BMW 328XI fuel system problems

FUEL/PROPULSION SYSTEM

Unknown

NHTSA complaint #11635483 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

The car was over heating and not starting as well as fuel pump error on my dash. There is an open recall on my vehicle starting March of 2022 it is now June and BMW says they don’t know when they will have a remedy for this and it could be months but I need my car.

NHTSA complaint #11470189 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Mileage Rollback

NHTSA complaint #11437624 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

MY VEHICLE IS EXPERIENCING THE SAME SYMPTOMS AND IS REPORTING THE SAME TROUBLE CODES RELATED TO RECALL NUMBER: 17V683000. HOWEVER, MY VEHICLE IS NOT INCLUDED IN THIS RECALL. I WOULD APPRECIATE IT IF THIS MATTER COULD BE INVESTIGATED AND MY VEHICLES VIN INCLUDED IN THIS RECALL.

NHTSA complaint #11413051 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 2010 BMX 328XI. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND THE CONTACT CONTINUED DRIVING HOWEVER, THE FAILURE RECURRED. THE VEHICLE FAILED TO RESTART. THE CONTACT AND A POLICE OFFICER PUSHED THE VEHICLE OFF THE ROADWAY. AFTER WAITING 30 MINUTES THE VEHICLE WAS RESTARTED AND DRIVEN BACK TO THE RESIDENCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL PUMP AND FUEL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

NHTSA complaint #11406958 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 2014 BMW 328XI. THE CONTACT STATED WHILE DRIVING 25 MPH, THE VEHICLE SEIZED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE TO THE SHOULDER OF THE ROADWAY. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE HOWEVER, THE VEHICLE FAILED TO RESUME NORMAL OPERATION. THE VEHICLE WAS TOWED TO BMW NORTHWEST (4011 20TH ST E, TACOMA, WA 98424) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. NO LEAKS WERE PRESENT. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT DRIVABLE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V189000 (FUEL SYSTEM, GASOLINE) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURE WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 61,000. VIN WAS NOT AVAILABLE.

NHTSA complaint #11362751 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

11/2016 - CAR STALLED ON THE INTERSTATE AND WOULDN'T RESTART. COMPLETE POWER FAILURE (ENGINE, BRAKES, STEERING) - MECHANIC REPLACED A GAS VALVE. THE EXACT SAME PROBLEM HAPPENED TWICE MORE. BMW REPLACED THE FUEL PUMP AND NOW WANTS TO REPLACE THE CONTROL MODULE. ALL THIS WITHIN 3000 MILES. SEEMS LIKE A MAJOR FUEL SYSTEM FAILURE. 04/03/18-104795 MILES ON THE VEHICLE IT WAS BROUGHT IN FOR -BLOWER MOTOR RECALL WAS PERFORMED DUE TO THE FACT THAT YOURS WAS INOPERABLE -PCV VALVE RECALL -CHECK ENGINE LIGHT WAS ON AND THE CAUSE WAS THE FUEL PUMP. CAR HAS BEEN DRIVEN 2766 MILES IN BETWEEN THE NEXT VISIT. 09/28/18-107561 MILES ON THE VEHICLE IT WAS BROUGHT IN FOR -A/C SERVICE DUE TO THE A/C NOT BEING COLD ENOUGH. -SLUGGISH RUNNING (CAUSE WAS THE DIFFERENTIAL PRESSURE SENSOR) AN EMISSIONS ITEM THAT HAS NOTHING TO DO WITH THE FUEL PUMP AND THE VEHICLE ALSO NEEDED THE (CHARCOAL CANISTER) REPLACED, ALSO AN EMISSIONS ITEM. CAR HAS BEEN DRIVEN 487 MILES 10/23/18-108048 MILES ON THE VEHICLE IT WAS BROUGHT IN FOR -AWD/ABS/EMERGENCY EBV LIGHT IS ON-( THIS IS CONTROLLED BY THE VTG MODULE) I'M NOT GETTING A SIGNAL FROM THIS MODULE. AFTER INSPECTING WHAT WE COULD OF THE MODULE THAT IS WHEN THE TECHNICIAN FOUND THAT THERE WAS WATER IN THE PASSENGER REAR FLOORBOARD. -FUEL PUMP MESSAGE ON THE SCREEN (CAUSE IS THE EKPS MODULE) THE MODULE CONTROLS WHAT THE FUEL PUMP DOES. IF THIS MODULE IS MALFUNCTIONING THEN THE FUEL PUMP ISN'T OPERATING PROPERLY RESULTING IN THE 'FUEL PUMP' MESSAGE ON THE SCREEN. IT IS THE SAME ISSUE, YET THEY HAVE "FIXED" TWO DIFFERENT PARTS OF THE FUEL SYSTEM ALREADY. WHAT ARE THE ODDS THAT A THIRD, EVEN MORE EXPENSIVE PART WOULD FAIL SO SOON?

