205 of the
762 complaints filed about the Volkswagen Taos
are about the engine —
27% of everything owners reported.
The worst model year for it is 2022.
On July 30, 2026, while driving my 2022 Volkswagen Taos out of my apartment parking lot, the EPC and check engine lights illuminated. The vehicle shook, lagged, stalled, and could not accelerate normally. I parked and turned it off. An authorized Volkswagen dealer diagnosed a faulty spark plug. On August 12, the same failure recurred. The EPC and check engine lights illuminated, the vehicle shook, and it again lost acceleration. The dealer attributed the misfire to poor fuel caused by Arizona monsoon and dust-storm conditions and added a fuel additive. However, the only major dust storm around these dates occurred on August 19, after the first two incidents. No fuel-test results were provided to support this explanation. On August 20, the failure occurred a third time while I was driving on a major road. The vehicle shook and experienced a severe loss of propulsion and acceleration. The check engine light remained on after the engine was turned off. I had to restart the vehicle three times before I could move it into a parking lot. I was less than one mile from entering a highway, and the sudden loss of acceleration in traffic created a serious collision risk. The vehicle was towed to the dealer. On August 21, the dealer again attributed the misfire to poor fuel. It added fuel-system cleaner, filled the tank with 91-octane fuel, and test-drove the vehicle, but the misfire remained. The technician then reported that three spark plugs were fouled and required replacement. The same dangerous loss-of-power condition occurred three times within 22 days despite two prior repair attempts. The cause of the repeated misfires and fouled plugs remains unidentified. The vehicle is at the Volkswagen dealership and is available for inspection. There was no crash, fire, or injury.
NHTSA complaint #11758707 — an unverified report by a vehicle owner.
I am filing this complaint because Volkswagen is refusing to honor its factory powertrain warranty to cover a catastrophic internal engine failure on a vehicle with only 22,531 miles. The vehicle is well within its manufacturer's powertrain warranty limits. I have provided Volkswagen with two official receipts proving routine oil changes, GEICO insurance records proving the accident caused no front-end or engine damage, and an official email from Volkswagen stating there were no pre-existing issues with the vehicle. Furthermore, the engine issues align closely with known fuel system and engine defects currently being litigated in the class-action lawsuit Hardy v. Volkswagen. The vehicle suffered an acute mechanical/electronic failure the engine revved past 4,000 RPM, but the vehicle experienced severe sputtering, shaking, and minimal forward propulsion. The EPC (Electronic Power Control) warning light illuminated on the dashboard. Volkswagen dealership at middletown even states via email as attached can not determine the exact cause of the failure.
NHTSA complaint #11756316 — an unverified report by a vehicle owner.
Per VW TSB 15-23-01, Volkswagen explicitly admits that the original engine production head gasket design is defective. A leaking head gasket can cause sudden engine overheating, power loss, or catastrophic engine failure while driving. This seems like a major , dangerous issue that should be covered under a recall
NHTSA complaint #11755980 — an unverified report by a vehicle owner.
head gasket well known issue with no campaign or warranty coverage Volkswagen issued an official TSB 15-23-01 (Head Gasket Leakage) acknowledging that the original factory head gasket design on early Taos models allows coolant to leak. The production line was eventually updated with a redesigned gasket. They denied coverage or even partial reduction in labor.
NHTSA complaint #11752754 — an unverified report by a vehicle owner.
On 7/9/2026, my 2022 VW Taos was brought to the dealer for being severely underpowered, check engine lights on, and a strong raw fuel smell inside the vehicle. On 7/10/2026, the dealer stated the vehicle was ready, claiming they replaced a turbo charge pipe O-ring. The service advisor verbally stated the vehicle had been successfully test-driven for 5 miles on streets and the highway. However, official paperwork only stated "cleared faults verified no leaks in system, vehicle is now operating as designed." Immediately upon driving home on the highway, as the vehicle reached 70–75 mph under load, a loud whistling noise and a sudden, dangerous loss of propulsion occurred simultaneously. The vehicle was returned to the dealer on 7/10/2026. On 7/13/2026, the vehicle was picked up after a second repair where the dealer admitted the plastic charge pipe (05E-145-673-Q) was actually fractured and had completely blown off the turbocharger during my highway drive, generating fault code P227900 (Intake Air System Leak). Upon reviewing the paperwork from both visits, I discovered the odometer had only increased by exactly 1 mile during the first service visit. The dealer completely failed to road-test the vehicle under actual highway boost loads before certifying it as safe, which directly caused a catastrophic structural engine failure and an emergency safety hazard at 75 mph.
NHTSA complaint #11750349 — an unverified report by a vehicle owner.
While driving at highway speeds, the a low coolant caution light came on. We immediately pulled over before the engine overheated and added coolant and brought the vehicle in for repairs. This Taos currently has 43,000 miles and needs its head gasket replaced for the SECOND time. The first head gasket was replaced on 12/23 with 16,000 miles under a technical bulletin by VW. This is a know issue for this vehicle. With a head gasket failure, this can lead to engine overheating and seizing. This needs to be a recall.
