32 of the
226 complaints filed about the Audi E-Tron
are about the other systems —
14% of everything owners reported.
The worst model year for it is 2019.
From time to time the driver's door does not latch completely so the door is only partially closing. Dealer was able to duplicate the problem but will not replace (estimated cost for new door latch is just under $800.) at their expense. It appears that others have had the same problem. When driving the car air rushes into the vehicle as the door is not fully shut. I worry that this problem could be very serious should I be in an accident with a partially closed door rather than a fully closed door. The problem first appeared early in the winter and seems to be getting worse.
NHTSA complaint #11736149 — an unverified report by a vehicle owner.
Audi dealership charged fee for a repair that they the,selves acknowledged is under a technical service bulletin and despite my having extended warranty that is supposed to cover such repairs. This is for the main media interface going blank repeatedly every ~5 minutes or so while driving. Audi charged me for a repair that is a known safetyissue and is covered under warranty.
NHTSA complaint #11728247 — an unverified report by a vehicle owner.
Tied with NHTSA Recall 25V900 - Review Camera Software. Dealer was unable to complete the recall due to internal malfunction of USB Interface on vehicle. Dealer quoted a non itemized Repair Estimate of $1,045.50 to replace the interface in order to be able to complete the open recall. No visible user caused damage to interface and prior Technical Support Bulletin (2066315) for issues with USB covering specific vehicle. Given the dependence on software within our vehicles, the USB interface used to perform required recall work should be covered when failure is internal to the interface module.
NHTSA complaint #11718481 — an unverified report by a vehicle owner.
INCIDENT SUMMARY: On [XXX], I brought my 2019 Audi e-tron (VIN: [XXX] , 70k miles) to Audi Salt Lake City for Safety Recall 93U9 (High Voltage Battery Module). Vehicle was functioning normally with no warning lights or electrical issues. IMPROPER RECALL COMPLETION: The dealership's technician (Chris Miller, [XXX] ) documented in the service notes: "I FOUND THE GROUNDING STRAP FOR THE REAR MOTOR WAS NOT INSTALLED AND WAS TUCKED UP BETWEEN THE MOTOR AND THE COVERS." This proves the technician failed to properly reinstall the critical grounding strap during recall service, leaving it disconnected in the high voltage system. IMMEDIATE FAILURES AFTER RECALL: Following the recall service, multiple critical failures occurred: Voltage converter failure (part #4KE-907-171-C) Battery charging malfunction (limited to 100 miles range vs normal 200+ miles) Multiple stored fault codes and dashboard warning lights Rear drive motor faults Parking brake system failures All failures are consistent with loss of proper grounding in a high voltage EV system. SAFETY CONCERNS: The technician drove my vehicle 55 miles during service (odometer: 70,651 IN to 70,706 OUT). Why didn't they notice the warning lights during this excessive test drive? Operating a high voltage EV with improper grounding creates risk of electrical fire, shock hazard, and component damage. How many other vehicles at this dealership had recall 93U9 improperly completed? DEALER RESPONSE: Dealership attempted to charge me $2,089 for repairs caused by their incomplete recall work. When I disputed, the General Manager threatened to call police if I didn't return the loaner vehicle. No repairs were ever authorized by me. INVESTIGATION REQUESTED: Please investigate Audi Salt Lake City's recall 93U9 completion procedures and quality control. This is negligent completion of federal safety recall work that endangered my safety and may affect other e-tron INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11709462 — an unverified report by a vehicle owner.
The vehicle's central locking system does not properly communicate with the keyfob resulting in the doors not unlocking as intended. I have had my child in the car seat in the back and if i accidentantly touch the handle the wrong way the doors will lock and I am unable to use the unlock feature to get my kid out. This could be a serious safety issue if someone becomes trapped in the rear seat and the central locking system does not allow unlocking of the doors.
NHTSA complaint #11702257 — an unverified report by a vehicle owner.
On at least two occasions, my car suddenly accelerated when I was trying to reverse from a parking spot. The acceleration was very sudden. I did not even have my foot on accelerator at the time. This is extremely scary. In one occasion, I did hit a passing car as my car accelerated. Fortunately no one was hurt (or killed!), but had damage to both the cars. Second time when this happened, fortunately I was able to stop it before it hit any car behind me. On internet there are many Audi E-tron owners have similar experience either while reversing or simply while trying to park the car - the car accelerates without any warning. NHTSA need to force Audi to recall these cars and make needed corrections and updates as needed to prevent any further disaster due to this issue.
