638 of the 11,236 complaints filed about the Chevrolet Blazer are about the fuel system — 6% of everything owners reported. The worst model year for it is 1995.
638
Complaints
6%
Share of all complaints
14
Crashes
11
Fires
FUEL/PROPULSION SYSTEM
Car will not crank, stalled while cranked, throws code P023F
NHTSA complaint #11758918 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
The car just stopped while I was driving. I was in an intersection. The car would not turn back on
NHTSA complaint #11754839 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
XXX the car had gas, turned over, but would not start. I had it towed to a repair center who towed, did diagnostics and came up with the codes for a bad fuel pump control module. It was replaced and the car starts. There was no warning. Problem was confirmed by an independent service center. All documentation is available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11749347 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
fuel pump control module failed at 26000. recall number N252516900. This is a recall that other 2021 blazers have ben part of. Over 300000 recalls so far. GM says my car isn't. Ridiculous. They dont want to acknowledge their fault. I need a formal statement that this module should be recalled for my car.
NHTSA complaint #11749371 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
"While attempting to merge onto a high-speed freeway on-ramp, the vehicle suffered a sudden and catastrophic loss of engine power, rendering it unable to accelerate and creating an immediate life-threatening safety hazard. The vehicle was restarte and driven home, where an onboard diagnostic check revealed an emissions system failure. The dealership later confirmed that BOTH close-coupled catalytic converters on the 3.6L V6 were damaged. The check engine light was a solid light. Not flashing.
NHTSA complaint #11748654 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Car stalled and told me to put in neutral. Could smell gas. Car wouldn't come back on. Code u18a2 (lost communication with fuel pump communication module), part is available for inspection, we were all at risk due to the car stalling on the highway with no prior warnings, check engine light came on after car stalled, ordered new part from GMC, fix the issue right away. This part has been recalled on other models just not on 2022.
NHTSA complaint #11744381 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
My car will be running fine but the lights on the AC panel wont work. My car will stop and shut down while driving. Ive taken it in for service and they told me my battery cabels were lose. The second time it happened I got a notification of low battery level and it shut off and will not start. I just replace the battery 2 years ago. The service department tested my battery and said it was fine
NHTSA complaint #11735381 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I am reaching out regarding an ongoing issue with my 2021 Chevrolet Blazer. The vehicle is experiencing a noticeable stutter or hesitation when shifting between second and third gear. In addition, there are instances where the vehicle accelerates unexpectedly or more aggressively than intended. This behavior is particularly concerning, as it presents a potential safety issue during normal driving conditions. These concerns have become increasingly noticeable, and I am concerned they may indicate a transmission or related mechanical problem that requires prompt inspection and resolution. Please advise if there are any known service bulletins, recalls, or warranty coverage related to these issues. For reference, the vehicle has been properly maintained and this behavior is not consistent with normal operation. Given that this is now the third major issue I’ve experienced with this vehicle, I am hoping this matter can be addressed without additional out-of-pocket expense. After additional research, I have learned that other owners have experienced the same issue. Others have stated the following: 1. Hesitation, stuttering, or jerking between gears Owners of 2020–2021 Blazers report hesitation and jerking during acceleration, sometimes described as gears “shifting in and out rapidly.” Forum users mention sluggish shifting or slipping feelings, especially at certain speeds. Others report hard or delayed shifts at low speeds (like 15–25 mph). 2. Shuddering / vibration (often tied to torque converter) There are repeated mentions of “shudder,” “surge,” or vibration during acceleration. Some cases were linked to: Contaminated transmission fluid Torque converter clutch (TCC) issues One owner said the problem felt like a bad torque converter and required service attention. 3. Unexpected acceleration / lunging Drivers across GM vehicles (including similar transmissions) report: “Jerking,” “bucking,” or “lunging” during acceleration Some describe needing to
