Owners have filed 251 complaints
about the 2008 Chevrolet Aveo with NHTSA between 2007 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 6 of 8 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 52
Against the median year of the Chevrolet Aveo. 50 means typical for this
model; 100 means roughly double.
Severity — 100
29.1% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 50
30% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
125.9%
1,000 – 9,999 miles
199.4%
10,000 – 24,999 miles
146.9%
25,000 – 49,999 miles
3617.7%
50,000 – 74,999 miles
3215.8%
75,000 – 99,999 miles
4019.7%
100,000 – 149,999 miles
4220.7%
150,000+ miles
83.9%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Frontal crash test
Side barrier crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2008 Chevrolet Aveo 4-DR. w/SAB
—
—
—
—
2008 Chevrolet Aveo 5-DR. Hatchback w/SAB
—
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Nov 2007peak 13Mar 2026
Recalls on the 2008 Chevrolet Aveo
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
14V261000
EXTERIOR LIGHTING:HEADLIGHTS
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Risk: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201418567,042 units in Canada
Electrical
On certain vehicles, heat generated within the daytime running light (DRL) module could cause the module to melt, potentially resulting in a fire, which may result in injury and/or property damage. Correction: Dealers will inspect, and if necessary, replace the DRL module.
Reports where the owner recorded a crash, a fire, an injury or a death.
Garland, TXFire
UNKNOWN OR OTHER
There was no prior warnings or notices that there was an issue. While diving on a major road with my children, smoke started coming into the cabin from the vents, and around the stereo. Luckily I was near a very vacant parking lot and immediately pulled over. I removed the kids from the car safely and did open the hood to try troubleshoot the problem. There was no smoke anywhere under the hood. Immediately after, sparks started falling from under the steering wheel to the gas pedal. Immediately after that the car was engulfed in flames. The car is currently located at my local police impound and is available for inspection upon request. From the time the smoke started to when the car was engulfed, it was approximately 5 minutes. This could have been dangerous had we been on a highway and unable to pull over and get out of the car safely within that time. It was only inspected briefly by the fire department who arrived to put out the fire and they reported it was an electrical issue that caused the fire.
NHTSA complaint #11609379 — an unverified report by a vehicle owner.
Garland, TXFire
ELECTRICAL SYSTEM
There was no prior warnings or notices that there was an issue. While diving on a major road with my children, smoke started coming into the cabin from the vents, and around the stereo. Luckily I was near a very vacant parking lot and immediately pulled over. I removed the kids from the car safely and did open the hood to try troubleshoot the problem. There was no smoke anywhere under the hood. Immediately after, sparks started falling from under the steering wheel to the gas pedal. Immediately after that the car was engulfed in flames. The car is currently located at my local police impound and is available for inspection upon request. From the time the smoke started to when the car was engulfed, it was approximately 5 minutes. This could have been dangerous had we been on a highway and unable to pull over and get out of the car safely within that time. It was only inspected briefly by the fire department who arrived to put out the fire and they reported it was an electrical issue that caused the fire.
NHTSA complaint #11609379 — an unverified report by a vehicle owner.
at 110,000 milesSaint Louis, MOFire
EXTERIOR LIGHTING
The contact owns a 2008 Chevrolet Aveo. The contact stated that the vehicle was parked and had the headlights illuminated. The contact's wife went to start the vehicle and turned off the lights when smoke began to emit from the dashboard and the engine compartment. The contact was able to disconnect the battery and the smoke had stopped. The contact stated no warning lights were illuminated. Upon investigation, the contact associated the failure with, NHTSA Campaign Number: 14V261000 (EXTERIOR LIGHTING) however the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was informed of failure and told the contact that they were able to assist but would not without the contact having computer access. The failure mileage was approximately 110,000.
NHTSA complaint #11428877 — an unverified report by a vehicle owner.
at 124,000 milesPittsburgh, PAFire
EXTERIOR LIGHTING
TL* THE CONTACT OWNED A 2008 CHEVROLET AVEO. WHILE DRIVING 20 MPH, SMOKE ENTERED THE CABIN OF THE VEHICLE FROM UNDER THE STEERING PANEL. THE CONTACT WAS ABLE TO SAFELY EXIT THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS TOWED TO A SALVAGE YARD. PRIOR TO THE FIRE, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC DUE TO AN ABNORMAL CHEMICAL ODOR IN THE VEHICLE. THE CONTACT WAS INFORMED TO LUBRICATE THE WIRES IN THE INSTRUMENT PANEL, REMOVE THE FUSES FROM THE FUSE PANEL, AND DO THE SAME WITH THE PROPER DI-ELECTRIC GREASE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE BEFORE PERFORMING THE LUBRICATION. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.
