504 of the
1,763 complaints filed about the Chrysler 300C
are about the fuel system —
29% of everything owners reported.
The worst model year for it is 2006.
Completed x53 extended warranty a year prior at dealership, car still stalls only after putting fuel even though always filling to 3/4-7/8 of tank. Had my children with me Car stalled again today at middle of busy street when about to make a left turn after i filled to 3/4 of a tank. Had dodge dealer in Manteca, CA diagnose after first stall half a year prior and they would not replace faulty new tank. Still had to pay diagnostic fee saying fuel liquid was getting into vapor lines and flooding engine and that new tank is not the issue even though it is allowing fuel liquid to pass through vent valve which caused saturation of vapor canister and purge solenoid and engine stalling. Car only stalls when pumping gas 3/4 tank or above
NHTSA complaint #11721320 — an unverified report by a vehicle owner.
Hello, I am worried about the problem that persists for more than 5 years that the car is in my possession, my 2005 Chrysler 300c, it is always the same problem when I fill the fuel tank, the car does not want to start, I have to wait at least 10 minutes at the pump trying several times to start it again, this occurs at an intersection, at a traffic light, and even while in traffic, endangering my life and the lives of other drivers, please I need help!!!!
NHTSA complaint #11691298 — an unverified report by a vehicle owner.
Hello, my name is [XXX] , and my car continues to have the same problem for more than 5 years that it has been in my possession, after refilling the car completely with fuel, the car automatically turns off and this happens at a traffic light or anywhere, this is very dangerous since I interfere with traffic, please I do not know what to do to solve it, in many forums there are many 2005 Chrysler vehicles that have the same problem from the factory, please I need help. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11669983 — an unverified report by a vehicle owner.
After Fueling on several occasions the vehicle just abruptly stalls out and it's very dangerous I notice that there is recalls on other 2006 Chrysler but mine isn't on there but I am very concerned about this as it could cause me to get in a accident
NHTSA complaint #11666755 — an unverified report by a vehicle owner.
Engine stall immediately following fuel tank fill up. Chrysler refuses x53 lifetime extended warranty. Service bulletin 14-002-14 Applies to 2005-2006. I own 2008. Identical car. Identical problem. Happens every time fuel is filled.
NHTSA complaint #11663061 — an unverified report by a vehicle owner.
car stalled after filling gas tank. I was driving through an intersection and had to stop for oncoming traffic, when the car stalled and would not immediately restart, it eventually did start after several panic moments of being stuck in the intersection while the light was changing to let opposite traffic proceed. It stalled 2 more times on the way home. Both times I was slowing the car down when this occurred. I have been fearful of driving this car again since this happened. I heard there was a recall from Chrysler for lifetime replacement of gas tank due to a possible control valve shutoff float failure. My vehicle has never had the gas tank or float replaced, but it does not show up for a recall when I enter VIN. What should I do?
NHTSA complaint #11656550 — an unverified report by a vehicle owner.
The OEM starter ignited a fire under the front end of my vehicle. Upon noticed, I immediately grabbed a fire extinguisher, and I put the fire out. I had my two young boys in the car at the time when it happened and I urged them to get out of the car immediately my young son has a fear from now on on getting in vehicles. There wasn’t any issuing warning lights that prompted any awareness. Initially started the car to run and get the juices flowing - seeing The car was parked. There wasn’t any movement to Initiate spark.
NHTSA complaint #11648850 — an unverified report by a vehicle owner.
There is a fuel smell in the car, for the first 1/4 tank of gas. The smell is really bad in the back seat. After the car is under 1/2 tank the fuel odor begins to subside. Passengers in car begin to have headaches and upset stomachs. After veiwing other chrysler forum's - I believe this to be common with this style of car and an extreme Safety issue
NHTSA complaint #11637997 — an unverified report by a vehicle owner.
gasket around fuel pump failed allowing gas to pool on top of fuel tank under the back seat on passenger side . this resulted in a strong "gas/fuel" smell from fuel vapors colecting inside the car and the obvious risk of ignition/explosion and negative health effects of breathing said fumes .the vehicle has not been inspected yet because we are afraid to start the vehicle let alone drive it to the shop . We are making araingements to have it towed to the repair shop . we have not had any warning lights . Mechanic said it was a common problem with seal failure around fuel pump . the vehicle has 127,000 miles
NHTSA complaint #11634454 — an unverified report by a vehicle owner.
The contact owns a 2006 Chrysler 300C. The contact stated that the fuel tank was previously replaced under an unknown extended warranty coverage; however, after the repair, the vehicle experienced a failure. The contact stated that after refueling the vehicle and driving at slow speeds, the vehicle stalled. The contact stated that the failure recurred several times while driving and coming to a complete stop. The vehicle was towed each time the failure occurred. The contact stated that the vehicle stalled in the middle of the road during the last failure. The contact was able to push the vehicle to the side of the road with assistance. The vehicle was towed to the residence. The vehicle was then towed to the dealer, where it was diagnosed and test-driven, but the cause of the failure could not be determined. The vehicle was not repaired. The failure mileage was approximately 214,624.
NHTSA complaint #11562356 — an unverified report by a vehicle owner.
Once fueled, the engine will consistently stall from start to cruising speed, and has even shut off while driving. There was an issue with Chrysler fuel tanks evap valve sticking open, which causes this fault, however I have not received any assistance from Chrysler or any authorized dealer.
NHTSA complaint #11555801 — an unverified report by a vehicle owner.
My Fuel Tank is stuck in open position, it is making my car stall, sputter, and cut off. When my gas is very low car doesn't cut off and runs fine, but when I fill car up it stalls and cuts off, this is very dangerous it cuts off at red lights, stop signs, slow traffic, I've seen this is a Warranty/Recall problem with the faulty fuel tanks, with stuck open fuel shutoff valve. My car is running at max fuel because of this problem. It's been like this since I bought car 2 months ago. I need this fixed immediately. And all parts on my car are brand new this Faulty fuel tank is the Culprit
NHTSA complaint #11552587 — an unverified report by a vehicle owner.
The car will just shut off while driving or at rest. My safety and other people on the road is unsafe in the vehicle because when it shuts off in the middle of the road the steering wheel is also not working. The car has been to multiple shops with each shop guessing what could be the problem and fixing what they think may be wrong and after 2,000 dollars the car is still stalling out while being drove. No lights or diagnostic test come up with anything that could cause the problem
NHTSA complaint #11541636 — an unverified report by a vehicle owner.
Fuel leaking through gas gasket under rear passenger seat near electrical components. Gas Fumes fill vehicle cabin when fuel tank is full and could be ignited by a small spark. No warnings of issue on dashboard. EXTREME DANGER!
NHTSA complaint #11515706 — an unverified report by a vehicle owner.
The fuel tank gasket failed. When fuel car to full the gas seeps out and puddles on top of access area under rear passenger seats and fills car with gas fumes. Only seeps out when you fill car to full
NHTSA complaint #11494325 — an unverified report by a vehicle owner.