Owners have filed 784 complaints
about the 2008 Chevrolet HHR with NHTSA between 2008 and 2026.
The largest single group is the steering.
Across this model's run it ranks 3 of 6 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 49
Against the median year of the Chevrolet HHR. 50 means typical for this
model; 100 means roughly double.
Severity — 47
9.2% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 36
21% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Electric Power Assist System
1122.4%
Body
1020.4%
Ignition
714.3%
Latch
612.2%
Hoses, Lines/Piping, AND Fittings
510.2%
Manual Transmission
48.2%
Side/Window
36.1%
Switch
36.1%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
223.6%
1,000 – 9,999 miles
355.7%
10,000 – 24,999 miles
477.6%
25,000 – 49,999 miles
9014.5%
50,000 – 74,999 miles
11919.2%
75,000 – 99,999 miles
12920.8%
100,000 – 149,999 miles
13722.1%
150,000+ miles
406.5%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jan 2008peak 38Aug 2026
NHTSA investigations into the 2008 Chevrolet HHR
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
PE20011Opened 5 Jul 2020Closed 17 Aug 2023FUEL/PROPULSION SYSTEM
Fuel Line Leak
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a pro...
Recalls on the 2008 Chevrolet HHR
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
14E021000
ELECTRICAL SYSTEM:IGNITION:SWITCH
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original ignition switch. The weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
Risk: If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
14V171000
ELECTRICAL SYSTEM:IGNITION
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
14V047000
AIR BAGS
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392
Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
08V444000
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Risk: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
08V046000
AIR BAGS
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Risk: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2014126367,972 units in Canada
Other
On certain vehicles, a defect may allow the ignition key to be removed from the ignition switch when the key is not in the "Off" position. This could result in unintended vehicle movement if the transmission is not in the "park" position (automatic transmission) or not in the reverse gear with the parking brake engaged (manual transmission), and increase the risk of a crash causing injury and/or property damage. Correction: Dealers will replace the ignition lock cylinder and/or ignition key.
Recall 2014101132,243 units in Canada
Other
A safety defect may exist in ignition switches sold as service replacement parts. The defect could allow the ignition switch to unintentionally move from the “run” position to the “accessory” or “off” position with a corresponding reduction or loss of power. This risk may be increased if the key ring is carrying added weight or the vehicle goes off road or experiences some other jarring event. The timing of the key movement out of the “run” position, relative to the activation of the sensing algorithm of the crash event, may result in the airbags not deploying, increasing the potential for occupant injury in certain kinds of crashes. General Motors Canada will notify owners of all vehicles not affected by recalls 2014038 (GM number 13454) and 2014060 (GM number 14063) that could potentially have had the affected ignition switches installed during service or repair work. Owners will be instructed to take their vehicle to a dealer for inspection and repair if required. Note: Until the inspection is performed, all items should be removed from the key ring.
Recall 201044786,345 units in Canada
Steering
Certain vehicles equipped with electric power steering may experience a sudden loss of power steering assist that could occur at any time while driving. If the power steering assist is lost, a message is displayed on the Driver Information Centre and a chime sounds to inform the driver. Typically, at the next ignition cycle, power assist is regained and the Driver Information Centre message will be off. Steering control can be maintained, as the vehicle will revert to a manual steering mode, but would require greater driver effort at low vehicle speeds, which could result in a crash causing property damage and/or personal injury. Correction: Vehicles will receive a special extended warranty coverage of 10 years/240,000 km from first registration. Under this special coverage program, vehicles which experience this condition will have the electric power steering motor replaced.
Recall 200832215,003 units in Canada
Other
On certain vehicles, the door on the storage bin in the top centre of instrument panel may not remain closed during an impact and could result in personal injuries. Correction: Owners will received a latch reinforcement kit and installation instructions.
Recall 200821414,465 units in Canada
Other
Certain vehicles fail to comply with the requirements of CMVSS 115 - Vehicle Identification Number (VIN). Specifically, the Gross Vehicle Weight Rating (GVWR) digit - position 4 in the VIN - should have had the letter "C" (for vehicles with a GVWR 4,001 - 5,000 lb), but instead contains the letter "D" (GVWR 5,001 - 6,000 lb). Correction: Since this does not pose any safety risk, no corrective action is required.
