Owners have filed 709 complaints
about the 2006 BMW 325I with NHTSA between 2005 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 1 of 9 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the BMW 325I. 50 means typical for this
model; 100 means roughly double.
Severity — 47
9% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 23
13% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Frontal
3756.9%
Latch
57.7%
Front Passenger
46.2%
Occupant Classification
46.2%
Tread/Belt
46.2%
Body
46.2%
Engine
46.2%
Door
34.6%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
81.4%
1,000 – 9,999 miles
193.4%
10,000 – 24,999 miles
223.9%
25,000 – 49,999 miles
6611.8%
50,000 – 74,999 miles
13724.6%
75,000 – 99,999 miles
12823.0%
100,000 – 149,999 miles
12221.9%
150,000+ miles
559.9%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Aug 2005peak 15Apr 2026
NHTSA investigations into the 2006 BMW 325I
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
1
investigation is
still open.
EA15001Opened 24 Feb 2015Still openAIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
PE14016Opened 11 Jun 2014Closed 2 Mar 2015AIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
EA08001Opened 4 Jan 2008Closed 31 Dec 2008AIR BAGS
BMW AIRBAG LIGHT ILLUMINATION
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN T...
Recalls on the 2006 BMW 325I
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
24V513000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
20V017000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
19V273000
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
BMW of North America, LLC (BMW) is recalling certain 2006 525i, 525xi, 530i, 530xi, 530xi Sports Wagon, 325i, 325xi, 325xi Sports Wagon, 330i, 330xi, Z4 3.0i and Z4 3.0si vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Risk: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
14V428000
AIR BAGS
BMW of North America, LLC (BMW) is recalling certain model year 2000 323i sedans, coupes, convertibles, and Sports Wagons; 2000 328i sedans and coupes; 2001-2005 325i sedans, coupes, convertibles, and Sport Wagons; 2001-2005 325xi sedans and Sports Wagons; 2006 325i coupes and convertibles; 2001-2006 330i sedans, coupes, and convertibles; 2001-2005 330xi sedans; and 2001-2006 M3 coupes and convertibles to address a safety defect in the passenger side frontal air bag which may produce excessive internal pressure that could cause the air bag inflator to rupture upon deployment of the air bag.
Risk: In the event of a crash necessitating deployment of the passenger's frontal air bag, excessive internal pressure could cause rupturing of the inflator resulting in metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
17V676000
ELECTRICAL SYSTEM:WIRING
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Risk: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
17V428000
AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION
BMW of North America, Inc. (BMW) is recalling certain 2006 325i, 325xi, 330i, 330xi, 525i, 525xi, 530i, 530xi, and 550i vehicles equipped with the Sport Seat option and certain 2006 525i, 525xi, 530i, 530xi, 550i vehicles with standard seats. The front passenger seat occupant detection mat that determines if, and how, the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Risk: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
13V564000
AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION
BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model year 2006-2007 750i, 750Li, and 760Li sedans, and model year 2006 X5 sports activity vehicles, equipped with certain seat types. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Risk: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Reports where the owner recorded a crash, a fire, an injury or a death.
Dallas, TXFire
ELECTRICAL SYSTEM
While driving the vehicle, the blower (A/C) began to cycle on and off. Then I began to smell electrical smoke. Then I began to see smoke coming from vents and where the windshield meets the dashboard, closer to the passenger side. I pulled over and shut off the car as the smoke was getting worse inside the car. I popped the hood and saw smoke coming from the passenger side. I then called 911. Smoke was beginning to billow from engine compartment. As I was talking to the 911 dispatcher, I saw flames beginning in the engine bay close to the firewall on passenger side. The car was a total loss and is in a tow yard. It can be inspected upon request. The 911 operated told me to be aware of smoke and explosions so I backed away about 30ft. Many cars were passing by, close to the car. There are 2 safety recalls on this vehicle that are related to possible fire. I have an open case with BMW USA. They have not inspected the car. I have liability only for insurance so they will not cover. There were no warning lamps or indicators before fire.
