BMW 525I transmission problems

POWER TRAIN

TRANSMISSION GOES IN TO SAFE MODE SUDDENLY ON THE FREEWAY AT HIGH SPEED RANDOMLY AND SLOWS DOWN MAKING IT DANGEROUS SITUATION. CODE P17EC .

NHTSA complaint #11350120 — an unverified report by a vehicle owner.

POWER TRAIN

TL* TAKATA RECALL. THE CONTACT OWNS A 2001 BMW 525I. THE CONTACT STATED THAT THE TRANSMISSION WAS SLOW TO CHANGE GEARS INTERMITTENTLY. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE TRANSMISSION ASSEMBLY NEEDED TO BE REPLACED. ALSO, WHILE DRIVING 25 MPH OVER A POTHOLE, THE UNDERCARRIAGE OF THE VEHICLE WAS DAMAGED AND THE AIR BAGS DEPLOYED WITH FORCE. THE DRIVER WAS NOT INJURED. THE VEHICLE REMAINED PARKED AT THE CONTACT'S RESIDENCE DUE TO THE FAILURE. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V015000 (AIR BAGS). THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA complaint #11189774 — an unverified report by a vehicle owner.

POWER TRAIN

I PURCHASED THIS BMW 525I USED FROM A PERSON THAT OBTAINED IT FROM A WHOLESALE DEALER, IT HAD SOME MINOR FRONTEND DAMAGE FROM A FENDER BENDER (BROKEN GRILL, DING TO HOOD) SHOWING 107900 MILES. EVERYTHING ELSE CHECKED OUT. I FEW MONTHS LATER I NOTICED A SLIGHT CHANGE IN TRANSMISSION SOUND, BUT IT MIGHT HAVE BEEN DUE TO THE COLD TEMPERATURES HERE IN WISCONSIN. A COUPLE OF DAYS LATER WHILE JUST FINISHING GOING UP A SLIGHT STRAIGHT INCLINE AT AROUND 45MPH THE TRANSMISSION DROPPED DOWN INTO LIMP DOWN MODE AND A TEMPORARY NOTICE CAME UP ON THE COMPUTER SCREEN INDICATING A TRANSMISSION PROBLEM. STOPPING AND RESTARTING THE ENGINE CLEARED THE PROBLEM, THE NEXT DAY NEAR THE SAME SPOT IT OCCURRED AGAIN. I ASSUMED THE TRANSMISSION MIGHT BE LOW ON FLUID BUT LOOKING ONLINE BMW INDICATED THIS IS A NO SERVICE TRANSMISSION BUT THAT IT IS POSSIBLE TO CHECK THE FLUID LEVEL BY ACCESSING A PLUG UNDER THE CAR. WHEN A SERVICE TECH CHECKED HE SAID THE FLUID LEVEL WAS NORMAL BUT SMELLED BURNT. HE RECOMMENDED AGAINST ANY SERVICE IN THAT IT LIKELY WOULD RESULT IN FASTER COMPLETE FAILURE. THE PROBLEM HAS NOT REOCCURRED AND NO CODES SHOW IN THE SYSTEM FILE, IN THAT BMW INSISTED ON NO PROVIDING A METHOD TO CHECK THE TRANSMISSION FLUID, THEY ASSUMED THE LIABILITY FOR FAILURE IF REGULAR MAINTAINANCE (TRANSMISSION FLUSH) COULD HAVE PREVENTED THIS FAILURE.

NHTSA complaint #11174764 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2005 BMW 525I. THE CONTACT STATED THAT THE VEHICLE DECELERATED INDEPENDENTLY WHILE BEING OPERATED AT LOW SPEEDS. THE AIR BAG WARNING INDICATOR AND SERVICE TRANSMISSION WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000. UPDATED 02/16/17

NHTSA complaint #10917934 — an unverified report by a vehicle owner.

