137 of the
1,332 complaints filed about the Buick Lucerne
are about the fuel system —
10% of everything owners reported.
The worst model year for it is 2008.
The contact owns a 2009 Buick Lucerne. The contact stated that while driving approximately 65 MPH, the vehicle suddenly stalled. The contact was able to safely drive onto the shoulder, and the tow truck was contacted. The vehicle was later towed to the local mechanic, who diagnosed that the fuel relay had failed. The contact was informed that the relay had failed due to the location under the driver’s side rear seat, and while touching the motor terminal. The contact stated that there was a TSB associated with the failure. The vehicle was not yet repaired. The manufacturer and local dealer were contacted. The failure mileage was 70,000.
NHTSA complaint #11729732 — an unverified report by a vehicle owner.
Fuel pump relay is overheating to dangerously high temperatures. At least 211 F degrees. Causes the fuel pump fuse to melt leaving me stranded. Immediate replacement of the 20 AMP fuse is necessary to get the car running again. The fuel pump relay gets really hot even if the AC is not on. Waited for hour and a half in near 100 F degree heat for a tow truck to it home. I’m lucky the car did not catch on fire. I know quite a few of the Buick Lucerne’s have had recalls regarding this item. Picture of the actual car is included. No police report was necessary as this was a breakdown situation. This has utterly disrupted my life because I do not have access to a car with good air conditioning until this problem is repaired.
NHTSA complaint #11727683 — an unverified report by a vehicle owner.
We have a Buick Lucerne 2010. We went out it would not start. Tow it to dealership they replace the fuel pump. We did. Get it home next day it will not start again. Tow it to dealership again. This time they find melted wire connectors. Under back seat and on a fuse box.They replace them it starts and melt them again. This time they call to junk yards to get a used fuse box and connectors. Because of cost. The junk yards did tell them it's a known problem with these cars and they sell these fuse boxes and connectors sell as fast as they get them. We said no used parts on this car. Come to find out that GM now's about this problem. And has not done anything about it. They meaning GM. Has even put out papers on the internet as how to try and fix it. Such as cut the insulation around the fuse box.And even cutting the seat belt bracket. My wife drives this car everyday. Now she is afraid of it. Because if it happened once could it happen again. I don't now. I have drove GM's all my life but am not happy about this. What do I do. Please help. I am a retired firefighter and I do not want her to drive this car if it could catch fire.
NHTSA complaint #11680803 — an unverified report by a vehicle owner.
Fuse box (rear) 2008 Buick Lucerne CXL. FUEL PUMP Relay burns fuses out quickly. The fuse box located under the back seat has been having issues of burning where the fuel pump relay is located. It then in turn shorts out the fuse box which keeps needing to be replaced. This is a safety issue as it catches fire under the back seat. Fuse box has been replaced before and continues to have issues and melts, causing the vehicle to die in mid traffic, does at stop lights or even just parked and running it dies out and smells like burning plastic. The fuse box has caught fire several times. The issue has been confirmed by several mechanics and dealerships. Also there is a history of electrical problems with the rear fuse box in carfax. There was no warning, and now the check engine light is illuminated. We bought the vehicle last year in June of 2024. There seem to be no problems at the time until shortly after we had bought the vehicle. Turns out there's a long history of electrical problems involving the rear fuse box with this vehicle. I have uploaded screenshots of the car report on this vehicle. There are more complaints.
NHTSA complaint #11613680 — an unverified report by a vehicle owner.
The car died suddenly and would not start, with no warnings or codes. Towed it to a Midas repair shop and it was diagnosed as a corroded Low Profile Fuel Pump relay. This was replaced, and the car ran fine for 3 days before going dead in the middle of driving and left me stranded in an intersection. Had to get it towed back to Midas where it was more accurately diagnosed that the issue with the relay was being caused by a faulty Rear Electrical Center. Both of these parts have been recalled, and I have only owned this car for a little over a year. It has only around 40,000 miles on it. Despite this recall, upon taking the car to the local Buick dealership, they stated they could not cover the recall due to it being expired before I even owned the car. I do not understand how it is right or fair for this to have to be paid out of pocket, for $183.53 and $818.81 respectively, when it is not my fault, it is a faulty GM parts issue, and GM stated they will not stand behind their product and cover the recall despite the evident risk to my safety if I was to continue driving the car without repair. I understand it is expired, but I fail to see how this is ethical when the part is still faulty to the point of being dangerous.
