The contact owns a 2009 BMW X5. The contact stated that upon turning the heater on, there was a strong burning odor coming from the A/C vents. There was no warning light illuminated. The vehicle was taken to the dealer where the failure was diagnosed as a burning oil odor. The vehicle was taken to an independent mechanic, where the intake gasket was replaced; however, the failure persisted. The vehicle was taken back to the local dealer, where it was diagnosed that the failure was related to the fan relay. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact contacted the local dealer and a second dealer, Hansel BMW of Santa Rosa (2925 Corby Ave, Santa Rosa, CA 95407), and was informed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The mileage was approximately 103,000. The VIN was not available. The consumer stated the dealer replaced the fuel pump under the recall.
NHTSA complaint #11510022 — an unverified report by a vehicle owner.
MY VEHICLE HAS THE COMMONLY AND POPULARLY KNOWN WEEP HOLE COOLANT LEAK. APPARENTLY, BMW HAS HAD THIS PROBLEM IN PREVIOUS YEAR MODEL CARS, DATING BACK TO 2002. THEY HAVE KNOWN THAT THIS WAS A FLAW IN THEIR DESIGN. HOWEVER, THERE HAS BEEN NO RECALLS ON THE REPAIR OF THIS ISSUE, WHICH COSTS OWNERS THOUSANDS OF DOLLARS FOR LABOR ALONE FOR A RATHER 'INEXPENSIVE' PART. IT WOULD ONLY BE FAIR FOR BMW TO ISSUE A RECALL ON THIS COMMONLY KNOWN ISSUE THAT SEEMS TO AFFECT HUNDREDS OF OWNERS OF BMWS WITH THE SAME ENGINES. THE COOLANT LEAKS ON THE FRONT SIDE OF THE ENGINE THROUGH A RANDOM HOLE AROUND THE ENGINE. IT IS A RATHER COSTLY FIX DUE TO SEVERAL COMPONENTS NEEDING TO BE REMOVED BEFORE ONE CAN GET TO THE BROKEN PART TO BE REPLACED. IT IS UNFAIR FOR CURRENT OWNERS TO HAVE TO PAY SIGNIFICANTLY FOR A CAR THAT HAS A MAJOR DESIGN FLAW. VERY UNHAPPY WITH THIS CURRENT UNFORTUNATE DISCOVERY. MY CAR SUDDENLY LEAKED ALL THE COOLANT OUT OF THE CAR AND INTO THE ROAD AND MY DRIVEWAY. THANKFULLY I WAS ALMOST HOME WHEN IT BROKE DOWN. I COULD HAVE BEEN IN THE FREEWAY OR ON THE STREET AND IT WOULD HAVE BEEN A RISK OF GETTING HIT BY OTHER CARS IF MY CAR JUST SUDDENLY STALLED. AND I WAS DRIVING WITH BABY ON BOARD! I SUGGEST THIS BE INVESTIGATED, AS IT'S AN ISSUE THAT'S APPARENTLY VERY COMMON IN THE N62 ENGINES.
NHTSA complaint #11220177 — an unverified report by a vehicle owner.
LOST POWER WHILE CRUISING AT 60 M/HR. OTHER CARS ALMOST HIT ME WHEN I WAS TRYING TO MOVE TO THE SIDE FOR SAFETY CAUSING LOTS OF TRAFFIC. THEN WENT TO THE BMW DEALER (PATRICT BMW) IN SCHAUMBURG IL FOR DIAGNOSTIC AND FOUND OUT THERE WAS A PROBLEM IN THE FUEL SYSTEM ELECTRICALLY. THE WIRING HARNESS WERE MELTED , BLEW FUSE AND RELAY AND THEY SAID THE MOTOR ALSO BURNED OUT. I WILL ATTACHED DOCUMENT FROM THE BMW DEALER FOR MOE INFO.
NHTSA complaint #11204941 — an unverified report by a vehicle owner.
