2005 Chevrolet Silverado 2500 engine problems

ENGINE

ENGINE POWERING DOWN....FOREST TO RE-START ENGINE

NHTSA complaint #10969745 — an unverified report by a vehicle owner.

ENGINE

THE ENGINE STARTED MAKING A STRANGE TICKING NOISE. THE DEALER REPAIRED/REPLACED THE PASSENGER SIDE EXHAUST MANIFOLD/BOLTS UNDER WARRANTY. THE DRIVER SIDE BROKE SEVERAL MONTHS LATER OUT OF WARRANTY. DEALER REPAIRED. BOTH SIDES BROKE AGAIN. YOU CAN SMELL EXHAUST GAS IN THE VEHICLE WHEN SITTING IN TRAFFIC.

NHTSA complaint #10617044 — an unverified report by a vehicle owner.

ENGINE

RIGHT SIDE EXHAUST MANIFOLDS BOLTS RUSTED OFF CAUSING EXHAUST GASES TO ESCAPE AND CAUSING CHECK ENGINE LIGHT TO COME ON.CANNOT GET THE VEHICLE STATE INSPECTED WITH THE CHECK ENGINE LIGHT ON. MECHANIC SAYS IT NEEDS TO BE REPAIRED TO GET VEHICLE INSPECTED.THE OTHERS LOOK LIKE THEY MAY BE FAILING ALSO. THIS IS A BIG OUT OF POCKET EXPENSE SINCE IT IS NO LONGER UNDER WARRANTY.

NHTSA complaint #10574415 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

STOPPED DO TO HEAVY TRAFFIC AND STARTED SMELLING EXHAUST IN CAB. PULLED OFF ON NEXT EXIST OPENED HOOD AND DRIVERS SIDE OF ENGINE WAS SMOKING. COUGHING AND LUNG DISCOMFORT. FOUND SOME SHADE TO LET TRUCK COOL. NOTICED BLACK COLOR ON REAR OF EXHAUST MANIFOLD, LOOKED CLOSER AND MISSING BOLT IN SAME AREA OF MANIFOLD. LOOKING ONLINE LOTS OF COMPLAINTS OF SAME PROBLEM BUT NO RECALLS. SHOULD BE EMISSIONS RECALL AND SAFETY RECALL IN MY CASE.

NHTSA complaint #10472456 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

THIS TRUCK IS EQUIPPED WITH THE 6.0L VORTEC V8 ENGINE AND HAS DEVELOPED AN EXHAUST LEAK ON BOTH SIDES OF THE ENGINE AT THE MANIFOLD GASKETS! THE LEAK IS FROM THE PORTS WHERE THE BOLTS SECURING MANIFOLD TO CYLINDER HEAD ARE BROKEN! GM IS WELL AWARE OF THIS ISSUE, DOES NOT WANT TO RECALL THE ISSUE OR WARRANTY THE REPAIRS. THERE ARE THOUSANDS OF COMPLAINTS FROM OWNERS OF GM VEHICLES WITH V8 ENGINES INCLUDING THE 4.8L, 5.3L, 6.0L ENGINES. THIS IS A PROBLEM IN MANY OF WAYS, MOST IMPORTANTLY THAT TOXIC EXHAUST FUMES ARE EMITTING FROM UNDER THE HOOD AND CAN ENTER THE CAB OF THE VEHICLES! INSPECTION LAWS REQUIRE THAT EXHAUST FUMES EXIT THE VEHICLE BEHIND THE REAR WHEEL! THE OTHER PROBLEMS INCLUDE THE FACT THAT THIS LEAK WILL AFFECT READINGS TAKEN FROM THE UPSTREAM OXYGEN SENSORS AND CAN THEREFORE CAUSE CHECK ENGINE LIGHTS FOR CATALYTIC CONVERTER DEFICIENCIES TO SYSTEM LEAN CONDITIONS. ALSO HAVING AN EXHAUST LEAK WILL FAIL SAFETY INSPECTIONS AND EMISSIONS TESTING. GM IS VIOLATING EPA LAWS BY ALLOWING THIS TO GO ON! THIS PARTICULAR VEHICLE IS PAST DUE FOR INSPECTION AND EMISSIONS AS WE ARE A PENNSYLVANIA RESIDENT AND I CANNOT AFFORD TO HAVE THIS FIXED AT A DEALER!

