2006 Chevrolet HHR door lock problems

LATCHES/LOCKS/LINKAGES

The contact owns a 2006 Chevrolet HHR. The contact stated that while driving at various speeds, the vehicle lost motive power and would not properly accelerate. Additionally, the front passenger’s side door would not open while using the interior door latch. The contact stated while using the cigarette lighter, the vehicle shut off, and smoke filled the cabin of the vehicle. The cause of the failure was not yet determined. The local dealer and manufacturer were not contacted. The failure mileage was 92,000.

NHTSA complaint #11534867 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:TRUNK LID:LOCK

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE, THE ENGINE TEMPERATURE GAUGE INDICATED THAT THE ENGINE WAS OVERHEATING. ADDITIONALLY, THE PASSENGER'S SIDE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY AND THE REAR HATCH DOOR WOULD ERRONEOUSLY OPENED AND WOULD NOT REMAIN SECURELY CLOSED. THE CAUSE OF THE FAILURES WERE NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT CONTACTED OR NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 220,000.

NHTSA complaint #11349208 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE DOOR HANDLES FRACTURED. THE FAILURE HAPPENED WITHOUT WARNING. THE CONTACT WAS UNABLE TO EXIT THE VEHICLE. THE BATTERY ALSO FAILED AND PREVENTED THE DRIVER AND PASSENGER SIDE WINDOWS FROM BEING USED. THE VEHICLE WAS DIAGNOSED AND THE DOOR HANDLES WERE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 175,000.

NHTSA complaint #10838112 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACTED STATED WHILE EXITING THE VEHICLE, THE DOOR HANDLE FAILED. AS A RESULT THE CONTACT WAS UNABLE TO EXIT THE VEHICLE. THE FAILURE RECURRED ON THREE OCCASIONS. THE VEHICLE WAS TAKEN A DEALER. THE MECHANIC STATED THAT THE DOOR HANDLE WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

NHTSA complaint #10618805 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER'S SIDE EXTERIOR DOOR LATCH FRACTURED ON TWO SEPARATE OCCASIONS. THE DEALER WAS NOTIFIED AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 08V444000 (LATCHES/LOCKS/LINKAGES). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 20,000.

NHTSA complaint #10597225 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE INTERIOR DOOR HANDLES BECAME FRACTURED AND WERE NOT REPLACED. IN ADDITION, NHTSA CAMPAIGN NUMBER 14V171000 (ELECTRICAL SYSTEM) WAS REFERENCED HOWEVER, THE CONTACT WAS UNABLE TO HAVE THE VEHICLE SERVICED UNDER THE RECALL BECAUSE THE PART WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA complaint #10592654 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER AND FRONT PASSENGER SIDE INTERIOR DOOR HANDLES WERE FRACTURED. THE CONTACT WAS UNABLE TO EXIT THE VEHICLE USING THE INTERIOR DOOR HANDLES. THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE DOOR HANDLES HAD BROKEN OFF DUE TO THE WEAKENED PLASTIC MATERIALS USED TO MANUFACTURE THEM. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 100,000. UPDATED 07/08/14 MA THE CONSUMER ALSO STATED THE VEHICLE STALLED.

NHTSA complaint #10582854 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER'S SIDE DOOR FAILED TO OPEN FROM THE INSIDE OR OUTSIDE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 93,724. *TR UPDATED 04/30/13

NHTSA complaint #10501152 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE INTERIOR DOOR HANDLE ON THE FRONT DRIVER'S SIDE BROKE OFF. THE VEHICLE WAS TAKEN TO A REPAIR SHOP, HOWEVER IT WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, HOWEVER NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE AND CURRENT MILEAGES WERE 124,000.

NHTSA complaint #10466602 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE PASSENGER SIDE DOOR HANDLE BROKE AWAY FROM THE CABLE THAT ALLOWED THE DOOR TO OPEN. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE CONTACT STATED THAT THE SAME FAILURE OCCURRED ON THE DRIVER'S SIDE IN THE PAST. THE DEALER STATED THAT THEY HAD TO REPLACE THE DOOR LATCH AND RECONNECT THE CABLE TO THE LATCH. THE MANUFACTURER WAS CONTACTED AND WOULD INVESTIGATE THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 77,000. ... UPDATED 07/27/12 *BF . THE COSUMER BELIEVES THAT THE PLASTIC BECOMES DEHYDRATED FROM AIR FLOW AND BAKING HEAT FROM THE SUN. UPDATED 08/02/2012

NHTSA complaint #10461492 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE PARKED, THE CONTACT ATTEMPTED TO OPEN THE FRONT DRIVER SIDE DOOR FROM THE INTERIOR OF THE VEHICLE BUT THE DOOR HANDLE DETACHED ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN ADVISED THAT THE DOOR PANEL WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 99,900. UPDATED 01/20/12*LJ THE CONSUMER STATED THE ENTIRE DOOR PANEL NEEDED TO BE REPLACED, JUST FOR AN EXPENSIVE HANDLE. UPDATED 01/27/12

NHTSA complaint #10440901 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

2006 DOOR HANDLE BROKE FOR NO REASON. IS UNABLE TO OPEN FROM INSIDE. ITS A SEFETY ISSUE IF U HAVE TO GET OUT IN AN EMERGENCY.

