Owners have filed 46 complaints
about the 2022 Volvo XC40 with NHTSA between 2021 and 2026.
The largest single group is the driver assist & collision avoidance.
Across this model's run it ranks 5 of 7 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 49
Against the median year of the Volvo XC40. 50 means typical for this
model; 100 means roughly double.
Severity — 90
17.4% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
100% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Camera
1250.0%
Automatic Emergency Braking
312.5%
Warnings
312.5%
Accelerator Pedal
28.3%
Exterior
14.2%
Rearview System Braking
14.2%
Blind Spot Detection
14.2%
Camera System
14.2%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
114.3%
1,000 – 9,999 miles
457.1%
10,000 – 24,999 miles
114.3%
25,000 – 49,999 miles
114.3%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Sep 2021peak 11Jan 2026
Recalls on the 2022 Volvo XC40
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
25V908000
BACK OVER PREVENTION:SOFTWARE
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Risk: A rearview camera image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.
25V282000
BACK OVER PREVENTION:SOFTWARE
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Risk: A rearview camera image that does not display reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.
21V109000
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM):SOFTWARE
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2022 XC40 Recharge vehicles. The Battery Energy Control Module (BECM) microprocessor may reset and cause the high voltage system to disconnect.
Risk: A disconnected high voltage system can cause a loss of drive power, increasing the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202571840,673 units in Canada
Visual System
Issue: On certain vehicles, a software problem could cause the rearview camera image not to display when the transmission is shifted into reverse. Note: This recall replaces Transport Canada recall no. 2025-233. Vehicles that were repaired under that recall also require this repair. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Volvo will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the vehicle software. Alternatively, you may schedule an appointment to have the update performed at a Volvo dealership.
Recall 202523340,673 units in Canada
Visual System
Issue: On certain vehicles, a software problem could cause the rearview camera image not to display when the transmission is shifted into reverse. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Volvo will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the vehicle software. Alternatively, you may schedule an appointment to have the update performed at a Volvo dealership.
Recall 202259531,117 units in Canada
Visual System
Issue: On certain vehicles, a software problem could cause the top-view camera to display instead of the rearview camera image when you are reversing. Canadian regulations require the rearview image to display when reversing. Note: This recall only affects vehicles equipped with a 360-degree park assist camera. Safety Risk: A rearview camera image that does not display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Volvo will notify owners in writing and send a wireless over-the-air update to each vehicle. If the update cannot be completed successfully, or for vehicles without over-the-air (OTA) update capability, Volvo will instruct you to schedule an appointment to have the update performed by a dealer.
Recall 2022216459 units in Canada
Electrical
Issue: On certain XC40 Recharge models, water may enter the wire harness for the accelerator pedal. If this happens, the accelerator pedal may not work properly. This problem could also cause the vehicle not to start. Safety Risk: An accelerator pedal that does not work properly could cause a loss of power to the wheels or a sudden unintended acceleration. Both could increase the risk of a crash. Corrective Actions: Volvo will notify owners by mail and instruct you to take your vehicle to a dealership to add a cable splice to the accelerator pedal wiring.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 33,710 milesThornton, COCrash
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2022 Volvo XC40. The contact stated the vehicle was in park, with no accelerator pedal or brake pedal being depressed when it experienced an unintended acceleration. As a result, the vehicle crashed into a pole where it came to a stop. The air bags did not deploy. A police report was not filed. No warning lights were illuminated on the vehicle. The contact mentioned the auto braking did not engage along with the other equipped safety features. The vehicle was restarted and driven to the owner's residence where it remains. The vehicle was not diagnosed or repaired. The local dealer and manufacturer were notified of the failure, and a case was opened with the manufacturer. The failure mileage was 33,710.
