2006 Chevrolet Silverado 1500 fuel system problems
18 of the
462 complaints about the 2006 Chevrolet Silverado 1500 are about the
fuel system — 4% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
65,000 miles.
B
18
Complaints
0
Crashes
2
Fires
0
Injuries
Exactly what failed
Fuel/Propulsion System
1055.6%
Fuel System, Gasoline
633.3%
Delivery
15.6%
Hoses, Lines/Piping, AND Fittings
15.6%
Fuel & Propulsion across every Chevrolet Silverado 1500 year
The auxiliary transmission fuel pump system is prone to failure. This makes it so the start/stop feature will not work, as the vehicle will stall when stopped (causing an unsafe situation), and it cannot pass state inspection. The part is entirely unavailable from Chevy, and results in the vehicle being scrapped. There is no way to permanently bypass this system.
NHTSA complaint #11632021 — an unverified report by a vehicle owner.
at 187,000 milesCentertown, MO
FUEL SYSTEM, GASOLINE
The contact owns a 2006 Chevrolet Silverado 1500. The contact stated that upon a vehicle inspection performed by an independent mechanic, it was discovered that the brake line and the fuel line were severely corroded. Upon further inspection, the contact stated that the brake lines had blown out. The contact was informed that the vehicle was unsafe to drive and that the lines needed to be replaced. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was repaired. The failure mileage was approximately 187,000.
NHTSA complaint #11581206 — an unverified report by a vehicle owner.
at 125,603 milesWellsville, NY
FUEL/PROPULSION SYSTEM
DUE TO FAULTY UNDERCOATING FROM FACTORY THE BACK CROSSMEMBERS ROT AND CAUSE SHOCKS TO BECOME DISPLACED AND GAS TANK TO UNSECURED ALONG WITH REAR SHAKELS TO GO THREW THE BOTTOM OF TRUCK BED.... WILL COST OVER $2500 FOR REPAIRS
NHTSA complaint #11355237 — an unverified report by a vehicle owner.
Harrisville, PA
FUEL/PROPULSION SYSTEM
THERE'S COMMON PROBLEM WITH GAS LINES AND FRAMES RUSTING OUT THE 2006 CHEVY PICKUP TRUCKS THAT IS A SAFETY PROBLEM. THE PRICE FOR THE GAS LINES ARE WAY OVER PRICED AT $318.
NHTSA complaint #11351765 — an unverified report by a vehicle owner.
at 199,674 milesOklahoma City, OK
FUEL/PROPULSION SYSTEM
TAKATA RECALL THE ENGINE IS NOT GETTING ENOUGH FUEL OIL PRESSURE GAUGE IS AT 80 TRANSMISSION IS SKIPPING ELECTRIC PROBLEMS SUSPENSION FAIL
NHTSA complaint #11175920 — an unverified report by a vehicle owner.
at 39,000 milesDerby, CT
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE THE VEHICLE WAS UNDERGOING AN INSPECTION, THE TECHNICIAN DIAGNOSED THAT THE FUEL LINES WERE SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE FUEL LINES WERE CONSIDERED A MAINTENANCE ITEM. THE FAILURE MILEAGE WAS APPROXIMATELY 39,000.
NHTSA complaint #10871512 — an unverified report by a vehicle owner.
at 74,340 milesStonington, CT
FUEL/PROPULSION SYSTEM
BRAKE PEDAL WENT TO FLOOR ON RURAL ROAD. ABLE TO STOP BY DOWNSHIFTING AND RUNNING OFF ROAD. BRAKE LINES HAD ROTTED OUT. DURING THIS REPAIR IT WAS FOUND THAT GAS LINE HAD ALSO ROTTED AND WAS LEAKING. TOTAL COST OF REPAIRS, NEARLY $2,000.00
NHTSA complaint #10838542 — an unverified report by a vehicle owner.
at 52,000 milesMaple Heights, OH
FUEL/PROPULSION SYSTEM
WAS DRIVING DOWN THE ROAD, AND STOPPED AT A TRAFFIC LIGHT. LEFT FROM THE TRAFFIC LIGHT ,AND THE ENGINE JUST STALLED, LIKE IT WAS OUT OF GAS. THE GAS GAUGE SHOWED THAT I HAD A 1\4 TANK OF GAS. SO I HAD IT TOWED HOME ANYWAY. THE NEXT DAY I WENT OUT TO START IT WITH NO LUCK. THEN I PUT 2 GALLONS OF GAS IN THE TANK, AND THE TRUCK STARTED RIGHT UP. NOW I KNOW THAT THE GAUGE IS 1\4 OF A TANK OFF. SOME AUTO TECHS HAVE TOLD ME THAT WHAT THEY CALL A FUEL CARD THAT IS LOCATED ON THE FUEL PUMP ASSEMBLY IS BAD. JUST WONDERING IF THIS IS TRUE, BECAUSE IT IS A LOT CHEAPER THAN A FUEL PUMP ASSEMBLY. THANK YOU.