NHTSA complaint #11730424 — an unverified report by a vehicle owner.
at 140,000 milesVero Beach, FLFire
ELECTRICAL SYSTEM
The contact owned a 2006 BMW 325i. The contact stated while driving 60-65 MPH, the A/C became inoperable and made an abnormally loud sound. The contact then noticed an abnormal burning wiring odor, and there was smoke coming out of the A/C vents. There was no warning light illuminated. The contact stated that she attempted to pull to the side of the road, but could not safely do so. The contact continued driving and came to a complete stop at the traffic light, where the cabin became engulfed in smoke. The contact then pulled into a business parking lot and immediately exited the vehicle. The contact stated upon opening the hood, the contact noticed a reflection of the flame inside the hood. The contact ran into the business and asked for assistance. The contact stated that upon returning to the vehicle, the contact noticed that the fire had started from the middle of the hood to the cabin of the vehicle. The contact and the business employee attempted to extinguish the fire with two fire extinguishers but were unable to do so. The fire was extinguished by the fire department. The contact stated that the vehicle burned to the ground from the middle of the hood to the trunk, where the gas tank was located, and the hood was fractured in half. The contact stated that there were burned particles around the parking lot, but there was no property damage. The fire department report was filed. A police report was filed, but the contact did not have the information available. There was no injury sustained. The vehicle was towed to a tow lot, where it was totaled. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 140,000.
NHTSA complaint #11634581 — an unverified report by a vehicle owner.
at 140,000 milesVero Beach, FLFire
ENGINE AND ENGINE COOLING
The contact owned a 2006 BMW 325i. The contact stated while driving 60-65 MPH, the A/C became inoperable and made an abnormally loud sound. The contact then noticed an abnormal burning wiring odor, and there was smoke coming out of the A/C vents. There was no warning light illuminated. The contact stated that she attempted to pull to the side of the road, but could not safely do so. The contact continued driving and came to a complete stop at the traffic light, where the cabin became engulfed in smoke. The contact then pulled into a business parking lot and immediately exited the vehicle. The contact stated upon opening the hood, the contact noticed a reflection of the flame inside the hood. The contact ran into the business and asked for assistance. The contact stated that upon returning to the vehicle, the contact noticed that the fire had started from the middle of the hood to the cabin of the vehicle. The contact and the business employee attempted to extinguish the fire with two fire extinguishers but were unable to do so. The fire was extinguished by the fire department. The contact stated that the vehicle burned to the ground from the middle of the hood to the trunk, where the gas tank was located, and the hood was fractured in half. The contact stated that there were burned particles around the parking lot, but there was no property damage. The fire department report was filed. A police report was filed, but the contact did not have the information available. There was no injury sustained. The vehicle was towed to a tow lot, where it was totaled. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 140,000.
NHTSA complaint #11634581 — an unverified report by a vehicle owner.
Thomasville, GAFire
ELECTRICAL SYSTEM
The contact's husband owns a 2006 BMW 325i. The contact stated moments after her son had started, parked and exited the vehicle, there was smoke coming from under the hood. The under hood caught on fire and the hood failed to open. The fire was extinguished by the fire department. The contact stated that the under hood, the front of the vehicle and the front tires burned significantly. A fire department report was filed. A police report was not filed. There was no injury sustained. The vehicle remained at the residence. The vehicle was awaiting to be destroyed. The dealer was contacted. The contact contacted the manufacturer and sent pictures of the incident to the manufacturer; however, the manufacturer informed the contact that the fire was not related to NHTSA Campaign Number: 22V119000(Engine and Engine Cooling). The failure mileage was unknown.
NHTSA complaint #11614154 — an unverified report by a vehicle owner.
Thomasville, GAFire
ENGINE AND ENGINE COOLING
The contact's husband owns a 2006 BMW 325i. The contact stated moments after her son had started, parked and exited the vehicle, there was smoke coming from under the hood. The under hood caught on fire and the hood failed to open. The fire was extinguished by the fire department. The contact stated that the under hood, the front of the vehicle and the front tires burned significantly. A fire department report was filed. A police report was not filed. There was no injury sustained. The vehicle remained at the residence. The vehicle was awaiting to be destroyed. The dealer was contacted. The contact contacted the manufacturer and sent pictures of the incident to the manufacturer; however, the manufacturer informed the contact that the fire was not related to NHTSA Campaign Number: 22V119000(Engine and Engine Cooling). The failure mileage was unknown.
