77 of the 693 complaints about the 1997 Chevrolet Malibu are about the engine — 11% of everything reported for this model year. Half of the failures with a mileage on record happened before 74,000 miles.
77
Complaints
1
Crashes
0
Fires
1
Injuries
Filed with NHTSA, in their own words.
ENGINE
Theft light. Car won’t start it’s happened 20 times in the last 6 months. I was driving and theft light caused everything to shut down. This is a dangerous thing that needs to be fixed
NHTSA complaint #11433505 — an unverified report by a vehicle owner.
ENGINE
Theft light keeps coming on, my car will stop when it happens. This has happened while driving. And will not start. I’ve had the recall fixed years ago that was said to be the reason. It didn’t fix the problem
NHTSA complaint #11422206 — an unverified report by a vehicle owner.
ENGINE
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT STATED THAT IT TOOK NUMEROUS ATTEMPTS TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE IGNITION SWITCH AND SENSOR WERE BOTH REPLACED. IN ADDITION, THE ENGINE PISTON SLAP MADE A LOUD KNOCKING NOISE WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.
NHTSA complaint #10637571 — an unverified report by a vehicle owner.
ENGINE
CAR GOES INTO LOCKDOWN FREQUENTLY BECAUSE OF THE THEFT ALERT SYSTEM AND YOU HAVE TO WAIT 10 MINUTES BEFORE THE CAR WILL START. I BELIEVE THIS IS A SAFETY CONCERN AND POTENTIAL HAZARD TO ANYONE IS OPERATING THIS VEHICLE. I CALLED DEALERSHIP TO DISCUSS THIS PROBLEM AND THERE REPLY IS "WELL THE CAR IS OLD AND YOU NEED TO SEE ABOUT PURCHASING ANOTHER ONE". I GOT THIS REPLY IN 2007. I HAVE ALSO RESEARCHED IT ON THE INTERNET AND FOUND THAT THIS IS A COMMON PROBLEM IN CHEVY MALIBU'S, WHICH TO ME CONSTITUTES A MANUFACTURING DEFECT AS WELL AS A SAFETY CONCERN.
NHTSA complaint #10482296 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
INTAKE MANIFOLD ON MY 1997 CHEVY MALIBU HAS STARTED TO GO BAD I KNOW ITS THE LOWER GASKET I CALLED CHEVY AFTER SEEING SO MANY OTHER PEOPLE WITH THE SAME PROBLEM I WAS TOLD CHEVY WOULD NOT REPLACE IT DUE TO IT BEING OVER TEN YEARS OLD WELL IT SEEMS LIKE WITH WAS A PROBLEM WAITING TO HAPPEN AS SOON AS THEY SEALED THE MANIFOLD AT THE FACTORY I THINK GM SHOULD REPLACE THIS ITEM ONCE FREE OF CHARGE PER CAR ALSO MY RACK AND PINION SEEMS TO STICK ON MY LEFT SIDE I'VE REPLACED THE POWER STEERING PUMP AND CHECKED THE RACK AND PINION SEEMS THE BALL BEARING WANTING TO COME OUT OR IS GONE I TOLD GM I DON'T THINK THEY REPLACED IT WHEN THEY RECALLED IT AND THEY TOLD ME THE FIRST OWNER DID BUT WONT SEND ME PAPERWORK ON THE REPAIR OR THE DEALERSHIP THAT DID THE WORK.
NHTSA complaint #10369571 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:COOLING SYSTEM
CAR ENGINE OVERHEATING NOT DUE TO THERMOSTAT OR WATER PUMP.
NHTSA complaint #10279791 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE
CAR ENGINE OVERHEATING NOT DUE TO THERMOSTAT OR WATER PUMP.
