2022 Chevrolet Colorado electrical problems

ELECTRICAL SYSTEM

Loss of power steering, Truck repaired by GM dealer, he stated it was the same failure mode described in Recall notice N2023254 10. The repair even though the same as the previous failures was not covered by GM because my VIN was not in GMs recall notice. Looking at this website there a number of reports of power steering failures for later model Colorado and Canyons that were not covered by the recall. Either GMs fix was not effective, or they did not select the right VIN population. So the Power steering failure repair on my truck even though it is the same failure mode as the previous recall was not covered by GM.

NHTSA complaint #11753756 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:IGNITION

The contact owns a 2022 Chevrolet Colorado. The contact stated that while parking the vehicle, it was difficult to remove the key from ignition switch. There was no warning light illuminated. The contact stated that the failure was a recurring failure. The dealer was contacted, and the contact was informed that parts were on a national back order. The manufacturer was not made aware of failure. The failure mileage was 23,750.

NHTSA complaint #11745892 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

key will not release from ignition. I will put the truck in park but the computer will not read that it is in park, so the key can only be rotated to the accessory position. This has been confirmed by the dealership. No codes are coming up nor any lights on the dash.

NHTSA complaint #11745203 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Issue 1: Cooling Fan Remained On After Engine Shutdown Component or system involved: Engine cooling system and fan control system, including the radiator cooling fan, fan relay, coolant temperature sensor, wiring, or engine control module (ECM). The vehicle is available for inspection upon request. What happened: After turning off the engine, the radiator cooling fan remained running continuously for approximately five minutes and would not shut off as expected. No warning light, message, or other dashboard indication appeared before or during the event. This was unusual behavior compared with normal operation. Safety risk: The unexpected fan operation created concern that the cooling system was malfunctioning and that the vehicle could overheat, experience an electrical problem, or become unreliable while driving. A cooling system or electrical failure while in traffic could put me and other drivers at risk. Reproduction or confirmation: The issue occurred several time and was confirmed by a Chevrolet dealer, and was told that my warranty did not cover the issue. I took it to outside mechanic to fix the issue as Chevrolet wanted to charge over $1500 for the issue. No warning lamps, messages, overheating indicators, or other symptoms appeared before the fan remained on. The problem occurred suddenly back in 2025. Issue 2: Ignition Key Gets Stuck and Cannot Be Removed Ignition lock cylinder, ignition switch, transmission shift-interlock system, park-position switch, or steering column lock mechanism. The vehicle is available for inspection upon request. The ignition key intermittently becomes stuck and cannot be removed from the ignition. The problem occurs after parking and turning the vehicle off, and I sometimes need to move the shifter or steering wheel repeatedly before the key can be removed. A stuck ignition key can prevent me from properly shutting down and securing the vehicle. It may also indicate a failure in the ignition or shift-interlock system.

NHTSA complaint #11743496 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

My key was getting stuck in the ignition back in 2024 and the dealership replaced my shifter assembly. I am now having the same issue later after 2 years and I am out of warranty and now having to pay out of pocket. My sister has the same truck, year and color and had hers replaced. Also the service advisor said they’ve had two others come in with the same truck and had the same issue. I am unable to remove my key for quite some time once it gets stuck and I called Chevrolet themselves and they are telling me there is nothing they can do.

NHTSA complaint #11740942 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

When turning off the ignition, the key will not go all the way "off" and the key will not release. If I turn the ignition back on and drive forward and backwards and SLOWLY put the vehicle into Park, and then attempt to turn off the vehicle, it will occasionally allow it at that point. It appears to be a disconnect of the system recognizing the vehicle is truly in Park and when it isn't and thereby releasing the ignition off function. the engine does shut off but I think it remains in ACC and will not release. Maybe safety switch in the shifter assembly.

NHTSA complaint #11737826 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Unknown on first appear - key gets stuck in the ignition. This happened for the first time shortly after we bought it. It was still under warranty and the Chevrolet dealership in Washington PA fixed it. We paid to have it fixed and now it’s out again and we can’t get our key out of the ignition and we sit there forever trying to get it to work. Restarting vehicle etc. We had an appointment the other day and sat there well over a half hour trying to remove the key from the ignition because you obviously can’t leave it in the vehicle. We even drive the vehicle to a different spot in a lot to see if it will release what seems to be pressure to get it out? There’s no warranty to fix it and we shouldn’t have to replace the same issue over and over again. I feel this should be a recall or a lemon issue. Also- we took our vehicle to a local inspection auto shop because we have an issue with the transmission shuttering like you are driving over a rumble strip. We were informed there has been recalls on the Colorado trucks through the years however we have no recall on our vin. I believe and feel this should be covered under the recall since it’s obviously is an ongoing issue through the years. There weren’t any warning lights and currently still no warning lights when these issues happen. This is a big inconvenience owning a truck that we bought brand new and having repeated issues that are known for this particular vehicle. Yes it will be available to be inspected upon request. Please assist. Attached is a receipt where we tried to see if the truck was possibly shuttering from being out of aligned. That wasn’t the case and they referred us to Middle Creek Garage where we paid to have it looked at and they told us about the transmission recalls and what they are known for. I can’t find my receipts. Washington Chevrolet in Pennsylvania is who has worked on our ignition key issues twice. Your date below is messing up. Transmission started in 09/2025.

