15 of the
151 complaints about the 2020 BMW X5 are about the
other systems — 10% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
170 miles.
The A/C evaporator coil failed on my 2020 BMX X5 S40i prior to 27,564 miles. It was taken into the local dealer for evaluation at a cost of $811.33 and UV dye was added with refrigerant, which escaped over a 2 week period. The final diagnosis after a further two weeks and at a cost of $301.38, later confirmed that the evaporator coil needed to be replaced. The BMW Dealer quoted $6,686.35 for the replacement. BMW USA refused to comp or co-op the repair. From my research I see that this is a common failure across a large segment of the BMW range and that a conservative minimum of 771,000 BMW vehicles could be affected and that the cost to cure each vehicle ranges between $4,000 & $8,000. I was very surprised to hear that the was no NHTSA recall nor Class Action Law Suit given the potential number of cases and huge expense to cure
NHTSA complaint #11758762 — an unverified report by a vehicle owner.
Cranston, RI
UNKNOWN OR OTHER
It’s a common issue between 2019-2020 where the oil pump which came from factory has plastic impellers which crack/disintegrate causing catastrophic failure to the engine disabling the vehicle the only warning signs before this happens is you cant read oil level and or the car prompts with a warning low oil messages if untreated the car will have catastrophic engine failure with little to no warning the car was mass produced and this is a common issue therefore should be recalled
NHTSA complaint #11751677 — an unverified report by a vehicle owner.
Plano, TX3 injured
UNKNOWN OR OTHER
The AC system blowed hot air. There's must be a problem with this model because my friend also have the 2021 BMW X5 and its AC also have problem. We're suffering from this due to Manufacturing defect.
NHTSA complaint #11748457 — an unverified report by a vehicle owner.
Redondo Beach, CAFire
UNKNOWN OR OTHER
While driving through west Los Angeles, the vehicle suddenly began emitting white smoke from the engine compartment. There were no prior warning lights, messages, or symptoms indicating a problem. The smoke quickly intensified and turned dark. Thick smoke filled the air, and the cockpit, with the smell of toxic fumes. I safely maneuvered to the shoulder and exited the vehicle with my passenger. Flames erupted from the front of the vehicle. We called 911, which dispatched the fire department. The LAFD responded, cutting open the hood in order to extinguish the fire. The vehicle was towed to a yard following the incident. The vehicle and its contents were declared a total loss. BWM North America dispatched a technician to inspect the vehicle. After inspection, the manufacturer indicated that the starter was the source of the fire. At the time of the incident, the vehicle was subject to a safety recall related to the starter with no remedy available. The failure occurred without warning. Both occupants were exposed to heavy smoke.
NHTSA complaint #11722345 — an unverified report by a vehicle owner.
Santa Monica, CA
UNKNOWN OR OTHER
My 2020 BMW X5 (VIN available upon request) is subject to safety recall 25V-644 due to a fire risk. The recall has been open since November 2025. BMW has confirmed there was no available remedy for an extended period, and a BMW-coordinated service visit on January 15, 2026 could not be completed due to dealership issues. Despite repeated follow-ups with BMW North America, there has been no confirmed repair date and no consistent transportation support while the safety recall remains unresolved. I am concerned about the prolonged delay in addressing this safety issue.
NHTSA complaint #11717073 — an unverified report by a vehicle owner.
Cedar Park, TX
UNKNOWN OR OTHER
Starter can malfunction and start fire. Unable to park in garage due to potential fire risk. BMW is aware of the problem. Care was serviced at BMW dealer and said that they have no remedy. This recall is over 15 months old.
NHTSA complaint #11707139 — an unverified report by a vehicle owner.
Mount Holly, NJ
UNKNOWN OR OTHER
I was having intermittent starting issues. After a starter recall was done, things got worse. Idrive will not turn off and car wont start draining battery. Battery was replaced and car still having idrive and start issues. It would not start after being hot. I was told extended warranty is not covered and that the center console was the problem after diagnostic. They want approximately $3000 to repair. The car will not start at all and the idrive will not shut off. They said it will continue until repaired.
NHTSA complaint #11704622 — an unverified report by a vehicle owner.
College Park, GA
UNKNOWN OR OTHER
When it rains water comes into the drivers side from the roof (sun visor area), and under the dashboard. Depending on how much rain, it leaves a puddle on the floor mat, and constantly drips on the driver as I drive.
NHTSA complaint #11666151 — an unverified report by a vehicle owner.
San Marcos, CAFire
UNKNOWN OR OTHER
I own a 2020 BMX X5 S40i. Car was parked and turned off. When I tried to turn the car ON, the car refused to start and smoke and fire smell started coming from engine compartment. I opened the hood and could smell a burning smell. Waited for smell to disappear and tried starting the car again. Car would not start and burning smell appeared again. Got a warning on the dashboard that engine compartment was overheated and car would be ready to start after 180 seconds. Called AAA to jump start car and same behaviour was observed and car refused to start. Technician also stated that battery was completely dead. Took car to dealer and replaced main and start/ stop battery. Car still would not start. On inspection dealer observed started mechanism was shorted and needed to be replaced. After replacement, car starts fine without burning smell. Going through recall database, this issue with fire hazard from starter assembly is documented for my make, model and year but when I enter the VIN number it doesnt apply to ny vehicle VIN number. 4 year old child and me were occupants of the vehicle when burning incident happened originally.
NHTSA complaint #11663702 — an unverified report by a vehicle owner.
