2003 Chrysler PT Cruiser suspension problems

SUSPENSION

MY EXTERIOR FRONT LIGHTS ARE VERY DULL AND AREN'T BRIGHT WHEN TURN THEM ON.

NHTSA complaint #11183941 — an unverified report by a vehicle owner.

SUSPENSION

I HAD PURCHESED A USED 2003 PT CRUISER AND ON THE HWY HOME SHORT TIME LATER I HEARD CLUNKING SOUND THREE TIMES FIRST WHEN MERGING ONTO HWY FROM CAR DEALERSHIP. FUTHERMORE, ABOUT 10 MIN INTO MY HWY DRIVE HOME I BECAME FRIGHTEND WHEN MY CAR ENDED UP HAVING A MIND IF ITS OWN AND STARED GOING TO THE LEFT SO I TRIED TO TURN STEARING WHEEL TOWARDS RIGHT AND I WAS UNABLE TO CORRECT IT FOR FEW SECONDS AND ENDED ON THE OTHERIDE OF WHITE LINE JUST ABOUT OFF HWY AND INTO GRAVEL BUT AT THAT POINT I SEENED TO REGAIN CONTROL OF MY CAR STEARING AND PROCEEDING BACK BETEEEN YELLOW AND WHITE LINE ON THE HWY, FOLLOWING WAS ANOTHER INCIDENT WAS WHEN I CAME TO COMPLETE STOP FOLLOWING WITH LEFT TURN (STARTED TO MAKE A CLUNKING SOUND EVEN LOUDER).DURNING MY ROUTE I MADE A RIGHT TURN THE SOUND AGAIN. I ENDED UP TAKING IT TO A DEALERSHIP TO TAKE A LOOK AT . THE MECHANIC SAID HE KNEW AT ONE POINT THEY HAD A SAFTY RECALL ON THE SUSPENSION FOR PT CRUSIERS BECAUSE THEY COULD CAUSE INJURY WITH MOTOR VEHICLE ACCIDENTS DUE TO LOSS OF CONTROL AS A RESULT OF LOWER CONTOL ARM /SWAY BAR / AND BAD BALL JOINTS WHICH I PERSONALLY PROB EXPERICEND ON MY WAY HOME FOLLOWING MY PURCHESE OF THE CAR. THE MECHANIC I SPOKE TO CHECKED MY VIN NUMBER AND IT DID NOT HAVE A RECALL ON IT HOWEVER THERE WAS RECALLS FOR A SET AMOUNT AND THAT MINE WASNT ONE OF THEM BUT SHOUKD HAVE BEEN AND THAT I SHOULD INFORM " NHTSA "ABOUT MY SITUATION BECAUSE THERE COULD BE OTHERS EXPERIENCING SAME SITUATION DUE TO MALFUNCTIONING PARTS BECAUSE A MALFUCTION CAN HAPPEN TO EVEN AFTER MARKET PARTS CAN LEAD TO DEADLY ACCIDENTS EVEN DEATH BECAUSE OF LOSS OF CONTROL. I STRONGLY AGREE WITH MECHANIC THAT THE RECALL SHOULD BE UPDATED EVEN ON THE AFTER MARKET PARTS FOR THE SUSPENION SUCH AS CONTROL ARM AND CALLED FOR EVERY 2003 PT CRUSIER GT BECAUSE OF LOSS OF CONTROL THAT ALMOST CAUSED ME TO BE IN ACCIDENT EVEN COULD OF BEEN FATAL. THANK YOU

NHTSA complaint #11079804 — an unverified report by a vehicle owner.

SUSPENSION

THE LOWER CONTROL BUSHINGS HAVE BEEN REPLACED 3 TIMES IN 46,197 MILES OVER 12 YEARS. THE LAST TIME CONTROL ARM AND BUSHING WERE REPLACED. FIRST TIME WAS 5-21-07 WITH 20,204 MILES ON THE CAR. SECOND TIME WAS 5-21-08, ONLY ONE YEAR LATER, 22,309 MILES ON THE VEHICLE, JUST OVER 2000 MILES FROM A YEAR AGO WHEN IT WAS DONE. THE DEALER COVERED IT BECAUSE IT WAS WARRANTY FROM A YEAR AGO. WONDER IF IT WAS EVER DONE THE FIRST OR SECOND TIME. WE JUST HAD THE CONTROL ARM AND BUSHINGS REPLACED 5-27-2015 AT 46,197 MILES. NOW THE DEALER ORIGINALLY TOLD MY WIFE THIS DOES NOT HAPPEN UNTIL THE VEHICLE HAS ABOUT 80,000. WOW LOOKS LIKE A MAJOR ISSUE FOR THEM.

