375 of the 4,753 complaints filed about the Chevrolet HHR are about the fuel system — 8% of everything owners reported. The worst model year for it is 2009.
375
Complaints
8%
Share of all complaints
0
Crashes
8
Fires
FUEL/PROPULSION SYSTEM
The fuel line rusted causing it to leak. We discovered it when we had some exhaust work done on the car. No one other then myself and the people that have done the exhaust work. There was no warning of the issue.
NHTSA complaint #11738005 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2008 Chevrolet HHR. The contact stated that while the vehicle was parked and turned off, the contact was informed that the vehicle was leaking gasoline. The vehicle was inspected, and the contact was informed that fuel was leaking from the driver’s side rear wheel well area, near the muffler. While at the residence, the contact observed that fuel was still leaking from the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed with a rusted fuel line located near the driver’s side rear wheel well, and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to have the vehicle diagnosed by a dealer. The approximate failure mileage was 68,900. The VIN was not available.
NHTSA complaint #11727264 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Started with gas smell and I was able to see gas dripping down from fuel pipeline in the rear wheel driver side.
NHTSA complaint #11727282 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Car has developed a fuel leak once again in the rear of the vehicle. this is the second time a fuel leak has been noted. the first time the mechanic replaced a portion of the line that had corroded and was leaking fuel near the driver rear tire. now the leak is in another section of the original pipe near the fuel tank. this is poor quality and engineering.
NHTSA complaint #11703297 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
The fuel line on the left back side of the car (back drivers side) was leaking fuel when it was in parking or sitting and idling. Noted fuel smell when car started up and was idling, car was taken to independent mechanic, fuel line was broke in 2 places. It was broke close by the wheel are and the other spot was back by the exhaust
NHTSA complaint #11659516 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Last week, I noticed fuel leaking out from the bottom of my vehicle on the rear passenger side in my driveway after returning home. I had my vehicle towed into a local shop to get looked at. The shop informed me that my entire fuel line assembly needed to be replaced. They stated that the metal assembly has rusted and corroded over time. At the time of this writing, my vehicle is still in the shop awaiting to get fixed. It is available to be inspected upon request. There are no warning signs on my computer system prior to this. This leaking fuel could have put myself and my family at risk for harm due to the fire risk.
NHTSA complaint #11631633 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
The fuel line is leaking due to it being metal and rusted.
NHTSA complaint #11629426 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Car is leaking gas on left rear side. Corrosion and rust due to fuel line.
NHTSA complaint #11628096 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Fuel line leaking next to exhaust. This is very dangerous and could kill someone. Bad design on Chevy's part.
NHTSA complaint #11627210 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Fuel line is leaking near left rear wheel wheel
NHTSA complaint #11627299 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2009 Chevrolet HHR. The contact stated that there was a fuel leak near the driver's side rear door. The contact stated that the TPMS, ESC, and check engine warning lights were illuminated. The contact researched online and determined that the failure was related to NHTSA Action Number: PE20011 (FUEL SYSTEM, OTHER, FUEL/PROPULSION SYSTEM, FUEL SYSTEM, GASOLINE). The contact called the local dealer and was informed there were no recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 136,440.
NHTSA complaint #11622868 — an unverified report by a vehicle owner.
FUEL SYSTEM, OTHER
The contact owns a 2009 Chevrolet HHR. The contact stated that there was a fuel leak near the driver's side rear door. The contact stated that the TPMS, ESC, and check engine warning lights were illuminated. The contact researched online and determined that the failure was related to NHTSA Action Number: PE20011 (FUEL SYSTEM, OTHER, FUEL/PROPULSION SYSTEM, FUEL SYSTEM, GASOLINE). The contact called the local dealer and was informed there were no recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 136,440.
NHTSA complaint #11622868 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
The contact owns a 2009 Chevrolet HHR. The contact stated that there was a fuel leak near the driver's side rear door. The contact stated that the TPMS, ESC, and check engine warning lights were illuminated. The contact researched online and determined that the failure was related to NHTSA Action Number: PE20011 (FUEL SYSTEM, OTHER, FUEL/PROPULSION SYSTEM, FUEL SYSTEM, GASOLINE). The contact called the local dealer and was informed there were no recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 136,440.
NHTSA complaint #11622868 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
last week we noticed gasoline showing up on the ground in front of the rear driver side tire. I looked underneath and found a pipe that seems to be corroded. I looked online and found that many people have the same problem, so I haven't had it checked at a dealership. The pipe continues to leak after you walk away and I'm afraid someone will discard a cigarette near the vehicle, or worse. We are generally home, and can be reached for inspection.
NHTSA complaint #11621763 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2009 Chevrolet HHR. The contact stated that while the vehicle was parked, and while driving the vehicle, there was a strong fuel odor coming from the vehicle. Additionally, the contact noticed that the vehicle was experiencing excessive fuel consumption. The contact also noticed that fuel had leaked onto the ground. The contact stated that upon inspecting the vehicle, the contact noticed that fuel was leaking from the driver's side rear wheel well, where the fuel tank was located. The contact related the failure NHTSA Action Number: PE20011(Fuel System, Other, Fuel/Propulsion System, Fuel System, Gasoline). The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 110,000.
NHTSA complaint #11620091 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Fuel lines corroded just like millions of other HHR's. Gas is leaking. What does it take to have a recall on this? Does someone really have to be killed?
NHTSA complaint #11610617 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Fuel leak coming from the Left (Drivers Side) of the vehicle in the area of the rear wheel. There was a strong odor of fuel, Fuel was observed dripping to the ground under the vehicle in front of the Left rear wheel. This condition was observed only when the vehicle was running and in park. The condition does not seem to happen when the vehicle is off and not running. No repair has been made yet , vehicle can be inspected in its current condition. This is a severe safety concern of ignition/explosion due to a fuel leak; risk of property damage or even death. This problem has not been addressed yet to a dealer or local mechanic as of yet . Failed component has not yet been inspected by GM, Police or insurance. No warning lamps or messages were illuminated on dashboard, prior to failure, vehicle did have some difficulty starting, possibly due to this problem, but it did start.
NHTSA complaint #11607862 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2008 Chevrolet HHR. The contact stated that on one occasion after her friend parked the vehicle, the contact observed condensation underneath the rear of the vehicle. The vehicle was inspected by the friend's nephew, and it was determined that the fuel line had a hole and was leaking fuel. The vehicle was then taken to a dealer where it was diagnosed and determined that the fuel line needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11607018 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Fuel line leak. My fuel line has cracked in multiple places and needs to be replaced entirely. The leak was consistent, with a constant stream leaking out when in operation and for several minutes after stopping the engine. The odor of gasoline was strong from inside of the vehicle when in operation and large puddles of gas were visible on the ground afterwards when I first noticed the issue. My repair quote is about $500 to get the line replaced entirely.
NHTSA complaint #11605034 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Gas lines rusted out after purchase.
NHTSA complaint #11604907 — an unverified report by a vehicle owner.