Houston, TXFire
UNKNOWN OR OTHER
A few months ago there was a recall on my car (some problem with starter engine) and after few month I started the engine by pressing the brake pedal and pressing the start button. But the engine did not start, I saw smoke from under the hood, then I opened the hood and saw fire near the engine on the right (driver's) side. People in the parking lot helped put out the fire with a fire extinguisher while I called 911 for fire department, they came and recorded it (fire slip -[XXX]), [XXX}., Houston, Texas, 77043 (place where it happened). I have pictures and videos this incident. We were afraid that we would die in this car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11644387 — an unverified report by a vehicle owner.
Manor, TX
UNKNOWN OR OTHER
Shark fin antenna - Telematic control module malfunctioning. Seems to have a leak issue causing modules inside/under antenna to get wet from rain or car washes. This is causing an error message "SOS emergency call system malfunctioning", you will not be able to make calls under an emergency. Other issues include GPS, remote start, lane assist, adaptive cruise control etc... not working properly and potentially causing an accident on the road.
NHTSA complaint #11635188 — an unverified report by a vehicle owner.
Fayetteville, AR
UNKNOWN OR OTHER
There is a known recall on this car for engine/starter. It is a hazard and should be repaired. On 10/23 we scheduled and took the car to BMW of NW Arkansas. They refused to complete the recall on the starter without us paying $189.00 for a vehicle diagnostic and I am sure that would have resulted in more fees. A recall should be completed free of charge as it directly relates to a safety issue. Another issue on the vehicle that I am not sure if it is a recall items is the GPS antenna allows water to intrude and thereby the GPS/safety location services to fail. It is a complained about issue online from BMW owners. BMW will not replace or repair this faulty item either. "A recall is issued when a manufacturer or NHTSA determines that a vehicle, equipment, car seat, or tire creates an unreasonable safety risk or fails to meet minimum safety standards." BWM refuses to adhere to this standard and is placing my family at risk by failing to repair without me paying for it. They should be forced to complete this at no cost.
NHTSA complaint #11624493 — an unverified report by a vehicle owner.
Roslyn, NYCrash
UNKNOWN OR OTHER
WHILE PARKING THE VEHICLE IN A HEAD-ON PARKING SPOT, THE CAR SUDDENLY ACCELERATED WITHOUT WARNING AND HIT A WALL. THE CAR THEN WENT INTO REVERSE AND SPED UP RAPIDLY UNTIL IT HIT A CONCRETE PATIO ON THE OTHER SIDE OF THE PARKING LOT. THE BRAKE PEDAL WAS DEPRESSED WITH SUBSTANTIAL FORCE THE ENTIRE TIME THE VEHICLE WAS MOVING BUT THE VEHICLE WOULD NOT STOP MOVING. THE BRAKES DID NOT ENGAGE. I DO NOT RECALL HOW THE CAR WENT FROM DRIVE TO REVERSE. FORTUNATELY, THERE WERE NO PEOPLE OR CARS IN THE PARKING LOT AT THE TIME OF THE INCIDENT. THE AUTO BODY SHOP THAT CURRENTLY HAS POSSESSION OF THE VEHICLE COULD NOT FIND ANYTHING WRONG WITH THE COMPUTER/ELECTRICAL SYSTEMS IN THE VEHICLE NOR WERE THEY ABLE TO RECREATE THE INCIDENT. I DO NOT KNOW HOW THOROUGH THEY LOOKED FOR PROBLEMS. BMW HAS BEEN NOTIFIED AND HOPEFULLY THEY WILL SEND A CREW TO INVESTIGATE. THE CAR IS CURRENTLY AT THE AUTO BODY SHOP BUT MY INSURANCE GOMPANY, GEICO, WILL HAVE THE CAR TOWED TO ONE OF THEIR FACILITIES IN A COUPLE OF DAYS. THE CAR HAS BEEN DEEMED A TOTAL LOSS DUE TO ALL OF THE DAMAGE. I HAVE BEEN HAVING ELECTRONICS ISSUES WITH THE CAR SINCE PURCHASE IN JUNE 2020, HOWEVER, THEY HAVE BEEN RELATED TO THE ENTERTAINMENT AND COMMUNICATION SYSTEMS. IN HINDSIGHT, I REALIZE THAT I HAD TWO OTHER INSTANCES IN THE PAST WITH SUDDEN ACCELERATION WITH THIS CAR. I THOUGHT NOTHING OF IT AT THE TIME BUT THEY MAY BE RELATED TO THIS LATEST INCIDENT.
NHTSA complaint #11492772 — an unverified report by a vehicle owner.
Lumberton, TX
UNKNOWN OR OTHER
squeaking and grinding in steering column, overheated steering column to the touch. Took to local BMW and was informed it was an issue with steering rack (after two visits there) and part has to be ordered and replaced.
NHTSA complaint #11482223 — an unverified report by a vehicle owner.
at 170 milesSikeston, MO
UNKNOWN OR OTHER
AIR CONDITIONING QUIT WORKING ON DAY 2 OF OWNERSHIP. DEALER SAYS THE COMPRESSOR NEEDS TO BE REPLACED AND THERE IS A LEAD TIME BETWEEN 2 WEEKS AND 2 MONTHS. AFTER PURCHASING A CAR THAT COST ABOUT $125,000 AND DRIVING IT ONE TIME, IT HAD TO BE SENT TO THE SHOP. SINCE IT IS SO HOT WHERE I LIVE, DRIVING THE CAR IS OUT OF THE QUESTION. BMW DID GIVE ME A LOANER CAR, BUT THE VALUE OF THE LOANER IS ABOUT 45% OF THE CAR I PURCHASED.
NHTSA complaint #11329328 — an unverified report by a vehicle owner.