Reports where the owner recorded a crash, a fire, an injury or a death.
Eureka, CACrash
STEERING
Power steering went out completely causing me to swerve on the highway to side of road. The steering locked up and it was raining and I would of crashed had anyone else been on the highway. I was going about 55 mph at the time. I then proceeded to CAREFULLY at about 30 mph force my car to drive another half mile to nearest exit ramp. The entire time I was driving in the middle of the lanes and a huge liability as far as safety is concerned. Thankfully I made it with no harm to myself vehicle or anyone else. I pulled over to side of road and slept in car till the rain stopped. Prior to this I backed into a fence when the steering failed backing into a carport resulting in body damage to front end under left headlight. Months before I had asked the Chevy dealership to diagnose issue and they found nothing wrong as in the beginning the car would still steer at its own leisure. The light didn't come on when they looked at it. After the night in the rain I have taken the fuse outta the power steering part and just manually steer. This should be replaced as it is a common issue to ALL HHR. Mine isn't covered as it is an SS but clearly it should be covered by a recall. Hopefully I don't die before this is taken care of.
NHTSA complaint #11426065 — an unverified report by a vehicle owner.
at 127,000 milesLogansport, INFire
FUEL/PROPULSION SYSTEM
SEVERE FUEL LEAK WHICH CAUSED A SMALL FIRE. LUCKILY WE HAD A FIRE EXTINGUISHER HANDY. THIS IS APPARENTLY VERY COMMON WITH HHRS AND THANK GOD I WASN'T AT A GAS STATION WHEN THE FIRE STARTED.
NHTSA complaint #11384757 — an unverified report by a vehicle owner.
at 134,000 milesAlton, ILCrash2 injured
AIR BAGS
TL* THE CONTACT OWNS A 2008 CHEVROLET HHR. WHILE DRIVING 45 MPH OVER BLACK ICE, THE CONTACT LOST CONTROL OF THE VEHICLE, DROVE OFF THE ROAD, AND CRASHED INTO THREE TREES. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED HEAD, NECK, BACK, AND RIB INJURIES. THE PASSENGER SUSTAINED MULTIPLE UNKNOWN INJURIES. BOTH OCCUPANTS RECEIVED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 134,000.
NHTSA complaint #11282432 — an unverified report by a vehicle owner.
at 40,000 milesGulfport, MSCrash2 injured
AIR BAGS
SINGLE CAR ACCIDENT/HIT AN ANIMAL / CAR SPUN OUT OF CONTROL/HIT SEVERAL TREES(CAR WAS A TOTAL LOSS) WIFE & DAUGHTER SEVERELY INJURED//NOT ONE AIR BAG DEPLOYED(HIGHWAY PATROLMAN VERIFIED IN HIS REPORT
NHTSA complaint #11096942 — an unverified report by a vehicle owner.
at 40,000 milesGulfport, MSCrash2 injured
STRUCTURE:BODY
SINGLE CAR ACCIDENT/HIT AN ANIMAL / CAR SPUN OUT OF CONTROL/HIT SEVERAL TREES(CAR WAS A TOTAL LOSS) WIFE & DAUGHTER SEVERELY INJURED//NOT ONE AIR BAG DEPLOYED(HIGHWAY PATROLMAN VERIFIED IN HIS REPORT
NHTSA complaint #11096942 — an unverified report by a vehicle owner.