NHTSA complaint #11735127 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Went to park car in a park to drop daughter off and it sputtered out and stalled out of nowhere with no warning. I had received a lamp warning very sporadically prior to this and on occasion that stated 'reduced steering assist drive with care' this resulted in heavy steering for that drive until car was shut off and then it would go away and be fine again, fixed the car through Knudtsen Chevy due to a recall about a month before on the issue with the engine being turned off and it thinking it was still hot and still running the fan (even though the car was not running). Knudtsen fixed that issue. Low battery voltage light did not come on however battery was older so had battery installed at park to ensure the issue was not due to the battery. The oil was fresh and showed no issues, changed 2 weeks before fresh oil no issues found during service. When tried to restart the car it would think it would try to start and then sputter out and not stay in idle. Les Schwab left and called a mobile mechanic to bring the computer. Computer was hooked up and it would try to start, however, it would not know it was already running and try to start again on it's own...the codes that came up were the PO101 code came up for Mass Air Flow issue...and then the codes would go in a wild sequence of fail.....mechanic checked for loose connections around air filter, took air filter out and it was clean no issues, checked pipe no visible issues. We walked away and walked around the park to give it some time to sit and then we tried it again and it tried and sputtered out and died again would not stay idling. Then all of a sudden we heard it try to start itself without us trying to start it and it clanked. We hauled it to Knudtsen for a diagnosis. They stated "the motor will not turn this way or that way and it is seized or locked up". This is a 2021 with only 89,000 miles it should have a longer life than this. Please investigate and is there anything we can do to fix it?
NHTSA complaint #11734510 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Re: Vehicle Safety Defect Complaint – 2023 Chevrolet Blazer To Whom It May Concern, I am submitting a formal safety defect complaint regarding my 2023 Chevrolet Blazer. This vehicle has exhibited multiple system failures that present a serious risk to driver safety and public roadway safety. The vehicle was purchased new on July 20, 2023. Beginning on April 21, 2025, at approximately 27,610 miles, the vehicle developed a progressive defect initially presenting as oil-related issues. Despite multiple repair attempts, the condition worsened and required a full engine replacement in January 2026. Following the engine replacement, the vehicle continued to experience critical safety failures, including engine stalling, reduced engine power warnings, and electronic stability control (ESC) alerts. On April 26, 2026, the vehicle experienced a driver assistance system malfunction in which it attempted to steer off the roadway. I was forced to manually disable the system to maintain control of the vehicle. On April 27, 2026, the vehicle exhibited a fuel system failure, including fuel leakage and fuel odor, along with multiple simultaneous warning indicators: • Reduced Engine Power • Service ESC • Steering Assist Reduced / Drive with Care • Power assist driver system disabled This combination of failures presents both a fire hazard and a loss-of-control risk. Additionally, I was informed by the dealership that a high-pressure fuel line, a one-time-use component, was not replaced during the engine installation. This raises concerns regarding improper repair and continued unsafe operation of the vehicle. The vehicle has undergone multiple repair attempts and a major powertrain replacement, yet continues to present serious safety concerns. Due to these ongoing issues, I do not feel safe operating this vehicle. I respectfully request that NHTSA review this matter for potential safety defects that may impact other vehicles of the same make and model.
NHTSA complaint #11734585 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
The vehicle accelerated without input and the brakes failed to respond. I am notifying you that this vehicle is a life-threatening safety risk and should not be rented again until a master technician clears the electronic throttle control and breaking system. This condition presents a serious safety risk and could lead to a car crash or injury. Additionally, the vehicles, climate control system behaved erratically, alternating between extremely hot and extremely cold air without adjustment. This may indicate a broader electronic or system malfunction affecting vehicle city.
NHTSA complaint #11726743 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I received a check engine light which i took to Bell tire for diagnosis. Here is there diagnosis Comments: The P01F0 code on a 2020 Chevy Blazer means the engine coolant temperature is below the normal operating range, often due to a stuck-open thermostat (or both thermostats in models with dual units), a faulty Engine Coolant Temperature (ECT) sensor, or low coolant, leading to poor fuel economy and potential wear; fixing it usually involves replacing the thermostat(s) or sensor after checking coolant levels and wiring. After that i took the vehicle to GM Dealership. Even though this is a know issue with many vehicles from same year, i was told that my VIN is not part of recall and dealership ended up charging me 600+ to fix the issue. I am reaching out to seek help as i had exact same problem but GM is not covering the repairs because my VIN is not in the recall. How is that possible?