NHTSA complaint #11280257 — an unverified report by a vehicle owner.
at 124,000 milesPittsburgh, PAFire
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
TL* THE CONTACT OWNED A 2008 CHEVROLET AVEO. WHILE DRIVING 20 MPH, SMOKE ENTERED THE CABIN OF THE VEHICLE FROM UNDER THE STEERING PANEL. THE CONTACT WAS ABLE TO SAFELY EXIT THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS TOWED TO A SALVAGE YARD. PRIOR TO THE FIRE, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC DUE TO AN ABNORMAL CHEMICAL ODOR IN THE VEHICLE. THE CONTACT WAS INFORMED TO LUBRICATE THE WIRES IN THE INSTRUMENT PANEL, REMOVE THE FUSES FROM THE FUSE PANEL, AND DO THE SAME WITH THE PROPER DI-ELECTRIC GREASE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE BEFORE PERFORMING THE LUBRICATION. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.
NHTSA complaint #11280257 — an unverified report by a vehicle owner.
at 124,000 milesNovi, MIFire
ELECTRICAL SYSTEM
TL* THE CONTACT CALLED ON BEHALF OF THEIR MOTHER WHO OWNED A 2008 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING APPROXIMATELY 35 MPH, A WHITE SMOKE WAS PRESENT COMING FROM THE REAR OF THE VEHICLE AND THE INSTRUMENT GAUGES BEGAN TO MALFUNCTION. THE ENGINE RPMS VIOLENTLY INCREASED AND DECREASED. THE HAZARDS WERE ENGAGED AND MOMENTS LATER SMOKE WAS SCENE COMING FROM UNDER THE HOOD OF THE VEHICLE. AFTER STOPPING AND EXITING THE VEHICLE, FLAMES WERE SEEN COMING FROM UNDER THE VEHICLE AND FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. DURING THE INCIDENT THE VEHICLE WAS DESTROYED. A FIRE REPORT WAS TAKEN AT THE SCENE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 124,000.
NHTSA complaint #11218247 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Mt. Ulla, NC
EXTERIOR LIGHTING
The wiring to my headlights have overheated and melted twice. I found the really on the year and model of my car but wasn't on the list when I entered my vin
NHTSA complaint #11726117 — an unverified report by a vehicle owner.
Hewitt, TX
ENGINE
California catalytic converter breaking
NHTSA complaint #11613285 — an unverified report by a vehicle owner.
Garland, TXFire
UNKNOWN OR OTHER
There was no prior warnings or notices that there was an issue. While diving on a major road with my children, smoke started coming into the cabin from the vents, and around the stereo. Luckily I was near a very vacant parking lot and immediately pulled over. I removed the kids from the car safely and did open the hood to try troubleshoot the problem. There was no smoke anywhere under the hood. Immediately after, sparks started falling from under the steering wheel to the gas pedal. Immediately after that the car was engulfed in flames. The car is currently located at my local police impound and is available for inspection upon request. From the time the smoke started to when the car was engulfed, it was approximately 5 minutes. This could have been dangerous had we been on a highway and unable to pull over and get out of the car safely within that time. It was only inspected briefly by the fire department who arrived to put out the fire and they reported it was an electrical issue that caused the fire.
NHTSA complaint #11609379 — an unverified report by a vehicle owner.
Garland, TXFire
ELECTRICAL SYSTEM
There was no prior warnings or notices that there was an issue. While diving on a major road with my children, smoke started coming into the cabin from the vents, and around the stereo. Luckily I was near a very vacant parking lot and immediately pulled over. I removed the kids from the car safely and did open the hood to try troubleshoot the problem. There was no smoke anywhere under the hood. Immediately after, sparks started falling from under the steering wheel to the gas pedal. Immediately after that the car was engulfed in flames. The car is currently located at my local police impound and is available for inspection upon request. From the time the smoke started to when the car was engulfed, it was approximately 5 minutes. This could have been dangerous had we been on a highway and unable to pull over and get out of the car safely within that time. It was only inspected briefly by the fire department who arrived to put out the fire and they reported it was an electrical issue that caused the fire.