NHTSA complaint #10452873 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT EXHAUST FUMES WERE EMITTED FROM THE VEHICLE IN AN UNUSUAL FASHION AND ENTERED INTO THE CABIN OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE ENGINE MANIFOLD WAS WARPED BECAUSE THE BOLTS WERE CORRODED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED APPROXIMATELY TWO YEARS LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND WAS REPAIRED A SECOND TIME FOR THE SAME FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 87,000. UPDATED 02/14/12*LJ THE CONSUMER STATED HE CORRECTED THE PROBLEM BY USING STAGE 8 BOLTS AND HEADERS. UPDATED 03/16/12

NHTSA complaint #10441596 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT EXHAUST FUMES WERE EMITTED FROM THE VEHICLE IN AN UNUSUAL FASHION AND ENTERED INTO THE CABIN OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE ENGINE MANIFOLD WAS WARPED BECAUSE THE BOLTS WERE CORRODED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED APPROXIMATELY TWO YEARS LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND WAS REPAIRED A SECOND TIME FOR THE SAME FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 87,000. UPDATED 02/14/12*LJ THE CONSUMER STATED HE CORRECTED THE PROBLEM BY USING STAGE 8 BOLTS AND HEADERS. UPDATED 03/16/12

NHTSA complaint #10441596 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

THE BOLTS THAT HOLD THE EXHAUST MANIFOLDS TO THE CYLINDER HEADS ARE BRAKING OFF FOR NO REASON CAUSING AN EXHAUST LEAK.

NHTSA complaint #10440967 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

MY 2005 CHEVROLET SILVERADO 2500HD HAD BROKEN EXHAUST MANIFOLD BOLTS. REPAIRED AT 87,000 MILES. WENT TO DEALERSHIP TODAY BECAUSE OF EXHAUST LEAK AND WAS TOLD THERE ARE MORE BROKEN BOLTS AT 136,000. OBVIOUSLY THERE IS A DEFECT. UNSAFE/RAW EXHAUST LEAKING INTO AIR AND CAB.

NHTSA complaint #10432942 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXHAUST MANIFOLD BOLT HEAD BROKE OFF. 1ST BOLT INITIALLY THEN SECOND BOLT NEXT TO IT BROKE AS WELL. NO WORK HAS BEEN DONE TO MOTOR OR AFTERMARKET PARTS ADDED THAT WOULD AFFECT THIS PART AND CREATE FAILURE. EXHAUST GAS ENTERS THE UNDERHOOD AREA SOMETIME CAN BE SMELLED INSIDE CAB. THE EXHAUST MAKES A BLACK PLUME UP SIDE OF MOTOR.

NHTSA complaint #10355058 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

I HAVE A 2005 CHEVROLET SILVERADO WITH A 6.0 LITER ENGINE. THE LEFT SIDE AND RIGHT SIDE EXHAUST MANIFOLD ARE MISSING 2 BOLTS EACH. I ONLY HAVE 50,000 MILES ON THIS VEHICLE. THE COST IS UNBELIEVABLE. THIS IS CERTAINLY A MATTER THAT GM SHOULD TAKE CARE OF.

NHTSA complaint #10347086 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXHAUST MANIFOLD GASKET LEAKING DUE TO EXHAUST MANIFOLD BOLTS BREAKING/RUSTING OFF ON MORE THAN ONE TRUCK, A 2001 CHEVY 3/4 TON WITH 6.0 AND A 2005 MODEL WITH A 6.0.

NHTSA complaint #10330655 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

I TOOK MY 2005 CHEVROLET SILVERADO PICK UP IN FOR A EXHAUST LEAK. THE MANIFOLD BOLTS ROTTED AWAY. 3 BOLTS HOLDING RIGHT AND LEFT EXHAUST MANIFOLDS IN PLACE. VARY VERY UNSAFE, ONE GOOD BUMP IN THE ROAD AND IT WOULD DROP. VEHICLES WITH LESS THAN 30,000 MILES HAVE THE SAME PROBLEM. GM KNOWS ABOUT THE PROBLEM AND SHOULD HAVE CONTACTED IT'S CUSTOMERS. VARY DANGEROUS. FIRE, ACCIDENT OR EXHAUST FUMES. NOT GOOD AT ALL!!

NHTSA complaint #10312240 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

2005 CHEVY SILVERADO 2500 DIESEL TRUCK ON FREEWAY ON 01/25/2010 AND THE TRUCK IMMEDIATELY LOST POWER WHILE PULLING A TRAILER. VERY DANGEROUS. CONSUMER NEVER MADE AWARE OF TECH BULLETIN OR PROBLEM. TSB #05-06-04-047B INJECTION HARASS. NHTSA #10017389. THE TRUCK HAS BEEN TAKEN TO DEALER FOR OTHER RECALL NOTICES AND DEALERS NEVER ADDRESSED THE PROBLEM AND SHOULD HAVE BEFORE WE WERE STUCK OUT IN THE MIDDLE OF THE DESERT AND HAD TO GET THE VEHICLE AND 5TH WHEEL TRAILER TOWED. THE CONSUMERS SHOULD BE NOTIFIED OF THIS PROBLEM AND CHEVY DEALERS SHOULD FIX PROBLEM WITH THE INJECTION HARNESS BECAUSE WHEN A VEHICLE LOSES POWER ON THE FREEWAY IT IS DANGEROUS.