NHTSA complaint #11715555 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Driving along vehicle shut down in middle of road replace fuel pump, fuel module control in August 2025. Now both top and bottom fuel hose needs replacing. On Nov 2025 I smelled gas and vehicle shut down
NHTSA complaint #11702777 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Driving the vehicle when all of a sudden the engine shut off. All electrical systems continued to function. Luckily this occurred at low speed in a parking lot but had it happened at high speed on the freeway it could have been a huge safety risk. The vehicle was towed to a nearby automotive shop that diagnosed it as a bad fuel pump controller. There is an open GM recall that includes the 2021 Chevy Blazer (and a suite of other GM vehicles), but not the 2022 Chevy Blazer. I am concerned that the GM recall does not fully cover all of the vehicles that could be impacted by this issue. Date: September 11, 2025 Subject: N252516900 - Emission Recall Fuel Pump Power Control Module [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11700288 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Car was running fine yesterday, today does not want to start. Thought it was the battery, bought anew battery. Still wouldn't start. Rest of cat is getting great power. Code reader is reading its a fuel pump control moduler which just so happens to be in an open recall for my exact year of vehicle yet my vin number does not pop up on the GMC website under active recall. I have a 2021 chevy blazer .
NHTSA complaint #11699684 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I was driving at approx 45 mph when my car lost all ability to accelerate and shut down in the street. Flashing check engine light and esc warning on the screen. It would try to start but wouldn't. I had it towed to a mechanic who diagnosed and informed me that it is the Fuel pump power control module. Upon review he I formed me that there was a recall posted in September 2025 for 2021 Blazer on this exact issue. My car has now been unusable for a week as my mechanic recommends it be repaired via recall at dealership.
NHTSA complaint #11695649 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Car wouldn’t crank
NHTSA complaint #11694234 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
This is the 2nd time I have been left stranded unable to charge my vehicle due to the charge door malfuction on the vehicle. This is a safty issue due to the fact that if you are unable to charge the vehicle, you can get starnded somewhere unsafe putting yourself and family at risk. This charge door failure has happened once within 8 months after purchasing the vehicle, the charge door was replaced under warranty back a year ago. Now its has started to bind up and not open leaving me unable to charge my vehicle. I have taken the vehicle back to the dealership and they had to special order the part. Currenty I have not been able to charge my vhecile properly. I have to forcefully open the charge door causing more damage, until the part is replaced. Please look into this issue, I have contacted other Blazer EV owners and have found they too have had the same peoblem.
NHTSA complaint #11693306 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Increasing speed by itself, let foot off gas pedal and gas pedal sticking, 1st time I tapped brakes and it quit. 2nd time it did not. I had to slam brakes and hokd until the point they had overheated and smell burnt and filed a separate complaint for that today. Gas pedal sticking and self accelerating. Pedal to the floor accelerating. I do not drive like that and scared the hell out of me. I bout it 5 days ago from a Chevrolet dealership. I'm tired of rip offs. Next one best be brand new and they reimburse me for outside mechanical I inspection period. Bc I trust no dealer now. Went from 7p to about 95 in 10 seconds for 10 min. Not sure what braking did bx I coukd care less about the phone whike I am trying not to hit cars in front of me literally almost jammed an 18 wheeler and moving truck with me pushing the brakes as gmhard as I could.
NHTSA complaint #11687753 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I was driving down 776 (a busy highway)Blazer completely shut off, so scary almost got hit by a semi, I don’t know how he managed to get around me , I jumped out of car! Sure thought it was my day to die! Called police for help! Had it towed home then to garage , was told it was the electrical fuel modular! Haven’t slept right in 3 days ! I’m still so shaken up!
NHTSA complaint #11684653 — an unverified report by a vehicle owner.