POWER TRAIN

BOUGHT FROM MANAGER AT BMW SERVICE DEPARTMENT W/89,920 ON 10/25/13. 2 OVERHEATED BROKE DOWN ON 11/29/13 ON JANUARY 7 RARELY PARK IN DRIVEWAY, PULL UP ON DRIVEWAY WITH AN INCLINE AT MY HOME. CAR WAS PLACED IN PARK BUT SORTA DID NOT CATCH GEAR RIGHT, FELT A ROLLBACK SO I ENGAGED MY E-BRAKE. DID NOT WANT TO RELEASE KEY, SO I GET STUFF AT HOUSE AND RESUMED INSPECTION OF VEHICLE, CAR DID NOT START. SO I ATTEMPTED TO REMOVE OUT OF PARK, TO NO AVAIL, THEN AFTER OFF AND ON ATTEMPTS IT CHANGED GEARS. SCREEN SAID GEAR CHANGE WITHOUT BRAKE POSSIBLE. TOOK IT IN THEY SAID HAD TO REPLACE GUIDE PLATE AND SOLENOID FOR 1250.00 I HAVE 4 KIDS AND A WIFE I LOVE, WE ARE ALWAYS IN VEHICLE, I FEEL MY FAMILIES SAFETY IS VIOLATED FOR BEING EXPOSED TO A POTENTIAL DANGEROUS EPISODE. DID RESEARCH PARKING PAWL GUIDE PLATE HAS RECALL. EXACT TO MY PROBLEM DEALERSHIP ACKNOWLEDGES IT BUT CLAIMS THAT MY CAR AIN'T BECAUSE RECALLS ON V8 MODELS. ONLY HAD CAR FOR SHORT TIME FRAME. FEEL SCAMMED, PAID 14600 W/ TAXES FROM BANK LOAN AND NOW I'M STUCK WITH A LEMON! HELP!!??

NHTSA complaint #10560152 — an unverified report by a vehicle owner.

POWER TRAIN

TRANSMISSION JERKS AND THE CAR GIVES A KICK WHEN THE CAR AUTOMATICALLY DOWNSHIFTS FROM 2 TO 1. THIS TYPICALLY HAPPENS WHEN SLOWING DOWN TO A STOP. SEEN MANY REFERENCES OF TRANSMISSION JERK / KICK ISSUES ONLINE ON BIMMERFEST. REPORTS TO BMW USA AS WELL. BMW USA REFUSES TO ASSIST WITH THIS ISSUE.

NHTSA complaint #10547438 — an unverified report by a vehicle owner.

POWER TRAIN

THE CAR BEEPS EVERY FEW MILES AND A WARNING LIGHT SHOWS IT NEED AN OIL CHANGE, I HAD JUST GOTTEN A CHANGE, SO THEY CHANGED IT AGAIN, THE NEXT DAY THE BELLS STARTED RINGING AGAIN. ALSO THE GEAR SHIFTER WENT OUT. IT IS STILL RINGING.

NHTSA complaint #10461806 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2005 BMW 525I. THE CONTACT STATED THAT THERE WAS A PAN SLEEVE GASKET LEAK COMING FROM THE TRANSMISSION. THE VEHICLE WAS TAKEN TO THE DEALER FOR A ROUTINE INSPECTION WHEN THEY FOUND THE TRANSMISSION LEAK. THE DEALER STATED THAT A GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS ADDRESSING THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 80,000.

NHTSA complaint #10455881 — an unverified report by a vehicle owner.

POWER TRAIN

TRANMISSION FAILURE ON THIS CAR. HAD TRANSMISSION REBUILT TO NO AVAIL (OVER $3000). WOUND UP GETTING OUR $$ BACK, THANK GOODNESS. APPARENTLY, IN READING ALL THE INFO ONLINE, THE 2004 525I TRANSMISSION FAILURES IS VERY COMMON. ONLY REMEDY IS A FULL-BLOWN BMW REPLACEMENT WITH THE CLUTCH ALREADY SET.

NHTSA complaint #10453353 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS 2004 BMW 525I. THE CONTACT STATED WHILE DRIVING 30 MPH THE TRANSMISSION WOULD NOT SHIFT AND WHEN IT DID SHIFT IT LUNGED FORWARD. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED SEVERAL TIMES BEFORE BUT HE WAS UNABLE TO BE DUPLICATE IT. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE MECHATRONIC SLEEVE WAS LEAKING TRANSMISSION FLUID AND AS A RESULT IT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 120,000.

NHTSA complaint #10447898 — an unverified report by a vehicle owner.

POWER TRAIN

I OWN A 2004 BMW 525I WITH 119,000 MILES ON THE ENGINE. I EXPERIENCED MY CAR MAKING A THUMP SOUND AND THEN THE I WOULD LOSE ACCELERATION. I CALLED THE MECHANIC AND THEY COULD NOT FIND THE PROBLEM BECAUSE IT DID NOT SHOW THE DASH ERRORS. THIS HAD BEEN GOING ON FOR 3 WEEKS AND THEN THE MECHANIC TOLD ME MY TRANSMISSION NEEDED REPLACING. I AM DISAPPOINTED THAT THIS IS A COMMON PROBLEM AND NOTHING IS BEING DONE ABOUT THIS. I WILL NEVER BUY A BMW AGAIN.

NHTSA complaint #10436149 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2003 BMW 525I. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE CHECK TRANSMISSION FAILSAFE MESSAGE ILLUMINATED. THE CONTACT STATED THAT THE TRANSMISSION BECAME STUCK IN THIRD GEAR AND DECELERATED UNTIL IT STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO ADVISED THAT THEY WOULD CONTACT HIM AT A LATER DATE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 100,825.

