708 of the
3,473 complaints filed about the Volkswagen Tiguan
are about the engine —
20% of everything owners reported.
The worst model year for it is 2022.
I brought my vehicle to the dealership because it was shifting itself into Park while I was driving. I have brought the car in four times. During the last two visits, the dealership performed a system update called **VW 47DM Collision Vehicle Software Update for Travel Assist/Emergency Assist**. Immediately after leaving the dealership following these updates, my vehicle developed additional and more serious problems. The infotainment system stops working for several minutes at a time before turning back on. The vehicle is also now displaying a “Front Assist Not Available” warning. In addition, the vehicle jerks violently while driving forward or accelerating, and the front end is making a grinding noise. This software update has made my vehicle worse than it was before. I have contacted Volkswagen Customer Care multiple times, but I have been denied assistance because there is reportedly no diagnostic code in the system. However, I have video evidence of these issues occurring while driving. Volkswagen has refused to repair the vehicle or take it back despite these ongoing problems. A vehicle shifting into Park while driving, jerking during acceleration, displaying a Front Assist warning, and experiencing other system failures presents a serious safety hazard to me, my passengers, and others on the road.
NHTSA complaint #11758908 — an unverified report by a vehicle owner.
The contact owns a 2020 Volkswagen Tiguan. The contact stated that while the outside temperature was cool, the vehicle operated normally. However, when the heat index was high, the message that the starter was hot was displayed. Shortly afterwards, the instrument cluster went black, and the vehicle stalled. The driver was able to coast the vehicle to the roadside. The contact waited approximately five minutes and restarted the vehicle. While driving in a subdivision, the vehicle stalled again. The local dealer was contacted, but there was no response despite the contact leaving a voicemail. The vehicle had not been diagnosed or repaired. The manufacturer had not been notified of the failure. The approximate failure mileage was 63,000.
NHTSA complaint #11757871 — an unverified report by a vehicle owner.
2022 VW Tiguan SE had PCV (positive crankshaft ventilation) also known as air-oil separator failed just outside of warranty creating a pressure cooker like effect in the engine which caused several seals and hoses, (such as the upper/front timing cover gaskets, rear main seal, and valve stem seals) to fail. The oil pan gasket was also destroyed. Although I was fortunate enough to be able to drive from my house around the corner to my local mechanic, this could have become a dangerous scenario considering most of my driving is done on busy freeways -- this could have caused severe oil slicking, sudden loss of power, and/or total engine failure. All of which could have resulted in a fatal, multi-vehicle accident. This appears to be a relatively common incident involving this particular year and model according to a New Jersey federal case ([XXX] et al v. Volkswagen [XXX] et al.), and several other complaints found. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11757593 — an unverified report by a vehicle owner.
On August 14, 2026, I brought my Volkswagen, with approximately 7,500 miles and still under warranty, to Bay Ridge Volkswagen, an authorized Volkswagen dealership in Brooklyn, NY. At approximately 8:00 AM, the dealer informed me that my vehicle had an applicable recall/service campaign and that several updates would be performed, in addition to scheduled maintenance. I was instructed to leave the vehicle until approximately 4:00 PM. At approximately 4:00 PM, dealership personnel specifically told me that the vehicle was ready. I accepted the vehicle and drove away. Immediately after leaving, I discovered that the engine warning/check-engine light was still illuminated. I immediately returned to the dealership. Only after returning was I informed that the problem associated with the warning light had apparently not been completed or resolved. I spoke directly with technical personnel and was told that some technicians had already left for the weekend and that the vehicle might require replacement of a component. The exact component responsible for the warning light is currently UNKNOWN. The vehicle remains available for inspection. My safety concern is that an authorized Volkswagen dealer represented the vehicle as ready and released it for operation while an engine warning condition remained unresolved and while dealership personnel were apparently still uncertain whether a component required replacement. The warning light was present immediately when I drove away from the dealership. The dealership had possession of the vehicle from approximately 8:00 AM until 4:00 PM that day. I have requested from Volkswagen the diagnostic trouble codes, technician notes, details of the applicable recall/service campaign, confirmation of what work was actually completed, and written confirmation as to whether the vehicle is safe to operate. The vehicle has only approximately 7,500 miles. I am requesting that NHTSA review this incident and the unresolved warning condition
NHTSA complaint #11757132 — an unverified report by a vehicle owner.
