217 of the
1,808 complaints filed about the BMW 325I
are about the electrical system —
12% of everything owners reported.
The worst model year for it is 2006.
The complaint was filed on behalf of the contact's mother. The contact's mother owned a 2005 BMW 325i. The contact stated that while the vehicle was parked and unoccupied, the contact's brother noticed that the vehicle was on fire. The contact's brother used a nearby water hose and extinguished the fire. The Fire Department and the Police arrived. A fire report and a Police report were filed, however the Police report information was unavailable. In addition, the contact was informed that the light module was the source of the fire. The contact stated that the failure was a known failure. The vehicle remained at the residence. The vehicle was deemed a total loss. The manufacturer was made aware of the failure. The failure mileage was approximately 127,000.
NHTSA complaint #11749301 — an unverified report by a vehicle owner.
While driving the vehicle, the blower (A/C) began to cycle on and off. Then I began to smell electrical smoke. Then I began to see smoke coming from vents and where the windshield meets the dashboard, closer to the passenger side. I pulled over and shut off the car as the smoke was getting worse inside the car. I popped the hood and saw smoke coming from the passenger side. I then called 911. Smoke was beginning to billow from engine compartment. As I was talking to the 911 dispatcher, I saw flames beginning in the engine bay close to the firewall on passenger side. The car was a total loss and is in a tow yard. It can be inspected upon request. The 911 operated told me to be aware of smoke and explosions so I backed away about 30ft. Many cars were passing by, close to the car. There are 2 safety recalls on this vehicle that are related to possible fire. I have an open case with BMW USA. They have not inspected the car. I have liability only for insurance so they will not cover. There were no warning lamps or indicators before fire.
NHTSA complaint #11730424 — an unverified report by a vehicle owner.
The Valvetronic Actuator malfunctions. The malfunction may have been caused by a Battery Positive Cable that has corroded over time. The result is that the vehicle stops unexpectedly during acceleration. Driver safety and that of others is put at risk due to the vehicle suddenly losing power and stoping while being driven. The vehicle was evaluated by the dealer. Warning lamps were intermittent and inconsistent. To my knowledge there is no Valvetronic Actuator or Battery Cable specific warning lamps or messages. There was a 2017 recall for the Battery Positive Cable, but my specific VIN was not covered (by a few months). My VIN (1986 325I) should have been included in the 2017 recall.
NHTSA complaint #11687394 — an unverified report by a vehicle owner.
I cannot use put my windows up/down, cannot open the trunk, cannot use interior lights, cannot unlock my gas lid. Due to a broke. Electronic part called the GM5
NHTSA complaint #11661364 — an unverified report by a vehicle owner.
The contact owned a 2006 BMW 325i. The contact stated while driving 60-65 MPH, the A/C became inoperable and made an abnormally loud sound. The contact then noticed an abnormal burning wiring odor, and there was smoke coming out of the A/C vents. There was no warning light illuminated. The contact stated that she attempted to pull to the side of the road, but could not safely do so. The contact continued driving and came to a complete stop at the traffic light, where the cabin became engulfed in smoke. The contact then pulled into a business parking lot and immediately exited the vehicle. The contact stated upon opening the hood, the contact noticed a reflection of the flame inside the hood. The contact ran into the business and asked for assistance. The contact stated that upon returning to the vehicle, the contact noticed that the fire had started from the middle of the hood to the cabin of the vehicle. The contact and the business employee attempted to extinguish the fire with two fire extinguishers but were unable to do so. The fire was extinguished by the fire department. The contact stated that the vehicle burned to the ground from the middle of the hood to the trunk, where the gas tank was located, and the hood was fractured in half. The contact stated that there were burned particles around the parking lot, but there was no property damage. The fire department report was filed. A police report was filed, but the contact did not have the information available. There was no injury sustained. The vehicle was towed to a tow lot, where it was totaled. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 140,000.
NHTSA complaint #11634581 — an unverified report by a vehicle owner.