NHTSA complaint #10310195 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

I PURCHASED A "NEW" 2005 CHEVY SILVERADO 2500 UTILITY BED WORK TRUCK...THE DEALERSHIP RIPPED ME OFF WITH THE TRADE IN;REFUSED TO APPLY THE CASH BACK AND DOWN PAYMENT ASSISTANCE GM WAS OFFERING-AND WHEN I GOT THE TRUCK HOME,SAW THE INSIDE OF TOOLBOXES WERE RUSTED...THE HEATER BLEW,THE AIRCONDITIONING QUIT WORKING,STEREO/CD PLAYER QUIT,AS WELL...THE DEALER REFUSED TO FIX THE RUST;DESTROYED THE PICS AND SERVICE REPORT REGARDING THE TRUST. THE OIL CAP BLOWS OFF...IT'S BEEN REPLACED SEVERAL TIMES- AND IN JAN 2009,TRUCK KEPT OVERHEATING & BRAKE LIGHTS WENT OUT...DEALER COULD NOT FIND SOURCE OF ENGINE LEAK;AND FAILED TO FIX BRAKE LIGHTS,.THEY STATE IT'S NOT THEIR PROBLEM. THE TRUCK HAS 33,000 MILES ON IT-I EVEN PURCHASED AN EXTENDED WARRANTY-BUT NO ONE CAN OR WILL FIX IT.FILED 2ND COMPLAINT WITH GM-THEY STATE THE SERVICE DEPARTMENT NEVER DOCUMENTED THE ENGINE LEAK/OVERHEATING/BRAKE PROBLEM !I TOOK THE TRUCK BACK TO DEALER DAY AFTER SIGNED THE CONTRACT-TRIED TO GET IT RESOLVED-THEY HID FROM ME!!!!AND SENT MY TRADE IN TO AUCTION...THEY ALSO FAILED TO INFORM ME OF MY 3 DAY RIGHT TO RESCIND;SO I CANCELED THE LOAN ON JAN.2009-UNDER THE TILA LAW. THEY ARE REFUSING TO ACKNOWLEDGE MY RIGHTS AS A CONSUMER;I WILL NOT PAY 23,000 FOR A TRUCK THAT IS INOPERABLE...HELP!

NHTSA complaint #10263125 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

2005 SILVERADO PICK UP WITH 77000 MILES PULLING EMPTY TRAILER( WORK) BLOWS HOLE IN #7 PISTON NO WARNING, MAKE IT TO NEAREST DEALER TAKES THEM 2 WEEKS TO DECIDE ENGINE RUINED BUT NOT COVERED BY WARRANTY, THEY SAID BY THERE ( GENERAL MOTORS) PAPERWORK IT LOOKS LIKE I HAVE A POWER ADDER( CHIP) THAT CAUSED THE PROBLEM( WHICH I DID NOT HAVE). AFTER OBTAINED THERE ( TSB) INFORMATION IT STATES THAT ONLY IF THERE ARE MULTIPLE PISTONS DAMAGED THEN THERE IS A POWER ADDER, IF ONLY ONE IS DAMAGED IT IS A BAD INJECTOR, THEY REFUSED TO PAY AND I COULD NOT AFFORD TO PAY THERE $16000+ BILL TO PUT A NEW ENGINE SO TOOK TO INDEPENDENT SHOP AND HAD ANOTHER ENGINE PUT IN.

NHTSA complaint #10243064 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

THE ENGINE OIL COOLER LINES AND THE TRANSMISSION COOLER LINES LEAK AT THE CRIMP WHERE THE RUBBER HOSE AND METAL LINES CONNECT. AFTER DOING RESEARCH ONLINE ABOUT THIS I HAVE DISCOVERED IT IS A VERY COMMON PROBLEM. SOME PEOPLE HAVE REPLACED THESE LINES MULTIPLE TIMES ONLY TO HAVE THEM LEAK A SHORT WHILE LATER. FOR THOSE OF US WHOSE VEHICLES ARE OUT OF WARRANTY THIS CAN BE VERY COSTLY. I WOULD ALSO THINK THAT TRANSMISSION FLUID AND MOTOR OIL CONTACTING HOT SURFACES LIKE AN EXHAUST POSE A FIRE HAZARD. AT THE VERY LEAST THE LEAKING OIL IS AN ENVIRONMENTAL HAZARD. I HAVE PURCHASED OIL COOLER LINES AND AM REPLACING THEM TOMORROW BUT I AM HAVING TROUBLE FINDING TRANSMISSION LINES.

NHTSA complaint #10224539 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

WHILE TOWING APPROXIMATELY 11,000 POUNDS, VEHICLE EXHAUST GAS TEMPERATURE EXCEEDED 1300 DEGREES. THIS HAS HAPPENED SEVERAL TIMES. DEALER, MOSSY CHEVROLET STATED THIS IS NORMAL.

NHTSA complaint #10191981 — an unverified report by a vehicle owner.