NHTSA complaint #11614154 — an unverified report by a vehicle owner.
at 178,000 milesDecatur, TXFire
FIRERELATED
The contact's husband owned a 2006 BMW 325i. The contact stated that while her niece was driving at an undisclosed speed, there was smoke coming from underneath the hood. The contact's niece pulled over, and she and her boyfriend safely exited the vehicle before it caught fire. No injuries were sustained and no medical attention was received. The fire department was able to extinguish the fire. A fire department report was filed. The vehicle was towed to a tow yard; however, it was not yet deemed totaled by the insurance company. The manufacturer was not made aware of the failure. Upon investigation, the contact was made aware that there were 3 unrepaired recalls associated with the VIN with NHTSA Campaign Numbers: 17V676000 (Electrical System), 19V273000 (Engine and Engine Cooling), and 22V119000 (Engine and Engine Cooling). However, the contact had not received the recall notifications. The failure mileage was approximately 178,000.
NHTSA complaint #11465204 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Dallas, TXFire
ELECTRICAL SYSTEM
While driving the vehicle, the blower (A/C) began to cycle on and off. Then I began to smell electrical smoke. Then I began to see smoke coming from vents and where the windshield meets the dashboard, closer to the passenger side. I pulled over and shut off the car as the smoke was getting worse inside the car. I popped the hood and saw smoke coming from the passenger side. I then called 911. Smoke was beginning to billow from engine compartment. As I was talking to the 911 dispatcher, I saw flames beginning in the engine bay close to the firewall on passenger side. The car was a total loss and is in a tow yard. It can be inspected upon request. The 911 operated told me to be aware of smoke and explosions so I backed away about 30ft. Many cars were passing by, close to the car. There are 2 safety recalls on this vehicle that are related to possible fire. I have an open case with BMW USA. They have not inspected the car. I have liability only for insurance so they will not cover. There were no warning lamps or indicators before fire.
NHTSA complaint #11730424 — an unverified report by a vehicle owner.
Lubbock, TX
ENGINE
Since the airbag was not fixed, it has caused PVC meltings as well as leakage
NHTSA complaint #11695308 — an unverified report by a vehicle owner.
Lubbock, TX
SERVICE BRAKES
Since the airbag was not fixed, it has caused PVC meltings as well as leakage
NHTSA complaint #11695308 — an unverified report by a vehicle owner.
Lubbock, TX
FUEL/PROPULSION SYSTEM
Since the airbag was not fixed, it has caused PVC meltings as well as leakage
NHTSA complaint #11695308 — an unverified report by a vehicle owner.
Rochester, NY
ELECTRICAL SYSTEM
The Valvetronic Actuator malfunctions. The malfunction may have been caused by a Battery Positive Cable that has corroded over time. The result is that the vehicle stops unexpectedly during acceleration. Driver safety and that of others is put at risk due to the vehicle suddenly losing power and stoping while being driven. The vehicle was evaluated by the dealer. Warning lamps were intermittent and inconsistent. To my knowledge there is no Valvetronic Actuator or Battery Cable specific warning lamps or messages. There was a 2017 recall for the Battery Positive Cable, but my specific VIN was not covered (by a few months). My VIN (1986 325I) should have been included in the 2017 recall.
NHTSA complaint #11687394 — an unverified report by a vehicle owner.
Rochester, NY
ENGINE
The Valvetronic Actuator malfunctions. The malfunction may have been caused by a Battery Positive Cable that has corroded over time. The result is that the vehicle stops unexpectedly during acceleration. Driver safety and that of others is put at risk due to the vehicle suddenly losing power and stoping while being driven. The vehicle was evaluated by the dealer. Warning lamps were intermittent and inconsistent. To my knowledge there is no Valvetronic Actuator or Battery Cable specific warning lamps or messages. There was a 2017 recall for the Battery Positive Cable, but my specific VIN was not covered (by a few months). My VIN (1986 325I) should have been included in the 2017 recall.
NHTSA complaint #11687394 — an unverified report by a vehicle owner.
Rochester, NY
FUEL/PROPULSION SYSTEM
The Valvetronic Actuator malfunctions. The malfunction may have been caused by a Battery Positive Cable that has corroded over time. The result is that the vehicle stops unexpectedly during acceleration. Driver safety and that of others is put at risk due to the vehicle suddenly losing power and stoping while being driven. The vehicle was evaluated by the dealer. Warning lamps were intermittent and inconsistent. To my knowledge there is no Valvetronic Actuator or Battery Cable specific warning lamps or messages. There was a 2017 recall for the Battery Positive Cable, but my specific VIN was not covered (by a few months). My VIN (1986 325I) should have been included in the 2017 recall.