NHTSA complaint #10725509 — an unverified report by a vehicle owner.

SUSPENSION

I PURCHASED THE CAR AND RIGHT FROM THE START I'VE HAD TO REPLACE THE WHEEL BEARINGS , I HAVE HAD TO DO SO 3 TIMES ALREADY WITHIN THE SHORT AMOUNT OF TIME I HAVE HAD THE CAR , THERE HAS BEEN NO UNUSUAL STRESS ON THE BEARINGS TO MAKE THEM WEAR OUT , NOW IN MY EXPERIENCE I HAVE NEVER HAD TO REPLACE A WHEEL BEARING ON A CAR WITH ANYTHING LESS THAN 100K MI ON IT , LET ALONE 3 TIMES , I DON'T KNOW WHAT TO MAKE OF IT, ALSO IM HAVING STALLING/ROUGH IDLE PROBLEMS THAT NO ONE CAN SEEM TO FIGURE OUT IT HAS STALLED 5 TIMES ALREADY AND REGULARLY IDLES ROUGH, THESE PROBLEMS ARE NOT NORMAL AND CANNOT BE FIGURED OUR ,I'VE REPLACES SEVERAL PARTS INCLUDING THE ERG VALVE PVC VALVE SPARK PLUGS AND WIRES THE IAC CLEANED THE THROTTLE BODY AND THE CARB AND IM STILL HAVING THESE ISSUES.

NHTSA complaint #10676314 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

2003 P T CRUISER WITH 44000 MILES AM TOLD IT NEEDS FRONT BEARINGS ON THE FRONT.

NHTSA complaint #10346931 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

LOWER CONTROL ARM BUSHINGS ARE BAD AT 60,000 MILES AND THE CAR IS WANDERING ON THE ROAD. CHRYSLER NEEDS TO ADDRESS THIS KNOWN ISSUE BEFORE SOMEONE IS HURT OR KILLED.

NHTSA complaint #10329522 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

2003 CHRYSLER PT CRUISER. CONSUMER STATES DEFECT INVOLVING THE LOWER CONTROL ARM BUSHINGS IN THE FRONT SUSPENSION *TGW IN AUGUST 2007 THE BUSHINGS HAD DETERIORATED AFTER ONLY 30,620 MILES. THE DEALER REPLACED THEM AT A COST OF $414.84 WHICH THE CONSUMER HAD TO PAY SINCE THE VEHICLE WAS BEYOND THE 36 MONTH WARRANTY. IN JUNE 2009, THE DEALER INFORMED THE CONSUMER THEY NEEDED TO BE REPLACED EVEN THOUGH IT HAD ONLY BEEN 12,292 MILES SINCE THEY WERE INITIALLY REPLACED. THE CONSUMER WENT TO AN INDEPENDENT MECHANIC AND HAD THEM REPLACED AGAIN.

NHTSA complaint #10328504 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

THIS IS THE SECOND TIME, CONTROL ARMS HAVE TO BE REPLACED ON MY CAR. MAY 2007, MILEAGE 40,054, BOTH LOWER CONTROL ARM BUSHINGS WORN OUT/CONTROL ARM HOLE OBLONG: BOTH REPLACED. AGAIN TODAY, APRIL 2009, MILEAGE 55,000, CAR IS IN SHOP FOR SAME SERVICE. ALSO, APRIL 2008, MILEAGE 46,856 FRONT LEFT HUB BEARING FAILED, HAD TO BE REPLACED.

NHTSA complaint #10265725 — an unverified report by a vehicle owner.

SUSPENSION

TWO PT CRUISERS, 02-03, BOTH NEEDING TIE RODS, CONTROL ARMS, WATTS LINKAGE, WHEEL BEARINGS AT AROUND OR LESS THEN 50,000 MILES. BASICALLY THE ENTIRE SUSPENSION NEEDED TO BE REPLACED. THIS IS UNHEARD OF.