NHTSA complaint #11724169 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The key will not come out after park and engine turn off. It getting harder and harder each time to get the key out.

NHTSA complaint #11696427 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

i am unable to remove the key from the ignition. i have to start the vehicle numerous times all while shifting the gear shifter back and forth between drive and park. after several attempts the key will finally release.

NHTSA complaint #11691660 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:INSTRUMENT PANEL:FUEL GAUGE

The contact owns a 2022 Chevrolet Colorado. The contact stated that the fuel gauge was providing an inaccurate fuel reading. The contact stated that the fuel gauge indicated that there was more fuel in the tank than there was. Additionally, the contact stated that the fuel gauge read Empty(E) intermittently while driving. The vehicle was taken to the dealer, where the fuel sensor kit was replaced several times; however, the failure persisted. The vehicle was taken back to the dealer; however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 4,600.

NHTSA complaint #11685913 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Not able to remove the key from the ignition.

NHTSA complaint #11664571 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Chevy shifter control gets stuck in a position that does not allow the car to recognize when it is in park and release the key out of the ignition switch. Yes, it is available upon request. Safety is at risk as the vehicle is not recognizing when the car is in park, could lead to further problems when in park. The problem occurs more often than not when switching the car into park, car must be turned back on on off multiple times to release the key or popping the shift release to trip part into engaging and thus releasing. The car was taken in today to a Chevy dealer for a $900 diagnostic and fix which was not performed, many complaints and issues with other newer chevy owners about the issue.No warning lights or tripped codes on code scanner.

NHTSA complaint #11624952 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

While driving, infotainment console/screen is over written with an INTERACTIVE screen demanding the driver to acknowledge privacy policy. INTERACTIVE while DRIVING. What kind of idiot thinks it's a good thing to distract a driver to fulfill a legal point??

NHTSA complaint #11624604 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Battery drains and discharges due to parasite draw drawdown from infotainment system leaving driver stranded in parking garages and other locations. Local deal will not respond. Service Bulletin: N 232 412 313 Covers 2023 Chevrolet Colorado pickup trucks, but not the 2022 model years.

NHTSA complaint #11611831 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Battery keeps draining and leaves you stranded at home or at a parking garage. GM knows that over 250,000 vehicles are affected in the Chevy, GMC line and apparently has spread to Cadillac. The problem is that when GM does over the air updates to the vehicles, the computer software will not disconnect and drains the batteries.

NHTSA complaint #11609460 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Fuel Guage will not move until there is about 200 miles after filling up. When filling up at the 320 miles the pump will shut off at 10 gals. The miles to empty will show that I can go anywhere from 400 to 500 miles. (This is impossible) this also does not match with the fuel gauge reads. Have taken this to the chevy dealer and they could not find anything wrong. It passed the sweep test and they drove it for about 200 miles and stated there was nothing wrong. Vehicle has 19000 miles. First time this happened was when it was at around 10000 miles. Issue is that I don't know and can't drive this very far due to not knowing how much fuel I have used. I have to rely on my phone gps to track how far I have driven and bounce it off of what is on the miles driven display. This has been going on for the last year.

NHTSA complaint #11573767 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I purchased a new 2022 Chevy Colorado LT in January. When driving home and it got dark I used the dimmer to see better. When using the dimmer all of the radio dials turn completely off / dark (not illuminated at all). I drove off the road, looking down trying to find them. I notified the dealership the next day. They had the vehicle for about a week and told me it was fixed. I went to pick it up but it was not. They kept it, tried to fix it again then stated it is how it is supposed to be. I opened a case with GM. They assured me it would be fixed. I brought it to another dealership. They replaced the radio and told me it was fixed and it was not. They took the truck in again for a week. This is now 3 times the truck has been in. Everyone (dealership and GM) telling me it is not right and should be fixed. They are now telling me it is operating as designed. They are saying there is nothing else they can do under the warranty. It is absolutely ridiculous. The radio dials are not illuminated at night if you use the dimmer at all. This issue is specific to all LT Colorado models The Z71 Colorado General Motors Corporation 100 Renaissance Center, P.O. Box 431301 Detroit, MI 48265 (313) 556-5000 If you have any questions or concerns, please contact the BBB assigned to your complaint: BBB of Detroit & Eastern Michigan 20300 W. Twelve Mile Rd Suite 202 Southfield, MI 48076- 6409 1- 866-788- 5706 Better Business Bureau® 2/28/23, 1:37 PM File Complaint against General Motors Corporation | Better Business Bureau https://www.bbb.org/file-a-complaint/0332-4005/form 2/3 issue is specific to all LT Colorado models. The Z71 Colorado model radio (which is identical) does not do this. I requested they used this radio as it is the same (just a different part number). They are stating they need a GM Supervisor or Engineer approval. GM has tried to fix this issue 3-4 times and had my truck for almost 30 days and is now refusing to fix it.

NHTSA complaint #11509523 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The truck only has 12,009 miles on it we purchased it new in November 2021. Now the fuel gage only shows Full regardless of the amount of gas in the tank. Also when we try to fill the tank the gas pump keeps stopping as if the tank is full even when the tank is not. We are extremely uncomfortable to travel any distance. The dealership looked at the issue and said everything checked out ok. It is NOT ok.

NHTSA complaint #11501191 — an unverified report by a vehicle owner.