The factory-installed mechanical water pump module suffered a severe internal seal and housing failure. This allowed pressurized engine coolant to migrate directly into the engine's vacuum control system and vacuum lines, damaging crucial emissions and vacuum tubing. This defect poses a severe safety risk as coolant entering the vacuum grid can cause sudden loss of engine power, erratic braking assist, and localized engine overheating while operating the vehicle at highway speeds.
NHTSA complaint #11757339 — an unverified report by a vehicle owner.
On XXX my 2014 Audi A6 failed to accelerate on a parkway. An EPC light appeared. I restarted. It reappeared and car was slow and shaky. I took right to nearest Audi dealership. The next day, they sent this video, admitting a common problem, and suggesting full engine replacement. [XXX] I have contacted Audi of America, Audi of Huntington and Audi of Manhattan. All refusing to help with our faulty engine. Further investigation shows so many cases on Audizone, North Anerican Audi Owners groups. Why was this not a recall? Could have been very dangerous highway accident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11752156 — an unverified report by a vehicle owner.
My 2019 Audi A6 was diagnosed with catastrophic internal engine failure on May 9, 2026 at Audi of Newton, Newton, NJ, at 93,645 miles. The vehicle required a full engine rebuild performed by REV Auto NJ at a cost of $12,000. The failure involved metal debris found in the engine oil, consistent with the documented EA839 3.0L V6 TFSI rocker arm needle bearing failure or piston skirt failure affecting this engine family. The EA839 engine used in this vehicle has a documented history of design defects: (1) Rocker arm needle bearings in early production engines were undersized and prone to disintegration, releasing metal debris into the oil supply and destroying camshaft lobes, balance shafts, and pistons. Audi silently revised the rocker arm part number three times (06M109417H -> 06M109417L -> 0P2109417), with the final revision featuring bearings twice the size of the originals - evidence of a known design defect. No recall was issued. (2) Audi of America issued a Piston Skirt Limited Warranty Extension in 2025 to 8 years/80,000 miles for EA839 piston failures. Independent engineering analysis by 034Motorsport, backed by laboratory testing, confirms that the EA839 piston design creates failure paths even under stock, unmodified conditions. Audi of America has not issued a safety recall for this engine failure pattern despite multiple documented failures across the A6, A7, A8, S4, S5, SQ5, Q7, and Q8 platforms sharing this engine. The failure mode - metal debris circulating through the lubrication system - poses a risk of sudden, complete engine loss while driving at highway speeds, creating an unreasonable safety risk to vehicle occupants and other motorists. I am requesting that NHTSA investigate the EA839 3.0T engine for a potential safety-related defect and consider whether a recall is warranted across the affected model population. I have incurred $12,000 in repair costs for a defect that evidence strongly suggests is a design flaw, not a maintenance issue.
NHTSA complaint #11749217 — an unverified report by a vehicle owner.
The car throw a EPC warning light which cause the car to go n limp mode. With doing research ot has to do with the transmission. This cause the car to drive sluggish unable to reverse at times unable to take the car out of park at times. It also cause the car to randomly shut off when reversing or at times when im sitting at a light n i begin to drive the car can randomly shut off at times. Which in my open is unsafe because what if the the person behind me isnt payimg attention and i get rear ended. Ive reached out to Audi dearlership is was told a part was discontiued and to bring it in for them to further diagnostic it. Ive had the codes read and im getting the symptoms of the code i pulled but told that part was discontiued. So i feel like if thats the case Audi should have did a recall on the car.
NHTSA complaint #11744229 — an unverified report by a vehicle owner.