NHTSA complaint #10264781 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

WE BOUGHT OUR 2003 PT GT CRUISER IN JAN.2004 WITH 600 MILES ON IT. AT 36,000 MILES THE FRONT WHEEL BEARINGS HAD TO BE REPLACED ( AT OUR EXPENSE) FOR THE FIRST TIME. DEALER ( PRESTON OF WARREN, OHIO ) SAID IT WASN'T COVERED UNDER WARRANTY. THEY WERE REPLACED AGAIN AT 45,000 MILES, AND 6 MORE TIMES SINCE THEN. THEY ARE AGAIN NEEDING REPLACED FOR THE NINTH TIME.I ALSO REPLACED TIERODS AND BUSHINGS ONCE, AND HUBS TWICE. I HAVE READ HUNDREDS OF ONLINE POSTS FROM OTHER PT OWNERS WITH STRIKINGLY SIMILAR STORIES WHICH PROMPTED ME TO FILE THIS COMPLAINT.

NHTSA complaint #10262026 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

I HAVE A 2003 PT CRUISER, I HAVE 53,000 MILES ON THIS CAR, AND THE CONTROL ARMS NEED TO BE REPLACED. I HAVE GONE TO THE CHYRSLER FORUMS, AND THERE IS A LOT OF COMPLAINTS BY ALOT OF OWNERS OF CHRYSLER HAVING THE SAME EXACT PROBLEMS. SOME WITH LESS MILES THAN MINE. CHRYSLER NEEDS TO STEP UP TO THE PLATE AND RECALL THIS PART. THANKS, DARLENE SMITH

NHTSA complaint #10261489 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

LOWER FRONT CONTROL ARM BUSHINGS AND FRONT WHEEL BEARINGS WENT BAD AT 38,000 MILES. 2 WATER PUMPS WENT BAD ON THE CAR AND CAR ONLY HAS 38,000 MILES ON IT. CAMSHAFT SENSOR WENT BAD WITH ONLY 25,000 MILES ON IT. OIL PAN ON ENGINE STARTED LEAKING WHEN CAR HAD 17,000 MILES ON IT.

NHTSA complaint #10260879 — an unverified report by a vehicle owner.

SUSPENSION

I OWN TWO PT CRUISERS, BOTH HAVE HAD CONTROL ARM BUSHING FAILURES AT 45K MILES. THIS IS A KNOWN PROBLEM TO CHRYSLER, ALL OVER INTERNET, FAILURES AT EARLIER MILEAGE AS WELL. THEY DO NOTHING. $650/CAR TO REPLACE CONTROL ARM.

NHTSA complaint #10256065 — an unverified report by a vehicle owner.

SUSPENSION

TL*THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT CONTINUED TO HEAR A CLUNKING NOISE AND STATED THAT THE VEHICLE WOULD "GET AWAY FROM HER" WHILE DRIVING VARIOUS SPEEDS ON THE HIGHWAY. THE DEALER REPAIRED THE TIRE, BUT AN INDEPENDENT MECHANIC STATED THAT CONTROL ARM BUSHINGS AND TIE ROD END REPAIRS WERE COMMON. THE DEALER OFFERED TO REPAIR THE VEHICLE AT THE COST OF MORE THAN $600. THEY ALSO STATED THAT A FRONT END ALIGNMENT WOULD BE NEEDED FOLLOWING THE REPAIRS. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 65,000. UPDATED 11/17/08 *CN UPDATED 11/24/08.

NHTSA complaint #10246495 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

TL*THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT FELT ROUGHNESS AND VIBRATING. THE VEHICLE WAS NOT OPERATING PROPERLY. THERE WERE NO PRIOR WARNINGS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DISCOVERED THAT THE FRONT END CONTROL ARM BUSHINGS FAILED. THE VEHICLE WAS REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 39,300 AND CURRENT MILEAGE WAS 39,330.