NHTSA complaint #11563100 — an unverified report by a vehicle owner.
at 7,000 milesLong Beach, CACrash1 injured
AIR BAGS
The contact owns a 2022 Volvo XC40. The contact stated while dropping off her niece at school, the vehicle was at a complete stop with the brake pedal depressed; however, the vehicle accelerated unintendedly and drove over the pavement. The brake pedal was depressed but failed to respond. The vehicle crashed into the wall of the school and crashed into the school fence. The curtain air bags were deployed; however, the front driver's side air bag failed to deploy. The contact sustained pain in the right shoulder. The contact received medical assistance the following day. A police report was filed. The vehicle was towed to a tow lot. The manufacturer was notified of the failure and referred the contact to a Volvo Collision Center. The Volvo Collision Center took the vehicle to their location and informed the contact that they were awaiting a Volvo engineer to diagnose the vehicle. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 7,000.
NHTSA complaint #11508568 — an unverified report by a vehicle owner.
at 7,000 milesLong Beach, CACrash1 injured
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2022 Volvo XC40. The contact stated while dropping off her niece at school, the vehicle was at a complete stop with the brake pedal depressed; however, the vehicle accelerated unintendedly and drove over the pavement. The brake pedal was depressed but failed to respond. The vehicle crashed into the wall of the school and crashed into the school fence. The curtain air bags were deployed; however, the front driver's side air bag failed to deploy. The contact sustained pain in the right shoulder. The contact received medical assistance the following day. A police report was filed. The vehicle was towed to a tow lot. The manufacturer was notified of the failure and referred the contact to a Volvo Collision Center. The Volvo Collision Center took the vehicle to their location and informed the contact that they were awaiting a Volvo engineer to diagnose the vehicle. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 7,000.
NHTSA complaint #11508568 — an unverified report by a vehicle owner.
at 7,000 milesLong Beach, CACrash1 injured
SERVICE BRAKES, HYDRAULIC
The contact owns a 2022 Volvo XC40. The contact stated while dropping off her niece at school, the vehicle was at a complete stop with the brake pedal depressed; however, the vehicle accelerated unintendedly and drove over the pavement. The brake pedal was depressed but failed to respond. The vehicle crashed into the wall of the school and crashed into the school fence. The curtain air bags were deployed; however, the front driver's side air bag failed to deploy. The contact sustained pain in the right shoulder. The contact received medical assistance the following day. A police report was filed. The vehicle was towed to a tow lot. The manufacturer was notified of the failure and referred the contact to a Volvo Collision Center. The Volvo Collision Center took the vehicle to their location and informed the contact that they were awaiting a Volvo engineer to diagnose the vehicle. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 7,000.
NHTSA complaint #11508568 — an unverified report by a vehicle owner.
at 300 milesSan Francisco, CA1 injured
STRUCTURE
The contact owns a 2022 Volvo XC40. The contact stated that material used to manufacture the rear lift gate parcel shelf in the vehicle would fracture when touched, causing small fiberglass shards to become stuck in the skin. The cause of the failure was not yet determined. The manufacturer and local dealer were both notified of the failure but no assistance was provided. The failure mileage was 300.
NHTSA complaint #11459123 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Greenbrae, CA
FORWARD COLLISION AVOIDANCE: WARNINGS
I am reporting a safety-related defect involving the Automatic Emergency Braking (AEB) system in my vehicle. The AEB system has repeatedly activated without any apparent reason, causing the vehicle to brake suddenly when there are no obstacles, vehicles, pedestrians, or road hazards present. These events have occurred under normal driving conditions. I have taken the vehicle to the dealership at least five times (possibly more) for this same issue. Each time, the dealer has stated that the vehicle is “operating as designed” or that they were unable to identify or correct the problem. Despite these visits, the unintended braking continues to occur. There have been passengers in the vehicle during these incidents who witnessed the sudden, unnecessary braking and can confirm that no hazard was present at the time. This defect creates a serious safety risk, as unexpected braking could easily result in a rear-end collision or loss of control. I am increasingly fearful that this issue will cause an accident. I am submitting this complaint so NHTSA can investigate whether this defect affects other vehicles with the same system and take appropriate action to protect public safety.
NHTSA complaint #11713966 — an unverified report by a vehicle owner.
