEN TRYING TO BACK UP THE CAMERA DOESN'T COME ON IT TAKES A WHILE OR IT BLANKS OUT AT TIMES. ALSO WHEN PULLING OFF MY VEHICLE IS SLOW ALSO ADVISED THAT. I HAD A LOANER CAR AND IT DROVE BETTER. MINES HAS A LOT OF NOISES AND SOUNDS.
NHTSA complaint #11258428 — an unverified report by a vehicle owner.