NHTSA complaint #11150196 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

BEFORE ANY PROMPTS ON THE NAVIGATION SCREEN EVER CAME UP, I WOULD OFTEN SOMETIMES SMELL SOMETHING BURNING OR GIVING OFF A HOT RUBBER SMELL WHICH I ADDRESSED AS SOON I PURCHASED THE VEHICLE FROM QUEENS AUTO MALL AUCTION, THEY SAID IT WAS NOTHING TO WORRY ABOUT IF I DID NOT SEE THE CHECK ENGINE LIGHT ON. WHILE I WAS DRIVING MY BMW 328 XI 2011 THE CAR SUDDENLY LOST POWER AND A FUEL PUMP MALFUNCTION DISPLAY PROMPTED ON MY NAVIGATION SCREEN. THE CAR STOPPED ON A BRIDGE IN THE LEFT LANE WITHOUT ME BEING ABLE TO PULL OVER. THE CAR WOULD NOT START UP AGAIN AT ALL AFTER SEVERAL ATTEMPTS. I WAITED ABOUT 30 MINUTES AND THE CAR STARTED UP AGAIN. I DROVE IT BACK HOME 5 MIN AWAY AND GOT MY VEHICLE TOWED TO THE BMW OF MANHATTAN WHERE THEY SAY THEY TOOK CARE OF THE PROBLEM. ONCE I PICKED UP THE VEHICLE, I DROVE FOR APPROXIMATELY 25-30 MINUTES BEFORE THE SAME EXACT THING HAPPENED AGAIN AND I WAS BARELY ABLE TO SWITCH INTO THE RIGHT LANE SO I CAN PULL OVER AND HAVE ANOTHER TOW COME AND TAKE MY CAR TO BMW OF MANHATTAN JUST AN HOUR AFTER I HAD IT SERVICED. I HAD THE RECALL FOR THE PCV VALVE HEATER REPLACED AT THAT SERVICE SO I KNOW THE SAME FIRE/RUBBER BURNING SMELL CAN'T POSSIBLY BE FROM THAT VALVE RECALL. I HAVE SEEN ONLINE MANY PEOPLE HAVE THE SAME PROBLEM WITH THEIR 3 SERIES, AND I AM CONCERNED THIS MAY BE AN UNDERLYING ISSUE WITH ALL 3 SERIES BMW 2006-2011. IN BOTH OF THESE SEPARATE INSTANCES I WAS DRIVING AND WAS VERY SCARED THAT I COULD HAVE GOTTEN INTO A SERIOUS CAR ACCIDENT IN NEW YORK CITY

NHTSA complaint #11131624 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I HAVE FUEL LEAKING FROM THE TOP OF MY FUEL TANK. I HAVE NEEN ADVISED THAT IT IS A FUEL TANK SENDING UNIT OR A SEAL. MY FUEL PUMP WORKS AS MY CAR IS OPERATIONAL. THE LEAK OCCURS WHEN THE GAS TANK IS OVER HALF FULL. THIS IS A SAFETY ISSUE AND SHOULD BE A RECALL.