EXPERIENCE GLYCOL-LEAKAGE FROM THE EGR (EXHAUST-GAS-RECIRCULATION) VALVE CAN OCCUR. IN COMBINATION WITH TYPICAL SOOT DEPOSITS AND THE HIGH TEMPERATURES NORMALLY PRESENT IN THE EGR MODULE THIS MIGHT RESULT IN SMOLDERING PARTICLES. THIS COULD LEAD TO THE MELTING OF THE INTAKE MANIFOLD AND IN EXTREMELY RARE CASES RESULT IN A FIRE. BMW EXTENDED A RECALL TO EUROPEAN AND ASIAN MODELS BUT NOT THE US MY CAR HAS ONLY 51000 MILES. PLEASE SEE THIS LINK HTTPS://WWW.BMWBLOG.COM/2018/08/14/SOUTH-KOREA-BANS-RECALLED-BMW-MODELS-FROM-PUBLIC-ROADS-UNTIL-ISSUE-IS-FIXED/
NHTSA complaint #11187214 — an unverified report by a vehicle owner.
OIL LEAK FROM THE VALVE COVER GASKET GETS INTO THE HOT MANIFOLD CAUSING A BURNING OIL SMELL AND SMOKE GETTING INTO THE CABIN THROUGH THE AC VENTS CAUSING A MAJOR SAFETY ISSUE.
NHTSA complaint #11183676 — an unverified report by a vehicle owner.
THE COOLANT LINES NEEDED COMPLETELY REPLACED CAUSING THE ENGINE TO START BARRELING SMOKE AFTER ABOUT 400-500 FT. LOOKED LIKE IT WAS ON FIRE THERE WAS SO MUCH SMOKE. GOT REPAIRED AT BMW OF WESTLAKE IN OHIO. THEY TOLD ME THERE WAS NOTHING I COULD DO TO HAVE PREVENTED IT.
NHTSA complaint #11144153 — an unverified report by a vehicle owner.
N63 ENGINE FAILURE AND BATTERY CHARGING PROBLEMS. ENGINE BLOWS MASSIVE AMOUNTS OF WHITE SMOKE FROM REAR TAILPIPES AND BATTERY INDICATOR STATES LOW CHARGE. THIS IS A KNOWN DEFECT TO BMW AS THOUSANDS HAVE COMPLAINED BUT BMW IS ATTEMPTING TO WEASEL THERE WAY OUT OF THIS BY NOT RELEASING A RECALL.
NHTSA complaint #11142958 — an unverified report by a vehicle owner.
RUNNING ON THE HIGHWAY RECEIVED HIGH ENGINE TEMP WARNING ORANGE. IT QUICKLY WENT TO RED AND READ ON DASH TO PULL OVER. THE VEHICLE LOST MUCH POWER AND STEPPING ON ACCELERATOR WOULD NOT LET IT GO FASTER. I HAD TO MOVE TO THE RIGHT ON THE HIGHWAY WHILE SOME VEHICLE SPED THROUGH TO THE RIGHT OF ME WHILE TRYING TO PULL OVER. 45,000 MILES AND WATER PUMP HAD FAILED WHEN I TOOK IT TO A SHOP.
NHTSA complaint #11113494 — an unverified report by a vehicle owner.
LOST POWER STEERING AS CAR WAS DRIVING APPROX 50 MPH ON GARDEN STATE PARKWAY AT TOP OF BRIDGE OVER THE RARITAN RIVER. BATTERY WARNING CAME ON DASH, CAR LOST POWER AND THEN STOPPED. NO COLLISION OR INJURY. CAR WAS TOWED AND REPAIRED BY C&T TOWING AND AUTO REPAIR, RAHWAY NJ. DAMAGE OBSERVED WAS PARTIALLY MELTED IDLER PULLEY AND SHREDDED DRIVE BELT. REPAIR INCLUDED REPLACEMENT OF DRIVE BELT, A.C. STRETCH BELT, IDLER PULLEY, DRIVE BELT TENSIONER AND SERPENTINE TENSIONER.