at 40,000 milesGulfport, MSCrash2 injured
ENGINE
SINGLE CAR ACCIDENT/HIT AN ANIMAL / CAR SPUN OUT OF CONTROL/HIT SEVERAL TREES(CAR WAS A TOTAL LOSS) WIFE & DAUGHTER SEVERELY INJURED//NOT ONE AIR BAG DEPLOYED(HIGHWAY PATROLMAN VERIFIED IN HIS REPORT
NHTSA complaint #11096942 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Eaton Rapids, MI
UNKNOWN OR OTHER
Remedy for campaign 14V047000 was executed defectively, creating an unsafe mechanical failure that destroyed the powertrain. Failure occurred while or shortly before vehicle stalled in heavy traffic. Vehicle would not restart, but ignition switch stuck in start position while attempting restart, causing starter motor to crank continuously until the switch was turned to the off position. It is believed that starter motor was running while engine was running since last successful start about 3 minutes prior to stall, interfering with normal operation of the engine and eventually causing engine to jump timing and sustain catastrophic internal damage. Subsequent GM dealer service visit found that a burr on the new key provided with campaign 14V047000 repair caused ignition switch to bind in start position. Service staff buffed out burr on key which resolved switch binding, but vehicle refused to start. Borehole inspection of engine found damaged valves and pistons, leading to diagnosis of jumped timing. No other work other that diagnosis has been attempted at this point. Estimate to replace engine is $8600
NHTSA complaint #11757032 — an unverified report by a vehicle owner.
Eaton Rapids, MI
ELECTRICAL SYSTEM
Remedy for campaign 14V047000 was executed defectively, creating an unsafe mechanical failure that destroyed the powertrain. Failure occurred while or shortly before vehicle stalled in heavy traffic. Vehicle would not restart, but ignition switch stuck in start position while attempting restart, causing starter motor to crank continuously until the switch was turned to the off position. It is believed that starter motor was running while engine was running since last successful start about 3 minutes prior to stall, interfering with normal operation of the engine and eventually causing engine to jump timing and sustain catastrophic internal damage. Subsequent GM dealer service visit found that a burr on the new key provided with campaign 14V047000 repair caused ignition switch to bind in start position. Service staff buffed out burr on key which resolved switch binding, but vehicle refused to start. Borehole inspection of engine found damaged valves and pistons, leading to diagnosis of jumped timing. No other work other that diagnosis has been attempted at this point. Estimate to replace engine is $8600
NHTSA complaint #11757032 — an unverified report by a vehicle owner.
Eaton Rapids, MI
ENGINE
Remedy for campaign 14V047000 was executed defectively, creating an unsafe mechanical failure that destroyed the powertrain. Failure occurred while or shortly before vehicle stalled in heavy traffic. Vehicle would not restart, but ignition switch stuck in start position while attempting restart, causing starter motor to crank continuously until the switch was turned to the off position. It is believed that starter motor was running while engine was running since last successful start about 3 minutes prior to stall, interfering with normal operation of the engine and eventually causing engine to jump timing and sustain catastrophic internal damage. Subsequent GM dealer service visit found that a burr on the new key provided with campaign 14V047000 repair caused ignition switch to bind in start position. Service staff buffed out burr on key which resolved switch binding, but vehicle refused to start. Borehole inspection of engine found damaged valves and pistons, leading to diagnosis of jumped timing. No other work other that diagnosis has been attempted at this point. Estimate to replace engine is $8600
NHTSA complaint #11757032 — an unverified report by a vehicle owner.
at 68,900 milesSpringfield, MA
FUEL SYSTEM, GASOLINE
The contact owns a 2008 Chevrolet HHR. The contact stated that while the vehicle was parked and turned off, the contact was informed that the vehicle was leaking gasoline. The vehicle was inspected, and the contact was informed that fuel was leaking from the driver’s side rear wheel well area, near the muffler. While at the residence, the contact observed that fuel was still leaking from the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed with a rusted fuel line located near the driver’s side rear wheel well, and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to have the vehicle diagnosed by a dealer. The approximate failure mileage was 68,900. The VIN was not available.
NHTSA complaint #11727264 — an unverified report by a vehicle owner.
at 200,000 milesTexas City, TX
AIR BAGS
The contact owns a 2008 Chevrolet HHR. The contact stated that the key was stuck in the ignition switch and failed to release. Additionally, the TPMS warning light was illuminated. The vehicle was towed to the local dealer, who confirmed that the key was stuck and needed to be broken, and any damages would be at the owner's expense. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 14V171000 (Air Bags, Electrical System). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 200,000.