NHTSA complaint #11687394 — an unverified report by a vehicle owner.
San Diego, CA
SEATS
The passenger seat occupancy sensor (OC3 mat) on my 2006 BMW 3 Series (VIN: [XXX] ) has failed. As a result, the front passenger airbag is disabled, which poses a serious safety risk. BMW issued a 15-year warranty extension for this issue, acknowledging it as a common failure, but my vehicle is now slightly outside the coverage period. This part is vital for detecting front-seat occupants and enabling the airbag during a crash. I believe BMW should still be required to fix this safety-critical defect, especially in vehicles where the issue was never repaired while under the extended coverage window. This should be reclassified as a full safety recall, not just an expired service campaign. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11669664 — an unverified report by a vehicle owner.
San Diego, CA
AIR BAGS
The passenger seat occupancy sensor (OC3 mat) on my 2006 BMW 3 Series (VIN: [XXX] ) has failed. As a result, the front passenger airbag is disabled, which poses a serious safety risk. BMW issued a 15-year warranty extension for this issue, acknowledging it as a common failure, but my vehicle is now slightly outside the coverage period. This part is vital for detecting front-seat occupants and enabling the airbag during a crash. I believe BMW should still be required to fix this safety-critical defect, especially in vehicles where the issue was never repaired while under the extended coverage window. This should be reclassified as a full safety recall, not just an expired service campaign. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11669664 — an unverified report by a vehicle owner.
at 140,000 milesVero Beach, FLFire
ELECTRICAL SYSTEM
The contact owned a 2006 BMW 325i. The contact stated while driving 60-65 MPH, the A/C became inoperable and made an abnormally loud sound. The contact then noticed an abnormal burning wiring odor, and there was smoke coming out of the A/C vents. There was no warning light illuminated. The contact stated that she attempted to pull to the side of the road, but could not safely do so. The contact continued driving and came to a complete stop at the traffic light, where the cabin became engulfed in smoke. The contact then pulled into a business parking lot and immediately exited the vehicle. The contact stated upon opening the hood, the contact noticed a reflection of the flame inside the hood. The contact ran into the business and asked for assistance. The contact stated that upon returning to the vehicle, the contact noticed that the fire had started from the middle of the hood to the cabin of the vehicle. The contact and the business employee attempted to extinguish the fire with two fire extinguishers but were unable to do so. The fire was extinguished by the fire department. The contact stated that the vehicle burned to the ground from the middle of the hood to the trunk, where the gas tank was located, and the hood was fractured in half. The contact stated that there were burned particles around the parking lot, but there was no property damage. The fire department report was filed. A police report was filed, but the contact did not have the information available. There was no injury sustained. The vehicle was towed to a tow lot, where it was totaled. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 140,000.
NHTSA complaint #11634581 — an unverified report by a vehicle owner.
at 140,000 milesVero Beach, FLFire
ENGINE AND ENGINE COOLING
The contact owned a 2006 BMW 325i. The contact stated while driving 60-65 MPH, the A/C became inoperable and made an abnormally loud sound. The contact then noticed an abnormal burning wiring odor, and there was smoke coming out of the A/C vents. There was no warning light illuminated. The contact stated that she attempted to pull to the side of the road, but could not safely do so. The contact continued driving and came to a complete stop at the traffic light, where the cabin became engulfed in smoke. The contact then pulled into a business parking lot and immediately exited the vehicle. The contact stated upon opening the hood, the contact noticed a reflection of the flame inside the hood. The contact ran into the business and asked for assistance. The contact stated that upon returning to the vehicle, the contact noticed that the fire had started from the middle of the hood to the cabin of the vehicle. The contact and the business employee attempted to extinguish the fire with two fire extinguishers but were unable to do so. The fire was extinguished by the fire department. The contact stated that the vehicle burned to the ground from the middle of the hood to the trunk, where the gas tank was located, and the hood was fractured in half. The contact stated that there were burned particles around the parking lot, but there was no property damage. The fire department report was filed. A police report was filed, but the contact did not have the information available. There was no injury sustained. The vehicle was towed to a tow lot, where it was totaled. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 140,000.