NHTSA complaint #10421705 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

THE POWER STEERING DOESNT WORK ANYMORE, BOTH OF THE FRONT INSIDE DOOR HANDLES BROKE OFF, WATER LEAKING IN PASSENGER FRONT COMING FROM THE MOTER AREA SOMEWHERE I CALLED THE DEALERSHIP BUT NO RECALLS AND I HAVE READ ON NUMORUS FORUMS OF OTHER PEOPLE HAVING THE SAME PROBLEM BUT GM STILL HASN'T ISSUED A RECALL.

NHTSA complaint #10421660 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE PARKED, THE INTERIOR DRIVERS SIDE DOOR HANDLE DETACHED FROM THE VEHICLE. AFTER OPENING THE WINDOW, THE CONTACT WAS ABLE TO OPEN THE DOOR FROM THE EXTERIOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A DIAGNOSTIC TEST AND THE TECHNICIAN STATED THAT THE DOOR PANEL WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 35,000. UPDATED 10/4/11 *CN UPDATED 10/26/11 IN DECEMBER 2013, THE DRIVER'S SIDE SEAT BELT FASTENER JAMMED AND WOULD NOT RELEASE. THE CONSUMER HAD THE DEFECT REPAIRED. IN MARCH 2014, SUDDENLY, WITHOUT WARNING, THE VEHICLE LOST POWER STEERING. THE CONSUMER PAID TO HAVE THE DEFECT CORRECTED. UPDATED 04/14/14

NHTSA complaint #10421337 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT HANDLE DETACHED FROM THE FRONT DRIVER SIDE DOOR WHEN ENTERING THE VEHICLE. THE SAME FAILURE OCCURRED A MONTH PRIOR TO THE RECENT FAILURE ON THE FRONT PASSENGER SIDE DOOR. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 74,500 AND THE CURRENT MILEAGE WAS 74,600.

NHTSA complaint #10421041 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

DRIVERS DOOR IS BROKEN, HAVE TO ROLL WINDOW DOWN TO GET OUT, ALSO, REMOTE IS NOT WORKING, I HAVE TO LOCK/UNLOCK WITH THE HORN HONKING EVERYTIME I PARK. AFTER DOING A SEARCH ONLINE, I FOUND THAT A LOT OF OTHER PEOPLE HAVE HAD THE SAME PROBLEM, AND IT SEEMS TO STEM FROM THE FACT, THAT CHEVY HAS DECIDED NOT TO BE BUILT LIKE A ROCK, INSTEAD, BUILT WITH PLASTIC. (CAN YOU EVEN RECYCLE IT?)

NHTSA complaint #10412374 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

INSIDE DRIVER SIDE HANDLE BROKE OFF, UNABLE TO OPEN DOOR FROM THE INSIDE THE ELECTRONIC WINDOW MUST BE OPENED AND DOOR OPENED FROM THE OUTSIDE.

NHTSA complaint #10409082 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

INSIDE DOOR HANDLE ON MY 2006 CHEVROLET HHR BROKE OFF WHEN I OPENED THE DOOR. THIS CREATES A SAFETY ISSUE FOR THE DRIVER AS THE DOOR CANNOT BE OPENED FROM THE INSIDE WITHOUT LOWERING THE LEFT FRONT WINDOW AND OPENING WITH THE OUTSIDE HANDLE. IF THE ELECTRICAL SYSTEM IS DAMAGED THEN THE WINDOW WILL NOT OPEN. THE DRIVER WOULD THEN NEED TO CRAWL OVER THE CENTER CONSOLE TO THE RIGHT DOOR OR THE FRONT SEAT TO EXIT THE CARS REAR DOOR. IN A COLLISION OR FIRE THE DRIVER MAY BE INJURED, PANICKED OR CONFUSED AND NOT BE ABLE TO EXIT THE VEHICLE. THE PLASTIC HANDLE SHOULD BE REPLACED WITH A MORE SUBSTANTIAL METAL ONE.

NHTSA complaint #10401358 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE ATTEMPTING TO OPEN THE DRIVERS DOOR THE INSIDE DOOR HANDLE DETACHED FROM THE DOOR PANEL. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER INSPECTED THE VEHICLE, AND STATED THAT THE DOOR HANDLE, AND THE DOOR PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 64,000.