NHTSA complaint #11720216 — an unverified report by a vehicle owner.
at 200,000 milesTexas City, TX
ELECTRICAL SYSTEM
The contact owns a 2008 Chevrolet HHR. The contact stated that the key was stuck in the ignition switch and failed to release. Additionally, the TPMS warning light was illuminated. The vehicle was towed to the local dealer, who confirmed that the key was stuck and needed to be broken, and any damages would be at the owner's expense. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 14V171000 (Air Bags, Electrical System). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 200,000.
NHTSA complaint #11720216 — an unverified report by a vehicle owner.
at 200,000 milesTexas City, TX
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
The contact owns a 2008 Chevrolet HHR. The contact stated that the key was stuck in the ignition switch and failed to release. Additionally, the TPMS warning light was illuminated. The vehicle was towed to the local dealer, who confirmed that the key was stuck and needed to be broken, and any damages would be at the owner's expense. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 14V171000 (Air Bags, Electrical System). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 200,000.
NHTSA complaint #11720216 — an unverified report by a vehicle owner.
at 64,000 milesOxford, NC
AIR BAGS
The contact owns a 2008 Chevrolet HHR. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 14V047000 (Air Bags, Electrical System); but the vehicle experienced a failure. The contact stated that the key could not be removed from the ignition switch while the key was in the "OFF" position. In addition, the battery was being drained. The contact stated that the battery was previously replaced several months ago. The contact stated that the key was stuck in the ignition switch. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000.
NHTSA complaint #11706785 — an unverified report by a vehicle owner.
at 64,000 milesOxford, NC
ELECTRICAL SYSTEM
The contact owns a 2008 Chevrolet HHR. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 14V047000 (Air Bags, Electrical System); but the vehicle experienced a failure. The contact stated that the key could not be removed from the ignition switch while the key was in the "OFF" position. In addition, the battery was being drained. The contact stated that the battery was previously replaced several months ago. The contact stated that the key was stuck in the ignition switch. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000.
NHTSA complaint #11706785 — an unverified report by a vehicle owner.
at 56,000 milesDenver, CO
VISIBILITY:GLASS, SIDE/REAR
The contact owns a 2008 Chevrolet HHR. The contact stated while warming up the vehicle, the rear window exploded without warning or impact. There was smoke coming from the front of the vehicle. There was an abnormal burning odor detected. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 56,000. The VIN was not available.
NHTSA complaint #11652486 — an unverified report by a vehicle owner.
Eugene, OR
VEHICLE SPEED CONTROL
vehicle ecm keeps reporting an error code p2138 that refers to a correlation issue between sensors on the throttle/pedal system, causing the vehicle to enter into reduced power and eventually disables engine. Problem persists even after replacing pedal component. Apparently water enters the compartment where the part is located and corrodes wiring between the ecm and the pedal system. GM is apparently aware but so far has done nothing. Problem is especially hazardous because engine power is reduced during acceleration and happens without warning. Vehicle could be in high density traffic and then suddenly experiences lack of power or total disability, and driver must try to navigate to the side of the road--not always possible or safe to do.
NHTSA complaint #11641227 — an unverified report by a vehicle owner.
Niles, MI
FUEL SYSTEM, GASOLINE
The contact owns a 2008 Chevrolet HHR. The contact stated that on one occasion after her friend parked the vehicle, the contact observed condensation underneath the rear of the vehicle. The vehicle was inspected by the friend's nephew, and it was determined that the fuel line had a hole and was leaking fuel. The vehicle was then taken to a dealer where it was diagnosed and determined that the fuel line needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11607018 — an unverified report by a vehicle owner.
