Chevrolet Cruze transmission problems

POWER TRAIN

For the first question, I’d strengthen it to: The vehicle has experienced repeated engine and engine-cooling system failures, including recurring overheating and coolant loss. Over approximately the past year, I have had to replace or repair numerous components, including the radiator, thermostat housing, temperature sensor, water outlet, turbocharger/turbocharger components, O-rings, multiple oil seals, and the head gasket. I have also had other cooling and engine components repaired, although I no longer have a complete list of every component that has been replaced. Despite these repairs, the vehicle continues to experience overheating and coolant loss. The vehicle has also experienced loss of power while driving. The vehicle is available for inspection upon request. The vehicle has repeatedly displayed an overheating warning. Other symptoms have included coolant loss, shaking and vibration, rough or uneven acceleration, loss of engine power while driving, and a check-engine light. The check-engine light has previously flashed during operation. The vehicle has also experienced unexplained engine-oil loss. These problems have continued despite extensive repairs over approximately the past year, including replacement of the radiator, thermostat housing, temperature sensor, water outlet, turbocharger/turbocharger components, O-rings, oil seals, and head gasket. The repeated failures have created a significant safety risk because the vehicle has overheated while being driven and has previously lost power while traveling on the highway. I have been forced to stop on the side of the road, where I was almost struck by another vehicle. The possibility of sudden loss of power or overheating while traveling in traffic creates a serious risk to both myself and other motorists.

NHTSA complaint #11758553 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2014 Chevrolet Cruze. The contact stated that while attempting to move the gear shifter, the vehicle hesitated while shifting into neutral(N) or drive(D) as intended, and there was an abnormal sound coming from underneath the vehicle. No warning light was illuminated. The contact stated that the failure had reoccurred. The vehicle was towed to a local independent mechanic, where it was diagnosed and determined that the transmission needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,000.

NHTSA complaint #11756664 — an unverified report by a vehicle owner.

POWER TRAIN

i’m unsure if the person i bought this vehicle from had the codes wiped before selling to me, but there were NO lights on dash for 3 days after minimal driving only to work and back, then all of a sudden the check engine light came on, and in the info box it would pop up saying “service stability system” - i took to o’reiley’s to see what it was for, apparently it was the ECM (electronic computer module) which essentially controls like everything. days go by i don’t do anything more about it and drive as usual to work, and it starts overheating, and smoking like crazy, but doesn’t say it’s hot on my dash, so i had no idea how hot it got or anything. i got to work, worked my shift, and went to put coolant in before returning home- just to find that it was full and i didn’t need to put any in. weird, right? ok well on my way home i’m going about 55mph on the highway and it suddenly just wouldn’t let me accelerate anymore and behaved as if i ran out of gas but i had over half a tank. when i came to a stop i turned the car off, and tried to turn it back on when it wouldn’t even turn over. i sat about 15 mins on the side of the highway before it actually started and i drove home. a week goes by, and now this ecm is effecting more and more- driving on the highway/streets it’s shifting really hard, immediately following that, my speedometer and rpm meter fall to “0” on the dash but the vehicle is still driving and the message pops up about the service stability system. i replaced my tire and now it’s telling me to service airbag system and the abs light is stuck on, as well as traction control and it’s just so weird. i just don’t feel safe in this car and after looking it up, apparently everyone with the make and model have very similar problems, but specifically searching by my VIN- apparently there’s no recalls and it’s just extremely frustrating and i don’t know what to do. if i fix the ECM will all these issues be resolved or will i waste $600-$800 replacing it?

NHTSA complaint #11745175 — an unverified report by a vehicle owner.

POWER TRAIN

Have called about this starting 2020. Had 137000. Also previous owner since 99000mi. Drive train & Turbo. Brake assist. Oil leaks, shutting off while driving. Now as of Saturday April 25 2026 Car shut off while driving and has been towed to dealership. Car deemed lemon by GM. In 2020 car to have been replaced I have all service contact numbers as well as my receipts. Car is a death trap. Do better Chevrolet & GM

NHTSA complaint #11734134 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2012 Chevrolet Cruze. The contact stated that while driving at 40 MPH and accelerating over a speed bump, the key slid out of the ignition switch. An independent mechanic was contacted. The vehicle was taken to the independent mechanic, and it was determined that the ignition switch needed to be replaced. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 16V502000 (ELECTRICAL SYSTEM, POWER TRAIN); however, the VIN was not included in the recall. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 74,522.

NHTSA complaint #11733293 — an unverified report by a vehicle owner.