NHTSA complaint #10240960 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

2003 PT CRUISER GT 2.4L 96K MILES STARTED TO NOTICE TIRE TREAD PROBLEMS AT 40K. THOUGHT IT WAS A BAD ALIGNMENT FROM NTB AND THEY DID ANOTHER ALIGNMENT FOR NOW CHARGE. 10K LATER AND I AM HAVING TIRES REPLACED AGAIN! ALSO HEAR ALIGNMENT PROBLEMS AND KNOCKING COMING FROM THE FRONT END. TOOK IT IN AND SERVICE TECH RECOMMENDED ALIGNMENT AND FRONT DRIVER SIDE BEARING BE REPLACED. HE ADD THE BUSHINGS ON THE DRIVER SIDE CONTROL ARM WAS GOING BAD BUT NOT NECESSARY FOR IMMEDIATE REPLACEMENT. I HAD THE FRONT BEARING REPLACED AND ALIGNMENT DONE. FRONT DRIVERS SIDE BEARING WENT BAD AGAIN BUT ON BOTH SIDES IN THE FRONT AT 88K. NOW I AM BEING TOLD FROM THE CHRYLSER DEALER THAT HUB AND BEARING IN THE FRONT ON BOTH SIDES NEED TO BE REPLACED. 600 BUCKS. JUST SPENT 500 ON NEW TIRES AND I STILL HEAR KNOCKING ON CONTROL ARM. LONG STORY SHORT....THE LOWER CONTROL ARMS WILL NEED TO BE REPLACE ON BOTH SIDES (FRONT), FOLLOWED BY HUB AND BEARING ON BOTH SIDES (FRONT), FOLLOWED BY AN ALIGNMENT OF THE VEHICLE. DOING RESEARCH ONLINE, THERE ARE HUNDREDS OF SPECIFIC COMPLAINTS DEALING WITH THE CONTROL ARM BUSHINGS AND/OR BEARINGS GOING BAD AT 15,000 MILES AND UP ON THE 03 GT PT CRUISER 2.4L. CHRYSLER DOES NOTHING FOR THE CONSUMER IN EVERY CASE HENCE THE COMPLAINTS TO FORUMS AND NHTSA.GOV. TO SAY THE LEAST, THIS SHOULD BE ADDRESSED DAIMLER CHRYSLER AND FIXED BY THEIR EXPENSE.

NHTSA complaint #10229461 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

PT CRUISER LOWER CONTROL ARM BUSHINGS NEED REPLACING AT 60K MILES. HAVE BEEN TOLD BY MECHANIC THAT THIS IS A COMMON PROBLEM WITH THIS MODEL AND COULD CAUSE LOSS OF CONTROL OF VEHICLE, ADDED WEAR TO BRAKES AND TIRES, SCRAPING OF FRONT END OF CAR ON PAVEMENT.

NHTSA complaint #10227143 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:WHEEL BEARING

I JUST FOUND OUT THAT I HAVE TO REPLACE BOTH THE RIGHT AND LEFT FRONT HUB BEARINGS ON MY 2003 PT CRUISER. THE DEALERSHIP IS CHARGING ME $600 TO DO THE JOB. I HAVE 69K MILES ON THE CAR AND CHRYSLER SAYS IT IS NORMAL WEAR AND TEAR AND IS NOT COVERED UNDER THE 7/70K WARRANTY....SO I SEARCHED THE INTERNET AND TO MY SURPRISE I FOUND OUT I AM NOT THE ONLY PT CRUISER OWNER WITH THIS PROBLEM....I SEARCHED FOR FRONT HUB BEARINGS FOR A PT CRUISER AND FOUND MANY COMPLAINTS ABOUT THE DEFECTIVE BEARINGS....THE BEARINGS ARE SUPPOSED TO BE A SEALED BEARING AND NEVER REQUIRE MAINTENANCE....THIS IS A SAFETY ISSUE AND NEEDS TO BE ADDRESSED BY CHRYSLER BY ISSUING A RECALL AND PAY TO FIXED THE PROBLEM...AND REPAY THE CUSTOMERS WHO HAD TO HAVE THE BEARINGS REPLACED.... THE DEALERSHIP EVEN STATED TO ME THAT IT WAS A SAFETY HAZARD AND THE BEARINGS NEEDED REPLACEMENT....WITH ONLY 69K MILES ON THE CAR AND OTHERS WITH FEWER MILES THIS SHOULD NOT HAPPEN ON A NEW CAR...MYSELF AND MY FAMILY WAS NOT INJURED BY AN ACCIDENT , BUT I WONDER HOW MANY PEOPLE HAVE BEEN INJURED FROM THIS DEFECT???....ANY HELP WOULD GREATLY BE APPRECIATED....THANK YOU MICHAEL G KELLY

NHTSA complaint #10218524 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:WHEEL BEARING

BOTH FRONT BEARINGS FAILING IN 2003 PT CRUISER...HAVE BEEN GETTING PROGRESSIVELY WORSE OVER THE PAST YEAR.