NHTSA complaint #11609379 — an unverified report by a vehicle owner.
at 121,000 milesMuncie, IN
POWER TRAIN
The contact owns a 2008 Chevrolet Aveo. The contact stated that while driving approximately 15 MPH, the transmission became unbolted and separated from the vehicle. Additionally, the engine separated from the motor mounts rendering the vehicle undrivable. The vehicle was later towed the local mechanic. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 121,000.
NHTSA complaint #11600077 — an unverified report by a vehicle owner.
at 121,000 milesMuncie, IN
ENGINE
The contact owns a 2008 Chevrolet Aveo. The contact stated that while driving approximately 15 MPH, the transmission became unbolted and separated from the vehicle. Additionally, the engine separated from the motor mounts rendering the vehicle undrivable. The vehicle was later towed the local mechanic. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 121,000.
NHTSA complaint #11600077 — an unverified report by a vehicle owner.
Elma, WA
POWER TRAIN
The left side mount-to-mount bracket bolt broke when accelerating normally from a stop. This is one of the bolts that holds the engine to the frame. This caused my shift stick to be thrown back on every acceleration. This is an obvious safety risk. I have not yet had this problem verified or confirmed by anyone. The car seemed to drive well and normal before and up to this incident.
NHTSA complaint #11490913 — an unverified report by a vehicle owner.
Richmond, VA
AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:STATUS INDICATOR LAMP/LIGHT
The contact's son owns a 2008 Chevrolet Aveo. The contact stated that while her son was driving at an undisclosed speed, the passenger's side air bag warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed that the passenger's side air bag needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unavailable.
NHTSA complaint #11452488 — an unverified report by a vehicle owner.
Middletown, NY
ELECTRICAL SYSTEM
In-dash clock module contains the vehicle 'Check Engine Light' - required to pass inspection. Solder joints are defective ('cold' or cracked) creating intermittent electrical connections. Prevents warning of engine defects to driver. Solder defects eventually cause destruction of the module incurring unreimbursed denial of transport and expense to driver to repair.
NHTSA complaint #11449748 — an unverified report by a vehicle owner.
at 110,000 milesSaint Louis, MOFire
EXTERIOR LIGHTING
The contact owns a 2008 Chevrolet Aveo. The contact stated that the vehicle was parked and had the headlights illuminated. The contact's wife went to start the vehicle and turned off the lights when smoke began to emit from the dashboard and the engine compartment. The contact was able to disconnect the battery and the smoke had stopped. The contact stated no warning lights were illuminated. Upon investigation, the contact associated the failure with, NHTSA Campaign Number: 14V261000 (EXTERIOR LIGHTING) however the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was informed of failure and told the contact that they were able to assist but would not without the contact having computer access. The failure mileage was approximately 110,000.
NHTSA complaint #11428877 — an unverified report by a vehicle owner.
Piscataway, NJ
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2008 CHEVROLET AVEO. THE CONTACT STATED THAT THE VEHICLE STARTED LOSING MOTIVE POWER AND DECELERATED HOWEVER, THE VEHICLE DID NOT STALL. THE CONTACT PULLED OVER AND WAITED FOR THE VEHICLE TO REGAIN FULL POWER. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC HOWEVER, THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. NEITHER A DEALER NOR THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11398506 — an unverified report by a vehicle owner.
Piscataway, NJ
ENGINE
TL* THE CONTACT OWNS A 2008 CHEVROLET AVEO. THE CONTACT STATED THAT THE VEHICLE STARTED LOSING MOTIVE POWER AND DECELERATED HOWEVER, THE VEHICLE DID NOT STALL. THE CONTACT PULLED OVER AND WAITED FOR THE VEHICLE TO REGAIN FULL POWER. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC HOWEVER, THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. NEITHER A DEALER NOR THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11398506 — an unverified report by a vehicle owner.