POWER TRAIN

For a year I have had my car to the shop multiple times due to a musty smell inside my car. I have never been able to find any fluids or moisture inside the car, however, the inside of my windshield tends to get a weird film on it, I am constantly cleaning to keep visibility especially at night. None of the mechanics that I have taken it to were able to figure it out, and most of them could not smell The musky smell that I smelled. The car had approximately 40,000 mi on it when this started about a year ago, Maybe 8 months. Recently I have noticed that the coolant in my car is disappearing, I have kept a constant check on it and about once a week have had to add fluids to keep it from getting too low. I have had the coolant system checked out. I've had it flushed. They pressure tested the coolant tank and all tests passed and they could find no issues. However, when my father came to town he checked it out and there is coolant fluid leaking inside my car under the dash and it is dripping slowly on to the underpad of the carpeting and I assume drying up before it gets to a point where it is making a wet spot in the floor. Obviously after more research my father has told me that this has been a known issue with this model of car, however, there is not a recall that I can find with my VIN number. Obviously being stuck in a hot car in Florida, breathing in the fumes from a poisonous liquid is not healthy for me or anyone in my car. This is a safety issue not only for the fumes that I have been breathing, but foggy residue that collects on my windshield creates visual issues especially at night. This could cause me to have a major accident and possibly lose my life. I should not be struggling with a car that I treat like my baby. I have read that this is a design flaw due to the plastic connectors on the hoses, I would like Chevy to stand behind their vehicle and fix this issue for me. I never use the heater, because I live in Florida!

NHTSA complaint #11730583 — an unverified report by a vehicle owner.

POWER TRAIN

The primary failure is a total loss of engine power and electrical systems while the vehicle is in motion. The dealership (Ray Skillman Southside Mitsubishi) has diagnosed this as a failed engine/body control computer system. The vehicle is currently located at the dealership's service center and is available for inspection. The vehicle has stalled/shut off completely while driving on four separate occasions. This resulted in an immediate loss of power steering and motive power, nearly causing collisions in traffic. A vehicle that loses all power without warning is a severe safety hazard to the driver, passengers, and other motorists on the road. Yes. The problem has been confirmed by the Ray Skillman service department. They have attempted to repair the issue 3 times without success and currently state that the vehicle is inoperable while they search for a used replacement computer component. The vehicle has been inspected multiple times by the Ray Skillman dealership technicians. To date, no representative from the manufacturer (General Motors) or insurance has performed an independent inspection, though a formal complaint has been initiated with the dealership's corporate management. There were no consistent warning lamps or symptoms prior to the failures. The vehicle would unexpectedly lose all power and shut down. These symptoms first appeared within the first 100 miles of ownership (purchased at 11,000 miles; current mileage approximately 11,800 The dealership has refused to provide a loaner vehicle and is currently attempting to resolve a recurring safety failure using a used/salvage electronic component rather than a certified new part, which I believe further compromises the safety of the vehicle.

NHTSA complaint #11728928 — an unverified report by a vehicle owner.

POWER TRAIN

The steering started to shake. The car seat started to shake as well. It felt very unsafe, but there was no serious injury. John from Feldman Chevrolet in New Hudson, Michigan said that there is a "Cylinder 1 misfire code". After the car started shaking, the engine light came on. John told us that the engine should be replaced.

NHTSA complaint #11718248 — an unverified report by a vehicle owner.

POWER TRAIN

My 2017 Chevy Cruze had the throttle body replaced by STG Auto Group in Montclair, CA. A few months after the repair, my car began shaking violently and then shut off in the middle of the street while I was driving on 11/17/2025 This created a serious safety hazard for me and other drivers. When I took the vehicle to a local auto zone once the vehicle turned on , they told me the throttle body “needs cleaning,” but a new throttle body should not get dirty within a few months. This suggests improper installation or a defective part. The problem returned even though the part was recently replaced. I immediately called the dealership who fixed it and the manager stated I’d have to wait to the following week for another inspection and that I can not be squeezed in . The vehicle is still unsafe to drive because it shakes and can stall unexpectedly. I am concerned because this issue has happened more than once and could have caused an accident. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11700010 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2011 Chevrolet Cruze. The contact stated that while driving 25-35 MPH, the vehicle failed to shift into the intended gear and then stalled. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to the residence. There was no warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 230,000.

NHTSA complaint #11699756 — an unverified report by a vehicle owner.