I am reporting a safety-related defect involving the Automatic Emergency Braking (AEB) system in my vehicle. The AEB system has repeatedly activated without any apparent reason, causing the vehicle to brake suddenly when there are no obstacles, vehicles, pedestrians, or road hazards present. These events have occurred under normal driving conditions. I have taken the vehicle to the dealership at least five times (possibly more) for this same issue. Each time, the dealer has stated that the vehicle is “operating as designed” or that they were unable to identify or correct the problem. Despite these visits, the unintended braking continues to occur. There have been passengers in the vehicle during these incidents who witnessed the sudden, unnecessary braking and can confirm that no hazard was present at the time. This defect creates a serious safety risk, as unexpected braking could easily result in a rear-end collision or loss of control. I am increasingly fearful that this issue will cause an accident. I am submitting this complaint so NHTSA can investigate whether this defect affects other vehicles with the same system and take appropriate action to protect public safety.
NHTSA complaint #11713966 — an unverified report by a vehicle owner.
Shawnee, KS
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Even after the last recall campaign, my vehicle still frequently fails to activate the backup camera with a message stating Backup Camera unavailable. The software update that was intended to resolve the issue has not worked. I've seen multiple other Volvo drivers complaining about the same issue online. This is regarding the following previous recall: Recall R10320 WAM Upgrade, Model Year 2021-2025 S60, V60, V60CC, S90, V90, V90CC, XC60, XC90, XC40, EX40, C40 and EC40 vehicles The supposed fix was provided in software version 3.5.14, and my vehicle is currently on 3.7.0
NHTSA complaint #11703383 — an unverified report by a vehicle owner.
Chevy Chase, MD
STEERING
While driving the power steering fails. This is after the dealer had installed a software fix for this problem
NHTSA complaint #11684162 — an unverified report by a vehicle owner.
Elmhurst, IL
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
The backup camera doesn't always work. There are times when you will put the car in reverse and it will attempt to display the backup camera but instead says camera is temporarily unavailable. There recently was a recall for this, twice, but the issue continues to occur.
NHTSA complaint #11681370 — an unverified report by a vehicle owner.
San Jose, CA
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
I was getting the "Rear Camera Not Available" warning, starting months ago. I received the notification of the Volvo recall R10320. I scheduled a software inspection/upgrade at the dealer. On July 8, the dealer installed the newer software that supposed to take care of it. Revision 3.6.4 was installed. It seemed okay for a week. Now the same warning message comes up about 25% of the time. Perhaps an even newer version may have fixed the issue? I made another appointment to check on it. But the dealer cannot see the car for another week.
NHTSA complaint #11677889 — an unverified report by a vehicle owner.
Arden Hills, MN
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
After recall took my car for repair to the volvo dealer. They installed the new software version 3.7 but it did not fix the problem..still i am getting backup camera not available massage.
NHTSA complaint #11677917 — an unverified report by a vehicle owner.
Laguna Hills, CA
ELECTRICAL SYSTEM
My vehicle is affected by the recall #R10320 or NHTSA # 25V282. The recall letter states that the dealerships have the updated software available to solve the back-up camera issue, also over the air update will solve the problem later if that is my choice. The problem is that I see this as just a marketing ploy to get me into the dealership and upsell me on something I don't want. The OTA update should be available at the same time the dealership has the software. This is not an acceptable situation. This issue has always been very annoying and inconvenient and continues to be so. I just don't want the inconvenience of going to the dealership where there should be an alternative.
NHTSA complaint #11677554 — an unverified report by a vehicle owner.
Austin, TX
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Car has had a previous software recall done at a Volvo dealership to address issues with the back-up camera, but even after the recall, the camera display is still frequently malfunctioning. When in Reverse, the back-up camera display often freezes for several seconds at a time while the car is in motion. This is very dangerous since anything moving behind the car (such as a small child or animal) is completely invisible until the display unfreezes. At least once a week the camera will fail to work entirely and just display a text error on screen: Camera is Temporarily Unavailable. This generally goes away on its own, but often takes putting the car into Park and back into Reverse. Occasionally, resetting the head unit is required to clear the problem.