NHTSA complaint #10279791 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
I HAVE A 1997 CHEVY MALIBU (54,000) MILES THAT SEIZED UP IN TRAFFIC DUE TO ANTIFREEZE IN THE OIL. I HAVE RECENTLY LEARNED THAT THE ANTIFREEZE (DEXA-COOL) USE BY GM HAS A LONG HISTORY OF CAUSING PREMATURE ENGINE FAILURES BY EATING AWAY THE GASKETS, WATER PUMPS AND OTHER ASSOCIATED ENGINE COOLING COMPONENTS. I?M NOT ABLE TO TAKE ADVANTAGE OF THE CLASS ACTION LAW SUIT SINCE MY PROBLEM HAPPENED LONG AFTER THE CLOSING DATE. I FEEL A NATIONAL RECALL SHOULD BE INITIATED BY NHTSA.
NHTSA complaint #10265876 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:COOLING SYSTEM
AUTOMOTIVE COOLING SYSTEM> VEHICLE BEGAN LOOSING COOLANT ON DRIVEWAY. TOOK VEHICLE TO REPAIR SHOP. WAS INFORMED THAT VEHICLES ENTIRE COOLING SYSTEM WAS CORRODED. AND NEEDED TO BE REPLACED. THE CAUSE WAS ATTRIBUTED TO THE USE OF THE COOLANT DEX-COOL THIS WAS REQUIRED BY GENERAL MOTORS TO KEEP UP WARRANTY ON THE VEHICLE. NOW I FIND THAT THIS WAS THE WRONG THING TO USE AND I WILL BE OUT $1800 IN REPAIR WORK. I BELIEVE G.M. SHOULD BE RESPONSIBLE FOR THE LARGEST PART OF THIS EXPENSE.
NHTSA complaint #10242013 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
I WOULD LIKE TO GET A REPLACEMENT,DISCOUNT OR FREE SERVICE ON MY 1997 MALIBU. I'VE HAD MY CAR SINCE 2004 AND HAD TO GET ANOTHER MOTOR IN 2005 WHICH IS NEEDED NOW .THIS CAR HAS PUT ME DOWN A LOT NOT ONLY PROBLEMS WITH THE MOTOR BUT THE IGNITION LOCKED UP AND I HAD TO REPLACE THAT AS WELL AS THE BRAKES AND ROTORS THAT LAST ABOUT 2 OR 3 MONTHS. I ALSO HAVE A PROBLEM WITH THE LIGHTS NOT WORKING PROPERLY THEY ONLY WORK ON HIGH BEAM. I CAN'T FIND A MORE REASONABLE MECHANIC THAT'S WILLING TO REPAIR THE MOTOR THAT I CURRENTLY HAVE DUE TO THE TYPE WHICH IS A 2.4 AND A USED MOTOR COST ABOUT HALF THE PRICE OF A NEW ONE. PLEASE HELP!
NHTSA complaint #10227398 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
I WAS DRIVING MY CAR ON THE BYWAY AND TOOK THE INTERSTATE MERGE LANE WHILE INCREASING MY SPEED TO MERGE INTO TRAFFIC I FELT A SNAP IN MY STEERING WHEEL AND GAS PEDAL, I THEN LOST THE DASH AND THE CAR IMMEDIATELY OVERHEATED, I HAD NO REAL POWER TO TURN THE WHEEL AND THE GAS PEDAL WAS A LOOSE PUSH. BEING THAT I HAD MERGED ONTO THE INTERSTATE WHEN THIS OCCURRED I HAD TO DRIVE AN ADDITIONAL 5 MILES TO THE NEXT EXIT. NOT EVERYONE HAS A CELL PHONE. WHEN I GOT TO THE NEXT EXIT I WAS ALMOST UNABLE TO TURN THE WHEEL ENOUGH TO GET IT INTO THE NEAREST PARKING LOT, IT WAS HARDER TO TURN THAN MY FIRST TRUCK A 1959 FORD TWIN I BEAM PICKUP. I FORTUNATELY DIDN'T HIT ANY ONE OR ANYTHING. UPON RAISING MY HOOD AFTER PARKING THE CAR I AM APPALLED TO SEE THAT THE TENSIONER PULLEY AND ONE OF THE IDLER PULLEYS ARE GONE AND MY SERPENTINE BELT IS SHREDDED. I HAVE REPLACED THE PARTS BUT SINCE THEN I ALSO FOUND THAT