NHTSA complaint #10631267 — an unverified report by a vehicle owner.
at 68,000 milesForkston Township, PA
FUEL/PROPULSION SYSTEM
WHILE LOOKING OVER MY TRUCK PRIOR TO INSPECTION I DISCOVERED THREE CROSS MEMBERS TOTALLY RUSTED THRU. THE ARE ALSO THE MAIN SUPPORTS FOR THE GAS TANK AND THE SHOCKS. I HAVE BEEN TRYING TO FIND REPLACEMENT PARTS AND THE MORE I LOOK THE MORE I HEAR HOW COMMON THE RUSTED CROSS MEMBERS ARE. I WENT TO THE LOCAL DEALERS PARTS DEPT. AND WHEN I ASKED FOR CROSS MEMBERS HE TOLD ME WHICH ONES I NEEDED AND POINTED THEM OUT ON AN ILLUSTRATED BRAKE DOWN. AFTER THE TRUCK BED WAS REMOVED I NOTICED THE EMERGENCY BRAKE CABLE IS RUBBING AGAINST THE PLASTIC GAS TANK AND IS JUST ABOUT WORE THRU THE TANK TO ABOUT THE THICKNESS OF A PLASTIC SANDWICH BAG. THE CABLE HAS ALSO RUBBED AGAINST IT'S SUPPORT BRACKET ALMOST ALL THE WAY THRU AS WELL AS INTO THE CABLE.
NHTSA complaint #10619093 — an unverified report by a vehicle owner.
Foresthill, CA
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER, WHO CLEARED THE CODE FROM THE COMPUTER BUT THE FAILURE RECURRED. ADDITIONALLY, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SOLENOID EVAPORATION EM HAD BEEN MODIFIED AND THAT THE SOLENOID EVAPORATION EM, THE CANISTER EVAPORATION EMI, THE SOLENOID, THE GAS CAP, THE CANISTER PURGE, THE FUEL TANK PRESSURE SENSOR, AND THE TUBING NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MIELAGE WAS NOT AVAILABLE.
NHTSA complaint #10588992 — an unverified report by a vehicle owner.
at 63,000 milesMilford, MI
FUEL/PROPULSION SYSTEM
THE RANGE INDICATOR STATED 54 MILES, YET RAN OUT OF FUEL. GAUGE READ 1/4 TANK. THE NEXT TIME RANGE WAS 89 MILES AND RAN OUT.
NHTSA complaint #10466911 — an unverified report by a vehicle owner.
at 67,000 milesGreenwood Lake, NY
FUEL/PROPULSION SYSTEM
DANGER/ WILL MY BRAKES WORK,TRUCK GO INTO FLAMES OR WILL THE FRAME BREAK IN HALF. RUST! MY 2006 CHEVY SILVERADO P/U IS SHOWROOM ON TOP AND 50 YEARS OLD ON THE BOTTOM. I AM AN AUTO TECH WITH 39 YEARS IN THE INDUSTRY AND HAVE NOT SEEN A FRAME AND WHAT'S ATTACHED TO IT RUST LIKE THIS. IM INTO BRAKE LINES, HOSES AND LABOR @ $1,000. ROTTEN FUEL LINES AND SENDER AND OH YES THE FUEL TANK STRAPS ROT AND TANK COULD FALL AND BREAK LINES ,WIRING $800-$1000. THEN TAKE TO BODY SHOP TO PAINT&SEAL FRAME $ UNKNOWN. IS THIS MY LAST GM?
NHTSA complaint #10463551 — an unverified report by a vehicle owner.
at 48,000 milesPleaseant Valley, NY
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED WHEN THE BRAKES WERE DEPRESSED, AFTER STARTING THE VEHICLE, THE BRAKE PEDAL EXTENDED TO THE FLOOR. THE DEALER DIAGNOSED THAT THE BRAKE LINE AND FUEL LINES WERE COVERED WITH RUST. THE ENTIRE FRAME WAS RUSTED AS WELL. THE MANUFACTURER WAS NOT CONTACTED REGARDING THE FAILURE. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 48,000. RVK
NHTSA complaint #10427895 — an unverified report by a vehicle owner.
at 80,000 milesEast Winthrop, ME
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHEN REFUELING THE VEHICLE, GASOLINE BEGAN SPEWING FROM THE FUEL FILLER NECK WHILE REFUELING. THE ONLY WAY THE CONTACT WAS ABLE TO REFUEL THE VEHICLE WAS TO SLOWLY PUMP THE FUEL FOR THREE SECONDS BEFORE ALLOWING THE FUEL TO DRAIN INTO THE TANK FOR APPROXIMATELY 10 SECONDS WITHOUT PUMPING. THE FAILURE RECURRED WHENEVER THE CONTACT ATTEMPTED TO REFUEL THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THEY WOULD HAVE TO REPOSITION PARTS OF THE FUEL SYSTEM TO REMEDY THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 110,000. UPDATED 03/29/11 *BF THE CONSUMER STATED WHILE LETTING THE FUEL DRAIN INTO THE TANK IT BLEW BACK AS IF IT WERE PRESSURIZED. UPDATED 06/12/11 UPDATED 12/28/2011
NHTSA complaint #10381573 — an unverified report by a vehicle owner.
at 24,147 milesOntario, NY
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
TL*THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE GAS LINE RUSTED AND CLOGGED ALL OF THE INJECTORS WITH RUST. THE DEALER REPLACED THE GAS LINE AND CLEANED THE INJECTORS. THE CURRENT AND FAILURE MILEAGES WERE 24,147. UPDATED 10/14/08 *BF UPDATED 10/24/08.