The contact's husband owns a 2006 BMW 325i. The contact stated moments after her son had started, parked and exited the vehicle, there was smoke coming from under the hood. The under hood caught on fire and the hood failed to open. The fire was extinguished by the fire department. The contact stated that the under hood, the front of the vehicle and the front tires burned significantly. A fire department report was filed. A police report was not filed. There was no injury sustained. The vehicle remained at the residence. The vehicle was awaiting to be destroyed. The dealer was contacted. The contact contacted the manufacturer and sent pictures of the incident to the manufacturer; however, the manufacturer informed the contact that the fire was not related to NHTSA Campaign Number: 22V119000(Engine and Engine Cooling). The failure mileage was unknown.
NHTSA complaint #11614154 — an unverified report by a vehicle owner.
On June 28,2024, after parking and turning off the ignition switch, the dash started smoking and within minutes the whole dash and front of car were on fire. The car almost completely burned to the ground before the fire department could get there. The car was recently serviced at a BMW for an air bag recall. Heater ducts were loose when returned. There are also recalls for the 2006 325i for similar dash fires. The cause could be either dealer work or a factory issue.
NHTSA complaint #11598027 — an unverified report by a vehicle owner.
On Tuesday June 20, 2023 at 7:20am I was awakened by my neighbor who informed me that my car was on fire. A report was done by the fire department and they did not believe it was done on purpose but something with my car. My car was totally consumed with fire nothing but ashes.
NHTSA complaint #11530869 — an unverified report by a vehicle owner.
Vehicle Steering Lock Malfunction - Car does not start and stuck in Park. Cannot move steering wheel which is locked. This is a design defect that needs to be addressed. Vehicle is rendered inoperative! Cannot move or start it! approx. mileage 105k. This is a new problem besides the current recall which has not been available yet. I've also been locked out of this vehicle and had to climb out of the window, thank God it was not a fire or flood! I was able to fix that problem myself. note: Steering Lock Malfunction is a widespread problem! Dealers want to replace the entire steering column in these cases at a very high cost. Thanks, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11475609 — an unverified report by a vehicle owner.
The contact owns a 2006 BMW 325i. The contact received notification of NHTSA Campaign Number: 17V676000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11465137 — an unverified report by a vehicle owner.
I am having a major electrical short in my trunk area affecting my critical tail lights functionalities and common trunk function. I cannot use my turning signals or brake lights or lights in general when driving my vehicle from the rear my lights are not operable. This is a huge safety concern and risk that’s need to be recalled affecting millions I'm for certain. Along with that I am having steering issue with my steering rack called “steering Wander”. Not being able to control you vehicle with supreme confidence is a issue which can easily lead to collisions.
NHTSA complaint #11435461 — an unverified report by a vehicle owner.
OIL FILTER HOUSING GASKET LEAKED ON TO ALTERNATOR CAUSING THE ALTERNATOR TO OVER HEAT AND MELT INTERNAL COMPONENTS WHICH CAUSING LACK OF POWER AND MULTIPLE FALSE CHECK ENGINE CODES TO COME ON AND SMOKE CLOUDED MY VIEW WHILE DRIVING SO VERY COMMON PROBLEM IS THE HEATER CORE LEAKING TOO
NHTSA complaint #11407804 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNED A 2003 BMW 325I. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, IT CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE CONTACT STATED THAT THE FIRE ARSONIST INVESTIGATOR FILED A REPORT AND PROVIDED A CASE NUMBER. THE VEHICLE WAS NOT TOWED TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
NHTSA complaint #11395920 — an unverified report by a vehicle owner.