WITHIN 5 MILES THE "DREADED" GASKETS THAT SO MANY PEOPLE HAVE COMPLAINED ABOUT, AND MINE WE ALREADY EATING FLUIDS IN SIPPS BEFORE THIS, WERE GONE. I HAVE REPLACED THE BROKEN PULLEYS SERPENTINE BELT ALTERNATOR WATERPUMP AND GASKETS NOT A MONTH LATER THE OTHER IDLER PULLEY THAT WAS UNAFFECTED IN THE FIRST INCIDENT WENT. WHEN THE FIRST TWO WERE REPLACED THAT DREADED SQUEAKING STOPPED FOR ABOUT 3 DAYS AND STARTED BACK UP AGAIN. SOMETHING MUST NOT BE STRAIGHT FOR ME TO HAVE TO KEEP REPLACING THE MOVING PARTS THAT RUN ON THE SERPENTINE BELT AND EVERYTIME ONE OF THEM GOES YOU LOOSE YOUR POWER STEERING AND THE CAR IS HARD TO TURN. NOT ONLY THAT BUT THE TAIL LIGHTS WOULD BE A BETTER PLACE FOR A GOLD FISH THAN A LIGHT BULB. EVERYTIME IT RAINS, OR SNOWS I HAVE TO REPLACE TAIL LIGHTS. THIS CAR IS THE BANE OF MY EXISTENCE. I HAVE THE FIRST IDLER PULLEY PART STILL THE REST OF THEM WERE LOST TO THE HIGHWAY THE THING IS MELTED.
NHTSA complaint #10223326 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
I WAS DRIVING MY CAR ON THE BYWAY AND TOOK THE INTERSTATE MERGE LANE WHILE INCREASING MY SPEED TO MERGE INTO TRAFFIC I FELT A SNAP IN MY STEERING WHEEL AND GAS PEDAL, I THEN LOST THE DASH AND THE CAR IMMEDIATELY OVERHEATED, I HAD NO REAL POWER TO TURN THE WHEEL AND THE GAS PEDAL WAS A LOOSE PUSH. BEING THAT I HAD MERGED ONTO THE INTERSTATE WHEN THIS OCCURRED I HAD TO DRIVE AN ADDITIONAL 5 MILES TO THE NEXT EXIT. NOT EVERYONE HAS A CELL PHONE. WHEN I GOT TO THE NEXT EXIT I WAS ALMOST UNABLE TO TURN THE WHEEL ENOUGH TO GET IT INTO THE NEAREST PARKING LOT, IT WAS HARDER TO TURN THAN MY FIRST TRUCK A 1959 FORD TWIN I BEAM PICKUP. I FORTUNATELY DIDN'T HIT ANY ONE OR ANYTHING. UPON RAISING MY HOOD AFTER PARKING THE CAR I AM APPALLED TO SEE THAT THE TENSIONER PULLEY AND ONE OF THE IDLER PULLEYS ARE GONE AND MY SERPENTINE BELT IS SHREDDED. I HAVE REPLACED THE PARTS BUT SINCE THEN I ALSO FOUND THAT WITHIN 5 MILES THE "DREADED" GASKETS THAT SO MANY PEOPLE HAVE COMPLAINED ABOUT, AND MINE WE ALREADY EATING FLUIDS IN SIPPS BEFORE THIS, WERE GONE. I HAVE REPLACED THE BROKEN PULLEYS SERPENTINE BELT ALTERNATOR WATERPUMP AND GASKETS NOT A MONTH LATER THE OTHER IDLER PULLEY THAT WAS UNAFFECTED IN THE FIRST INCIDENT WENT. WHEN THE FIRST TWO WERE REPLACED THAT DREADED SQUEAKING STOPPED FOR ABOUT 3 DAYS AND STARTED BACK UP AGAIN. SOMETHING MUST NOT BE STRAIGHT FOR ME TO HAVE TO KEEP REPLACING THE MOVING PARTS THAT RUN ON THE SERPENTINE BELT AND EVERYTIME ONE OF THEM GOES YOU LOOSE YOUR POWER STEERING AND THE CAR IS HARD TO TURN. NOT ONLY THAT BUT THE TAIL LIGHTS WOULD BE A BETTER PLACE FOR A GOLD FISH THAN A LIGHT BULB. EVERYTIME IT RAINS, OR SNOWS I HAVE TO REPLACE TAIL LIGHTS. THIS CAR IS THE BANE OF MY EXISTENCE. I HAVE THE FIRST IDLER PULLEY PART STILL THE REST OF THEM WERE LOST TO THE HIGHWAY THE THING IS MELTED.