Saginaw, MI
FUEL/PROPULSION SYSTEM
Gas line leaking, leaves puddles and can visibly be seen dripping
NHTSA complaint #11594455 — an unverified report by a vehicle owner.
at 184,025 milesJasonville, IN
FUEL SYSTEM, GASOLINE
The contact owns a 2008 Chevrolet HHR. The contact stated that while parking the vehicle, the contact detected an abnormally strong fuel odor. Upon inspection, the contact noticed a leak coming from underneath the rear driver's side door. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Action Number: PE20011 (Fuel System, Other, Fuel/Propulsion System, Fuel System, Gasoline). The failure mileage was 184,025.
NHTSA complaint #11585773 — an unverified report by a vehicle owner.
at 199,000 milesRussellville, MO
FUEL SYSTEM, GASOLINE
The contact owns a 2008 Chevrolet HHR. The contact stated that after starting the vehicle, the contact became aware of a fuel leak nearby the rear driver’s side wheel. There were no warning lights illuminated. The contact towed the vehicle to an independent mechanic who diagnosed that the fuel line had completely rusted due to being wrapped in heat-reliant tape. The contact was informed that the fuel lines needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and was informed that there was a recall related to the rust failure of the fuel line of another make and model vehicle however, the VIN was not included. The approximate failure mileage was 199,000.
NHTSA complaint #11562254 — an unverified report by a vehicle owner.
Butler, PA
FUEL/PROPULSION SYSTEM
FUEL LINE LEAKING IN TWO PLACES, IN THE REAR AND IN THE FRONT. COMPLETELY RUSTED OUT. MY CAR ONLY HAS 60,800 MILES ON IT. TYPE OF CAR IS A 2008 CHEVY HHR LT 2.4. GAS IS LEAKING ON THE GROUND AND A STRONG SMELL OF GAS IS EMITTED FROM THE CAR. THIS IS VERY DANGEROUS BECAUSE THE CAR COULD CATCH FIRE. I DID NOT THINK THIS WOULD HAPPEN TO MY CAR WITH SO FEW MILES ON THE CAR. I DID NOT KNOW THERE WAS A PROBLEM AND DROVE THE CAR 130 MILES AWAY FROM HOME TO MY DAD'S FUNERAL. THEN I HAD TO DRIVE IT BACK BECAUSE TH E TOW WOULD HAVE BEEN $700. THE MECHANIC WHO INSPECTED THE CAR. BUDDY LLOYD'S LAKEVIEW AUTOMOTIVE AT 4757 SANG RUN ROAD IN MCENRY, MD 21541, SAID IT WOULD COST ABOUT $2,000 TO FIX BECAUSE OF THE EXTENT OF THE CORROSION AND THE CHAEP MATERIALS USED. IN ADDITION, THE FUEL LINES ARE LOCATED UNDERNEATH OTHER MAJOR PARTS AND WOULD HAVE TO BE TAKEN OFF TO GET TO THE FUEL LINES. THE MECHANIC SAID AT ANY MOMENT IF I HIT A BUMP THAT THE GAS COULD EMPTY THE TANK AND POSSIBLY CATCH FIRE!
NHTSA complaint #11552766 — an unverified report by a vehicle owner.
at 80,900 milesWinterville, NC
AIR BAGS
The contact owns a 2008 Chevrolet HHR. The contact stated while driving at approximately 35 MPH, the air bag warning light illuminated. The service air bag soon message was displayed. The vehicle was taken to the local dealer, where it was diagnosed that two unknown modules were defective and needed to be replaced. The dealer informed the contact that the modules were no longer manufactured. The vehicle was not repaired. The vehicle was taken to an independent mechanic, but no assistance was provided. The manufacturer was contacted and informed the contact that the part had been discontinued. The failure mileage was approximately 80,900.
NHTSA complaint #11551839 — an unverified report by a vehicle owner.
Savanna, IL
STEERING
While driving steering motor just stops working causing hard steering and not steer properly. You try to pull off busy highway. stop put in park shut off car then restart steering works fine just out nowhere you loose steering. its intermitten.,
NHTSA complaint #11549969 — an unverified report by a vehicle owner.
at 6,000 milesDetroit, MI
FUEL SYSTEM, GASOLINE
The contact owns a 2008 Chevrolet HHR. The contact stated that there was fuel leaking from the fuel tank. There was no warning light illuminated. The vehicle was taken to an independent mechanic who replaced the fuel tank however, the failure persisted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 6,000.