NHTSA complaint #11634581 — an unverified report by a vehicle owner.
at 130,000 milesAustell, GA
AIR BAGS
The contact owns a 2006 BMW 325I. The contact stated while driving at undisclosed speeds, the air bag warning light illuminated. The contact received notification of NHTSA Campaign Number: 24V513000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The dealer offered an inspection but declined to repair the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer referred the contact to the NHTSA Hotline. The failure mileage was approximately 130,000. Parts distribution disconnect.
NHTSA complaint #11634322 — an unverified report by a vehicle owner.
West Covina, CA
ENGINE
This compliant is regarding the cooling system of BMW 32d5i 2006. Experience overheating of the car. The BMW dealership service department has confirmed that the water pump is at fault. And the quote for water pump replacement is their system. Yes, this is the second recurrency of overheating. Yes, the dashboard indicated overheating. The second warning was October 23,2024. The first warning was several years prior.
NHTSA complaint #11623286 — an unverified report by a vehicle owner.
Rocklin, CA
AIR BAGS
There is a recall 17v-428 for the seat mat, and i went to my local BMW dealer and said this car was not on the list, but they acknowledge it’s the same issue but because this VIN was not included they can’t fix it at no charge . They want $2100 to repair. Can you help me ? Thanks
NHTSA complaint #11616440 — an unverified report by a vehicle owner.
Thomasville, GAFire
ELECTRICAL SYSTEM
The contact's husband owns a 2006 BMW 325i. The contact stated moments after her son had started, parked and exited the vehicle, there was smoke coming from under the hood. The under hood caught on fire and the hood failed to open. The fire was extinguished by the fire department. The contact stated that the under hood, the front of the vehicle and the front tires burned significantly. A fire department report was filed. A police report was not filed. There was no injury sustained. The vehicle remained at the residence. The vehicle was awaiting to be destroyed. The dealer was contacted. The contact contacted the manufacturer and sent pictures of the incident to the manufacturer; however, the manufacturer informed the contact that the fire was not related to NHTSA Campaign Number: 22V119000(Engine and Engine Cooling). The failure mileage was unknown.
NHTSA complaint #11614154 — an unverified report by a vehicle owner.
Thomasville, GAFire
ENGINE AND ENGINE COOLING
The contact's husband owns a 2006 BMW 325i. The contact stated moments after her son had started, parked and exited the vehicle, there was smoke coming from under the hood. The under hood caught on fire and the hood failed to open. The fire was extinguished by the fire department. The contact stated that the under hood, the front of the vehicle and the front tires burned significantly. A fire department report was filed. A police report was not filed. There was no injury sustained. The vehicle remained at the residence. The vehicle was awaiting to be destroyed. The dealer was contacted. The contact contacted the manufacturer and sent pictures of the incident to the manufacturer; however, the manufacturer informed the contact that the fire was not related to NHTSA Campaign Number: 22V119000(Engine and Engine Cooling). The failure mileage was unknown.
NHTSA complaint #11614154 — an unverified report by a vehicle owner.
at 132,000 milesDallas, TX
ENGINE AND ENGINE COOLING
The contact owns a 2006 BMW 325I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated while driving 40 MPH, there was a significant amount of smoke coming out of the exhaust pipe and coming from underneath the hood of the vehicle. The check engine warning light was illuminated. The contact drove to the local dealer, where it was diagnosed that the PCV valve heater fuses had failed. The dealer charged a fee for the repair because the recall remedy was not available. The dealer installed an inline fuse and wiring that connected the PCV valve to the PCV valve heater. The contact stated that he received a second notice advising that the recall remedy was available, and the vehicle was taken back to the dealer, where the recall repair was performed. The vehicle was repaired. The contact later contacted the manufacturer for reimbursement, but the manufacturer referred the contact back to the dealer for assistance. The contact stated that he followed up with the dealer, who advised him that the failure was not related to the recall. The contact was not reimbursed. The failure mileage was approximately 132,000.