at 130,200 milesFairlawn, NJ
AIR BAGS
2008 CHEVY AVEO SEDAN - [XXX] - AIRBAG WARNING LIGHT REMAINS ON AT ALL TIMES - NO BODY CODES ARE PRESENT / DETECTED - (USING FOXWELL ELITE NT630 SCANNER WHICH CLAIMS TO READ / CLEAR AIRBAG CODES) - I'VE ALREADY RESEARCHED THIS ISSUE - "MUCHO PROBLEMOS" - WITH OVER HALF OF ALL CHEVY AVEO COMPLAINTS INCLUDING AIRBAG WARNING LIGHT REMAINS ON. IT'S MOST LIKELY EITHER THE CLOCK MODULE - WHICH PASSES THE PASSENGER SIDE AIRBAG SIGNALS TO THE MAIN SRS CONTROLLER, THE SRS CONTROLLER MODULE (LOCATED UNDER CENTER SHIFT CONSOLE AREA) OR THE PASSENGER SIDE AIRBAG ITSELF - CODE SCANNER ONLY SEES PASSENGER SIDE AIRBAG STAGE 2 - (NO STAGE 1 SEEN) ... DRIVER'S SIDE SHOWS BOTH STAGE 1 AND STAGE 2 ... ALL PRETENSIONERS ARE PROPER (2 OHMS CIRCUIT RESISTANCE) ... BATTERY STRONG / GOOD / NEW - 1 YEAR OLD - 13.5 VOLTS - I'M WORRIED DEALER (HAWTHORNE CHEVROLET - HAWTHORNE NJ) WILL ACTUALLY NOT KNOW THE EXTENSIVE ISSUE WITH CHEVY AVEO AIRBAG WARNING LIGHT COMING ON - AND WILL WRONGLY DIAGNOSE AND TRY TO CHARGE BIG BUCKS - AND PROBLEM WILL RETURN - THIS IS A SAFETY ISSUE - SINCE WITH AIRBAG WARNING LIGHT STAYING ON - SRS AIRBAG SYSTEM WILL NOT OPERATE, NO AIRBAG PROTECTION - I HAVE ALSO NOW CONTACTED CHEVROLET ON THIS SUBJECT / PROBLEM - WAITING FOR THEIR REPLY - LOCATED IN NORTHERN NJ - HAWTHORNE CHEVROLET WOULD BE THE PROPER DEALERSHIP - (I PURCHASED THE CAR THERE - 10 YEARS AGO - THEY HAVE SERVICED THE CAR FOR ROUTINE REPAIRS) ... WILL BE CONTACTING THEM ON THIS SRS AIRBAG WARNING LIGHT PROBLEM - BUT WORRIED THEY ARE NOT REALLY KNOWLEDGEABLE ON IT ... THERE SHOULD BE A RECALL ON THIS PROBLEM - SRS / AIRBAG WARNING LIGHT STAYING ON - SAFETY RELATED FAILURE - CHEVY KNOWS ABOUT THIS BY NOW FOR SURE - INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11283037 — an unverified report by a vehicle owner.
at 124,000 milesPittsburgh, PAFire
EXTERIOR LIGHTING
TL* THE CONTACT OWNED A 2008 CHEVROLET AVEO. WHILE DRIVING 20 MPH, SMOKE ENTERED THE CABIN OF THE VEHICLE FROM UNDER THE STEERING PANEL. THE CONTACT WAS ABLE TO SAFELY EXIT THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS TOWED TO A SALVAGE YARD. PRIOR TO THE FIRE, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC DUE TO AN ABNORMAL CHEMICAL ODOR IN THE VEHICLE. THE CONTACT WAS INFORMED TO LUBRICATE THE WIRES IN THE INSTRUMENT PANEL, REMOVE THE FUSES FROM THE FUSE PANEL, AND DO THE SAME WITH THE PROPER DI-ELECTRIC GREASE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE BEFORE PERFORMING THE LUBRICATION. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.
NHTSA complaint #11280257 — an unverified report by a vehicle owner.
at 124,000 milesPittsburgh, PAFire
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
TL* THE CONTACT OWNED A 2008 CHEVROLET AVEO. WHILE DRIVING 20 MPH, SMOKE ENTERED THE CABIN OF THE VEHICLE FROM UNDER THE STEERING PANEL. THE CONTACT WAS ABLE TO SAFELY EXIT THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS TOWED TO A SALVAGE YARD. PRIOR TO THE FIRE, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC DUE TO AN ABNORMAL CHEMICAL ODOR IN THE VEHICLE. THE CONTACT WAS INFORMED TO LUBRICATE THE WIRES IN THE INSTRUMENT PANEL, REMOVE THE FUSES FROM THE FUSE PANEL, AND DO THE SAME WITH THE PROPER DI-ELECTRIC GREASE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE BEFORE PERFORMING THE LUBRICATION. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.