NHTSA complaint #11532941 — an unverified report by a vehicle owner.
Drummonds, TN
FUEL/PROPULSION SYSTEM
Corrosion of the metal fuel lines underneath the vehicle towards the rear and in the vicinity of the left rear wheel well.
NHTSA complaint #11497101 — an unverified report by a vehicle owner.
Fort Lauderdale, FL
FUEL/PROPULSION SYSTEM
2008 HHR Chevy LS 4D. Within 10 months of purchasing this car (October, 2017) the smell of gasoline became so strong I took it to the local mechanic. The fuel line had completely rusted out. I was told it could have caught fire! Cost of replacement was $420.00. A huge financial burden for a senior citizen. I have original bill for this amount and receipt of payment.
NHTSA complaint #11478091 — an unverified report by a vehicle owner.
Midland, TX
STEERING
Needless to say, General Motors has dealt with their share of recalls lately and while much of the GM recall news has been devoted to the ignition failures which have forced new CEO Mary Barra to stand before the US Government, this new recall has nothing to do with the ignition cylinder failures. Although the ignition problems can cause a steering issue and some of the vehicles included in the ignition recall are also included in this new recall, this recall pertains specifically to the power steering system. It seems that in the 1.3 million affected vehicles, one or more components of the electric power steering assist system could fail and when that happens, the car will not have the same level of power assist. The General Motors statement announcing this recall is a bit on the vague side in terms of explaining exactly what is causing this loss of power assist, but the automaker has explained that it could be due to a problem with the power steering motor, the steering column assembly, the power steering control unit or a combination of the power steering column and the power steering control unit. Regardless of which of those components fail, it will become much more difficult to steer the car at low speeds, although when driving at higher speeds it may almost be unnoticeable. However, with the increased possibility of accidents, GM isn’t taking any chances so they have made the decision to add these 1.3 million cars to their already lengthy list of recalled models. My 2008 HHR is not listed in any recalls by it's VIN
NHTSA complaint #11474408 — an unverified report by a vehicle owner.
Midland, TX
ELECTRICAL SYSTEM
Needless to say, General Motors has dealt with their share of recalls lately and while much of the GM recall news has been devoted to the ignition failures which have forced new CEO Mary Barra to stand before the US Government, this new recall has nothing to do with the ignition cylinder failures. Although the ignition problems can cause a steering issue and some of the vehicles included in the ignition recall are also included in this new recall, this recall pertains specifically to the power steering system. It seems that in the 1.3 million affected vehicles, one or more components of the electric power steering assist system could fail and when that happens, the car will not have the same level of power assist. The General Motors statement announcing this recall is a bit on the vague side in terms of explaining exactly what is causing this loss of power assist, but the automaker has explained that it could be due to a problem with the power steering motor, the steering column assembly, the power steering control unit or a combination of the power steering column and the power steering control unit. Regardless of which of those components fail, it will become much more difficult to steer the car at low speeds, although when driving at higher speeds it may almost be unnoticeable. However, with the increased possibility of accidents, GM isn’t taking any chances so they have made the decision to add these 1.3 million cars to their already lengthy list of recalled models. My 2008 HHR is not listed in any recalls by it's VIN
NHTSA complaint #11474408 — an unverified report by a vehicle owner.
Dunlap, TN
FUEL/PROPULSION SYSTEM
Gas leak has started on the driver side in front of the rear tire.
NHTSA complaint #11474303 — an unverified report by a vehicle owner.
Houston, TX
STEERING
Power steering dashboard light came on. Difficult to steer vehicle. Losing power steering is dangerous. Will report the matter to the Chevrolet dealership. No other inspections were done. The dealership may inspect the vehicle. Trying to find recalls to fix this problem for free, but it looks like Chevrolet has not provided a recall for this problem although there are numerous complaints about the failed power steering in their HHR vehicles.
NHTSA complaint #11470790 — an unverified report by a vehicle owner.