2022 Chevrolet Suburban electrical problems

ELECTRICAL SYSTEM

The telematics control module in this vehicle failed. A dealer diagnostic scan on 03/09/2026 at 67,839 miles documented the following active and history codes: U0198 Lost Communication with Telematics Module, reported independently by the Radio, Body Control Module, and Instrument Panel Cluster Control Module; U0499 Invalid Data Received from Telematics Module, reported by the Engine Control Module; U1962 Unable to Authenticate Serial Data Message; B1A1F Ethernet Bus 4 (+) Circuit Open with a Low Voltage/High Temperature symptom; and P00FF Body Control Module Requested MIL Illumination, listed as Current. As a result, the check engine light is commanded on. All OnStar functions are inoperative, including Automatic Crash Response and Emergency SOS, which are safety systems. The OnStar button has no illumination at all. Remote functions and vehicle connectivity are dead. No warning message or notification of a module fault was ever displayed in the vehicle. The infotainment system reports “Your Software is Up-to-Date” and the Device Registration screen reports “Registered.” The last over-the-air software update this vehicle received was in August 2023

NHTSA complaint #11758065 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

The contact owns a 2022 Chevrolet Suburban. The contact stated that while attempting to start the vehicle, the instrument panel displayed a blank screen. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed, and it was determined that the instrument panel needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 95,000.

NHTSA complaint #11758091 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The telecommunications module for vehicle GPS and OnStar emergency services failed after a factory software update. Now the vehicle has no GPS location, information emergency OnStar services or the ability to access vehicle Telematic via cell signal or an app. Dealer refused to cover the item under the 36 month bumper-to-bumper warranty leaving the consumer stuck with a $2000 cost just to have GPS in the vehicle and maintain contact with emergency services through OnStar.

NHTSA complaint #11739446 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2022 Chevrolet Suburban. The contact stated that the vehicle was taken to the local dealer for painting services. Upon retrieval of the vehicle, the service drive assist message was displayed. The doors failed to lock. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. Additionally, the contact contacted a lawyer. The failure mileage was approximately 28,000.

NHTSA complaint #11738482 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

The contact owns a 2022 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the instrument cluster failed to function as intended. The instrument cluster displayed a screen with lines. In addition, the contact stated that while attempting to start the vehicle, the instrument panel displayed a blank screen. The vehicle was taken to the dealer, where it was diagnosed with a failed instrument cluster. The contact was informed that the instrument cluster needed to be replaced. The vehicle was not repaired. The contact stated that on March 03, 2026, the vehicle was serviced at the dealer. The contact stated that four unknown recall repairs were performed, and the failure occurred a week after the recall repairs were performed. The manufacturer was made aware of the failure. The failure mileage was approximately 46,448.

NHTSA complaint #11730249 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

In several separate unreplicable instances, the vehicle has turned off while driving, once on the highway, once on my street, once turning across heavy traffic, and others. I've almost died a couple times and I've taken it to the dealership several times, they have Not been able to find anything wrong with it and have been unable to replicate the issue. The engine has been replaced, and it was happening before and since. My 2023 is also doing the same thing.

NHTSA complaint #11722195 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Vehicle accelerated while driving. The RPMs gage turned red; however, the vehicle stopped in the middle of the road with other cars coming. After the vehicle came to a full stop it would not move. Finally it started moving slowly and I was able to get off the road. When the tow truck arrived the vehicle would only go forward. No reverse. Error message on dashboard picture attached

NHTSA complaint #11721068 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Onstar, my vehicle's core safety communication system, stopped working without notice, without an alert on the dash. Nothing. I press the onstar button and nothing happens. What if I was in trouble? Didn't have my phone? The issue was not communicated to me through the infotainment system. This seems like a serious issue.