NHTSA complaint #11119559 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

UPON A COMPLETE REFILL OF THE VEHICLE WITH FUEL, RAW GASOLINE WAS FOUND LEAKING DOWN THE TANK AND PUDDLING UNDER THE CAR. DIAGNOSTIC INSPECTION UPON LOWERING THE FUEL TANK FOUND A DEFECTIVE "DUMMY PORT" SEAL AT THE TOP OF THE TANK. THIS PORT WAS USED IN EARLY MODELS FOR EMISSION CONTROL SENSING. THE CAP OVER THE SEAL WAS NOT PROPERLY SEALED ALLOWING FUEL TO SPILL OUT THE TOP OF THE TANK. WHEN IN MOTION THIS FUEL BLOWS ONTO THE HOT MUFFLER AND POSES A POTENTIAL FOR CATASTROPHIC FIRE

NHTSA complaint #11112816 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

FUEL PUMP IS BURNING OUT AND LIQUID ISN'T PASSING THROUGH THE TANK PROPERLY. THE CAR IS OVERHEATING ANF FEELS LIKE IT'S GOING TO START FIRE.

NHTSA complaint #11105188 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

2009 328XI BMW FIRST BATTERY GOES DEAD,ONE MONTH LATER CAR STOPS WHILE DRIVING,BMW SAID IT WAS FUEL PUMP AND HOSE,THEY FIXED THAT,WHILE AT DEALER THEY SAID FAULTY CODE CAME UP FOR ALTERNATOR . ALL THIS WITHIN 1 MONTH. NO SIGNS OF LIGHTS DIM,CAR NOT STARTING,HOW DOES THIS HAPPEN ALL AT ONCE AND WITH NO WARNING.SEEMS THERE IS A BIGGER ISSUE.DEALER FIXED FUEL PUMP.BUT HOW DOES ALTERNATOR GO WITH NO SIGNS.

NHTSA complaint #11091990 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

2009 328 XI BMW WITH 120K FUEL PUMP JUST BREAKS. BMW REPLACED FOR FREE DUE TO ALL THE COMPLAINTS AND RECALL INFO,THIS SUCH BE A NATIONAL RECALL AS SOMEONES CAR CAN JUST STOP WHILE DRIVING,AND THIS IS A SAFETY ISSUE.

NHTSA complaint #11091478 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WITHOUT ANY TIME TO PULL OVER, MY CAR HAS SUDDENLY STOPPED ON A BUSY HIGHWAY AT SPEEDS OF ABOUT 45 AND 65 NOT ONCE BUT TWICE IN ABOUT A 3 MONTH SPAN. FIRST TIME I WAS STUCK IN A MIDDLE LANE GOING ABOUT 45MPH AND MY CAR COMPLETELY CAME TO A STOP. I NEEDED POLICE TO COME OUT AND AN EMERGENCY TOW DUE TO LOCATION. I TOOK MY CAR TO MY BMW DEALERSHIP AND WAS TOLD IT WAS A FUEL PUMP PROBLEM AND THAT IT HAD BEEN CORRECTED. NOW 3 MONTHS LATER IT HAS HAPPENED AGAIN ON A DIFFERENT PART THE SAME BUSY HIGHWAY AT ABOUT 65MPH AND I HAD TO HAVE A POLICE OFFICER COME OUT AND PUSH ME INTO THE SHOULDER BECAUSE AGAIN, BY CAR COMPLETELY CAME TO A STOP WITH NO TIME TO SWITCH LANES AND GET TO A SHOULDER.

NHTSA complaint #11075712 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

HI I HAVE A BMW 2011 328XI, RECENTLY I WAS DRIVING THE CAR ON THE FREEWAY WHEN THE CAR COMPLETELY SHUT DOWN ON ME AND LITERALLY LEFT ME 10 SECS TO GET ON THE SHOULDER. MIND YOU THIS IS BUSY TRAFFIC HOUR COMING BACK FROM CHICAGO. I REPLACED THE FUEL PUMP LAST YEAR, AND BMW TAKES NO OWNER SHIP OF THE PROBLEM. I CALLED THE CUSTOMER SERVICE AND ALSO ASKED THEM TO DIAGNOSE IT , BUT THEY KEEP TELLING ME OH WE CANNOT DETECT IT. THIS IS VERY FRUSTRATING AS THIS IS MY WIFES CAR AND I WOULD NOT WANT ANYTHING HAPPENING TO HER IF THE CAR RANDOMLY STOPS IN THE MIDDLE OF THE FREE WAY.