NHTSA complaint #11677135 — an unverified report by a vehicle owner.
Las Vegas, NV
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Backing in to garage got camera not available, happens intermittently, cause is due to inherently underpowered CPU for head unit Volvo installed, it was out of date at time of manufacture, they have announced a new cpu for 2025/26 model year vehicles. Vehicle is on latest software that was supposed to address this issue
NHTSA complaint #11676303 — an unverified report by a vehicle owner.
Ofallon, MO
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
I was parked at the grocery store. Got in the car and selected Reverse. The Infotainment screen cleared and produced a Camera is Temporarily Unavailable. I tried the same thing several other times. Same result. My software level is 3.6.4. My understanding is this level includes the fix for Recall R10320.
NHTSA complaint #11673166 — an unverified report by a vehicle owner.
at 24,480 milesKansas City, MO
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
The contact owns a 2022 Volvo XC40. The contact stated while attempting to reverse the vehicle, the rearview camera not available message was displayed. The vehicle was repaired under NHTSA Campaign Number: 25V282000 (BACK OVER PREVENTION); by the previous owner however, the repair failed to repair the vehicle. The contact stated that the failure had occurred on several occasions. The manufacturer was notified of the failure, and informed the contact that a supervisor would reach out. The failure mileage was 24,480.
NHTSA complaint #11672883 — an unverified report by a vehicle owner.
Arlington, VA
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
On 7/5 car's cameras (all of them) went off again when and Camera Not Available message displayed on console. We had already gotten the NHTSA required software upgrade on 7/2 that was to correct this problem. Once the vehicle was turned off - and started again -- the cameras worked. But it's anyone's guess how long that will last. I called the dealership and they reported that "about two other vehicles" that had the recall and had their software upgraded also came back in with the same complaint. There's no remedy yet from Volvo. Just wanted you to know their "fix" in response to you is not really a "fix."
NHTSA complaint #11671576 — an unverified report by a vehicle owner.
Mechanicsburg, PA
POWER TRAIN
In the past 3 months, my 2022 Volvo XC40 has experienced four complete power failures, each requiring a tow. 1️⃣ The first incident occurred while waiting at a left-turn lane; the car stalled and would not restart. 2️⃣ The second incident happened at a car wash where the vehicle died mid-process and could not be restarted. 3️⃣ The third incident was the most dangerous—while driving at 50–60 mph on a single-lane road, the car suddenly lost all power. I was fortunate to find a safe spot to pull over. 4️⃣ The fourth incident occurred on July 4th while I was visiting a town 2.5 hours from home. After stopping for gas, the car wouldn’t restart and had to be towed to a local Volvo dealership. These repeated failures create a serious safety risk, especially for drivers like myself who use highways regularly. Sudden loss of power at high speeds could result in a collision or leave occupants stranded in dangerous situations.
NHTSA complaint #11671271 — an unverified report by a vehicle owner.
Mechanicsburg, PA
ELECTRICAL SYSTEM
In the past 3 months, my 2022 Volvo XC40 has experienced four complete power failures, each requiring a tow. 1️⃣ The first incident occurred while waiting at a left-turn lane; the car stalled and would not restart. 2️⃣ The second incident happened at a car wash where the vehicle died mid-process and could not be restarted. 3️⃣ The third incident was the most dangerous—while driving at 50–60 mph on a single-lane road, the car suddenly lost all power. I was fortunate to find a safe spot to pull over. 4️⃣ The fourth incident occurred on July 4th while I was visiting a town 2.5 hours from home. After stopping for gas, the car wouldn’t restart and had to be towed to a local Volvo dealership. These repeated failures create a serious safety risk, especially for drivers like myself who use highways regularly. Sudden loss of power at high speeds could result in a collision or leave occupants stranded in dangerous situations.
NHTSA complaint #11671271 — an unverified report by a vehicle owner.