I recently brought my 2019 A6 to Nyack Audi for an unrelated repair, after performing their complimentary inspection the service advisor told me my water pump was leaking coolant into the vacuum hose system; and the pump, PCV valve, sensors, solenoids and vacuum hose system need to be replaced, costing $6,186. My A6 was out of warranty at that point, so Audi would not pay for the $6,186 in repairs. Engine coolant purportedly leaks into the vacuum system and other electrical components, causing contamination of the vacuum system. Leaking coolant will cause an overheated engine and possible FAILURE of the (EA839)engine and even the turbocharger . Today I did some online research line research and discovered a class action lawsuit involving their 1.8 & 2.0 engine water pumps which failed prematurely for the same reason. A major class-action settlement (Zhao v. Volkswagen Group of America) was approved covering certain 2014–2021 Audi vehicles equipped with 1.8L and 2.0L engines. And now, there is a class action involving the 2.9 & 3.0 V6 engines; “the lawsuit alleges the water pumps are defective in Audi's 2.9-liter and 3.0-liter EA839 V-6s; these engines were available in nearly every Audi model on sale from the 2018 to 2024 model years. The lawsuit—Larr, et al., v. Volkswagen Group of America, Inc., et al. —has been filed in the U.S. District Court for the District of New Jersey”. Apparently, Audi has know about this issue since at least 2018 and done nothing to try and resolve it. Please put the pressure of the federal government on Audi to settle the lawsuit, DO THE RIGHT THING and cover the cost of repairs. Also find a solution to prevent this from happening to other Audi owners. I can’t afford $6,186 for a repair, nor go purchase a different vehicle…..Rock & a hard place. Please help. Thank you .
NHTSA complaint #11744302 — an unverified report by a vehicle owner.
The contact owns a 2021 Audi A6. The contact stated while driving at an undisclosed speed, the vehicle overheated. The engine overheating and the low coolant warning light illuminated. In addition, the engine seized. The vehicle was taken to the dealer where it was diagnosed with a coolant leak and a failed coolant pump vacuum. The contact was informed that the coolant pump vacuum assembly needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the failure was a known failure of the vehicle. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 80,000.
NHTSA complaint #11736958 — an unverified report by a vehicle owner.
Complete shut down of all electrical associated components while driving on highway Loss of power steering loss of braking loss of ability to accelerate transmission failure loss of lane detection, loss of car detection. Diagnosed as , faulty alternator recall repaired and continuation of same electrical failures despite six additional repairs Multiple failures of all electrical components on highway road and side roads
NHTSA complaint #11732943 — an unverified report by a vehicle owner.
2011 Audi A6 seems to be overlooked compared to the rest of the Audi’s yet the Audi has so many different issues such as timing chain such as water pump, such as brake issues, such as rack pinion yet there hasn’t been anyone investigating this in particular make a model it needs to be done for safety reasons. Additionally, I was never contacted for the airbags cars registered DMV and nobody has bothered to inform me of the New airbag issues. What other issues are there brought to one’s attention?
NHTSA complaint #11717713 — an unverified report by a vehicle owner.
My 2019 Audi A6 sedan displays warnings for the Start/Stop system malfunction indicated in Audi's document: "Emissions Service Action Code: 27BQ" [XXX] I'm still waiting to hear if this has been elevated to Recall status. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11712442 — an unverified report by a vehicle owner.
IT WAS RECENTLY BEGAN TO LEAK FUEL FROM THE TOP OF THE ENGINE CLOSE TO THE WINDSHIELD. THEN THE WHOLE CABIN SPECIALLY IN THE FRONT WHERE THE STEERING WHEEL BEGAN TO HAVE BAD VIBRATION DURING REVERSED, AND IDLE, ALSO WHEN THE AC IS ON. THEN THERES THE AIRBAG FOR THE PASSENGER, THE LIGHT IS ON, IT USED TO SAY '"OFF" THEN WHEN THE SEAT IS USED IT WILL SHUT OFF. NOW IT JUST STAYS ON. LAST IS THE AC COMPRESSOR SEEMS TO BE RATTLING LIKE A BOLT IS LOOSE. ALL THE RECALLS HAVE BEEN HAPPENING WITH MY AUDI AND STILL MY VIN IS NOT INCLUDED.
NHTSA complaint #11690179 — an unverified report by a vehicle owner.