NHTSA complaint #11605954 — an unverified report by a vehicle owner.
Our Buick Lucerne would crank but wouldn't turn over when trying to start after trying to pick up take out. 1) It was suggested to me by a passerby that it sounds like a fuel pump relay. 2)I started to smell something burning. The passerby who happens to be familiar with Buick Lucerne tried to help. He lifted the back seat and showed me the fuel pump relay which was burned. Then he switched the electrick window relay which is the exact same relay switch and the car started. Went immediately to an autozone and bought spare fuel pump relay. Thought that solve the problem, but every 2 to 3 days I'd smell that burning smell. 3) The mechanic I've been going to for 10 years confirmed the issue 4)Have not taken to dealer or insurance rep 5)Absolutely no visual warning on dashboard. the warning happens when I start smelling the burning odor. Started one and a half months ago....
NHTSA complaint #11578072 — an unverified report by a vehicle owner.
Fuel Pump relay fuse is getting burnt up and not allowing car to start. This is a known problem and Nhtsa has already made a recall but mine isn’t recalled. You would think since mine is a 2008-2011 Buick Lucerne it would be able to get fixed. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11567044 — an unverified report by a vehicle owner.
Bought my car Sept. 2022.Within the first couple of months I started having intermittent problems that seemed fuel related.After some research I found out my car had a TSB that has been out since 2016. With this knowledge I took the back seat out of my car and the problems all stopped.June of 2023 started having some problems that were sort of similar to what I was experiencing before with some power loss, had vehicle taken to mechanic who diagnosed an interlock system problem.I thought maybe that would fix all my problems and put my back seat back. I travel 4 hours once a month to go see my son and only took my car once on that trip because of not being able to have a back seat.Me thinking the interlock fix was the solve all to my problems I put the back seat in and started my drive to go see my son. 3 hours in stop for gas, try to start my car, cranks won’t start, not getting fuel. Called mechanic who just worked on my car, suggested to check my fuel pump fuse and fuel relay, find my fuel relay is melted. Replace fuel relay and pulled the back seat out, car fires right up no problems. Continue hour drive to see my son, picked up my son so had to put the back seat in. Drive about 7 blocks and stop at Walmart, try to start car and same problems as before. Replace Fuel relay, propped up the back seat around the fuse box trying to still make it safe enough for my son to ride back there, no more problems that trip, propped seat left leaning in the back. August-Was driving down the Highway at 65mph with the cruise on, when all of a sudden my car begins to lose power and proceeds to stall with no warning. Lost complete control of steering and had minimal control breaking, had to coast to a stop with no breaks or steering, lucky was on a straight rural hwy, can’t imagine if I was in the city. Seat had fallen up against fuse box fried fuel relay again and the control module. Take to shop for repair, control module, fuel pump replaced NSB complete all at my expense.
NHTSA complaint #11549297 — an unverified report by a vehicle owner.
I went to start the vehicle and it failed to start. I found the fuel pump relay to be badly burned 🔥. On the 30 pin. The board was melted at the 30 pin spot for the fuel pump relay. I purchased a new relay from NAPA. I questioned whether they had a new replacement fuel pump. They told me it was not available only through the dealership. My concern was that where the relay was located at there was a possibility of a fire given how badly the relay and board was burned. I replaced the relay and purchased an extra incase this might happen again. To my surprise it happen just days later while I was driving on the expressway. I had to get off the road immediately. Engine died, no power steering. I checked the relay, it was smoking hot. I will have to have the problem resolved. There is no way a relay should ever get hot, let alone that hot. The fuel pump fuse was not effected. Why is the relay not protected from getting so hot. There is definitely a real risk of fire. No one sits in the back seat normally. But, my grandson's. This should not ever happen.