NHTSA complaint #11701757 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I own a 2022 Chevrolet suburban and bought the 72k mile extended warranty. Recently my telematics module went bad which is covered by the GMPP. I lost wifi, my clock is wrong everytime etc. However General Motors no longer makes this part anymore. Parts department utilizes a third party company called specmo for a refurbished authorized unit. However, GMPP will only cover the original msrp not the inflated price from the company specmo that GM uses for these parts. This part is 100% covered based on an msrp for a part that they no longer use and states that policy does not allow them to cover the full cost over the original msrp of the part. This is an issue that is all over the forums and internet and is ridiculous that GMPP is an extension/better than manufactures warranty yet they will not fully cover the full cost of the part that is covered. A few days later I was driving and my abs, traction control, steering, brakes, everything was flashing and not responsive or dramatically reduced like my brakes where I could not stop immediately with me and my 5 kids in the car.

NHTSA complaint #11690625 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Onstar module failed, no longer have wifi, navigation or other onstar supported features. Cannot perform system updates for vehicle due to onstar module. Cannot use app due to onstar module.

NHTSA complaint #11689230 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Driving down to Florida, No warning, no lights, never any issues except a belt replacement. I get oil changes, tire rotation every 3500 miles. Almost got killed doing 75 miles per hour, engine sputtered, totally shut down. Coasted onto an exit ramp thank God it was right there or we could of been killed. Tow truck towed to Davis Chevy Gainsville, they called me on Monday said good news I have a warranty bad news Total Engine Failure, will take 3-4 weeks to replace. Now I am trying to find a GM rental large enough to get me and my family back to TN since GM said they will only pay for a GM rental car. Scary, could of gotten killed. NO NOTICE FROM GM ABOUT ANY POSSIBE PROBLEMS....WE ALMOST GOT KILLED AND CRASHED along with the other drivers on the road. Thank God it was a Sunday and 6 am so not much traffic or it would of been worst.

NHTSA complaint #11674355 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

While driving on vacation our car just slowed down gave the message, “reduced acceleration, drive with care” and then shut off while on the high way. We were able to start it again but after that haven’t had that message but have had the message to service safety restraint system multiple times. I have taken my SUV to the dealership multiple times for both issues and they have said multiple codes generate but they can’t find anything to fix.

NHTSA complaint #11668592 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

While driving on the highway at 55 mph during a long-distance trip, the engine of my 2022 Chevrolet Suburban (6.2L V8) failed suddenly without any warning lights, messages, or prior symptoms. The vehicle lost power unexpectedly, creating an extremely dangerous situation. I was traveling to a national wheelchair basketball tournament and had a passenger in the vehicle at the time. Our safety was immediately at risk due to the abrupt loss of power in a high-speed traffic environment. The vehicle was towed to the dealership, where the issue was confirmed as a complete engine failure. The dealership later replaced the engine under warranty. I was informed that the engine installed was the same model currently under active recall (N252494001), which affects the 6.2L V8 engine in this vehicle type due to defective crankshaft or connecting rod components. The failed engine is no longer available for inspection, but the dealership should have records of the inspection and replacement. There were no warning lamps, error codes, or drivability issues prior to the failure. The malfunction was immediate and severe.

NHTSA complaint #11661502 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

While traveling back from Labor Day Weekend on [XXX], I was driving in the Dallas Fort Worth area when I experienced loss of power to our vehicle on a major highway [XXX] and [XXX] ) and directly on a bridge with my entire family in the vehicle (4 kids and all of our luggage). It was a very dangerous and scary situation. We had to wait one hour for a tow truck to come and take my vehicle to the closest GM dealership. I was left stranded, 3 hours from my home with my four children and luggage. The Chevrolet dealership contacted me 9 days later and informed me the technician looked at the vehicle and determined the engine was locked up/seized. It would take 9 months to get the vehicle back into the shop to determine what caused the issue and then take 6-12 months for a new engine. I have a family of 6 and I'm left car-less for two years. Yet I still have to make the monthly payment on a vehicle that I won't be driving or be in possession of. MY BIGGEST ISSUE: GM has known that they have had engine issues for many years. Particularly, with Dynamic Fuel Management causing lifter issues which leads to engine failure, yet never disclosed this to me when I purchased the vehicle. Furthermore, they never disclosed that the issue was so prevalent that motors were back ordered for over a year. Consumers are being misled into spending their hard earned money on vehicles that have major mechanical design flaws known to the manufacturer. Once the mechanical flaw is realized, the vehicle can't be repaired for up to two years. Hiding this data from consumers should be criminal. Furthermore, General Motors to this point has been no help, with the GM customer satisfaction team telling us they can't do anything until a dealer diagnosis the issue, and the dealer stating they can't diagnose the issue until May of next year, at which time they would then look to order the motor which will take 9-12 months to deliver and install. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11614502 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