NHTSA complaint #10241431 — an unverified report by a vehicle owner.
at 15,000 milesMills, WYFire
FUEL SYSTEM, GASOLINE:DELIVERY
I'M FIRE INVESTIGATOR REPORTING THIS INCIDENT. UNEXPLAINED FIRE FROM UNDERNEATH TRUCK NEAR GAS TANK AREA. VEHICLE HAD BEEN IDLED 1/2 HOUR AND DRIVEN AT HIGHWAY SPEEDS BEFORE AND AFTER THE IDLING PERIOD UNTIL FIRE DISCOVERED BY DRIVER. TRUCK HAD 15KMILES, REGULAR SERVICING, NO MECHANICAL PROBLEMS UNTIL FIRE.
NHTSA complaint #10203185 — an unverified report by a vehicle owner.
Mena, TX
FUEL SYSTEM, GASOLINE
TL*- THE CONTACT STATED THE VEHICLE WAS IDLING LOW. THE VEHICLE HAS BEEN TAKEN TO A REPAIR SHOP TO BE ADJUSTED ONCE. SINCE THE ADJUSTMENT THE GAS MILEAGE HAS GOTTEN WORST. HE SAID THE VEHICLE IS RUNNING AT ABOUT 1000 RPM TO WARM UP.
NHTSA complaint #10176375 — an unverified report by a vehicle owner.
at 3,800 milesSAN Francisco, CAFire
FUEL SYSTEM, GASOLINE
I PURCHASED A BRAND NEW 2005 CHEVROLET SILVERADO 1500 IN MAY, 2006. I HAD NO TROUBLE WITH THE VEHICLE.. UNTIL OCTOBER 27. I HAD 3800 MILES ON THE TRUCK. I HAD FILLED MY GAS TANK JUST OUT OF SAN FRANCISCO AND DROVE APPROXIMATELY 60 MILES JUST OUT SIDE OF CALISTOGA, CALIFORNIA NORTHBOUND ON HWY 29. A WINDING, UPHILL MOUNTAINOUS ROAD, SINGLE LANE TRAFFIC EXCEPT FOR A FEW PASSING LANES AND TURN-OUTS. I WAS DRIVING UP AN INCLINE. I NOTICED SMOKE WISPING BEHIND THE CAB. ALMOST IMMEDIATELY, THE TRUCK DIED... RED INDICATORS ON. FORTUNATELY, IT DIED RIGHT AT A WIDE PASSING LANE LOCATION, AND I VEERED TO THE RIGHT, BLOCKING ONE OF TWO NORTHBOUND LANES. I GOT OUT OF THE TRUCK AND SAW SERIOUS SMOKE AND SOME FLAME COMING FROM UNDER THE BED OF THE TRUCK, UP BETWEEN THE CAB AND THE FRONT OF THE BED. A VEHICLE BEHIND ME, EVIDENTLY SAW IT ALREADY AND PULLED OVER TO ASSIST. ANOTHER VEHICLE, DRIVING SOUTHBOUND PULLED OVER, HAD AN EXTINGUISHER WHICH I SHOT UNDERNEATH THE BED, BUT IT DID NOT HELP. AT THAT POINT, I WAS CONCERNED THAT THE VEHICLE WOULD BLOW UP . THERE WAS AN EXTREME FIRE DANGER IN THE AREA AND THERE WAS A STRONG POSSIBILITY THAT THIS COULD ALSO TURN INTO A FOREST FIRE. THERE WAS NO STOPPING THE FIRE . THE TRUCK WAS ENGULFED IN FLAMES. THE CALISTOGA FIRE DEPARTMENT WAS ENROUTE. THE FIRE DEPARTMENT ARRIVED AND DOUSED THE TRUCK FIRE AND A BRUSH FIRE. CALIFORNIA HIGHWAY PATROL SHOWED UP. SECURED THE AREA FOR THE FIRE DEPARTMENT TO NEUTRALIZE ANY RESIDUAL FIRES AND THE ARRIVAL OF THE TOW TRUCK. THE TRUCK WAS TOTALLY BURNED. A FULL BLOWN RAGING TRUCK FIRE, ON A SINGLE LANE HIGHWAY IN EXTREMELY DRY CONDITIONS, IN THE MIDDLE OF AN AREA WITH BLIND TURNS IN BOTH DIRECTIONS. ABSOLUTELY AMAZING.
NHTSA complaint #10173307 — an unverified report by a vehicle owner.