Mechanicsburg, PA
ENGINE
In the past 3 months, my 2022 Volvo XC40 has experienced four complete power failures, each requiring a tow. 1️⃣ The first incident occurred while waiting at a left-turn lane; the car stalled and would not restart. 2️⃣ The second incident happened at a car wash where the vehicle died mid-process and could not be restarted. 3️⃣ The third incident was the most dangerous—while driving at 50–60 mph on a single-lane road, the car suddenly lost all power. I was fortunate to find a safe spot to pull over. 4️⃣ The fourth incident occurred on July 4th while I was visiting a town 2.5 hours from home. After stopping for gas, the car wouldn’t restart and had to be towed to a local Volvo dealership. These repeated failures create a serious safety risk, especially for drivers like myself who use highways regularly. Sudden loss of power at high speeds could result in a collision or leave occupants stranded in dangerous situations.
NHTSA complaint #11671271 — an unverified report by a vehicle owner.
Elmhurst, IL
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The front driver or passenger doors do not open 100% of the time when pulling on the handle. This behavior happens after the car has been unlocked. It happens when pulling at an angle that is slightly up and quick in motion. If you pull directly out, away from the car body, and slower it will open up without issue. I was able to reproduce the behavior at the dealership and was informed that Volvo doors don't open when you do that quick of a motion. Based off that response I do not believe the dealership inspected the door mechanism but instead left it as an accepted issue with the car. I fear if there were a situation when I needed to get into the car immediately it may require multiple pulls on the door handle to work properly.
NHTSA complaint #11670584 — an unverified report by a vehicle owner.
Elmhurst, IL
STRUCTURE:BODY:DOOR:HANDLE:EXTERIOR
The front driver or passenger doors do not open 100% of the time when pulling on the handle. This behavior happens after the car has been unlocked. It happens when pulling at an angle that is slightly up and quick in motion. If you pull directly out, away from the car body, and slower it will open up without issue. I was able to reproduce the behavior at the dealership and was informed that Volvo doors don't open when you do that quick of a motion. Based off that response I do not believe the dealership inspected the door mechanism but instead left it as an accepted issue with the car. I fear if there were a situation when I needed to get into the car immediately it may require multiple pulls on the door handle to work properly.
NHTSA complaint #11670584 — an unverified report by a vehicle owner.
Las Cruces, NM
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Hi, I have a 2022 Volvo XC40 Recharge (Full Electric) I and EVERYONE else has had issues with the back-up camera flickering and going out completely and giving a "Camera Not Available" message on the screen in the car. Volvo has said a few times they have a fix for this issue. And the latest vehicle OS update 3 5.24 which I had installed at the dealer last week said they fixed the issue. They have NOT. I am still getting the message and no camera. This is not an isolated issue. I am member of a Volvo XC40 recharge forum and this issue is on all cars. It's a software issue. Its very dangerous to start backing up with the camera on and then all of a sudden it goes out. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11664927 — an unverified report by a vehicle owner.
Arden Hills, MN
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
When I tried to back up my car, the backup camera on the screen keeps displaying temporarily unavailable warning on the screen. This happens 5 out of 10 times...
NHTSA complaint #11661552 — an unverified report by a vehicle owner.
Rancho Palos Verdes, CA
UNKNOWN OR OTHER
My car was sitting inside my garage, and just formed a crack, with no external disturbance. There is absolutely no way this was caused by external damage. You will see in the pictures that there is no external damage, and you can mainly see the crack looking up from inside the car. If you look at pictures of the glass, you see that the crack is on the underside of the glass, and that there is no single point of impact (like a radial crack, or chip, or anything on the outside surface). The Volvo dealership I took my car to said that even if it is a defect or an installation issue, that Volvo would do everything in their power to deny my claim. The dealer said they will document that that this was caused by external damage like a rock hitting the roof, even though I told them several times that the car was not being driven and was sitting inside my garage for months. I asked the dealer if they could show me exactly where the damage was, if they could point out to me where he initial outside impact or chip was. The dealership could not specifically point out where the chip was. I have contacted Volvo customer service and filed ethical complaints. They have more or less admitted to denying warranty claims on false evidence. It is also clear that the dealer gets paid more if it is not done through warranty, so they have no incentive to tell the truth (that this was a manufacturing/installation defect) I have done plenty of online research and found that many many other Volvo xc40 owners have the same defect in cars between 2020-2022 (their roof glass forms a horizontal crack completely unprovoked.) [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11642785 — an unverified report by a vehicle owner.