NHTSA complaint #10223326 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. WHILE DRIVING 55 MPH THE CONTACT SMELLED ANTIFREEZE AND NOTICED SOME ON THE ENGINE. THE MECHANIC STATED THAT THE MANIFOLD GASKET WAS DEFECTIVE. THE FAILURE WAS REMEDIED AT APPROXIMATELY 50,000 MILES. THIRTY DAYS LATER THE SAME FAILURE OCCURRED. ONCE AGAIN, THE MECHANIC STATED THAT THE MANIFOLD GASKET WAS DEFECTIVE AND PERFORMED THE REPAIRS. THE FAILURE RECURRED. THE MANIFOLD GASKET WAS REPLACED ON TWO MORE OCCASIONS. THE CURRENT MILEAGE IS 80,000 , AND FAILURE MILEAGE WAS 50,000.
NHTSA complaint #10188581 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
DT*: THE CONTACT STATED THERE WAS ANTIFREEZE ON THE GROUND UNDER THE ENGINE. AN INDEPENDENT REPAIR SHOP DETERMINED THE INTAKE GASKET NEEDED TO BE REPLACED.
NHTSA complaint #10151337 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
STEERING WHEEL MADE AN IRRITATING SOUND WHEN TURNED. THE DEALERSHIP WAS NOTIFIED. UPON INSPECTION THEY INDICATED THAT THE STEERING GEAR HAD AN INTERNAL FAULT, AND REPLACED IT. CAUSE OF THE INTERNAL FAULT WAS NOT DISCLOSED TO THE CONSUMER. *AK RECALL CAMPAIGN# 03V527000. THE STEERING WAS REPAIRED. A YEAR LATER THE ENTIRE STEERING ASSEMBLY HAD TO BE REPLACED AGAIN. THE CHECK EMISSIONS LIGHT WOULD COME ON INTERMITTENTLY. THERE WERE NOISES WHEN THE VEHICLE WAS TURNED LEFT DUE TO THE STEERING GEARS INTERNAL FAULT AND THE GEAR WAS REPLACED, THE LEFT FRONT TIRE HAD A STEEL BELT SHOWING ON THE INSIDE. *SC
NHTSA complaint #10117415 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
SUDDENLY BRAKES STOPPED WORKING, AND CONSUMER'S VEHICLE WAS INVOLVED IN FOUR COLLISIONS. . IN THE MOST RECENT COLLISION CONSUMER'S VEHICLE STRUCK THE REAR END OF A TRUCK AT 30 MPH. ALSO, VEHICLE STALLED AND CUTS OFF IN TRAFFIC.
NHTSA complaint #10106676 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:COOLING SYSTEM
COMPLAINT #1 A/C CUTS ON AND OFF. COMPLAINT #2 SUSPENSION KNOCKING, SERVICED 4 TIMES, STILL HAVE SAME PROBLEMS.
NHTSA complaint #10091025 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
VEHICLE STALLED WHILE DRIVING. WHEN THIS OCCURRED THE VEHICLE WAS TOWED TO THE DEALER, WHO PERFORMED A DIAGNOSTIC TEST IN WHICH NO FAILURE CODE WAS FOUND. DEALER WAS UNABLE TO FIND THE CAUSE OF THE PROBLEM.