NHTSA complaint #11280257 — an unverified report by a vehicle owner.
at 50,000 milesLOS Angeles, CA
POWER TRAIN
TL* THE CONTACT OWNS A 2008 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE VEHICLE RESTARTED AND WAS TAKEN TO ANTELOPE VALLEY CHEVROLET (877-385-0885, LOCATED AT 1160 MOTOR LN, LANCASTER, CA). THE DEALER REPLACED THE THROTTLE BODY. THE CONTACT ALSO STATED THAT THE VEHICLE LOST POWER IN THE MIDDLE OF TRAFFIC. THE CONTACT SHIFTED INTO PARK, SHUT OFF THE ENGINE, AND RESTARTED THE VEHICLE. WHEN THE VEHICLE WAS IN PARK, THE ENGINE REVVED AND JERKED WHEN IT WAS SHIFTED INTO DRIVE. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES, BUT THE VEHICLE RESTARTED EACH TIME. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE THROTTLE BODY AGAIN, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.
NHTSA complaint #11241846 — an unverified report by a vehicle owner.
at 50,000 milesLOS Angeles, CA
ENGINE
TL* THE CONTACT OWNS A 2008 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE VEHICLE RESTARTED AND WAS TAKEN TO ANTELOPE VALLEY CHEVROLET (877-385-0885, LOCATED AT 1160 MOTOR LN, LANCASTER, CA). THE DEALER REPLACED THE THROTTLE BODY. THE CONTACT ALSO STATED THAT THE VEHICLE LOST POWER IN THE MIDDLE OF TRAFFIC. THE CONTACT SHIFTED INTO PARK, SHUT OFF THE ENGINE, AND RESTARTED THE VEHICLE. WHEN THE VEHICLE WAS IN PARK, THE ENGINE REVVED AND JERKED WHEN IT WAS SHIFTED INTO DRIVE. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES, BUT THE VEHICLE RESTARTED EACH TIME. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE THROTTLE BODY AGAIN, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.
NHTSA complaint #11241846 — an unverified report by a vehicle owner.
at 124,000 milesNovi, MIFire
ELECTRICAL SYSTEM
TL* THE CONTACT CALLED ON BEHALF OF THEIR MOTHER WHO OWNED A 2008 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING APPROXIMATELY 35 MPH, A WHITE SMOKE WAS PRESENT COMING FROM THE REAR OF THE VEHICLE AND THE INSTRUMENT GAUGES BEGAN TO MALFUNCTION. THE ENGINE RPMS VIOLENTLY INCREASED AND DECREASED. THE HAZARDS WERE ENGAGED AND MOMENTS LATER SMOKE WAS SCENE COMING FROM UNDER THE HOOD OF THE VEHICLE. AFTER STOPPING AND EXITING THE VEHICLE, FLAMES WERE SEEN COMING FROM UNDER THE VEHICLE AND FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. DURING THE INCIDENT THE VEHICLE WAS DESTROYED. A FIRE REPORT WAS TAKEN AT THE SCENE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 124,000.
NHTSA complaint #11218247 — an unverified report by a vehicle owner.
at 124,000 milesNovi, MIFire
ENGINE
TL* THE CONTACT CALLED ON BEHALF OF THEIR MOTHER WHO OWNED A 2008 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING APPROXIMATELY 35 MPH, A WHITE SMOKE WAS PRESENT COMING FROM THE REAR OF THE VEHICLE AND THE INSTRUMENT GAUGES BEGAN TO MALFUNCTION. THE ENGINE RPMS VIOLENTLY INCREASED AND DECREASED. THE HAZARDS WERE ENGAGED AND MOMENTS LATER SMOKE WAS SCENE COMING FROM UNDER THE HOOD OF THE VEHICLE. AFTER STOPPING AND EXITING THE VEHICLE, FLAMES WERE SEEN COMING FROM UNDER THE VEHICLE AND FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. DURING THE INCIDENT THE VEHICLE WAS DESTROYED. A FIRE REPORT WAS TAKEN AT THE SCENE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 124,000.