NHTSA complaint #11749254 — an unverified report by a vehicle owner.
The engine coolant is leaking and the cylinder head gasket is leaking at the back of the engine. This requires full replacement. This is a known issue with Technical Service Bulletin 15-23-01 from Volkswagen back in 2023, and both VW and our Dealership are refusing to cover the costs of replacement.
NHTSA complaint #11747011 — an unverified report by a vehicle owner.
The contact owns a 2022 Volkswagen Taos. The contact stated that while driving at various speeds, the vehicle unintendedly decelerated. The contact associated the failure with NHTSA Campaign Number: 22V687000 (Engine and Engine Cooling). The contact associated the failure with the recall. The contact stated that several unknown warning lights and the EPC and engine temperature warning lights were illuminated. The contact stated that the dealer was contacted but was unable to determine the cause of the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 25,000.
NHTSA complaint #11746041 — an unverified report by a vehicle owner.
The systems failing are electrical, engine, and fuel/propulsion systems. VW TAOS 2022 purchased Sept. 2023. Two weeks after purchasing the vehicle, I'm driving down the street and the vehicle began to lose power and start slowing down. It eventually cut off. About a week later, I experienced the same issue. I called the dealer and they had me to bring my car in. I was told that they couldn't find the problem, but that the car was misfiring. They "repaired" and returned it to me. As I drove on local streets and the interstate, I have problems with acceleration. The car does not pick up speed like it should and lags behind and then suddenly jerks forward (even after battery rest times during a stop). It rides a bit rough. Occasionally, my dashboard blacks out while I'm driving. My auto-start doesn't always work, even after the fob batteries have been changed. My gas seems to disappear and I find myself gassing up more often than I should be. I would contact the dealership, they'd coordinate service around my scheduled service dates and claim that they could never find or duplicate the problems that I'm having. The problems continue. My engine light came on while I was driving and stayed on. I was told to bring in my car. The dealership kept it from July-Sept 2025, replacing parts and then returned it to me. Two days later the engine light came back on and I had to return to the dealer again for service. After leaving a parking lot (Jun 2026), two blocks down the street the TAOS began to lose power, the engine light is flashing and the EPC code (engine control malfunction) light lit up. I called VW and they dispatched a tow. My TAOS was towed to Checkered Flag VW. My safety (and others) is at risk because the power loss just happens without warning. If a driver is not paying attention, they could run into the back of me or hit me on the side during a lane change due to the slow movement.
NHTSA complaint #11743911 — an unverified report by a vehicle owner.
The EVAP line has a fault, stuck open, affects nothing whatsoever. But has every single light on the dash on. It tells me the brakes don't work, the air bags don't work, the cruise doesn't work. Everything. The confusing thing is some things actually work and some don't. The brakes work, the cruise doesn't. The auto detection doesn't work. What's worse, you can't replace that part. No one sells it. This is absolutely horrendous and very dangerous.
NHTSA complaint #11743340 — an unverified report by a vehicle owner.
Had my car in at a Volkswagen dealership for its routine maintenance they called me back, letting me know that I had the head gasket leak and that coolant was leaking.
NHTSA complaint #11741341 — an unverified report by a vehicle owner.
Head gasket failure is a known issue for this model. Some owners report failure at 12k miles in for quite some time. I am now faced with this known issue VW has had time to remedy. If it is a known failure why not take care of it especially if it spans across 3 models 2022 - 2024. I should not have to absorb this type of repair 4 years 57k miles in on my vehicle. Of course, everything pops up right as warranties expire. I was refused even dealer “good faith” for being 7,000 miles over the threshold VW powertrain warranty of 4 years 50k miles. Now to find $4638.83 for parts plus whatever labor will be.
NHTSA complaint #11740807 — an unverified report by a vehicle owner.
The vehicle has intermittent hesitation/delayed acceleration from a stop and during low-speed stop-and-go driving. At times, engine RPM increases before the vehicle responds or accelerates normally. This creates a safety concern when entering traffic, turning, merging, or accelerating from a stopped position because the vehicle does not always respond predictably to throttle input. The concern was reported to a Volkswagen dealer in writing during a prior repair process and was later formally documented on a repair order as hesitation on acceleration. The vehicle has prior Volkswagen repair history involving a coolant warning/low coolant concern, head gasket repair, and later camshaft seal/belt cover repair. After the most recent repair, the delayed acceleration/hesitation concern remained unresolved. The vehicle is currently under review with Volkswagen Customer Care, but the safety-related drivability concern has not yet been fully resolved. Supporting documents include the 2025 written report of jerking from a stop, the 2026 repair order documenting hesitation on acceleration, and post-repair emails showing the issue remained unresolved. After I notified the dealer in writing that the hesitation/delayed acceleration concern remained after the most recent repair, I did not receive a documented response or resolution, and the concern remains unresolved with Volkswagen Customer Care.
NHTSA complaint #11740065 — an unverified report by a vehicle owner.