NHTSA complaint #11545205 — an unverified report by a vehicle owner.
The contact owns a 2009 Buick Lucerne. The contact stated while attempting to start the vehicle, the vehicle would not start. The vehicle was towed to the dealer and the fuel pump was replaced; however, the failure persisted. The fuel module was replaced by the contact but the failure reoccurred. While driving 55 MPH, the vehicle lost motive power. The contact pulled over on the side of the road and had the vehicle towed. The vehicle was not repaired. The manufacturer was contacted and stated there was no recall on the VIN for the failure. No additional assistance was provided. The failure mileage was 41,000.
NHTSA complaint #11534910 — an unverified report by a vehicle owner.
The contact owns a 2009 Buick Lucerne. The contact stated that while starting the vehicle, the vehicle sputtered and failed to start. There was no warning light illuminated. The vehicle was taken to an independent mechanic who recommended that the fuel pump relay be replaced. The mechanic became aware that the fuse was melted. The vehicle was repaired but the failure persisted. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 140,000.
NHTSA complaint #11532285 — an unverified report by a vehicle owner.
The rear fuse box burned out the fule pump relay because of the metal hooks for the seat hit it and pop the fuse out causing it to ark and burn out. I had to have the fule pump replaced twice as that what I was told at auto shops. Going on line was the only reason I found out about the fuse box. After my car died and wouldnt start, opened the casing and sure enough the fule pump housing was completely burned. So now after replacing two fule pumps my emergency money is gone and who knows how long it will before am able to buy a 400$ fuse box with probably another couple hundred in labor to change it out. All because there was to much metal on the seat hooks.
NHTSA complaint #11513148 — an unverified report by a vehicle owner.
The fuse box or fuse holder under the back seat had the fuel pump relay fail due to pressure on the fuse box lid from the seat above it. This is a known issue by Buick as they keep the fuse box in stock (for about $300) I have owned two similar Lucernes with this issue. The fuel pump relay caused enough heat to melt into the fuse box, causing a disconnection. This caused the fuel pump to stop pumping, causing the car to stop running. The problem can be confirmed by calling any Buick dealer. I'm sure they have had several examples of this issue besides my pair. There are many examples mentioned on the internet, as well as videos as to how to fix it. There are no warning lamps prior to the failure. The engine dies and refuses to restart.
NHTSA complaint #11507455 — an unverified report by a vehicle owner.
The fuel pump relay keeps getting hot and burning, causing the car to not start or loosing power while driving. Lost power going up a hill and around curve with no place to pull over. Could have been hit when car died in blind spot in road. Looked it up and other people on line are saying it is the seat clips hitting fuse box causing short circuit in fuse box and damaging fuse box. People said they thought it was fuel pump but still had same problem after replacing fuel pump. A lot of upset people on line saying there should have already been recall on this problem. Have had 2 mechanics look at it. Have bought 3 relays. Afraid to drive car if it will start, fear of loosing power in middle of road and getting killed. Not to mention could cause fire since fuse box and battery are under back seat.. Genius engineer, I'll tell you! Don't know if I can ever completely trust this buick again. Never had anything like this happen to any car I've ever owned.Something needs to be done. Recall Recall Recall !!!!!!!!!!!!!!
NHTSA complaint #11497249 — an unverified report by a vehicle owner.
The contact owns a 2009 Buick Lucerne. The contact stated while parked, the vehicle was not able to be started. There was no warning light illuminated. The vehicle was towed to the dealer. The dealer diagnosed a failure with the fuse box. Additionally, the fuel pump relay was melted. The vehicle was currently being repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 71,000. The VIN was not available.
NHTSA complaint #11476076 — an unverified report by a vehicle owner.