NHTSA complaint #11680439 — an unverified report by a vehicle owner.
The car sunroof has started leaking in which for they have released an extended warranty. Although my car at this falls under the 80,000 mile limit the dealership refuses to work in the car. This is a hazard as batteries and water do not work together as this is a electric car.
NHTSA complaint #11671233 — an unverified report by a vehicle owner.
I have a 2019 Audi eTron. The worse incident was when on the freeway, I had a warning signal then thankfully, I exited and was on feeder when he was completely stopped, towed to dealership and was told a major component engine equivalent or battery had to be repaired or replaced. There are records at Audi dominion. Regarding current complaint, I have reached out to Audi for maybe two l+ years? Trying to get safety recall for high voltage battery but they kept saying they have not received software part to remedy this.
NHTSA complaint #11666480 — an unverified report by a vehicle owner.
Charging limited to 80% for over 18months now with the safety recall. Batteries are degraded and range dropped to 130miles earlier this year. Ability to drive safely impacted by low battery warning on multiple occasions and forced reduced speeds in rush hour traffic during in city commute. Local dealership is pointing to Audi not sending replacement batteries and safety limitation of 80% charge.
NHTSA complaint #11662975 — an unverified report by a vehicle owner.
I was driving on the highway and my sunroof spontaneously exploded. Nothing hit it, but there was a loud noise like a gunshot and the roof exploded outwards. Shards of glass landed in front of the car behind me who swerved to avoid them.
NHTSA complaint #11657083 — an unverified report by a vehicle owner.
No specific incident, but the expected resolution date for this recall has been pushed out 3 or 4 times, and now there is no expected resolution date. I've already implemented the interim step for the recall and had to have a battery cell replaced, which took over 2 weeks for the dealership to complete. It's frustrating to constantly have a potential 2+ week fix hanging over our head, not to mention the fact that they recommend only using the vehicle at 80%, severely limiting our range, and, ultimately, the risk of the battery catching fire or exploding at any point! The recall has been open for almost a year and a half now, and it's only supposed to be a software update to fix it! I'd like to see them actually implement the final resolution!
NHTSA complaint #11653377 — an unverified report by a vehicle owner.
I'm deeply concerned about the safety risks my family faces due to unresolved Audi recalls. On December 19 and 20, 2023, Audi issued two recalls: one for high-voltage battery modules that may self-discharge, leading to overheating and an increased risk of fire, and another for the 220V/240V charging cable, which can overheat home wiring, posing a serious fire hazard. On September 19, 2024, I took my car to Niello Audi to address these recalls, but they advised me to take the car home despite the significant safety risks. The service representative told me I couldn't receive a replacement charging cable because I did not have the original one; as the second owner, I never received it from the previous owner. He also mentioned that there was no remedy available for the battery issue and to come pick up my car the next day. I'm using an aftermarket charging cable, which the representative warned could increase the risk of fire. But I cannot get the cable required because I do not have the original. I transport my two young children in this car, and the thought of driving an unsafe vehicle is terrifying. On September 20, 2024, I contacted Audi America to file a claim and initiate the buyback process, as there is no safe solution available. I expressed my urgent concerns and requested a loaner car while the buyback is processed, but my request was denied despite stating it clearly was a safety issue. The Audi America representative told me to pick up my car and drive it, even after acknowledging the safety risks. Niello Audi provided a loaner for only one week, which is not long enough to navigate this complex process. This situation has left me feeling incredibly unsafe. My home is at risk of fire due to the unresolved charging cable issue, and I continue to worry about driving a vehicle with these serious problems. The ongoing recalls create an alarming risk for me and my family.
NHTSA complaint #11615697 — an unverified report by a vehicle owner.