NHTSA complaint #10401018 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER SIDE DOOR HANDLE FRACTURED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE ENTIRE DRIVER SIDE DOOR PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 63,000.

NHTSA complaint #10400034 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THE FRONT DRIVER SIDE INTERIOR DOOR HANDLE COMPLETELY FRACTURED AND SHE COULD NOT EXIT THE VEHICLE. AN AUTHORIZED DEALER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE ENTIRE DOOR PANEL WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS THEN NOTIFIED AND THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 60,000.

NHTSA complaint #10399642 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

THE INTERIOR DOOR HANDLES ON THE 2006 CHEVROLET HHR FELL OFF. THE ONLY WAY TO FIX IT IS TO REPLACE THE ENTIRE DOOR PANEL JUST FOR THE CHEAP PLASTIC HANDLE FOR APPROXIMATELY $500.00. IF I WAS IN AN ACCIDENT AND THE CAR WOULD NOT START AGAIN, I COULD NOT GET OUT OF THE CAR THROUGH THE DRIVER'S SIDE BECAUSE I WOULD NOT BE ABLE TO ROLL DOWN THE WINDOW TO OPEN THE DOOR FROM THE OUTSIDE. OR IF THE CAR WERE ON FIRE, I SIMPLY WOULD NOT BE ABLE TO ESCAPE. THIS NEEDS TO BE A RECALL ITEM AS THIS IS A HUGE SAFETY FACTOR. A BIGGER SAFETY FACTOR THAT THE LATCH ON THE POP UP MIDDLE CONSOLE ON THE CHEVY HHR THAT WAS RECALLED BACK IN 2008 (I THINK). THERE ARE BLOGS ALL OVER THE INTERNET OF PEOPLE LIKE ME WHO ARE EXPERIENCING THE SAME PROBLEM. I AM A SINGLE WORKING GIRL WHO SIMPLY CANNOT AFFORD A $500 INTERIOR DOOR PANEL REPLACEMENT FOR A CHEAP PLASTIC HANDLE BECAUSE THIS IS NOT REASONABLE. I TRIED TO GET CHEVY TO REPLACE IT AND THEY SIMPLY SAID THEY WOULD GIVE ME A $40 DISCOUNT. THAT IS RIDICULOUS!!! I BOUGHT THE CAR BE CAUSE IT WAS ECONOMICAL AND NOT ONE THING ABOUT THIS REPLACEMENT SOUNDS ECONOMICAL. THIS IS A SAFETY HAZARD AND COULD LEAD TO A DEATH.

NHTSA complaint #10395920 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

I HAVE A 2006 HHR. WHILE TRYING TO EXIT OUT THE PASSENGER SIDE DOOR THE DOOR HANDLE BROKE IN MY HAND SO NOW ANYONE SITTING THERE HAS TO OPEN THE WINDOW AN REACH OUT AND OPEN THE DOOR (OR SOMEONE HAS TO OPEN FOR THEM). THE OTHER PROBLEM I JUST ENCOUNTERED IS THAT THE "DOOR OPEN" MESSAGE AND DINGING NOISE KEEPS COMING UP WHILE I AM DRIVING. THE DOOR IS NOT OPEN! ALSO, THE RADIO WON'T SHUT OFF WHEN YOU TURN THE CAR OFF AND OPEN THE DOOR. WHEN PUSHING THE INSIDE LOCK/UNLOCK BUTTON ON THE DRIVER'S SIDE, ALL THE DOORS LOCK EXCEPT THE DRIVER'S SIDE. IT GOES DOWN, BUT COMES BACK UP. MY MECHANIC THINKS IT IS A DOOR LATCH PROBLEM. ALSO THE ALARM GOES OFF BY ITSELF AFTER LOCKING THE CAR WITH THE REMOTE. I WAS AWOKEN AT 3:00 AM TO THE SOUND OF MY CAR GOING OFF, THIS HAS NEVER HAPPENED BEFORE! GM NEEDS TO DO SOME RECALLS ON THESE ITEMS, AS I SEE A LOT OF COMPLAINTS CONCERNING THE SAME ITEMS.

NHTSA complaint #10394293 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

DRIVER SIDE INSIDE DOOR HANDLE BFOKE OFF, NEED TO OPEN WINDOW AND REACH OUTSIDE TO OPEN DOOR.

NHTSA complaint #10393571 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR LT. THE CONTACT STATED THAT WHILE OPENING THE DRIVER SIDE DOOR, THE INTERIOR HANDLE FRACTURED FROM THE DOOR FRAME. THE MANUFACTURER ADVISED THAT THE DOOR HANDLE FAILURE WAS NOT RECALLED AND THAT THEY WILL NOT ASSIST WITH THE REPAIR. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 67,000 AND THE CURRENT MILEAGE 70,648.