NHTSA complaint #10083606 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
WHILE DRIVING AT ANY SPEED INTERMITTENTLY VEHICLE STALLED. DRIVER CONSUMER HAD MANAGED TO GET VEHICLE OUT OF TRAFFIC. HAD TRIED TO RESTART VEHICLE, AND SOME TIMES HAD TO WAIT AN HOUR TO RESTART VEHICLE. HOWEVER, VEHICLE WAS INSPECTED BY TWO SEPARATE DEALERSHIPS, BUT COULD NOT DUPLICATE OR CORRECT THE PROBLEM.
NHTSA complaint #10081962 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:COOLING SYSTEM
I BOUGHT A 1997-MALIBU LS BRAND NEW. BEFORE IT TURNED 14,000 MILES HAD TO HAVE WORK DONE ON BRAKES. BEFORE EVEN TURNING 30,000 MILES I HAD TO REPLACE A COMPLETE BRAKE JOB, (2ND SET) TIRES, WATER PUMP, WHEEL CYLINDERS, MY HEAD LIGHTS POP ON, AND I HAVE A LITTLE OVER 33,000 MILES.THE DEALER WERE I BOUGHT THE CAR SAID UNLESS THEY SEE THE LIGHTS POP ON.THEY COULD DO NOTHING. GM SENT OUT A RECALL. WHICH I DID TAKE MY CAR INTO DEALER. I TOOK IT TO THE DEALER I BOUGHT IT FROM A FEW TIMES.I MOVED BACK TO INDIANA AND TOOK IT TO COYLE CHEVROLET IN NEW ALBANY. I HAVE HAD NOTHING BUT PROBLEMS WITH THIS CAR.BOTH DEALERS SAID THERE WAS NOTHING I COULD DO AS A CONSUMER..I AM MAD AS HELL-AND FEEL I WAS RIPPED OFF, AND WILL NOT RECOMMEND TO NO ONE TO EVER BUY A MALIBU. I HAD ONE IN 1969. AND, IT WAS THE BEST CAR. WHEN YOU PAY AROUND $25,000.00 FOR A NEW CAR-YOU WOULD THINK YOU WOULD NOT HAVE ALL THE BRAKE TROUBLE. I TO THIS DAY DO NOT FEEL SAFE WITH THESE BRAKES. I AM A SINGLE WOMEN AND THOUGHT BY BUYING A NEW CAR I WOULD FEEL SAFER. PLEASE CHECK INTO THIS. AS SOON AS I CAN AFFORD TO GET RID OF THIS CAR I PLAN TOO. I HAVE SPENT SEVERAL HUNDRED DOLLARS ON OUT OF POCKET REPAIRS. BATTERY-2 BRAKE JOBS-ABS BRAKES-WHEEL CYLINDERS-ROARIES-WATER PUMP.
NHTSA complaint #10080895 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
ENGINE CHECK LIGHT AND THE ABS LIGHT ILLUMINATED WHILE DRIVING. VEHICLE BEEN TO A REPAIR SHOP ON 3 SEPARATE OCCASIONS, AND THE PROBLEM HAD NOT BEEN RESOLVED. VEHICLE HAD ITS GAS TANK CAP REPLACED, AND THE BRAKE SYSTEM WAS OVERHAULED. BUT PROBLEM RECURRED.
NHTSA complaint #10081649 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
I HAVE HAD TO REPLACE THE INTAKE MANIFOLD GASKET TWICE ON THE CAR ALREADY. THE LAST REPAIR WAS IN MARCH OF 2004. IT IS ONLY THREE MONTHS FROM THE LAST REPLACEMENT, AND IT IS LEAKING ANTI FREEZE AGAIN. I WOULD REPAIR THE CAR, BUT APPARENTLY IT IS NOT GOING TO DO ANY GOOD. EACH REPAIR WAS OVER FOUR HUNDRED DOLLARS. THERE HAS GOT TO BE SOME KIND OF MAJOR DEFECT WITH THIS PART. I HAVE ONLY OWNED THE CAR FOR FOUR YEARS AND IT ONLY HAS 81,000 MILES ON IT, AND YET THIS IS THE THIRD TIME THE GASKET HAS FAILED.