NHTSA complaint #11556402 — an unverified report by a vehicle owner.
at 229,896 milesSparta, TN
FUEL SYSTEM, GASOLINE
The contact owns a 2006 BMW 325I. The vehicle was taken to the local dealer for routine maintenance. The mechanic informed the contact that vehicles older than 2013 were not serviced by the dealer. The vehicle was diagnosed with a fuel leak. There were no warning lights illuminated. The vehicle was not repaired. The contact stated that while adding fuel, he noticed that fuel was leaking from the fuel tank. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 229,896.
NHTSA complaint #11540074 — an unverified report by a vehicle owner.
Tallahassee, FL
SEATS
Put a box of moderate weight into the passenger seat (hard drives) - probably 40 lbs. After driving for a few minutes and over a few bumps, the seat belt warning light came on because the seat sensor was tripped by the weight. Put the seat belt on to silence the warning. Shortly thereafter, both the seatbelt and passenger airbag warning lights showed on the dash, regardless of occupancy. Hooked up to scanning tool and cleared the codes but they always return. This is not a rare event from reading the online forums - it is likely due to the sensor mat in the seat for occupancy being defective, or a combination of that and the seat belt pre-tensioner being defective, for the passenger side only. The vehicle operates normally other than the warning lights. Obviously have not tested the airbag, but that is highly unlikely to be the actual problem from my investigation of the symptoms.
NHTSA complaint #11530296 — an unverified report by a vehicle owner.
Tallahassee, FL
SEAT BELTS
Put a box of moderate weight into the passenger seat (hard drives) - probably 40 lbs. After driving for a few minutes and over a few bumps, the seat belt warning light came on because the seat sensor was tripped by the weight. Put the seat belt on to silence the warning. Shortly thereafter, both the seatbelt and passenger airbag warning lights showed on the dash, regardless of occupancy. Hooked up to scanning tool and cleared the codes but they always return. This is not a rare event from reading the online forums - it is likely due to the sensor mat in the seat for occupancy being defective, or a combination of that and the seat belt pre-tensioner being defective, for the passenger side only. The vehicle operates normally other than the warning lights. Obviously have not tested the airbag, but that is highly unlikely to be the actual problem from my investigation of the symptoms.
NHTSA complaint #11530296 — an unverified report by a vehicle owner.
Tallahassee, FL
AIR BAGS
Put a box of moderate weight into the passenger seat (hard drives) - probably 40 lbs. After driving for a few minutes and over a few bumps, the seat belt warning light came on because the seat sensor was tripped by the weight. Put the seat belt on to silence the warning. Shortly thereafter, both the seatbelt and passenger airbag warning lights showed on the dash, regardless of occupancy. Hooked up to scanning tool and cleared the codes but they always return. This is not a rare event from reading the online forums - it is likely due to the sensor mat in the seat for occupancy being defective, or a combination of that and the seat belt pre-tensioner being defective, for the passenger side only. The vehicle operates normally other than the warning lights. Obviously have not tested the airbag, but that is highly unlikely to be the actual problem from my investigation of the symptoms.
NHTSA complaint #11530296 — an unverified report by a vehicle owner.
Rochester Hills, MI
SEATS
Existing vehicle recall excludes this particular VIN among the same MY and model even though this VIN is affected. Report Receipt Date: NOV 12, 2013 NHTSA Campaign Number: 13V564000 Component(s): AIR BAGS Potential Number of Units Affected: 76,565 Manufacturer: BMW of North America, LLC SUMMARY: BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, [shortened]. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure. CONSEQUENCE: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
NHTSA complaint #11504177 — an unverified report by a vehicle owner.
Rochester Hills, MI
AIR BAGS
Existing vehicle recall excludes this particular VIN among the same MY and model even though this VIN is affected. Report Receipt Date: NOV 12, 2013 NHTSA Campaign Number: 13V564000 Component(s): AIR BAGS Potential Number of Units Affected: 76,565 Manufacturer: BMW of North America, LLC SUMMARY: BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, [shortened]. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure. CONSEQUENCE: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
NHTSA complaint #11504177 — an unverified report by a vehicle owner.
Ft Worth, TX
AIR BAGS
After recall done pvc valve and blower heat a/c now not working the car engine light come up abs /brake and more
NHTSA complaint #11503057 — an unverified report by a vehicle owner.
Ft Worth, TX
ELECTRICAL SYSTEM
After recall done pvc valve and blower heat a/c now not working the car engine light come up abs /brake and more
NHTSA complaint #11503057 — an unverified report by a vehicle owner.