2005 Chevrolet Silverado 2500 problems

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Odometer Fraud. The contact purchased a 2005 Chevrolet Silverado 2500. The contact stated that it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the mileage was 122,000. After obtaining a Carfax report, it was discovered that the mileage was 202,000.

NHTSA complaint #11709100 — an unverified report by a vehicle owner.

TIRES

I bought tires from Walmart.com website in July 15 2023 and had them installed on a 2005 Chevrolet 2500 HD pickup. This was at the Walmart Laramie store. Between that time and Fall of 2024 one of the tires had a flat and Walmart Laramie, Wy replaced it. On October 7 2024 going to Riverton, Wy. the right rear passenger tire had a blow out. This was on I-80 going west towards Rawlins. It scared the beejeezus out of my young grandchildren. Four hours later, it was replaced with the spare (I did not have a jack in the vehicle and called a tow company). I took the tire to Walmart Riverton and they told me in the tire center that the tire was too badly damaged. They wondered where I had bought the tires. I told them in Laramie at Walmart. They looked me up online and found the tires. They told me they could not replace the tire although it was under warranty. The problem was that they are car tires and not light truck tires!!! They told me to call up Laramie Walmart and the tire manager would take care of me. I went home and did so. Jackson the tire manager said he wasn't going to replace them and that it was all my fault and that I forced them to put those tires on! He lied to me about what happened with the tires and them installing them. I went back to Riverton Walmart and again talked to the tire manager (Tyrone). He said that he would talk to the store Manager and they would make it right. He said he would order the correct ones, install them and then charge the Laramie store. I'm not driving the vehicle anywhere. What can I do about it? I know nothing about tires and have never been a tire company employee. This has been going on for months. Last week the Riverton store said they could mount and balance tires for free but I would have to seek a refund from the Laramie store to reimburse me after I buy new tires for $1200. I live on Social Security of $1229 a month!! 2 of 4 tires have failed and I don't have anywhere near the 60,000 miles warranty Can you help us?

NHTSA complaint #11666161 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Frame is rotten badly but cab and bed hardly any rust. Used bad metal for frame and crossmembers.

NHTSA complaint #11443882 — an unverified report by a vehicle owner.

TIRES:TREAD/BELT

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500 EQUIPPED WITH BF GOODRICH RUGGED TERRAIN TIRES, SIZE: LT265/75/R16 (NA). WHILE DRIVING APPROXIMATELY 55 MPH, THE REAR PASSENGER TIRE STARTED TO MAKE AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO DISCOUNT TIRE TO BE INSPECTED. THE CONTACT WAS INFORMED OF PLY SEPARATION TO THE TIRE. THE TIRE WAS REPLACED. APPROXIMATELY 26 DAYS LATER, THE REAR DRIVER'S SIDE TIRE EXPERIENCED A BLOWOUT. THE TIRE WAS REPLACED. THE TIRE MANUFACTURER WAS CONTACTED BY DISCOUNT TIRE AND INFORMED OF THE FAILURES. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 138,000. THE TIRE FAILURE MILEAGE WAS UNKNOWN.

NHTSA complaint #11195613 — an unverified report by a vehicle owner.

WHEELS

I HAVE HAD TWO VALVE STEM FAILURES IN THE LAST TWO MONTHS. THE VALVE STEMS THAT WERE PUT IN WHEN I REPLACED THE TIRES ARE RATED AT 65 PSI MAX. THE TRUCKS RECOMMENDED TIRE PRESSURE IS 80 PSI. THE TWO TIRE INSTALLERS THAT I TALKED TO SAY THE 65 PSI VALVE STEMS ARE INSTALLED FOR ALL VEHICLES. IS THIS REALLY SAFE?