NHTSA complaint #10430075 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2005 BMW 545I. THE CONTACT STATED THAT WHILE BRAKING, THE TRANSMISSION SHIFTED AND THE VEHICLE ABNORMALLY ACCELERATED BARELY MISSING A COLLISION WITH A PEDESTRIAN. THE CONTACT STATED THE FAILURE WOULD OCCUR INTERMITTENTLY WHEN DRIVING AT SPEEDS OF 20-40 MPH. THE DEALER ADVISED THERE WAS A PROGRAMMING ERROR THAT COULD BE REPAIRED, BUT THE REPAIR WAS NOT COVERED UNDER THE CONTACT'S WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 45,000.

NHTSA complaint #10336605 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

I OWN A 2004 BMW 525I WITH 92,000 MILES ON THE ENGINE. I EXPERIENCED MY CAR CUTTING BACK AND THOUGHT I NEEDED A TUNE UP. I CALLED MY MECHANIC WHO STATED I DIDN'T NEED A TUNE UP. HE REQUESTED THAT I BRING THE CAR IN TO THE SHOP. THE NEXT WEEK I WAS DRIVING ALONG AND THE CAR SLOWED DOWN LOSING ACCELERATION. THE MESSAGE ON THE DIAGNOSTIC SCREEN STATED "TRANSMISSION FAULT". CAR WILL LOSE ACCELERATION AND YOU MAY NOT BE ABLE TO GO INTO "REVERSE". FAILSAFE STATUS..DRIVE MODERATELY. I TOOK MY CAR TO MY MECHANIC. HE PUT THE CAR ON THE DIAGNOSTIC MACHINE AND STATED NO CODE WAS INDICATED. IT DID NOT SHOW ANY PROBLEMS WITH THE TRANSMISSION. I FOLLOWED UP BY MAKING A CALL TO A LOCAL BMW DEALER. I TOOK THE CAR IN TO HAVE THE PROBLEM CHECKED. I WAS INFORMED THAT I NEEDED A NEW TRANSMISSION. I WAS DEVASTATED. I CALLED BMW NA AFTER I READ THAT NUMEROUS BMW OWNERS HAVE AND ARE STILL EXPERIENCING THE SAME PROBLEM. BMW NA WAS NOT WILLING TO OFFER ME ANY ASSISTANCE TO REPLACE MY TRANSMISSION. I WAS TOLD THE WARRANTY HAS EXPIRED AND THE ENGINE'S AT BMW DID NOT AGREE THAT THE "NO REVERSE" TRANSMISSION PROBLEM WAS A RECALL ISSUE. I RECEIVED A FOLLOW UP CALL ON 9/22/09 FROM BMW NA RESTATING THE FACT THAT THEY COULD NOT OFFER ME ANY ASSISTANCE. I FEEL THEIR IS A PROBLEM WITH THE ENGINEERING OF ALL BMW TRANSMISSIONS.

NHTSA complaint #10284870 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

2004 525I BMW WITH 70,000 MI HAD TRANSMISSION GO OUT SUDDENLY. I AM THE ORIGINAL OWNER AND HAVE HAD ALL SCHEDULED MAINTENANCE AT THE DEALER WHERE THE CAR WAS PURCHASED. I WAS TOLD THE TRANSMISSION IS A TOTAL LOSS AND IT IS NOTHING THAT I DID OR COULD HAVE PREVENTED, BUT THE REPAIR BILL IS ~7,000.00.

NHTSA complaint #10283339 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TL*THE CONTACT OWNS A 2007 BMW 525I. WHILE DRIVING APPROXIMATELY 75 MPH, THE TRANSMISSION WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND THE TRANSMISSION BEGAN TO SLIP. THERE WAS ALSO A VERY LOW POWER RESPONSE WHEN ACCELERATING. THE WARNING INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND THEY DETECTED FAILURE WITHIN THE COMPUTERIZED SYSTEM. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE HAS NOT BEEN REPAIRED AGAIN. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 18,000.