What component or system failed or malfunctioned, and is it available for inspection upon request? During a multipoint inspection that was earlier than advised due to multiple dashboard lights engaging, we were told that our car has an oil leak due from the timing covers and lower pan seal. They removed the oil separator and found value stem seals to be out towards the exhaust side creating an oil leak that stemmed from blown timing covers and the lower oil pan seal being the cause of the leak. The oil separator was noted as failed. This car has been brought in for every inspection and continued to have lights on post inspection that we were told regularly that they forgot just to turn off the lights but that the oil had been changed. In fact, our next oil change wasn't due until February 2027. How was your safety or the safety of others put at risk? Our safety has been put at risk driving a car with a substantial oil leak and faulty components that only seem found after we are 8,000 over the warranty. In searching the internet, this oil valve and leak situation is common in 2022 Tiguans enough so that there are multiple threads and articles about it. Has the problem been reproduced or confirmed by a dealer or independent service center? The dealer confirmed that this is an ongoing issue with these cars and that Volkwagen may be looking into doing a rebate for repairs. That doesn't fix the issue with the safety of the vehicle. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? We will be checking in with our insurance provider as well as an independent service center after dealing with Heritage Volkswagen Group due to our warranty. That warranty obviously provided us nothing for its cost or coverage. The lights were present and always brought in to be checked at the dealer we bought the car from. Again, we were always told that the lights didn't mean anything and they were left on after service accidentally
NHTSA complaint #11756299 — an unverified report by a vehicle owner.
The contact owns a 2018 Volkswagen Tiguan. The contact stated that while driving 70 MPH, there was an engine failure, and internal parts fell apart and started grinding into the oil pan. The message "LIMP Mode” and the vehicle failed to exceed 4,000 RPM. The vehicle was towed to the dealer. The dealer stated that the engine needed to be disassembled to be fully diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.
NHTSA complaint #11755859 — an unverified report by a vehicle owner.
PCV value/oil leak is a known issue with this specific model of car. The repair I was quited was over $2700 when the car is just out of warranty. There was no oil light indication showing that the oil was low! I only checked everything out because I saw oil in the drive way. The car read zero oil on the dip stick. I added 4 quarts and finallt started to get into operating range. My wife drives this car and could have been in a major accident if it hadn't been noticed. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755894 — an unverified report by a vehicle owner.
The car, a 2019 VW Tiguan, had a “check engine” light come on, and the resulting diagnosis and repairs - using VW’s specific engine fault codes - led to the replacement of both water pumps at 72,000 miles. An investigation of the water pump problem on such cars revealed that Volkswagon previously settled a major nationwide class-action lawsuit (apparently kept secret) covering certain 2014–2021 models with 1.8L and 2.0L engines. This resulted in an extended warranty covering the repair or replacement of failed water pumps. For some reason our car was not covered by the extended warranty, even though the engines in the 2017 Tiguans are all the same. Why weren't we, as the owners of a 2019 Tiguan, notified of the results of the class-action lawsuit, and given the extended warranty? I want to know the difference between the water pumps in the affected vehicles, and the one in our car. The water pump # in her Tiguan is identified as O6L 121 111 M. What differentiates her water pump from those covered by the settlement? Why are we forced to pay a good deal of money to correct a pretty disturbing VW design flaw (a plastic water pump), when others aren’t?
NHTSA complaint #11755432 — an unverified report by a vehicle owner.