NHTSA complaint #11184189 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

WHILE DRIVING MY VEHICLE ON A CITY STREET AT APPROXIMATELY 45 MILES PER HOUR, I SET THE CRUISE CONTROL TO MAINTAIN THE 45 MILE PER HOUR SPEED. AFTER LESS THAN 60 SECONDS, THE CRUISE CONTROL CAUSE THE VEHICLE TO ACCELERATE RAPIDLY TO 85 MILES PER HOUR. STEPPING ON THE BRAKE AT FIRST DID NOT CANCEL THE CRUISE CONTROL. WHEN IT DID FINALLY CANCEL, I CONTINUE TO DRIVE MANUALLY. THE CRUISE CONTROL THEN TOOK OVER AGAIN AND CAUSE THE VEHICLE TO ACCELERATE RAPIDLY, EXCEEDING THE SPEED LIMIT. ONCE AGAIN, THE BRAKES WERE APPLIED AND THE CRUISE CONTROL CANCELLED. THE CRUISE CONTROL WAS TURNED OFF AT THE MAIN SWITCH ON THE TURN SIGNAL STEM. LATER ON, THE CRUISE CONTROL WAS TURNED BACK ON AND TESTED AGAIN WITH THE SAME RESULTS. AFTER THE THIRD ATTEMPT TO SET THE CRUISE CONTROL AT 45 MPH, THE CRUISE WOULD NOT SET AT ALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP. THEY WERE NOT ABLE TO FIND ANY SPECIFIC ELECTRICAL PROBLEMS. BUT THEY DID INDICATE THAT THE CRUISE CONTROL MODULE ITSELF WOULD PROBABLY BE AT FAULT. IF THE CRUISE CONTROL SWITCH IS LEFT IN THE ON POSITION, BUT THE CRUISE IS NOT SET, IT MAY RANDOMLY TAKE OVER THE THROTTLE AND ACCELERATE OR SOMETIMES HOLD ITS OWN SPEED FOR SEVERAL MINUTES AT DIFFERENT RATES OF SPEED. THIS CREATES A HAZARDOUS SITUATION FOR ALL OCCUPANTS OF THE VEHICLE ALONG WITH OTHERS THAT MAY BE IN THE PATH OF THE TRUCK WHEN IT RANDOMLY ACCELERATES. AS OF THE TIME OF THIS WRITING, A SOLUTION HAS NOT BEEN FOUND TO CORRECT THIS SITUATION.

NHTSA complaint #11109971 — an unverified report by a vehicle owner.

AIR BAGS

SERVICE AIRBAG WARNING ON VEHICLE.

NHTSA complaint #11097014 — an unverified report by a vehicle owner.

SEATS

DRIVER SIDE SEAT HEATER TURNS ON BY ITSELF. THIS IS A DANGEROUS SITUATION BECAUSE THE DRIVER IS DISTRACTED WHILE DRIVING AND MUST LOOK DOWN TO FIND THE OFF SWITCH. OFTEN, THE SEAT HEAT COMES BACK ON AGAIN ALMOST RIGHT AWAY.. THIS SITUATION SEEMED TO OCCUR IN APPROX 2003 TO 2007 MODELS. INTERNET FORUMS SHOW THAT GM HAS SERVICE BULLETINS THAT INSTRUCT TECHNICIANS TO DO A 'FIRMWARE FIX". THE ONLY WAY FOR ME TO STOP THIS CONDITION WAS TO LOCATE AND DISCONNECT A SMALL GREEN CONNECTOR UNDER THE SEAT THAT DISABLES THE SEAT HEATER. CHANGING THE CONTROL MODULE DIDN'T REMEDY THE SITUATION. IT HAPPENS WHILE DRIVING AND IS INTERMITTENT. SEEMS LIKE GM HAS REMEDIED THE SITUATION IN NEWER MODELS. SEEMS TO ME THEY SHOULD BE RECALLING OLDER MODELS TO INCORPORATE SOME SORT OF "FIX". THE DISTRACTION OF LOCATING AND TURNING OFF THE HEATER IS AS BAD AS "DRIVING WHILE TEXTING". I ALWAYS HAVE TO PULL OVER TO GET IT SHUT OFF. OFTEN, WHEN I RESUME DRIVING, THE HEATER WILL COME BACK ON. EVENTUALLY IT STOPS TURNING ITSELF ON.