Subject: Formal Complaint Regarding Water Ingress and Electrical Damage – Seeking Damages Dear Audi Customer Service, I am writing to formally lodge a complaint regarding significant issues with my Audi vehicle, which have led to severe damage and financial loss. Below are the details of the incidents: Initial Incident of Water Ingress: A few months ago, my Audi experienced water ingress through the sunroof, causing water to enter the front of the vehicle. This issue was addressed and repaired by your dealership under warranty. Recent Incident of Water Ingress: From June 13 to June 15, during heavy rains in Florida, my vehicle was stationary and parked. On [XXX], while driving the vehicle, I noticed an electrical burning smell and had to stop immediately. All the lights were displaying errors. Upon taking the vehicle to the Audi dealership, it was discovered that there was water ingress into the battery area and the rear of the vehicle. Despite the previous repairs for water ingress, the recent inspection revealed extensive water damage. The dealership has stated that the damage cannot be repaired under warranty and provided an estimated repair bill of $23,000. Consequently, my insurance company had to declare the vehicle a total loss. Given the history of water ingress issues and the failure of the initial repair to prevent further damage, it is evident that there is a significant defect in the vehicle. It is unacceptable that such a defect has not been adequately addressed, posing a safety hazard to consumers. PLEASE INVESTIGATE AS I AM not the only victim of this problem and audi is aware. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11595973 — an unverified report by a vehicle owner.
I talked to an Audi representative and it appears there are recalls for sunroof leaking in various cars it was installed upon that include Volkswagen and Audi. My 2019 Audi was not included and the representative cannot explain why even though I have an identical issue with leakage from the sunroof. The exact problems that plagues other cars that were already given a recall. Instead of a recall, a TSB, was offered for my car but because it is not an actual recall, Audi will not pay for any repairs. From my online search, it looks like there was a class action lawsuit from a law firm called Milberg with my model included that was settled for extended the warranty of 8 years (2028) or 80k miles to repair the leaking sunroof. My car has a TSB and acknowledgment in the class action lawsuit that there was a faulty sunroof but because my car has 94k miles on it, Audi refuses to pay it. I believe that NHTSA needs to make an immediate recall for 2019 Audi E-tron for leaking sunroof because it is the same recall other cars have had with the same sunroof system installed, a class action lawsuit that offered payment for those not able to get the recall on their car, and Audi issuing a TSB because they know there is the same problem on my car. Audi keeps using the excuse that NHTSA didn't force them to make a recall on the 2019 Audi E-tron even though it suffers from the same problem as the other cars with the same sunroof system, so they are refusing to cover any costs to fix it.
NHTSA complaint #11583567 — an unverified report by a vehicle owner.
This vehicle is equipped with a hands free tailgate sensor to allow hands-free opening with a kick or wave of a foot under the rear bumper. The problem is that while we are standing at the back of the vehicle, loading or unloading items, the tailgate sensor will activate and the tailgate will begin to close, requiring quick action to get out of the way. This happens unpredictably and has occurred more than once. Of course, there is a chance of injury from the tailgate or when trying to suddenly move out of the way.
NHTSA complaint #11579861 — an unverified report by a vehicle owner.
Rearview and camera displays showed a blank screen. The instance showed up when the vehicle was in Reverse. The screen turned blank besides other features on the display such as camera views. Each view showed blank. An inoperative rearview camera display reduces the driver's rear visibility, increasing the risk of a crash.
NHTSA complaint #11574632 — an unverified report by a vehicle owner.
We have several recalls for this car the battery and the ball joints are bad we called the dealer for help with the issue and never received any update , we can not drive this car due to a fire hazard and it is a real safety issue for all the public and our selves we need help. Please help my family thanks and god bless.
NHTSA complaint #11567520 — an unverified report by a vehicle owner.
I discovered the following recall on your site but the AudiUSA site does not show the issue. I am alarm at the serious nature of this recall and Audi is only saying it does no have a remedy yet. that is unacceptable considering what could happen. We need a faster remedy to this very dangerous situation. A timely manner is right now, not later in the year. Dec 20,2023 Manufacturer Recall Number93U9 NHTSA Recall Number23V867 Recall StatusRecall Incomplete, remedy not yet available Summary A potentially critical self-discharge condition exists in certain high-voltage battery modules that, in some instances, may lead to thermal overload, possibly resulting in smoke or a fire. A high-voltage battery overheating increases the risk of a fire. Affected high-voltage batteries may experience a loss of range and/or performance as an early indication. Safety Risk A high-voltage battery overheating increases the risk of a fire. Remedy REPAIR NOT YET AVAILABLE Audi is working on an interim measure to help provide support for vehicles in this recall until the remedy becomes available. More information will be provided at a later date once the details of the interim measure are defined.
NHTSA complaint #11565809 — an unverified report by a vehicle owner.