NHTSA complaint #11104935 — an unverified report by a vehicle owner.
I WOULD LIKE TO REPORT A VANOS ISSUE THE CAMSHAFT BOLTS LOOSEN AND BREAK AND IT COULD BE CATASTROPHIC. MY BOLTS LOOSENED AND I CAUGHT IT IN TIME BUT IF I DIDN'T KNOW ANY BETTER I COULD'VE HAD A COMPLETE ENGINE FAILURE. MY CODE ORIGINALLY CAME UP AS CAMSHAFT STICKING. WHEN THE PROBLEM ORIGINATED I WAS TRAVELING ON A MAIN CITY ROAD AND MY CAR WENT INTO REDUCED POWER MODE.
NHTSA complaint #11083702 — an unverified report by a vehicle owner.
DURING HARD ACCELERATION OF THE CAR WHILE GETTING ON THE FREE WAY RAMP, THE CAR WENT INTO LIMP MODE. THE ENGINE PERFORMANCE WAS DEGRADED AND I HAD TO PULL ON THE SIDE OF THE ROAD TO RESTART THE CAR. THE CAR WAS TAKEN TO BMW OF BELLEVUE NEXT WEEK AFTER INITIAL DIAGNOSIS OF A DME INTERNAL FAULT BY A SIGNATURE INDEPENDENT KIRKLAND. BMW OF BELLEVUE REPLACED AIR MASS FILTER AND OIL FILLER CAP. A FEW WEEKS LATER THE ISSUE HAPPENING AGAIN DURING REGULAR DRIVING ON THE FREEWAY. BMW OF BELLEVUE DIAGNOSED THIS AS A VACUUM HOSE LEAK. A FEW WEEKS LATER THE CAR WENT INTO LIMP MODE AGAIN WHILE GETTING ON THE FREEWAY, BMW OF BELLEVUE DIAGNOSED THIS AS A HIGH PRESSURE FUEL SENSOR SHORT, BMW OF NORTH AMERICA OPENED A PUMA CASE, BUT DID NOT RECOMMEND REPLACING THE DME YET. RIGHT AFTER PICKING UP THE CAR I HIT THE ISSUE AGAIN WHERE THE CAR WENT INTO LIMP MODE WHILE ACCELERATING ON THE FREEWAY RAMP. BMW OF BELLEVUE WORKED WITH BMW OF NA TO REPLACE THE DME WHICH IS COVERED UNDER WARRANTY. BEFORE HANDING THE CAR BACK THE SERVICE ADVISOR DID A TEST AND WAS ABLE TO STILL REPRODUCE THE CAR GOING INTO LIMP MODE GETTING ON THE FREEWAY, DIAGNOSIS IS STILL NOT KNOWN. IT HAS BEEN 3 MONTHS TODAY SINCE THE ISSUE FIRST HAPPENED AND THE CAR HAS BEEN OUT OF USE FOR MORE THAN A MONTH AND THERE IS STILL NO CONCLUSION ON THE ROOT CAUSE.
NHTSA complaint #11080383 — an unverified report by a vehicle owner.
WHILE DRIVING MY CAR FOR APPROXIMATELY 3 MINUTES ENGINE SEIZED WITHOUT WARNING. I COASTED ON TO THE SHOULDER OF THE ROAD AND PUT IT IN NEUTRAL AND TRIED TO START IT.... NOTHING. OIL LEVEL WAS GOOD . I HAD IT TOWED TO BMW DEALER AND THEY TOLD ME ENGINE WAS LOCKED UP BUT COULDN'T TELL ME WHY. I JUST HAD RECALL WORK DONE ABOUT A MONTH OR TWO AGO AT THE SAME BMW DEALER. THEY MENTIONED AN AFTERMARKET OIL FILTER BUT THAT DOSE NOT MAKE ANY SENSE TO ME. HAS THE MANUFACTURER EXTENDED WARRANTY COVERING THIS ?