- Truck makes a sizzling sound when parked - Car wouldnt start and needed battery jump, unknown source draining the battery - Truck has engine issues , started shaking and died in the middle of the highway, GM replaced engine - Engine replaced after less than a week, truck would not start, Gm replaced starter - After 2 days and using the vehicle once, truck would not start again. GM is trying to root cause issue but cant find a resolution Since the car stopped when we were on the highway and none of the fixes seem to be working I am worried that the car will abruptly stop again and put my life and others at risk

NHTSA complaint #11602226 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2022 Chevrolet Suburban. The contact stated that while his wife was driving at an undisclosed speed, the vehicle stalled. The message to restart the vehicle was displayed. The contact stated that the failure had occurred while the Auto START/STOP feature was enabled and disabled. The failure forced the contact's wife to shift into park or neutral before the vehicle would restart. The failure occurred several times while the contact's wife was driving the vehicle several times and stopping at the red light when the vehicle stalled. The contact stated that the vehicle had been taken to a dealer previously and the failure was not duplicated. The contact stated that the failure occurred intermittently. The vehicle was taken to a second dealer, but the failure could not be duplicated. The vehicle was not repaired. The contact was informed that unless the failure was recognized, the vehicle could not be diagnosed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 10,000.

NHTSA complaint #11575296 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The car turned itself off while driving 55 to 60 mph on a highway. Would not turn back on after getting to the side of the road. Very dangerous.

NHTSA complaint #11571524 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

It was diagnosed as the Telecommunication Module, this part malfunctioned causing issues with audio in the vehicle. The audio would at times play normal, at times go completely out losing all sound to turn signals, hazard signals, and safety sensor audios inside the vehicle. It would additionally lose communication between the key fob and the unit causing warnings during driving and non-start issues. With that said, the lose of audio when expecting safety sensor sounds, or sudden audio on complete full volume with the only resolution being to shut the car off is a safety issue. The vehicle had to be pulled over on the travel portion of the highway to resolve the sound issues on multiple occasions. Software updates, radio head change didn’t matter, until it was diagnosed as the module described above. Occurrences were completely random.

NHTSA complaint #11529216 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

When I started up the vehicle with the key fab button I noticed the cabin air blower came on as normal however when we went to the cockpit we noticed the engine was not running. When we went to start the vehicle (holding break and pressing start button) the dashboard started the Z71 launch sequence and then went to a dashboard as if I was in the normal drive mode however the dashboard was extremely dimly lit as if the backlight was not on and the engine still was not running. After several attempts to start using the brake+start button method we noticed a clicking sound that seemed to be coming from the engine cabin just in front of the passenger cabin however it would never ignite/start the engine. After several attempts to start the engine through the brake+button, we tried to just press the start button, which would sometimes be prompted on the dashboard, and get some feedback from the dashboard through better backlighting and messages I now cannot recall but never ignited the engine. When we tried again with the key fab x2 button (hoping it would either start or "cancel" the current vehicle state), we received no response from the vehicle. When we attempted to shift, it stated the "conditions were not met", which I perceived as the correct response. The vehicle was stuck in this "mode" with the air blower still running and exterior lights still on and it was only a matter of time until the battery ran out. When it ran out later that day (though not completely ded) in rebooted in the same tweener mode. However, when we came the next day with a tow truck and a fully dead battery in the Suburban, the vehicle booted right up as normal. The tow truck driver indicated several new Tahoe drivers experiencing the same issue. To me, this is a software launch issue. While the vehicle was not perceived to be in danger, it left us stranded in what could be a dangerous location. Several episodes as reported by tow truck. Unsure if inspected. No symptoms before problem.

NHTSA complaint #11486651 — an unverified report by a vehicle owner.