NHTSA complaint #11089772 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

DRIVER SIDE SEAT HEATER TURNS ON BY ITSELF. THIS IS A DANGEROUS SITUATION BECAUSE THE DRIVER IS DISTRACTED WHILE DRIVING AND MUST LOOK DOWN TO FIND THE OFF SWITCH. OFTEN, THE SEAT HEAT COMES BACK ON AGAIN ALMOST RIGHT AWAY.. THIS SITUATION SEEMED TO OCCUR IN APPROX 2003 TO 2007 MODELS. INTERNET FORUMS SHOW THAT GM HAS SERVICE BULLETINS THAT INSTRUCT TECHNICIANS TO DO A 'FIRMWARE FIX". THE ONLY WAY FOR ME TO STOP THIS CONDITION WAS TO LOCATE AND DISCONNECT A SMALL GREEN CONNECTOR UNDER THE SEAT THAT DISABLES THE SEAT HEATER. CHANGING THE CONTROL MODULE DIDN'T REMEDY THE SITUATION. IT HAPPENS WHILE DRIVING AND IS INTERMITTENT. SEEMS LIKE GM HAS REMEDIED THE SITUATION IN NEWER MODELS. SEEMS TO ME THEY SHOULD BE RECALLING OLDER MODELS TO INCORPORATE SOME SORT OF "FIX". THE DISTRACTION OF LOCATING AND TURNING OFF THE HEATER IS AS BAD AS "DRIVING WHILE TEXTING". I ALWAYS HAVE TO PULL OVER TO GET IT SHUT OFF. OFTEN, WHEN I RESUME DRIVING, THE HEATER WILL COME BACK ON. EVENTUALLY IT STOPS TURNING ITSELF ON.

NHTSA complaint #11089772 — an unverified report by a vehicle owner.

SERVICE BRAKES

MY 2005 CHEVROLET SILVERADO 2500 HD WITH 133,606 MILES EXPERIENCED TOTAL BRAKE FAILURE APRIL 13,2018 AT 9PM EASTERN STANDARD TIME. INCIDENT HAPPENED IN GREENVILLE, OHIO ON GARDENWOOD DR. HEADING WEST. STOPPED AT A 4 WAY STOP WITH NO INDICATION OF ANY KIND OF MUSHY BRAKES ETC. TOOK OFF FROM STOP AND ACCELERATED TO 25MPH THE POSTED SPEED LIMIT. WENT APPROXIMATELY 400 FEET, WHEN A RABBIT DARTED IN FRONT OF TRUCK. HIT THE BRAKES WITH MODERATE FIRM PRESSURE, BUT NOT EXTREME AND BRAKE PEDAL WENT TO THE FLOOR. HAD ZERO BRAKING FORCE. DUMB FOUNDED, I IMMEDIATELY TRIED TO FIND THE PARKING BRAKE PEDAL WITH MY LEFT BOOT IN THE DARK. AFTER 40 YARDS OF COASTING AND APPLYING THE PARKING BREAK WAS ABLE TO STOP THE TRUCK. THANK GOD FOR THE RABBIT, CAUSE THE ROAD DEAD ENDS INTO STATE ROUTE 118. THE BRAKE LINE FAILED UNDER DRIVERS SIDE DOOR NEAR FRAME AND RUNS TO THE MASTER CYLINDER ASSEMBLY. AFTER REMOVING LINES, THE LINES THAT LOOKED GOOD WERE BRITTLE IN SPOTS THAT ARE IMPOSSIBLE TO VISUALLY INSPECT WITHOUT REMOVING. TWO OTHER LINES THAT DIDN'T FAIL COULD BE EASILY SNAPPED IN TWO WITH ALMOST ZERO FORCE. ENTIRE BRAKE SYSTEM OTHER THAN THE STEEL LINES HAD BEEN REPLACED IN THE PAST 2YRS. POWER WASHED UNDER THE TRUCK AT A MINIMUM OF EVERY 6 MONTHS. SPRAYED WD 40 ON BRAKE LINES EVERY 6 MONTHS PAST 4YRS, DUE TO MECHANIC INFORMING ME THAT THE LINES COULD GO BAD ALONG FRAME AND THAT THEY ARE DIFFICULT TO REPLACE. THOUGHT I HAD DONE A GOOD JOB AT PREVENTING SUCH AN INCIDENT. HAVE EXTENSIVE MECHANICAL SKILLS FROM EXPERIENCE, HENCE I'M REPLACING ALL THE BRAKE LINES MYSELF. WAS A MAC TOOL DISTRIBUTOR IN THE PAST AND RAISED ON A FARM. LUCKY I HAD REPLACED THE REAR DISKS AND PARKING BRAKE SHOES, BECAUSE THEY ARE LESS THAN ADEQUATE TO STOP A FULL SIZED TRUCK IMO. I'M PISSED OFF THIS HAPPENED. THE LINES NEED REPLACED ON ALL THESE VEHICLES, BEFORE THEY FAIL AND HURT OR KILL INNOCENT PEOPLE.