My name is [XXX], and I am writing today to express my complete frustration mentally and financially with a CPO 2021 Volkswagen Tiguan (VIN [XXX]) I purchased XXX. To date my vehicle has been in for service multiple times – countless times for an issue with the infotainment system and driver warning indicators that is still unresolved and again for months waiting on a new engine due to an oil consumption issue that was finally resolved November of 2025 (Case XXX). My recent service visit on XXX was due to a “12 v battery not charging” error message. The vehicle was immediately taken to VW of [XXX] where we were advised it would be 3 weeks before my vehicle would even be looked at (which is atrocious) and not to drive it because further damage would be caused with no alternative solution offered for transportation. I then had the vehicle towed to a repair shop where I was advised the alternator “fried a 400-amp fuse and killed the battery, which should not happen, especially on a vehicle that has less than 50,000 miles on the odometer.” I paid $1,605.37 for a new alternator, 400-amp fuse and battery. Completely appalling and disappointing considering I take excellent care of my vehicle and it is supposedly an inspected, certified pre-owned vehicle – that’s a lemon in my opinion! I am seeking reimbursement for this huge expense for a vehicle that should not have these issues! I look forward to a resolve to this urgent complaint. Regards, INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755246 — an unverified report by a vehicle owner.
The vehicle has experienced multiple intermittent electrical and safety-related malfunctions that have become more frequent over time. The most serious issue involves the Automatic Emergency Braking system activating unexpectedly while the vehicle is slowly reversing out of a residential driveway. The brakes suddenly apply with significant force even when there is no visible obstacle behind the vehicle. This causes the vehicle to stop abruptly, jerks all occupants forward, and creates a risk of being struck by other vehicles because the sudden stop is unexpected. The vehicle has also experienced an intermittent engine shutdown while stopped in traffic. While waiting at a stoplight or waiting for another vehicle to reverse, the engine will unexpectedly shut off and a message appears instructing the driver to place the vehicle in Park. This creates a safety hazard because the vehicle cannot continue moving until it is restarted. Additional intermittent electrical issues include the infotainment/navigation screen freezing or glitching, the air conditioning unexpectedly blowing warm or hot humid air instead of cold air, and the horn failing to operate properly. The horn will sometimes not sound at all or will be much quieter than normal, reducing the driver’s ability to warn other motorists or pedestrians in an emergency. These problems occur intermittently and without warning. There are no consistent warning lights prior to the failures other than the message instructing the driver to place the vehicle in Park when the engine shuts off. The unexpected braking, engine shutdown, and horn malfunction create significant safety concerns for the driver, passengers, pedestrians, and other motorists. The cause of these issues is UNKNOWN.
NHTSA complaint #11755378 — an unverified report by a vehicle owner.
My 2014 Tiguan, VIN [XXX], has been serviced at an authorized VW dealer since I purchased it. From 2014 to December 2025, the vehicle was serviced at a VW dealer and March 2026 to present at a service facility that only works on VWs and is owned and operated by a prior VW certified technician who only works on VWs. My vehicle has been serviced at all the VW recommended maintenance mileage. Looking back at the maintenance records, I can see that in March and August 2025, my vehicle experienced a check engine light issue that resulted in EVAP system small leak fault and vibration at start up caused by misfire cylinder. In April 2026, June 2026 and July 2026, I had to take my Tiguan in because I felt the engine shake, check engine light came on and power decrease. The VW technican replaced some components related to the turbocharger system in April and the check engine light turned off. The check engine light turned back on in June in June and July 2026. The technician stated the issue was likely a airflow flap within the turbocharger causing the issue and the entire turbocharger would have to be replaced to remedy the issue. I discovered the recent class action settlement on this same issue and shared it with my mechanic. His professional opinion was that the issues I was having were exactly what was covered in the settlement covering my vehicle but i had 94k miles and had to have less than 85k miles. So, I was not covered because of the mileage. But I believe the issues the vehicle had going back to March 2025, were all turbocharger issues. In any case, my mechanic reached out to VW to get assistance because of the mounting repair costs for me and for all of his other VW owners experiencing turbocharger defects. It is my hope that others have shared similar complaints in search of relief from NHTSA investigating the defective VW turbocharges. VW has a negative track record on it's turbochargers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755013 — an unverified report by a vehicle owner.