Fuel pump relay under vehicles back seat fried out due to the back seat hitting the fuse box cover and grounding out the fuel pump relay. My child was in the back seat and said there was smoke coming from the back seat and the fuse box nearly caught on fire. After reading online I am appalled that this has not been recalled yet. There was 0 warning, no lights on dash, I did not file a police report or do anything with my insurance as there was no accident. Just a car bomb manufactured by GM
NHTSA complaint #11448734 — an unverified report by a vehicle owner.
See GM Bulletin # 15-na-051 Vehicle died, required tow, found out due to fuel pump relay per bulletin cited above. Rear seat bracket interfered with fuse box, disabling vehicle requiring tow. Vehicle repaired at owners cost. Due to safety factor involved, the seriousness of the situation, for what portion of the costs of repair will the manufacturer be responsible?
NHTSA complaint #11435760 — an unverified report by a vehicle owner.
1. Fuse box was replaced, yes. 4th repair shop replaced. I say only time will tell for sure. i don't drive every day 2. driving I-95 from VA to MD at speeds of 30+ to 75+ cars driving close behind could have ran into rear causing my car, their car, and multiple other cars to be in major accident with possible multiple deaths. 3. reproduced, no. independent service center, no 4. No. Other - the 4th repair shop inspected vehicle component. 5. No warning lamps. No messages or symptoms, car just stalled and would not start/move and when I tried to start car again car would not start, but had all kinds of warnings lamps lit up. The first time the engine stalled was driving (moving) into entrance of toll booth in Richmond, VA, July 27, 2021 approx. 2:15 pm. additional info: Four (4) times car stalled while driving in traffic without warning, car would not start again had to be towed each time to a repair shop. Three (3) repair shops did not repair the problem. First repair shop charged me approx. $350.00 +- for repairs. PLUS I had to stay over night in hotel costing me approx. $120.00+- Total $470.00 +- Car still had same problem!! Second repair shop did not charge me for repairs, but not sure if any work was done, had to get a car rental to get back to Maryland. s second shop kept car ofr 6 days before working on problem. Car rental cost me $467.27. Total $467.27 Car still had same problem!!! Third repair shop kept car for 5 days, charged me approx. $125.+-, still the car had the same problem. Total $125.00+- Car still had same problem!!!! Fourth repair shop says he found fuse box to be the problem, repair cost me approx $554.00+- Total $554.00 My total expenses are approx. $1,491.20 only time will tell if problem has been fixed, not to mention the extreme emotional stress dealing with delays on repairs and extreme emotional stress driving not knowing when or how car would stall again.
NHTSA complaint #11430965 — an unverified report by a vehicle owner.
-The electrical system failed, causing the fuel pump to not work properly due to design flaw in the backseat putting pressure on the fuse box which is located under the backseat. The spot where contact is made to the fuse box, is where the fuel pump relay is. Pressure from the seat bracket (with or without a passenger in the seat) causes the pump replay to not make proper contact with the terminal, therefore causing the power to arc and get so hot that the relay starts smoking, melting the relay, fuse box and surrounding fuses and leaving black scorch marks on the inside of the lid to fuse box and making the car smell like burnt plastic. In addition to now having to purchase multiple replacement relays it has also caused additional electrical issues which resulted in having to replace multiple fuses as well as purchase another battery due to theses issues putting added strain on my battery which caused it to drain and not hold a charge any more. Yes the car and parts are available for inspection. -My safety and the safety of others is at risk due to major risk of catching on fire which could happen while driving and therefore cause an accident, could cause one of my passengers, including my child or myself to be severely hurt/burnt. -Yes the issue has been reproduced by many other owners of the same year/make/model as per the hundreds of previous complaints found about the same issue. -No there were no warning lights, signals or messages before the failure. No warning at all.
NHTSA complaint #11426686 — an unverified report by a vehicle owner.
The contact owns a 2009 Buick Lucerne. The contact stated that on multiple occasions the vehicle would not immediately start-up. The vehicle was examined by an independent mechanic who diagnosed that the fuel pump relay was faulty and needed to be replaced. After replacing the fuel pump relay the failure was temporarily fixed before it recurring. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 79,000.
NHTSA complaint #11418865 — an unverified report by a vehicle owner.