NHTSA complaint #11088428 — an unverified report by a vehicle owner.

SERVICE BRAKES

2005 CHEVROLET SILVERADO 2500. CONSUMER WRITES IN REGARDS TO BRAKE FAILURE, LINES HAD TO REPLACED DUE TO RUST AND CORROSION. *LD

NHTSA complaint #10994770 — an unverified report by a vehicle owner.

STEERING

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT EVERY TWO YEARS, THE PITTMAN ARM WOULD PREMATURELY FRACTURE. THE PART HAD ALREADY BEEN REPLACED MORE THAN THREE TIMES. THE PART HAD TO BE REPLACED A FOURTH TIME BY AN INDEPENDENT MECHANIC WHO STATED THAT THE PARTS WERE OEM. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE MANUFACTURER ISSUED 16 TSBS ON THE STEERING, THREE RECALLS ON THE STEERING, AND 27 TSBS ON THE SUSPENSION. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA complaint #11076284 — an unverified report by a vehicle owner.

SUSPENSION

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT EVERY TWO YEARS, THE PITTMAN ARM WOULD PREMATURELY FRACTURE. THE PART HAD ALREADY BEEN REPLACED MORE THAN THREE TIMES. THE PART HAD TO BE REPLACED A FOURTH TIME BY AN INDEPENDENT MECHANIC WHO STATED THAT THE PARTS WERE OEM. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE MANUFACTURER ISSUED 16 TSBS ON THE STEERING, THREE RECALLS ON THE STEERING, AND 27 TSBS ON THE SUSPENSION. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA complaint #11076284 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

HEATER CONTROLL MODULE FAILURE WIRES HEAT UP AND MELT THE SHEILDING AND THE CONNECTOR ENDS.

NHTSA complaint #11067090 — an unverified report by a vehicle owner.

POWER TRAIN

NO SEPTEMBER 3RD 2016 I WAS AT STUTZ EXCAVATING DRIVING FOR THEM AND WENT I GOT OFF AND WALKED TO MY PICKUP I GOT IN THE TURNED THE KEY AND THE HOUR METER WAS ON 00.0 AND THE MILES HAD 127300 OR SO I HAD JUST CHANGE THE OIL AND HAD OVER 4000 HRS ON MY TRUCK SOMEONE BROKE IN AND HACKED MY PICKUP IN STUTZ EXC LOT AND ON DEC 20TH I WAS LEAVING DR BUGERS LOT AT 5:10 PM AND MY HEAD LIGHT WOULD NOT WORK I GOT HOME AND THE HEADLIGHTS WORKED FINE I SINCE THEY READ ABOUT CAR HACKS AND PULLED THE RADIO FUSE AND AND TRUCK HAD NO MORE PROBLEMS INFILL APRIL 28 MY TRUCK WOULD NOT GO I REVERS AND THE DOOR LOCKS LOCKS THEMSELF AND THE HRS WERE GOING UP WITH DRIVING IT THE DEALER SAID YOU CAN NOT EARESE THE HOUR ON THAT TRUCK THEY ARE BURNED IN THE COMPUTER. SO IF STUTZ CAN REMOVE THE HOUR THEY CAN REMOVE THE MILES FROM THE TRUCK I GOT POLICE REPORTS ON THE VW JETTA BUT NONE ON THE PICKUP THE PICKUP AND CAR WAS MOVING THREW EDWARDSVILLE WHEN THE HEADLIGHTS WENT OUT I GOT HOME WITH MY FOG LIGHTS AND AGAIN THE EDWARDSVILLE POLICE ARE FRIENDS WITH STUTZ AND TOLD ME IT CAN'T HAPPEN SO NOW I LIVE IN FEAR THAT STUTZ CAN SHUT MY LIGHTS OFF ON A RAINY NIGHT ON A DARK ROAD MIKE WEBER AT 3832 RAMOND RD IS CHRIS STUTZ FATHER IN LAW SO MOST OF THE BRACK IN HAVE BEEN HAPPING AT HOME AND AGAIN COPS REFUSE TO BELIEVE ME

NHTSA complaint #11014099 — an unverified report by a vehicle owner.