Palo Alto, CA
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Backup camera not working: Repeated get no backup camera image - just see a black screen with message "Camera unavailable" or "Camera temporarily unavailable". This happens more often than the camera works. Seems to be related to OTA software update - had no camera problems for a most of the year and then after an OTA the camera issues began.
NHTSA complaint #11633941 — an unverified report by a vehicle owner.
Nashville, TN
SUSPENSION
Both front strut upper bearings failed with less than 30k miles. Continued noise coming from front end diagnosed as failed left strut, causing left upper bearing and strut to be replaced. Polestar 2, which uses the same assembly and Volvo have issues technical journals. Polestar is issuing an upgraded part, though it appears Volvo is not. Owner forums comment on this issue and it is well known with Volvo. A solution for the front suspension should be implemented under a recall as failure of these parts is premature and seems to represent a manufacturing defect.
NHTSA complaint #11578280 — an unverified report by a vehicle owner.
E. Dummerston, VT
FORWARD COLLISION AVOIDANCE: WARNINGS
I am on my third Volvo in ten years, a 2022 XC40 that I purchased in new from the dealer. It's actually my second Volvo XC40. However I have had serious safety issues with the current model as it has repeatedly engaged the anti collision braking nearly causing an accident on one of the 8-9 times this has happened. It was taken in to two different dealers multiple times for repeat errors with the anti collision system. Each time the system has activated - 8-9 times - the road conditions are perfectly fine and there are no cars or obstructions in the road. On a recent incident in 2023 my kids were thrown forward and all of our luggage ended up dispersed throughout the car. It was a hard brake from about 40 mph down to nearly zero before I could get control of the vehicle. The only warning was a message and red colors on the dashboard at the same time as the braking. If a car had been following me we would certainly have been hit from behind. It has been a terrifying experience with each inaccurate activation of the anti collision feature, but Volvo services in contact with Volvo engineers can't fix it. And they won't provide me with any details or access the computer to substantiate my claims. I contacted my salesperson out of desperation and he agreed that this wasn't normal. He submitted a request for a trade assist but it was denied by Volvo. I feel compelled to let other owners know as it is a very serious safety flaw that is being ignored by Volvo.
NHTSA complaint #11570507 — an unverified report by a vehicle owner.
I am on my third Volvo in ten years, a 2022 XC40 that I purchased in new from the dealer. It's actually my second Volvo XC40. However I have had serious safety issues with the current model as it has repeatedly engaged the anti collision braking nearly causing an accident on one of the 8-9 times this has happened. It was taken in to two different dealers multiple times for repeat errors with the anti collision system. Each time the system has activated - 8-9 times - the road conditions are perfectly fine and there are no cars or obstructions in the road. On a recent incident in 2023 my kids were thrown forward and all of our luggage ended up dispersed throughout the car. It was a hard brake from about 40 mph down to nearly zero before I could get control of the vehicle. The only warning was a message and red colors on the dashboard at the same time as the braking. If a car had been following me we would certainly have been hit from behind. It has been a terrifying experience with each inaccurate activation of the anti collision feature, but Volvo services in contact with Volvo engineers can't fix it. And they won't provide me with any details or access the computer to substantiate my claims. I contacted my salesperson out of desperation and he agreed that this wasn't normal. He submitted a request for a trade assist but it was denied by Volvo. I feel compelled to let other owners know as it is a very serious safety flaw that is being ignored by Volvo.
NHTSA complaint #11570507 — an unverified report by a vehicle owner.