NHTSA complaint #11055988 — an unverified report by a vehicle owner.
REPAIRING THE TWIN-TURBO IN MY CAR AGAIN IN LESS THAN A YEAR. LAST YEAR THE HOSES WERE ALL REPLACED THIS YEAR THE DEALER SAYS ONE OF THE TWO TURBO UNITS IN THE VEHICLE NEEDS TO BE REPLACED (SMALLER ONE). THE CAR IS DOING THE SAME THING IT DID LAST YEAR LOSING POWER AND MAKING IT DANGEROUS TO DRIVE IN TRAFFIC. IF I AM AT A LIGHT, IT TAKES ABOUT HALF A BLOCK FOR IT TO ACCELERATE TO NORMAL SPEED. I ENDED UP HAVING THE CARE TOWED TO THE BMW DEALER BECAUSE IT WAS NOT SAFE TO DRIVE IN TRAFFIC. AFTER DOING SOME RESEARCH, THE TURBO HAS BEEN AN ONGOING PROBLEM IN THE X5D. THE CAR IS JUST UNDER 85,000 ORIGINAL MILES AND SINCE I PURCHASED TWO YEARS AGO, HAVE LOGGED LESS THAN 20,000 MILES. .
NHTSA complaint #11054582 — an unverified report by a vehicle owner.
I AM WRITING IN REGARDS TO A TECHNICAL SERVICE BULLETIN / RECALL FROM BMW SI B16 0102 WHICH I OBTAINED FROM THE NHTSA WEBSITE. MY BMW, [XXX], WAS SHOWING AN EMISSIONS FAULT CODE RELATED TO THE PART ADDRESSED IN THE UNLIMITED AGE/MILEAGE TSB. I WENT TO THE DEALER REGARDING THIS ITEM TO FIGURE OUT WHAT CAN BE DONE AT AROUND 110,000 MILES IN APRIL OF 2017. I WAS INFORMED THE PART IS NOT IN STOCK. WHEN I RETURNED IN JUNE TO SEE ABOUT THE SERVICE BEING DONE, I WAS, AGAIN, TOLD THE PART WAS NOT IN STOCK - AND THAT I ALSO DO NOT QUALIFY AS THE VEHICLE NOW HAS 130,000 MILES, AND THE NEW BULLETIN HAS A MILEAGE CUTOFF OF 120,000 MILES. I WAS INFORMED I COULD CONTACT BMW DIRECTLY AND DISCUSS A 'HARDSHIP.' UPON CONTACTING BMW DIRECTLY, I WAS INFORMED THAT THEY WOULD NOT DO ANYTHING TO HELP. I AM ATTACHING THE ORIGINAL TSB AND UPDATED TSB FOR THE DIESEL EXHAUST FLUID ISSUE. I AM ALSO ATTACHING THE RESPONSE FROM BMW. ADDITIONALLY, MY VEHICLE IS NOW EXHIBITING PROBLEMS WITH THE HIGH PRESSURE FUEL PUMP, ANOTHER COVERED EMISSIONS ITEM FOR UNLIMITED MILEAGE; AND AM NOT SEEING ANY RESOLVE FOR THAT. THE TSB IS ATTACHED. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'
NHTSA complaint #11046486 — an unverified report by a vehicle owner.