POWER TRAIN

Apparently there is a TSB from GM regarding the end for updated/replacement of parts concerning the hydraulic piping, slave cylinder and accumulator. My clutch became spongy then stuck on the floor. This happened unexpectedly (reservoir full) while driving and almost caused an accident. Apparently GM doesn't take enough accountability to update the failure before or after failure. Reporting this hoping it will eventually force a recall!

NHTSA complaint #11699905 — an unverified report by a vehicle owner.

POWER TRAIN

The car is making a whistling sound, the check engine light is on and it has low power. Also wanting to stall

NHTSA complaint #11682554 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2011 Chevrolet Cruze. The contact stated that on two separate occasions while driving at undisclosed speeds, the vehicle shut off unintendedly and without warning. The contact stated that after restarting the vehicle, the vehicle operated normally. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer had not yet been contacted regarding the failure. The contact was informed that the VIN was not included in NHTSA Campaign Number: 16V502000 (ELECTRICAL SYSTEM, POWER TRAIN). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 129,000.

NHTSA complaint #11680047 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2014 Chevrolet Cruze. The contact stated while driving at various speeds, the door locks were opening and closing independently. The contact stated that the instrument cluster was also flashing several unknown warning lights. The contact stated that the heater and the A/C were also functioning independently. The contact stated that the failure was intermittent at first but became a constant failure. Additionally, the contact stated that the transmission occasionally slipped out of gear, almost causing the vehicle to stall, making the steering wheel difficult to turn. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The contact replaced the 12-Volt battery and the fuse box; however, the failure reoccurred. The manufacturer was not informed of the failure. The failure mileage was approximately 177,000.

NHTSA complaint #11663067 — an unverified report by a vehicle owner.

POWER TRAIN

Had a 3-5-R wave plate failure. Symptoms started at around 87,000 miles. Bouncing/jerking when put into reverse. 5th gear slams hard into gear when upshifting and downshifting, making it feel like I have been rear ended. Now 3rd gear is starting to shift hard like 5th. Soon I'll have no gears. Car has been both regular and preventative maintained so should not have such a massive failure at under 100k miles. Other vehicles with the same transmission (6t40) have been recalled due to similar issues, like the 1.4 turbocharged Cruze, but not the 1.8l Cruze for whatever reason. Now I have to pay $4k for a rebuild on something that Chevrolet should be liable to pay.

NHTSA complaint #11655044 — an unverified report by a vehicle owner.

POWER TRAIN

While sitting at a stop light the hydraulic clutch line failed causing the clutch pedal to stick to the floor. This issue prevents the clutch actuation preventing the the transmission from being disconnected from the engine. General Motors Bulletin number: PIP5558C was found and appears to be the issue.

NHTSA complaint #11650501 — an unverified report by a vehicle owner.

POWER TRAIN

Car started jerking when put in reverse and slams hard into 5th gear only. Taken to transmission shop and they have no idea what's causing it. They said they've never seen something like this before, and said it doesn't feel like a major transmission failure. Car only had 98,000 miles on it when hard shifting started. Regularly maintained. Motor and trans mounts were checked and fine. More than normal amounts of metal in trans fluid when drain and fill was performed.

NHTSA complaint #11649148 — an unverified report by a vehicle owner.

POWER TRAIN

Transmission won’t shift into gear while driving and the brakes won’t engage when this happens, this will cause a wreck and hurt someone, the codes are showing po700 tcm code

NHTSA complaint #11645360 — an unverified report by a vehicle owner.

POWER TRAIN

Vehicle does not shift gears, jumpy, sluggish, disengages then jerks back into gear. Hazard when trying to pickup speed to accelerate into highway traffic. Does not engage in reverse gear at times, have to turn vehicle off, wait a few minutes then turn vehicle back on for reverse gear to engage. Sometimes when vehicle is in park, vehicle will not start, have to fidget with gear and key, sometimes for several minutes before it will register in park and allow you to start the vehicle. When on highway transmission will jolt and jerk making you think you have lost your transmission on the roadway. This is a major hazard for my daughter who drives this vehicle to college. I am aware of a lift plate that can be installed to fix this problem that has existed in all 2011 Chevy Cruze s since they were manufactured. NHTSA Bulletin issued Oct. 10, 2024 NHTSA ID#11010651 Manufacture Communication #24-NA-223 Bulletin to all technicians for an alternative procedure for a lift plate that can be installed into the transmission to correct this problem. This needs to be a nationwide issued RECALL because of the endangerment people are being put in while driving these unsafe Chevy Cruze with faulty transmission issues.

NHTSA complaint #11639585 — an unverified report by a vehicle owner.