The water pump on my 2016 Audi A6 has failed multiple times prematurely. The first water pump failed at 36,965 miles in May 2019. That repair was covered under an extended warranty I purchased. The second water pump failed around 83,000 miles in September 2025, and Audi is now quoting me $2,350 out of pocket to replace it. I am now facing a third water pump replacement, which is far earlier than expected for this type of component. These repeated failures create a significant safety concern, as sudden coolant loss can cause the engine to overheat, potentially leading to engine failure or loss of power while driving. Each problem has been diagnosed and confirmed by an authorized Audi service center. The vehicle was inspected by Audi technicians, and repairs were recommended both times. The repeated failure of this critical component strongly suggests a systemic defect with the water pump design on this model. Despite a recent Audi water pump settlement, my vehicle was excluded, even though it has now experienced two failures and is requiring a third replacement.
NHTSA complaint #11686225 — an unverified report by a vehicle owner.
This vehicle had a claim for water pump replacement and the 3.0 model has a recall for the turbo charger. This vehicle is experiencing the same issues and went from 70 mph to 0 and stalled on the freeway. Thankfully the semi and other vehicles were able to avoid me or my family would be reaching out instead of me. Currently the vehicle is parked in my garage because it is unsafe to drive. Can you please advise Audi to take responsibility and offer the same recalls on the 2.0 vehicles for the water pump and turbo charger because they have the same internal parts as the 3.0 vehicles that failed and these parts were covered.
NHTSA complaint #11650550 — an unverified report by a vehicle owner.
I purchased a 2014 Audi A6 2.0T Quattro premium plus on November 15, 2024 with 99,141 miles. I got the 14 day dealership extended warranty, which covered powertrain systems. After 3 days of driving exactly 103 miles the oil light came on my dashboard telling me that the oil was low. I immediately brought it back to the dealership and their mechanic look at it, he said there was nothing wrong and changed the oil so it should be good now. I drove it another 3 days 136 miles this time, and the oil light came on once again. Brought it back a 2nd time to the dealership’s mechanic. After about a week, we heard back and they told us he still couldn’t find anything wrong, but agreed that for some reason, the engine is consuming oil more than it should be. At this point we go to an actual Audi dealership where they tell us that the pistons and turbo were the problem so they would have to rip apart the engine and seal everything back up. At the time we purchased the vehicle on top of the 14 day dealership warranty we also purchased an extended warranty by a company called integrity warranty LLC. Our warranty company decided that they were not going to cover the cost of the parts and labor in order to fix my Audi, because they said it was a pre-existing issue prior to us purchasing the vehicle which we had not heard of before, or even seen on the Carfax report. On February 25 I was driving at night 25 mph and I came to a red light stopped my car and began smelling a very strange smell. Saw a lot of smoke coming from the exhaust in the back, the dashboard lights began flickering, the steering wheel start to shake, and then the car just shut down. Now I am without a vehicle, the dealership will not help us, the warranty company will not help us, and I now have to purchase a new car while still making payments on the Audi that doesn’t work.
NHTSA complaint #11646146 — an unverified report by a vehicle owner.
Yellow battery indicator light came on while driving car in 35 degree weather after a week of sitting in garage (holidays). I pulled over, read the manual and it said this could cause battery light to illuminate. I called the dealership service to ask them, they said possible reason. I decided to drive across city to dealership, 25 minutes away. On HOV lane, red warning lights flashing to pull over then 5 seconds later everything went black. No electrical, no engine, car died. VERY DANGEROUS!! Read later that this has been happening on Audi A6 (& other models) for 2+ years. Towed to dealership and they have had 1.5 weeks and still not fixed.
NHTSA complaint #11636241 — an unverified report by a vehicle owner.
The contact owns a 2015 Audi A6. The contact stated that while driving on neighborhood roads at approximately 25 MPH, the coolant warning light was illuminated. The contact proceeded to park on the side of the road and walk to her residence to pick up coolant to refill the coolant tank. The vehicle was then taken to the independent mechanic where it was diagnosed that the coolant tank needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 79,000.
NHTSA complaint #11620102 — an unverified report by a vehicle owner.