21 of the 175 complaints about the 2023 Chevrolet Bolt EUV are about the steering — 12% of everything reported for this model year.
21
Complaints
1
Crashes
0
Fires
1
Injuries
Filed with NHTSA, in their own words.
STEERING
After completing a turn, the car's steering wheel does not fully return to center. It remains at 30 degrees under 10mph, 10-15 degrees at 20mph. Dealer has claimed it is behaving as intended.
NHTSA complaint #11758965 — an unverified report by a vehicle owner.
STEERING
When driving and turning, the steering wheel does not come back to center and the car keeps turning after releasing the steering wheel causing the car to veer off the road if not turned back manually. This is very unexpected and an unsuspecting driver might not realize this until too late. I am in the process of contacting the dealer I bought the car from. But, searching the internet it seems to be a know problem.
NHTSA complaint #11756146 — an unverified report by a vehicle owner.
STEERING
Steering gear box failure diagnosis from dealer
NHTSA complaint #11755554 — an unverified report by a vehicle owner.
STEERING
Steering fails to return to center after turning. This is unexpected behavior and creates a danger when turning and releasing the steering wheel. There are no warnings or messages that coincide with this issue.
NHTSA complaint #11754266 — an unverified report by a vehicle owner.
STEERING
The steering is heavier on the car and does not return to center after turning. This causes danger while driving if someone cuts off in front of me or I have to stop suddenly due to an animal or any other conditions. I am also assuming this will be dangerous to drive in wet weather as well. I took it to the dealer to check it, and it was diagnosed as a failing steering system; the rack and pinion need to be replaced.
NHTSA complaint #11753794 — an unverified report by a vehicle owner.
STEERING
Rattling noise started coming from the steering wheel, it can be felt through the steering wheel. Doing an inspection it's coming from the the U joint area and steering wheel. The steering wheel also doesn't properly turn back into place when turning at lower speeds. Issue started around 40k miles. Searching the online the issue lots of people are having the same issue. Per Chevy Dealership, In need of roughly $2,850 repair parts are Steering Gear, Steering Shaft, Steering ujoin
NHTSA complaint #11751103 — an unverified report by a vehicle owner.
STEERING
I was driving on the highway with GM Super Cruise engaged. I was within the speed limit on a straight road with my hands near the wheel. Without warning, the steering turned sharply to the left on its own and locked — I was unable to correct it or override the system. The vehicle left the road, spun, and was totaled. I walked away with minor injuries. There were no warning lamps or messages prior to the failure. The vehicle has been inspected by police (report exists) and insurance representatives. The vehicle is currently at a dealership and is available for inspection. The problem has not been reproduced or confirmed by a dealer. I believe the Super Cruise system malfunctioned and caused the steering to lock in a direction I could not override.
NHTSA complaint #11743970 — an unverified report by a vehicle owner.
STEERING
I have a 2023 Chevy Bolt EUV, and I'm experiencing a steering issue. When making left or right turn, the steering wheel does not return to center automatically. This problem has been present since the beginning, and it has gradually been getting worse.
NHTSA complaint #11741046 — an unverified report by a vehicle owner.
STEERING
Steering wheel does not return to center; likely due to failing steering gear or rack due to faulty lubrication at factory.
NHTSA complaint #11736201 — an unverified report by a vehicle owner.
STEERING
Steering rack failure (wheel does not return to center, crunchy steering with increasingly more resistance over time).
NHTSA complaint #11731208 — an unverified report by a vehicle owner.
STEERING
Steering gear assembly malfunction. Internal rack & pinion failure is present. Rack is binding/seized. When making a turn on the vehicle, the steering wheel does not return to center, creating a highly dangerous situation where if the steering wheel is not manually returned to center it can cause a motor vehicle accident. In other words, once a turn is initiated the car will remain in a turned state unless the steering wheel is wrestled with to return to traveling in a straight line. The problem has been reproduced and confirmed by an independent service center. The vehicle has not been inspected by the manufacturer, police, insurance representative, or others outside of an independent service center. There were no warning lamps, messages, or other symptoms of the problem prior the failure. The failure appeared starting at about 25,000 miles and gradually became worse to just under 40,000 miles which is the mileage on the car now.
NHTSA complaint #11720568 — an unverified report by a vehicle owner.
STEERING
Turn Signal no longer returns to the original position after making a turn.
NHTSA complaint #11718271 — an unverified report by a vehicle owner.
STEERING
The steering wheel locks at 9 and 3 when turning the wheel. It doesn’t spin back like it should when returning straight. Very dangerous!
NHTSA complaint #11706314 — an unverified report by a vehicle owner.
STEERING
I am experiencing a well known flaw in the Chevy Bolt steering rack. The rack loses grease over time and eventually begins making clunking sounds, does not return the steering wheel to center, and makes steering less precise. This is a very common issue within Chevy Bolt forums and should be addressed by Chevy as a safety issue.
NHTSA complaint #11697225 — an unverified report by a vehicle owner.
STEERING
2023 Bolt's steering wheel doesn't return to center position while driving making it dangerous to drive.
NHTSA complaint #11696634 — an unverified report by a vehicle owner.
STEERING
Steering system not behaving as expected. Very stiff when making left and right turns at slow and moderate speeds, with a failure of the steering wheel to return to center.
NHTSA complaint #11695668 — an unverified report by a vehicle owner.
STEERING
Steering wheel will not return to center after turning. This is a known issue with other model year bolts. PLEASE ISSUE A RECALL!
NHTSA complaint #11674918 — an unverified report by a vehicle owner.
STEERING
Steering wheel will not return to center after making turns in any direction. Steering has gradually stiffened, but is immediately noticeable. This car is driven daily by my spouse. Our child with his new learner's permit noted how he had to turn the wheel back and it didn't happen automatically like the car he took driving lessons in. I drove the car and it was plainly obvious that the steering wheel was stiff and nearly frozen. Car has 42,000 miles and is no longer covered by GM's warranty. I am bringing it to an independent mechanic for repair, immediately.
NHTSA complaint #11672671 — an unverified report by a vehicle owner.
STEERING
The steering wheel occasionally becomes unresponsive and does not return to center after making turns or slight adjustments, particularly at low to moderate speeds. It was forcing me to manually re-center the wheel. Almost had a bad accident because of this! I have kids and don’t want something bad to happen.
NHTSA complaint #11659116 — an unverified report by a vehicle owner.
STEERING
When I drive the car the steering binds up. After doing some research they are several vehicles that have this issue. The steering does not return to center and you have to make sure you forcibly turn back to center when driving. I have never drove a vehicle that it would not return to center and drive straight. Please review the complaints on this issue.
NHTSA complaint #11645881 — an unverified report by a vehicle owner.
STEERING
Multiple instances seemingly at random of steering wheel not adjusting to center, wanting to turn one direction or another, and generally loose feeling of steering. This is all with the lane keep assist feature off.
NHTSA complaint #11537461 — an unverified report by a vehicle owner.