NHTSA complaint #11031525 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I WAS DRIVING WEST DOWN ROUTE 66 IN VIRGINIA. CAR HAD STALLED 5 TIMES IN A 60 MILE TRIP STATING WITH A MESSAGE FUEL PUMP FAILURE CONTINUED DRIVING IS POSSIBLE. IT LEFT ME WITH NO POWER STEERING OR BRAKES. THE VEHICLE WILL RESTART AFTER A 5 MINUTE COOL DOWN PERIOD AND CONTINUED DRIVING IS THEN POSSIBLE. THIS HAS BEEN HAPPENING WITH THIS VEHICLE SINCE 70K MILES.

NHTSA complaint #10990475 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TRAVELING AT 65MPH ON A STATE HIGHWAY, THE VEHICLE EXPERIENCED AN ABRUPT LOSS OF POWER, DECELERATED TO 25MPH, AND NARROWLY AVOIDED REAR-END COLLISION. DEALERSHIP DIAGNOSIS WAS A DEFECTIVE HIGH-PRESSURE FUEL PUMP.

NHTSA complaint #10980995 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

DRIVING DOWN HIGHWAY AUTO SUDDENLY STOPPED RUNNING LUCKILY NO ACCIDENT CONSIDERING HEAVILY TRAVEL ROAD AUTO WOULDN'T START AGAIN HAD AUTO TOWED OFF ROAD TO NEAREST GARAGE SAFETY HAZARD.BMW HAS SPECIAL WARRANTY FOR SUPER LOW EMISSION VEHICLES 15YRS OR 150000 MILES THIS AUTO FITS THAT DESCRIPTION IN CERTAIN STATES PA IS ONE OF THESE STATES IF YOU READ THE WHOLE WARRANITY NOT JUST THE FIRST LIST OF STATES. THE AUTO WAS REGISTRED IN PA FOR 6YRS AND IN NORTH CAROLINA ONE MONTH.BMWNA SAID THE AUTO DOESN'T QUALIFY THEY DIDN T BOTHER TO READ THEIR WHOLE WARRENITY AND THEIR SECOND EXCUSEIS THE AUTO IS REGISTRYED IN NORTH CAROLINA A NONE EMISSION STATE.THIS IS FOOLISH THEY ADMIT THE HAVE A PROBLEM WITH FALLITY PARTS THAT BREAK AND CREAT SAFETY HAZARDS BUT DON'T HAVE A RECALL OR EVEN IN FORM THE OWNERS OF THIS DANGEROUS SITUATION. THE FUEL PUMP AND FUEL TANK HAVE TO BE REPLACED. THERE ARE LINES IN SIDE OF TANK THAT CAUSE FUEL PUMP TO SHORT OUT AS THEY FALL APART AND YOU HAVE TO REPLACE THE WHOLE TANK BECAUSE HOW LINES ARE SITUATED. THERE WARRENTY SAYS THE WILL HONOR WARRENTY FIRST OWNERS AND FUTURE OWNERS BUT THEN THE DON'T DELIVERY ON THERE WORD

NHTSA complaint #10905125 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I WAS DRIVING AND THE VEHICLE AT APPROXIMATELY 20MPH ON A CITY STREET WHEN IT JUST STALLED OUT AND DASH LIGHTS WENT OUT AND BACK ON. I HAVE ONLY 66000 MILES ON THE CAR. REPAIR SHOP IS SAYING FUEL PUMP IS SEIZED UP AND NEEDS TO BE REPLACED WHICH MAY BE RELATED TO THIS RECALL NHTSA CAMPAIGN NUMBER: 13V044000. I WAS NEVER NOTIFIED OF ANY RECALL. I PURCHASED THIS CAR USED FROM BMW IN FEBRUARY OF 2013. WHEN I RUN THE VIN NUMBER NO RECALL COMES UP

NHTSA complaint #10897846 — an unverified report by a vehicle owner.