NHTSA complaint #10275030 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

MY 2004 BMW 525I TRANSMISSION HAS FAILED. I WAS DRIVING AND HAD STOPPED AT A STOP SIGN AND ATTEMPTED TO PROCEED AND THE CAR INCHED OUT AND JUST STOPPED.. I ALMOST HAD AN ACCIDENT AT THAT TIME BECAUSE THE CAR WOULD NOT PROCEED IN THE INTERSECTION.. A MESSAGE ON THE DASH READ THAT THE "TRANS DRIVE SAFE DRIVE MODERATELY" OR SOMETHING TO THAT EFFECT. WHEN I GOT TO MY DESTINATION I TURNED THE CARE OFF. THE NEXT TIME I STARTED THE CAR THE MESSAGE WAS GONE UNTIL ABOUT TWO WEEKS LATER. I LOOKED UP ANY INFORMATION THAT I COULD FIND ON BMW TRANSMISSIONS AND FOUND OUT THAT THERE ARE NUMEROUS CONSUMERS WHO HAVE EXPERIENCED OR ARE EXPERIENCING THE SAME PROBLEMS AND ARE DESPERATE FOR HELP. THE MAIN MALFUNCTION AT THIS POINT IS THAT THE CAR IS SLUGGISH AT TAKE OFF AND DEFINITELY WILL NOT GO INTO REVERSE AND THE DEALER HAS TOLD ME THAT THE TRANSMISSION IS SHOT. DRIVING THIS VEHICLE IS VERY DANGEROUS AND AT ANY TIME, UNKNOWINGLY THE TRANSMISSIONS ON THESE CARS CAN FAIL. PEOPLE DRIVING THESE BMW'S WITH FAULTY TRANSMISSIONS SHOULD BE MADE AWARE OF THE PROBLEM BEFORE SOME ONE IS SERIOUSLY HURT. I AM STILL PAYING ON THIS AUTOMOBILE IT'S FOUR YEARS OLD AND IT HAS FAILED WITH A MAJOR PROBLEM. PLEASE GO TO CONSUMER AFFAIRS ON THE INTERNET AND YOU WILL SEE THE NUMEROUS PEOPLE WHO HAVE THE SAME COMPLAINT ABOUT THIS EXPENSIVE AUTOMOBILE THAT HAS FAILED AND CONSUMERS HAVE TO PAY THOUSANDS OF DOLLARS TO GET REPAIRS DONE. MY CAR IS IN THE SHOP AS WE SPEAK, I HAVEN'T RECEIVED A QUOTE ON THE COST AS OF YET, BUT THE MECHANIC HAS ADVISED ME THAT THE TRANSMISSION IS NO GOOD.

NHTSA complaint #10251684 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

MY TRANSMISSION WENT OUT IN MY 1994 BMW 525I. THIS HAS BEEN REPORTEDLY HAPPENING TO MANY OF US. THE FAILURE WAS IN THE REVERSE GEAR FIRST, THEN THE FIRST TWO FORWARD GEARS.

NHTSA complaint #10250678 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION SLIPPING. I HAVE A 1995 525 BMW WITH 112000 MILES. THE TRANSMISSION INSTANTLY ONE DAY SLIPPED AND THE INDICATOR LIGHT WENT ON TO SEE MY DEALER. I DID AND WAS TOLD THE TRANSMISSIONS ON BMW'S MUST BE REPLACED, THEY CANNOT BE FIXED OR REPAIRED. I CALLED BMW AND SPOKE TO A TIM IN CUSTOMER SERVICE. I ASKED FOR SOME TYPE OF WARRANTY, AND WAS GIVEN A POLITE ANSWER OF 'NO' WE DON'T GIVE WARRANTIES TO ANYONE WHOSE CAR IS OVER THE WARRANTY. I TOLD HIM I WORKED FOR FORD FOR 20 YEARS, AND THEY HAD A REP COME OUT AND LOOK INTO EACH PROBLEM, EVEN IF OUT OF WARRANTY. TIM TOLD ME, BMW DOES NOT SEND REPS OUT TO DO THAT. I ASKED HIM WHO HIS BOSS WAS, I"LL TALK TO THEM. HE SAID HE DIDN' T HAVE A BOSS. I SAID, 'IF YOU REALLY WANTED TO HELP SOMEONE, YOU WOULD GET THEM A NEW TRANSMISSION FOR FREE, WOULDN'T YOU?" HE SAID 'YES' , WELL, THERE WAS MY ANSWER. HE DIDN'T WANT TO DO IT AT ALL. HE ALSO SAID AND CONFIRMED THAT THE TRANSMISSIONS ARE NOT ABLE TO BE TAKEN APART AND REPAIRED, THEY MUST BE REPLACED. THERE WAS NO HELP FROM BMW ON THIS PROBLEM. I DO HAVE A FEELING THAT TIM'S RELATIVES AND FRIENDS GET THEIR CARS REPAIRED UNDER WARRANTY EVEN THOUGH OUT OF THE TIME LIMIT. BUT, JUST A COMPLAINT HERE. I AM SELLING THIS CAR AND GOING BACK TO A FORD. I DO KNOW THE TRANSMISSIONS LAST FAR LONGER THAN 112000 MILES, AND I DO KNOW THEY SEND REPS OUT TO TALK TO PEOPLE AND WORK WITH THEM ON THEIR VEHICLES. SOUNDS LIKE OLD HENRY DID IT RIGHT, A TRUE AMERICAN. LISTEN TO THE WORKER.

NHTSA complaint #10116551 — an unverified report by a vehicle owner.