X5 XDRIVE 35I SAV; WHILE DRIVING UNDER NORMAL STREET AND HIGHWAY CONDITIONS, VEHICLE SPEED AND ENGINE RPM HAVE BECOME UNSTABLE. THIS CAUSES THE VEHICLE TO INCREASE AND DECREASE IT'S SPEED INTERMITTENTLY AND WITHOUT WARNING. THE VEHICLE IS NOT TRUSTWORTHY AS YOU MAY LOSE POWER, OR UNINTENTIONALLY ACCELERATE WHILE TRYING TO EXECUTE A DRIVING MANEUVER, CAUSING A DANGEROUS CONDITION. CHECK ENGINE WARNING LIGHT ILLUMINATES. VEHICLE WAS BROUGHT TO BMW DEALERSHIP (ZT MOTORS) FOR DIAGNOSTICS. SERVICE PERSONNEL STATED THAT THE HIGH PRESSURE FUEL PUMP INDICATED A LOW FUEL PRESSURE AT THE INLET. THIS WOULD TELL ME THAT THE LOW PRESSURE FUEL PUMP IS NOT DELIVERING THE CORRECT FUEL FLOW/PRESSURE TO THE HIGH PRESSURE FUEL PUMP. REF NHTSA CAMPAIGN # 16V746000 ET AL. DIAGNOSTICS ALSO INDICATED THE VALVETRONIC MOTOR SHOWS IT SHORT CIRCUITING. DEALER RECOMMENDED REPLACEMENT OF VALVETRONIC MOTOR, CAM SHAFT AND OIL INJECTORS. THE REPLACEMENT OF THE CAM SHAFT AND OIL INJECTORS ARE UNNECESSARY MAINTENANCE ITEMS, ONLY THE VALVETRONIC MOTOR WOULD NEED TO BE REPLACED, AND FUEL SYSTEM REPROGRAMMED. REF NHTSA CAMPAIGN # 14V176000 ET AL. RECOMMEND RECALL REPLACEMENT OF BOTH HIGH PRESSURE AND LOW PRESSURE FUEL PUMPS, VALVETRONIC MOTOR, VANOS CAM SHAFT AND OIL INJECTORS AS WELL AS REPROGRAMMING OF FUEL OPERATING SYSTEM. ALSO REPLACE CAM SHAFT MOUNTING BOLTS.
NHTSA complaint #11030853 — an unverified report by a vehicle owner.
DRIVE THE VEHICLE ON VACATION AND THE ENGINE WOULD STUDDER AND STALL ON THE HIGHWAY AND AN ERROR PROMPTED ON THE VEHICLE DASHBOARD THAT DISPLAYED "ENGINE MALFUNCTION" REDUCED POWER. OCCASIONALLY THE VEHICLE ENGINE WOULD CUT OFF WHILE ON THE ROAD AND NEEDED TO BE TOWED TO THE DEALERSHIP. THE DEALER DIAGNOSED THAT IT HAS A HIGH PRESSURE FUEL PUMP MALFUNCTION THAT NEEDED TO BE REPLACED AND ALTHOUGH THE VEHICLE IS NOT PART OF THE RECALL IT SHOWED THE SAME SYMPTOMS AS SOME PROBLEMATIC MODELS. THIS OCCURRED WHILE DRIVING THE VEHICLE ON BOTH LOCAL ROADS AND THE HIGHWAY. IN ONE OCCASION, I NEEDED TO RESTART THE CAR TO GET IT TO A SAFE LOCATION.
NHTSA complaint #11020569 — an unverified report by a vehicle owner.