NHTSA complaint #10217461 — an unverified report by a vehicle owner.

SUSPENSION

I READ ON THE INTERNET THAT A GREAT DEAL OF OWNERS OF CHRYSLER PT CRUISERS HAVE HAD PROBLEMS SIMILAR TO MINE. MY 2003 HAS ONLY 50,000 KM. (NOT MILES) AND I HAVE TO REPLACE THE WHEEL BEARINGS. THIS SEEMS MUCH TOO SOON TO REPLACE SUCH AN ITEM.

NHTSA complaint #10216914 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:WHEEL BEARING

FRONT WHEEL BEARINGS FAILED AT 71,000 MILES.

NHTSA complaint #10215439 — an unverified report by a vehicle owner.

SUSPENSION

2003 CHRYSLER PT CRUISER WITH DEFECTED CONTROL ARM BUSHINGS. CONSUMER STATED THAT THE BUSHINGS ARE WEARING PREMATURELY. *KB THE CONSUMER STATED HE HAS HAD PROBLEMS WITH THE TRANSMISSION, STEERING COLUMN, FRONT BEARING AND WATER PUMP.

NHTSA complaint #10212754 — an unverified report by a vehicle owner.

SUSPENSION

I WENT TO HAVE MY BRAKES CHECKED AND WAS TOLD MY RIGHT AND LEFT LOWER CONTROL ARM BUSHINGS WERE BROKEN. I TOOK THE CAR TO THE DEALERSHIP (TOWED IN BECAUSE THE TRANSMISSION WENT OUT) AND THE BUSHINGS WERE REPLACED. THE MECHANIC SAID HE HAS VERY SELDOM SEEN BUSHINGS IN THE SUSPENSION BREAK WITH ONLY 60,000 MILES ON THE CAR. MY CAR IS A 2003 CHRYSLER PT CRUISER. I COMPLAINED NUMEROUS TIMES ABOUT THE TRANSMISSION BUT WAS NOT ACKNOWLEDGED UNTIL THE CAR WAS INOPERABLE. I AM QUITE HAPPY THAT THE MECHANIC WHO DOES MY BRAKES NOTICED THE CONTROL ARMS. I ASKED CHRYSLER TO CHECK THEM WHILE MY TRANSMISSION WAS BEING REPAIRED, IF NOT, THEY WOULD NEVER HAVE CHECKED. THE SUSPENSION IS OF COURSE, NOT COVERED BY THE WARRANTY ANY LONGER. REPAIR COSTS WERE NEARLY $600.

NHTSA complaint #10172488 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

PT CRUISER LOWER CONTROL ARM BUSHINGS SHOT WITH ONLY 32000 MILES. THIS IS A COMMON PROBLEM. A DEFECT IN THE BUSHING MATERIAL IS SUSPECT AND FAILURE CAN LEAD TO LOSS OF CONTROL.

NHTSA complaint #10170718 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

I HAVE A 2003 PT CRUISER THAT JUST WENT OUT OF POWER TRAIN WARRANTY 7K MILES AGO-WITH NO WARNING, NO HESITATION, LACK OF POWER, MY TRANSMISSION WENT OUT TAKING THE CONVERTER, PUMP AND TORQUE CONVERTER-LEAVING ME STRANDED IN THE MIDDLE OF A BUSY INTERSECTION! I WAS NOT ABLE TO MOVE IN 1,2,3,D OR R-NOW I AM STUCK WITH A $2643.50 BILL. MY RIGHT FRONT TIRE CONSTANTLY VIBRATES, BEEN TO SHOP NUMEROUS TIME TO RESOLVE BUT NO BODY CAN FIND ANYTHING-TIRES ARE FINE, CV JOINT, NOTHING CAN BE FOUND. I AM ABSOLUTELY TERRIFIED TO DRIVE THIS CAR ANYMORE-MY SEAT BELT UNBUCKLES BY ITSELF, POSSIBLY LEAVING ME WITH NO RESTRAINT IN THE POSSIBILITY OF A WRECK. I AM FILING COMPLAINTS WITH CHRYSLER, BBB, DISTRICT ATTORNEYS OFFICE, NHTS, LEMON LAW AND ANYTHING ELSE I CAN FIND-