NHTSA complaint #10392759 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE ATTEMPTING TO EXIT THE VEHICLE, FROM THE DRIVERS SIDE, THE INTERIOR DOOR HANDLE FRACTURED. THE CONTACT WAS UNABLE TO ACCESS THE EXTERIOR DOOR HANDLE AND FIFTEEN MINUTES LATER, HE WAS ASSISTED IN EXITING THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE FAILURE WHERE HE WAS ADVISED THAT THE ENTIRE DOOR WOULD NEED REPLACING IN ORDER TO CORRECT THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE DOOR HANDLE REMAINED FRACTURED. IN ADDITION, THE KEYS WOULD SPORADICALLY BECOME STUCK IN THE IGNITION AND THE CONTACT WOULD HAVE TO ENGAGE THE EMERGENCY RELEASE BUTTON IN ORDER TO DISENGAGE THE KEYS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE HE WAS ADVISED THAT THE IGNITION LOCK CYLINDER AND REMOTE WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 21,000 AND THE CURRENT MILEAGE WAS 27,920. UPDATED 05/25/11 *BF UPDATED 1/5/12

NHTSA complaint #10390146 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER SIDE INTERIOR PLASTIC DOOR HANDLE FRACTURED FOR THE SECOND TIME. THE DOOR HANDLE WAS PREVIOUSLY REPAIRED FOR THE SAME FAILURE. THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZED DEALER BUT WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 59,000. UPDATED 4/11/2011 *CN UPDATED 04/25/11

NHTSA complaint #10384514 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DOOR PANEL INTERIOR WAS INTERFERING WITH THE OPENING OF THE DOOR. SHE ALSO MENTIONED THAT SHE WOULD HAVE TO WIND DOWN THE WINDOW IN ORDER TO OPEN IT FROM THE OUTSIDE. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT SHE NEEDED TO REPLACE THE INTERIOR DRIVER SIDE DOOR PANEL. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000. UPDATED 3/7/11 *CN THE CONSUMER STATED HE/SHE WAS UNABLE TO OPEN THE DOOR, UNLESS HE STUCK HIS HAND OUT THE WINDOW TO OPEN IT FROM THE OUTSIDE. UPDATED 03/14/11

NHTSA complaint #10379710 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

WHILE OPENING THE LEFT FRONT DOOR FROM THE INSIDE THE PLASTIC CHROME DOOR HANDLE BROKE OFF IN MY HAND MAKING IT IMPOSSIBLE TO OPEN THE DOOR FROM THE INSIDE. THIS WILL IMPAIR THE ABILITY OF THE OCCUPANTS TO EXIT THE VEHICLE IN THE EVENT OF AN EMERGENCY.

NHTSA complaint #10379718 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

2006 CHEVROLET HHR. CONSUMER STATES SEVERAL PROBLEMS WITH VEHICLE *TGW THE CONSUMER STATED HIS SONS VEHICLE HAD A SEVERE SHIMMY IN THE STEERING WHEEL AND BECAME PROGRESSIVELY WORSE WHEN THE BRAKE WAS APPLIED. THE PADS AND ROTORS WERE REPLACED TWICE AND THE THIRD TIME THE ROTORS WERE MACHINED, BUT THE PROBLEM CONTINUED. THERE WAS ALSO A STRANGE NOISE COMING FROM THE FRONT SUSPENSION, BUT THE DEALER WAS UNABLE TO PINPOINT THE PROBLEM. AT 42,000 MILES THE AIR CONDITION MADE A LOUD SCREECHING NOISE FOR 2 MINUTES, THEN STOPPED WORKING. AT 68,000 MILES, A METAL SKID PLATE HAD FALLEN FROM UNDERNEATH THE VEHICLE. SOON AFTER, THE EXHAUST WAS VERY LOUD. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP AND THE CONSUMER WAS INFORMED THE CATALYTIC CONVERTER HAD CRACKED. THE VEHICLE LOST POWER AND A CYLINDER HAD TO BE REPLACED, THE CHECK ENGINE LIGHT WOULD COME ON AND THEN GO OFF, THE TEMPERATURE GAUGE DID NOT WORK, SO THE AIR CONDITION ONLY WORKED IF THE CHECK ENGINE LIGHT WAS OFF. THE DOOR LOCKS DID NOT WORK, THE RADIO WORKED INTERMITTENTLY, THE SUN VISOR WOULD FALL DOWN AT RANDOM TIMES. THERE WERE TIMES WHEN THE VEHICLE WOULD NOT START. THE CONSUMER STATED EVEN WITH AN ALIGNMENT, NEW STRUTS, SHOCKS AND GOOD TIRES, THE VEHICLE CONTINUALLY PULLED TO THE RIGHT.

NHTSA complaint #10377874 — an unverified report by a vehicle owner.