On April 27, 2025, in [XXX] , the vehicle displayed a low coolant warning in the morning. The owner replenished the coolant as instructed, the warning cleared, and the vehicle was driven to work without incident. Later that day, while traveling southbound on [XXX] at approximately 60 mph, the engine overheat warning activated, forcing the driver to stop and pull over. The vehicle required two separate tows — first to the residence, then to the dealership the following day. On April 30, 2025, the dealership completed a full warranty repair replacing the engine head gasket and seals under TSB 2071245/1, a Volkswagen-issued Technical Service Bulletin acknowledging a known manufacturing defect in the 2022–2023 Taos cooling system, for which there is no recall issued. A formal case was opened with VW Customer Care prior to the repair visit and is on record. This incident occurred just before the vehicle’s warranty expiration at 30,000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11736809 — an unverified report by a vehicle owner.
This vehicle has ongoing drivability issues that have not been resolved despite multiple repair attempts involving engine-related components and repairs. The issue began in November 2024 while the vehicle was under warranty with coolant and engine warnings. At that time, I reported coolant loss, warning messages, hesitation during acceleration, and abnormal vehicle vibration. I was initially told no issue existed. Shortly after warranty expiration, the vehicle required a major head gasket repair in 2025 after continuing to exhibit the same coolant-related issues. In 2026, the vehicle required an additional engine-related repair involving a camshaft seal in the same area of the engine that had previously been dismantled and rebuilt. Despite these repairs, the same drivability symptoms remain. The vehicle intermittently hesitates during acceleration, particularly from a stop or during merging conditions, where engine RPM increases significantly before the vehicle responds. The vehicle also exhibits significant steering wheel and seat vibration at highway speeds and during extended driving. These conditions create a potential safety concern because the vehicle does not consistently respond as expected during acceleration and becomes unstable and uncomfortable to operate at highway speeds. The hesitation creates concern when entering traffic, crossing intersections, or attempting to accelerate in situations requiring predictable vehicle response. The issue has been repeatedly presented to the dealership and repair attempts have been performed, including major engine work, but the condition remains unresolved. The repairs were treated as separate isolated issues rather than a continuation of the original condition first reported under warranty. The vehicle has been out of service for approximately 43 days across these repairs. No loaner vehicle was provided during those periods. The vehicle remains in its current condition with unresolved issues.
NHTSA complaint #11735956 — an unverified report by a vehicle owner.
The contact's daughter owns a 2022 Volkswagen Taos. The contact stated that while her daughter was driving at an undisclosed speed, the engine coolant warning light illuminated. The vehicle was taken to an independent mechanic, who determined that the head gasket needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 35,000.
NHTSA complaint #11736017 — an unverified report by a vehicle owner.
This vehicle has a known design flaw which causes the cylinder gasket to leak and require replacement. VW has only issued a Technical Service Notice which was no provided to owners regarding the part that needed replacement. They are correcting the problem with a differently designed part in order to try to cure the design flaw. This can cause catastrophic engine failure. It should have been a recall. I should have been notified and the car should have been repaired at VW’s expense. They have explained since your agency didn’t issue a recall, they dot need to inform the public. Now they are expecting me to pay $3000 to correct their design error and also pay for rental car while it is under repair. This is a major violation of the lemon law, and yet there are numerous verified complaints. Issue a recall on the 2023 Taos, they are clearly scamming owners and leaving them in danger with a vehicle that has a faulty engine part. Owners like me, should have their car repaired by the responsible party, VW
NHTSA complaint #11734447 — an unverified report by a vehicle owner.
The vehicle suffered a recurring mechanical failure of the fuel injectors and a flooded EVAP charcoal canister, causing the engine to run lean (Fault P2177) and lose power. This defect creates an unreasonable safety risk as it can cause the engine to stall or lose motive power unexpectedly at highway speeds. Furthermore, the fuel system defect led to a flooded EVAP system, which poses a potential fire hazard and fuel vapor accumulation. Volkswagen Technical Assistance confirmed the mechanical failure of all four injectors . The defect was initially misdiagnosed as 'fuel contamination,' which delayed the critical safety repair for over 25 days and resulted in a total electrical system failure (battery death) while the vehicle was inoperable.
NHTSA complaint #11734257 — an unverified report by a vehicle owner.
My 2025 Volkswagen Taos is exhibiting active symptoms of a known safety recall involving electrical system malfunctions. The vehicle experienced multiple failures including the instrument cluster going blank, screens shutting off, and a false start condition where the dashboard illuminated with multiple warning lights. The vehicle became inoperable and required towing to a Volkswagen dealership. The dealership confirmed that the symptoms are consistent with the current recall but stated there is no available remedy at this time. They insist the vehicle be returned to me after only charging the battery, without any repair addressing the recall condition. I refused. I do not consider the vehicle safe to operate given the ongoing electrical failures and lack of an available fix. This complaint is being filed because a recalled vehicle is actively experiencing the defect, and the manufacturer is unable to provide a repair or safe interim solution.
NHTSA complaint #11734340 — an unverified report by a vehicle owner.