THE GROUND WIRE ON MY BREAK LIGHT HAS BURNED THROUGH THE 8 PIN CONNECTOR NOT ONLY IS THIS LIMITING MY ABILITY TO WARN OTHER DRIVERS IT IS A MAJOR FIRE HAZARD THIS WAS DISCOVERED DURING A RECALL SERVICE AT THE LOCAL DEALERSHIP I DO NOT BELIEVE. THE PROPER STEPS HAVE BEEN TAKEN TO REMEDY THIS PROBLEM AND IF THIS CAN NOT BE RESOLVED INFORMALLY I WOULD LIKE TO PURSUE FORMAL LITIGATION AGAINST ALL PARTIES INVOLVED AND FOR DISCOVERY PURPOSE ALL RELATED CORRESPONDENCE, VIDEO, AND RECORDED EVIDENCE SHOULD BE PRESERVED. CURRENTLY THE BREAK LIGHT IS NOT WORKING AND THERE ARE DEFECTIVE AND HAZARDOUS AIRBAGS.
NHTSA complaint #11377873 — an unverified report by a vehicle owner.
I WAS TRAVELING TO A LOCAL STORE. MY CAR SUDDENLY JERKED,RADIO TURNED OFF WHILE LIGHTS ON DASH FLICKERED ON AND OFF. I LOST POWER TEMPORARILY AND I BEGAN SMELLING WIRES. I ALSO NOTICE A 'POP' AS I ATTEMPTED TO PULL OVER AND NOTICE NO BRAKE OPERATIONS SO I HAD TO COAST TO A STOP WITH MY 2 YEAR OLD IN THE BACKSEAT. I STARTED MY FLASHERS AND TURN OFF CAR TO SEARCH FOR SMELL. IT SEEMS LIKE DASH BUT I DIDN'T SEE ANY SMOKE. I GET BACK IN CAR AND ATTEMPT TO START IT AND NOTHING! I STILL HAVE POWER SO I WAS CONFUSED, I CHECK TRUNK ULTIMATELY AND REMOVE BATTERY COVER AND THIS IS WHAT I FOUND! THIS IS A SAFETY ISSUE AND VERY DANGEROUS. I GOT THE CAR TOWED HOME AND WON'T DRIVE UNTIL IT IS REPAIRED OBVIOUSLY. I AM UPSET BUT EVEN HAPPIER ME AND MY KID MADE IT HOME SAFELY, SOMETHING KEEPS TELLING ME TODAY WAS A BLESSING WE MADE IT.
NHTSA complaint #11340277 — an unverified report by a vehicle owner.
HAVE HAD THE CAR LESS THAN TWO MONTHS AND I HAVE BEEN EXPERIENCING NON-SAFE SITUATIONS. THE CAR JUST ONE DAY SUDDENLY DOESN?T COME OUT OF PARK. IT FINALLY GOT OUT OF PARK AND WHEN I TRY TO DRIVE AND IT REVERSES AND MAKE ALOT OF NOISE AND WHEN I SOMETIMES TRY TO REVERSE. IT DRIVES. THIS IS NOT SAFE. I?VE NEARLY GOTTEN MYSELF KILLED DUE TO THIS FAULTY BAD CAR. I TRIED TO CALL FOR A TRADE OR A REFUND AND THE COMPANY WAS RUDE TO ME. THIS CAR TAKES MY GIRLFRIEND AND I TO WORK AND THIS IS THE ONLY CARE WE HAVE. IT HASN'T BEEN A YEAR AND THE CAR HAS SO MANY ISSUES DOWN TO CAR NOT READING GEARS, BAD SPARK PLUGS , HOLE UNDERNEATH, FAULTY AIRBAGS, WINDOWS NOT WORKING, TIRE PRESSURES UNSAFE AND MUCH MORE THAT NO ONE WOULD WANT TO EXPERIENCE.
NHTSA complaint #11331454 — an unverified report by a vehicle owner.
2006 BMW 325I THE BIODEGRADABLE WIRING HAS DETERIORATED CAUSING THE DIRECTIONAL AND HEADLAMPS TO FAIL RESULTING IN EXPENSIVE REPAIRS AND JEOPARDIZES THE SAFETY OF THE DRIVERS OF THE VEHICLE WHILE IN USE.
NHTSA complaint #11310930 — an unverified report by a vehicle owner.