ON SATURDAY MAY 6TH 2017. I WAS DRIVING WHEN I HEARD THIS NOISE TO MY UNTRAINED EAR IT SEEMED AS IF THE NOISE WAS COMING FROM MY FRONT TIRES? I PULLED OVER GOT OUT TO CHECK MY FRONT TIRES/WHEEL'S AND THERE WAS NOTHING, I GET BACK INTO MY VEHICLE AND START DRIVING AGAIN AFTER A FEW MINUTES THE SAME NOISE COULD BE HEARD AGAIN SO ONCE AGAIN I PULLED OVER GOT OUT AND CHECKED MY TIRES/WHEELS AND UNDERCARRIAGE. AS I AM LOOKING THERE IS NOTHING HANGING OR LOOSE, I GET BACK INTO THE VEHICLE AND STARTED TO HEAD TOWARDS MY HOUSE I WAS ONLY ABOUT 6 BLOCKS AWAY FROM HOME SO I CALL MY FIANCE AND ASKED HE TO COME OUTSIDE (I WANTED HER TO DRIVE THE VEHICLE JUST A LITTLE SO THAT I COULD SEE IF MY WHEELS WERE DOING ANYTHING STRANGE, THIS WOULD HELP ME TO BETTER EXPLAIN WHAT I THROUGH WAS HAPPING TO MY VEHICLES WHEELS/TIRES) AS SOON AS I HANG THE PHONE UP I SLOWED DOWN TO GO OVER A SPEED HUMP AT THE TIME I DID NOT NOTICE BUT I HAD LOST POWER IN THE VEHICLE AS I TRIED TO USE MY BREAKS THE VEHICLE DID NOTHING AND I DO MEAN NOTHING SO NOW I AM ROLLING STRAIGHT AND GO THROUGH TWO STOP SIGNS HOPING AND PRAYING THAT ONE HITS ME, DUE TO THE VEHICLE HAVING NO POWER. A MESSAGE SHOWS UP ON THE SCREEN SAYING 'TRANSMISSION MALFUNCTION' THE MALFUNCTION MAYBE RESOLVED BY RESTARTING. CONTRACT NEAREST BMW CENTER IF NECESSARY. USE EMERG. RELEASE TO DISENGAGE PARK DETENTION PRIOR TO TOWING OR PUSHING VEHICLE. NOW MINE YOU THIS MESSAGE ONLY SHOWED AFTER THE VEHICLE LOST ALL POWER. AS I AM GOING THROUGH THE SECOND STOP SIGN THERE IS A SLIGHTL/SMALL HILL THAT I WENT UP AND THE VEHICLE LOST ENOUGH SPEED THAT I WAS ABLE TO SMASH THE BRAKES REAL HARD TO STOP THE VEHICLE FROM MOVING. A CAR ALL MOST HIT ME IN THE REST BECAUSE OF THIS ACTION, AND NOW I AM SITTING ON THIS SLIGHT HILL HOLDING MY FOOT ON THE BREAK. ONCE THE VEHICLE WAS TOWED TO A BMW DEALERSHIP I WAS TOLD ABOUT THE DRIVESHAFT RECALL.
NHTSA complaint #10985577 — an unverified report by a vehicle owner.
VEHICLE KEEPS STALLING AND ACCELERATING SHUTS OFF IN THE MIDDLE OF THE ROAD WHILE DRIVING MAINLY IN THE CITY I COULD B TURNING OR DRIVING STRAIGHT AND SHUTS OFF AND TAKES AWHILE TO RESTART...ELECTRICAL WIRING KEEPS SHORTING OUT SUNROOF SHORTS OUT AND TAIL LIGHT KEEPS BURNING OUT...I TOOK IT TO DEALER PAID $5000 AND SAME PROBLEM CONTINUES TO OCCUR
NHTSA complaint #10980933 — an unverified report by a vehicle owner.
ENGINE SUDDENLY OVERHEATS DUE TO DEFECTIVE WATER PUMP AND SHUTS DOWN QUICKLY. OVER HEAT WARNING CAME ON A FEW SECONDS BEFORE ENGINE IMMEDIATELY DERATED AND WENT TO IDLE. VERY DIFFICULT TO GET OUT OF HARMS WAY WITH NO ACCELERATION AT ALL. ONLY 37,700 ON VEHICLE. BMW OWNERS REPORTING HIGH FREQUENCY OF PREMATURE WATER PUMP FAILURES. REPAIRS COST $1,499 WITH ADDITIONAL TOWING CHARGES OF $285. THE ELECTRIC WATER PUMPS HAVE POOR QUALITY PLASTIC IMPELLERS. BMW SHOULD RECALL THIS COSTLY REPAIR DUE TO SAFETY CONCERNS. MY FAMILY AND I WERE STRANDED FOR HOURS WAITING ON A TOW DURING UNSAFE CONDITIONS.
NHTSA complaint #10979346 — an unverified report by a vehicle owner.