NHTSA complaint #10162940 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

DT*: THE CONTACT STATED A KNOCKING SOUND IS HEARD WHEN THE VEHICLE IS PLACED INTO REVERSE, OR WHEN A STOP, AND THEN PLACED INTO PARK. THE SOUND IS COMING FROM THE DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE STALLS AFTER EACH START AND HAS TO BE RESTARTED. THE DEALERSHIP DETERMINED THE LOWER CONTROL ARMS AND THE SKIM MODEL IN THE COMPUTER WAS DEFECTIVE AND NEEDS TO BE REPLACED. UPDATED 07/05/06.

NHTSA complaint #10159226 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:WHEEL BEARING

DT*: THE CONTACT STATED A NOISE WAS COMING FROM THE FRONT END WHILE DRIVING STRAIGHT. AN INDEPENDENT REPAIR SHOP DETERMINED THE RIGHT FRONT WHEEL BEARING NEEDED TO BE REPLACED. UPDATED 2/28/2006 -

NHTSA complaint #10148752 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

REAR BUSHING ON FRONT-RIGHT AND LEFT LOWER CONTROL ARM OF SUSPENSION FAILED AT APPROXIMATELY 65,000 MILES, CAUSING SLOP IN CONTROL ARM, WHEEL CAMBER TO VARY DURING OPERATION AND AUTO TO TEND TO WANDER ON ROAD (ALONG WITH THE SOUND OF METAL-TO-METAL CONTACT IN THE SUSPENSION). DC DEALER REFUSED TO COVER REPLACEMENTS AS A DEFECTIVE BUSHING (OUT OF WARRANTY) AND ADVISED ME ON 1/20/06 THAT THE PART IS CURRENTLY UNAVAILABLE - ON BACK ORDER - 7,500 UNITS ON ORDER FROM SUPPLIER. I AM VERY CONCERNED THAT THIS IS A POTENTIALLY WIDE-SPREAD FAILURE OF THIS BUSHING WITH THE RESULTANT LOSS OF STEERING CONTROL DUE TO CAMBER CHANGES DURING OPERATION. - I HAVE ALSO BEEN INFORMED THAT THIS FAILURE CAN LEAD TO DAMAGE TO THE WATTS LINKAGE IN THE DRIVE TRAIN, AND EXCESSIVE WEAR OF TIRES.

NHTSA complaint #10148530 — an unverified report by a vehicle owner.

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

REAR BUSHING ON FRONT-RIGHT LOWER CONTROL ARM OF SUSPENSION FAILED AT APPROXIMATELY 35,000 MILES, CAUSING SLOP IN CONTROL ARM, WHEEL CAMBER TO VARY DURING OPERATION AND AUTO TO TEND TO WANDER ON ROAD (ALONG WITH THE SOUND OF METAL-TO-METAL CONTACT IN THE SUSPENSION). THE BUSHING WAS REPLACED BY DEALER UNDER WARRANTY AT THAT TIME. AT 64,000 MILES 1/10/06) THE REAR BUSHING ON FRONT-LEFT LOWER CONTROL ARM OF SUSPENSION FAILED CAUSING SIMILAR PROBLEMS. I THEN INSPECTED THE REAR BUSHING ON THE RIGHT SIDE THAT WAS REPLACED AT 35,000 MILES AND DETERMINED THAT IT IS SHOWING INDICATIONS OF BEGINNINGS OF ANOTHER FAILURE. DC DEALER REFUSED TO COVER LEFT SIDE AS A DEFECTIVE BUSHING (OUT OF WARRANTY) AND ADVISED ME ON 1/16/06 THAT THE PART IS CURRENTLY UNAVAILABLE - ON BACK ORDER - 7,500 UNITS ON ORDER FROM SUPPLIER. I AM VERY CONCERNED THAT THIS IS A POTENTIALLY WIDE-SPREAD FAILURE OF THIS BUSHING WITH THE RESULTANT LOSS OF STEERING CONTROL DUE TO CAMBER CHANGES DURING OPERATION.

NHTSA complaint #10148017 — an unverified report by a vehicle owner.