The vehicle logged code P0491 due to a clogged cylinder head internal port at 28,000 miles (26,000 at the time vehicle was inspected.) Volkswagen's official repair protocol requires a complete engine cylinder head replacement. The vehicle's onboard computer has disabled the factory-installed remote start system as a result of this engine fault.
NHTSA complaint #11755056 — an unverified report by a vehicle owner.
Our 2018 Volkswagen had a light that came on so we took to dealership. The part that needs replaced is the cylinder head assembly which will be over $6000 plus $3k for timing. It will take over 28 weeks to get the part. So the car is not able to be driven. After looking into this, this is a known issue and there is a class action lawsuits going on right now. There are 4,600 back order parts nationwide. This is a defective part that the company has not recalled. The dealership is aware also that this is a known issue. There was not an injury but they say it is unsafe to drive. Volkswagen has no resolution for problem for a known defect part.
NHTSA complaint #11754799 — an unverified report by a vehicle owner.
This vehicle is burning oil! I have stayed on top of getting the regular/required oil changes but inbetween we have had to constantly top off the oil. I also get all oil changes at the dealer. Last time when I complained about it the guy told me that it would be a lot of work to try to find out why and left it at that. My warranty expires in November and I don't want to get burned by this by needing a new engine!
NHTSA complaint #11754140 — an unverified report by a vehicle owner.
My Tiguan leaks and burns oil like crazy. Now it has 111k miles on it, but this has been an ongoing issue for the last five years since I've had it. I now have to put a quart of oil in every 100 miles. This is not the fault of me getting an oil change, this is a persistent problem caused by the manufacturing of the car. I have had the engine nearly seize up while driving on the freeway due to low oil from this issue. Please investigate and fix.
NHTSA complaint #11754156 — an unverified report by a vehicle owner.
The contact owns a 2022 Volkswagen Tiguan. The contact stated that while stopped at a traffic light on an extremely hot day, the message that the starter was hot was displayed and the vehicle shut off unexpectedly. On another occasion, while making a turn, the vehicle stalled and lost power. The contact was able to safely coast over to the emergency lane. After waiting for the engine to cool down, the vehicle was restarted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 67,000.
NHTSA complaint #11752979 — an unverified report by a vehicle owner.
The contact owns a 2025 Volkswagen Tiguan. The contact stated that while driving 30 MPH, the vehicle suddenly stopped. The check engine warning light was illuminated. The message “Service Now” was displayed. The vehicle was taken to the local dealer, where it was diagnosed with fuel pressure sensor and fuel system sensor failure. The vehicle was repaired, but the failure reoccurred. The manufacturer was contacted, and a grievance was filed. The failure mileage was approximately 7,500.
NHTSA complaint #11750999 — an unverified report by a vehicle owner.
XXX my Tiguan was serviced at Byers VW and received the recommended 80k maintenance. During this recommended service my vehicle passed the multi-point inspection except tires and brakes. On XXX I contacted your service department because as I was driving to [XXX] my check oil level came on. An appointment was scheduled for Tuesday. After the inspection was completed Tuesday it was determined that the value seal needed to be replaced which was already completed 25k miles prior therefore a request to replace the cylinder head would be sent to my warranty company which is through VW Drive Easy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11750842 — an unverified report by a vehicle owner.
Excessive oil consumption. Check Oil Level light comes on repeatedly between oil changes. The vehicle is available for inspection upon request. The dealer has now looked at the issue 2x. Potential safety issue should the engine be affected while driving. The problem has not been reproduced by the dealer. The vehicle has been inspected by the dealer 2x. 1st issue appeared at approx. 33k miles and again at about 35k miles.
NHTSA complaint #11750506 — an unverified report by a vehicle owner.