NHTSA complaint #10080546 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
MY FIRST ISSUE IS WITH THE LIGHTS ON THE MALIBU. MY LIGHT DEVELOPED CONDENSATION IN THEM WHICH IN THE REAR CAUSED THE LIGHT TO GLOW DIM, AND CAUSED E TO GET PULLED OVER ON A NUMBER OF TIMES. IN THE FRONT IT HAS CAUSED THE GLASS SHIELD TO FOG CAUSING ME TO FAIL VEHICLE INSPECTION. THERE HAVE ARE MANY OTHER ELECTRICAL MALFUNCTIONS ON MY CAR SUCH AS THE THEFT LOCK SYSTEM, THE POWER MOON ROOF, THE MANUFACTURER'S CD PLAYER, THE HEADLIGHT CONTROL SWITCH. THEN IT HAS A PROBLEM WITH EMISSIONS. THE HEADLINER IS FALLING OFF THE CEILING.
NHTSA complaint #10073144 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
BASICALLY THIS IS TO COMPLAIN ABOUT THE GM 3.1L V6 ENGINE IN MY 1997 CHEVROLET MALIBU. I UNDERSTAND THAT THERE ARE 1100 SUCH COMPLAINTS AND WOULD APPRECIATE SOME HELP WITH MY SITUATION ALSO. IN THE LAST COUPLE OF WEEKS MY VEHICLE HAS BEGUN TO HAVE A MULTITUDE OF PROBLEMS THAT HAD LED UP TO MY CURRENT FIASCO. ABOUT 2 WEEKS AGO AFTER AN OIL CHANGE MY 97 MALIBU BEGAN TO HAVE PROBLEMS WITH A LIFTER TICKING. MY MECHANIC SUSPECTS A COLLAPSED LIFTER; THIS HAS NOT BEEN REPAIRED YET. MY CAR ALSO NOW RUNS VERY ROUGH AND DOES NOT HAVE THE POWER IT USED TO HAVE. TODAY 10/2/03 I HAD TO DRIVE INTO SEATTLE AND BEGAN TO HAVE A SEVERE HEATING PROBLEM WITH THE CAR. MY WIFE AND I WERE DEATHLY AFRAID WE WERE GOING TO BE STRANDED ON THE FREEWAY SOMEWHERE OR STUCK IN A PART OF SEATTLE WE DID NOT FEEL VERY SAFE IN. THE TEMP GAUGE BEGAN TO RISE VERY QUICKLY AS WE ARRIVED AT OUR DESTINATION JUST SOUTH OF SEATTLE, THE NEEDLE WAS PEGGED AND THE TEMP LIGHT ACTUALLY CAME ON. I HAD DEX-COOL ANTI-FREEZE LEAKING ALL OVER THE ENGINE AND ALL OVER THE GROUND. WE WAITING APPROX 30 MINUTES BEFORE WE STARTED OUT AGAIN AND YES WERE AFRAID THE ENTIRE WAY HOME THAT WE WOULD GET STRANDED ON THE ROAD SOMEWHERE. I GOT THE CAR TO MY MECHANIC AND HE HAS INFORMED US THAT WE PROBABLY NEED A NEW ENGINE, ON A CAR THAT ONLY HAS 95,000 MILES ON IT. I HAVE READ OTHER COMPLAINTS ON THE INTERNET ABOUT THE FAULTY GASKETS WHICH RESULT IN ANTI-FREEZE LEAKING INTO THE ENGINE CAUSING BAD CAMSHAFTS, BAD BEARINGS AND WHO KNOWS WHAT ELSE. IF I HAD THE RESOURCES TO DUMP THE PIECE OF JUNK I JUST MIGHT, HOWEVER I DO NOT HAVE THE RECOURSES TO DO THAT, I MUST GET IT FIXED. RIGHT NOW A $4000.00 DOLLAR REPAIR WILL NOT BE GOOD FOR MY FAMILY. FRANKLY I AM TIRED OF BEING SOLD JUNK, 20000.00 DOLLARS MIGHT NOT BE MUCH TOO SOME PEOPLE BUT IT IS TO ME. MY CAR NOW IS BARELY WORTH $4000.00 AND THE THOUGHT OF PUTTING $4000.00 INTO IT JUST TO GET IT RUNNING AGAIN MAKES ME SICK. I WILL THINK TWICE THE NEXT TIME ABOUT PURCHASING A GM PRODUCT.