NHTSA complaint #11218247 — an unverified report by a vehicle owner.
at 62,000 milesNEW York, NYCrash1 injured
AIR BAGS
CAR SHUTOFF WHILE DRIVING
NHTSA complaint #11203401 — an unverified report by a vehicle owner.
at 62,000 milesNEW York, NYCrash1 injured
ELECTRICAL SYSTEM
CAR SHUTOFF WHILE DRIVING
NHTSA complaint #11203401 — an unverified report by a vehicle owner.
at 62,000 milesNEW York, NYCrash1 injured
ENGINE
CAR SHUTOFF WHILE DRIVING
NHTSA complaint #11203401 — an unverified report by a vehicle owner.
at 106,744 milesIndianapolis, IN
AIR BAGS
AIRBAG LIGHT IS ON, HAS BEEN ON WHEN I BOUGHT THE CAR FROM THE DEALER, SAID PASSENGER SIDE AIRBAG FUSE WAS BAD, NEEDED REPLACED. NOTED THAT THE PASSENGER ON/OFF WILL AT RANDOM TURN ON OR OFF OR NOT EVEN SHOW AT TIMES, I HAVE ALSO NOTED THE SEAT MAKING SOME SORT OF NOISE WHEN TURNING THE CAR ON.
NHTSA complaint #11186052 — an unverified report by a vehicle owner.
at 81,200 milesMansfield, TX
ENGINE
SOMEWHERE IN BETWEEN THE 81,100 - 81,300 MILES MARK MY VEHICLE HAS RECEIVED THE CHECK ENGINE LIGHT P2135 CODE, FOR THROTTLE/PEDAL SENSOR/SWITCH A / B VOLTAGE CORRELATION. AT THE TIME OF RECEIVING THE CODE I DID NOT NOTICE ANYTHING IRREGULAR UNTIL I RESEARCHED THE PROBLEM. ONE OF THE SYMPTOMS BEING, REVVING OF THE ENGINE WHEN GAS PEDAL IS NOT PRESSED. THAT'S WHEN I REALIZED MY CAR HAD BEEN DOING THAT JUST RECENTLY ON START UP BEFORE RECEIVING THE CODE. FINALLY AFTER ABOUT A MONTH, DRIVING VERY MINIMALLY MAYBE 10 SHORTS TRIPS OR LESS, THE CAR STALLED OUT AFTER APPROXIMATELY 0.1 MILES OF BELOW 15MPH DRIVING. I GOT OUT AND CHECKED UNDER THE HOOD AND I DIDNT SEE ANYTHING WRONG SO I BEGAN TO PUSH THE CAR BACK HOME. AFTER I REALIZED IT WOULD TAKE SOME MANEUVERING I DECIDED TO TRY STARTING THE CAR BACKUP AND IT DID SO I QUICKLY TURNED IT AROUND AND DROVE IT BACK HOME. STALLING OF THE ENGINE IS ALSO A SYMPTOM OF THE P2135 CODE. SINCE THAN OUT OF NECESSITY I'VE DRIVEN THE CAR TWICE FOR 13 MILE TRIPS WITHOUT STALLING OUT BUT THE CHECK ENGINE LIGHT HAS NOT GONE AWAY. THE ENGINE STILL REVS ON ITS ON START UP UNTIL FINALLY SETTLING INTO CONSISTENCY. AFTER TRYING TO FIGURE OUT WHAT EXACTLY NEEDS REPLACING ONLINE, IT APPEARS EVIDENT TO ME THAT A LARGE AMOUNT CHEVY AVEOS NO MATTER THE YEAR OR SPECIFIC MODEL, ENCOUNTER THIS PROBLEM. IT'S JUST A MATTER OF HOW MANY OWNERS TALKED ABOUT THE PROBLEM ONLINE AND REPORTED IT. THOSE WHO HAVE TAKEN IT ONLINE FIXED THE PROBLEM BY CLEANING THE THROTTLE BODY, WHICH ONLY LASTED FOR SO LONG AND COULD RESULT IN DAMAGE OR GETTING A WHOLE NEW THROTTLE BODY ASSEMBLY WITH A NEW THROTTLE POSITION SENSOR ATTACHED.
NHTSA complaint #11166124 — an unverified report by a vehicle owner.
PT. Pleasant, NJFire
UNKNOWN OR OTHER
"TAKATA RECALL" I WAS TRAVELING ALONG THE GARDEN STATE PARKWAY NORTHBOUND WHEN MY CAR STOPPED ACCELERATING. I PULLED OVER TO THE SHOULDER THE CAR COMPLETELY SHUT OFF AND CAUGHT ON FIRE. THE WHOLE CAR WENT UP INTO FLAMES WHILE I WAS STILL IN THE CAR AND WAS ABLE TO JUMP OUT OF THE PASSENGEER SIDE DOOR. THE CAR IS TOTALED.
NHTSA complaint #11154906 — an unverified report by a vehicle owner.