NHTSA complaint #10070992 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
INTAKE MANIFOLD GASKET LEAKS ON MY 1997 CHEVROLET MALIBU. THE LOCAL CHEVROLET DEALER VERIFIED THIS PROBLEM WITH MY CAR AND RECOMMENDED GASKET REPLACEMENT AT A COST OF $585. MILEAGE IS ONLY 46,000. I MUST CONTINUE TO ADD COOLANT AT REGULAR INTERVALS OTHERWISE ENGINE WILL OVERHEAT.
NHTSA complaint #10062633 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
MY CAR HAS ALWAYS USED AN EXCESSIVE AMOUNT OF ANTI-FREEZE. APPARENTLY, MY CHEVY MALIBU IS NOT THE ONLY, AND FROM THE MECHANIC I TALKED TO TODAY, HE SAYS THAT IT IS THE ENGINE. I NOW HAVE TO GET A NEW MANIFOLD, WHICH TO ME COSTS A LOT OF MONEY. IT SEEMS TO ME THAT IF THE SAME CARS ALL OVER ARE HAVING THE SAME PROBLEM IT WOULD BE SOME SORT OF MANUFACTER DEFECT AND THE CONSUMERS SHOULD NOT BE RESPONSIBLE.
NHTSA complaint #10052310 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:COOLING SYSTEM
BRAKES GONE (AGAIN). BEEN REPLACING ABOUT EVERY 10000 MILES. THIS CAR HAS BEEN ONE THING WRONG AFTER ANOTHER. ALREADY REPLACED LOWER CONTROL ARMS AT 7500 MILES, LEAKING ANTIFREEZE GASKET, A/C CONTROL HEAD (TWICE), AND THE BRAKES ARE ONGOING.
NHTSA complaint #10050934 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
INTAKE MANIFOLD GASKET, 1997 CHEVROLET MALIBU (3.1 V6 ENGINE). MY UNDERSTANDING IS THAT THIS IS AN EXTREMELY COMMON PROBLEM WITH GM PRODUCTS, PARTICULARLY THIS ENGINE AND CAR. I ALSO SEARCHED THE COMPLAINTS DADABASE AND I FOUND THAT IT APPEARS TO BE A COMMON PROBLEM. ALSO, THEFT SYSTEM LIGHT COMING AND EXCESSIVE BRAKE PAD WEAR AND ROTOR WARPING APPEARS TO BE A VERY COMMON PROBLEM. THIS WAS FIXED ONCE, THE PROBLEM IS REACCURING. $1200 IN MAJOR REPAIRS SO FAR ON A 1997 CHEVROLET MALIBU, NOT TO MENTION THE OTHER SMALL BUT FREQUENT REPAIRS. I AM DISSATISFIED WITH BOTH OF MY RECENT GM PRODUCTS BECAUSE THEY BOTH HAD SIMILAR PROBLEMS THAT LEAD TO COSTY REPAIRS OR ENGINE FAILURE AT 120,000 MILES ON A 1994 GRAND AM AND 89,000 MILES ON A 1997 MALIBU. I HAVE HAD TO FIX THE RADIO NUMEROUS TIMES (CABLE COMES UNPLUGGED QUITE OFTEN).
NHTSA complaint #10050776 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
EXCESSIVE BRAKE PAD USEAGE WITH THIS CAR. THE INTAKE MANIFOLD HAD TO BE REPLACED AT 88,000 MILES. I AM VERY VERY DISSATISFIED WITH THIS CAR AND DO NOT PLAN ON PURCHASING ANOTHER GM AT THIS TIME.
NHTSA complaint #10050673 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE
WHILE DRIVING AT ANY SPEED AND WITHOUT ANY WARNING VEHICLE STALLED.
NHTSA complaint #10046240 — an unverified report by a vehicle owner.