Owners have filed 244 complaints
about the 2005 Chrysler PT Cruiser with NHTSA between 2004 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 6 of 10 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 36
Against the median year of the Chrysler PT Cruiser. 50 means typical for this
model; 100 means roughly double.
Severity — 89
17.2% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 52
30% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2005 compares with every other Chrysler PT Cruiser
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Glass, Side/Rear
721.9%
Engine
618.8%
Front
515.6%
Wheel Bearing
39.4%
Cooling System
39.4%
Body
39.4%
Frontal
39.4%
Switch
26.3%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
136.3%
1,000 – 9,999 miles
125.8%
10,000 – 24,999 miles
2311.1%
25,000 – 49,999 miles
3416.4%
50,000 – 74,999 miles
5124.6%
75,000 – 99,999 miles
2813.5%
100,000 – 149,999 miles
3416.4%
150,000+ miles
125.8%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Frontal crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2005 Chrysler PT Cruiser 4-DR.
—
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jul 2004peak 7Feb 2026
NHTSA investigations into the 2005 Chrysler PT Cruiser
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA07004Opened 16 Feb 2007Closed 5 Apr 2007VISIBILITY:GLASS, SIDE/REAR
REAR QUARTER PANEL GLASS SEPARATION
DAIMLERCHRYSLER CORPORATION (DCC) WILL RECALL MODEL YEAR 2005 AND 2006 PT CRUISER VEHICLES PRODUCED FROM 5/17/05 THROUGH 9/1/05 TO CORRECT A POTENTIAL DEFECT IN THE REAR QUARTER PANEL GLASS THAT MAY SEPARATE FROM THE VEHICLE.DCC WILL INSPECT THE REAR QUARTER PANEL GLASS AND REPLACE IF NECESSARY.DCC WILL BEGIN NOTIFYING OWNERS IN MAY 2007. VEHICLES PRODUCED PRIOR TO AND AFTER THE ABOVE BUILD DATES ARE NOT AFFECTED.A CHANGE MADE BY THE ASSEMBLY PLANT IN MAY 2005 THAT MODIFIED THE GLASS ATTACHMENT LED TO THE POTENTIAL FOR GLASS SEPARATION.IN SEPTEMBER 2005, SUBSEQUENT CHANGES TO THE PROCESS WERE...
PE04028Opened 15 Mar 2004Closed 18 Jun 2004STEERING
ENGINE COMPARTMENT FIRES
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL C...
Recalls on the 2005 Chrysler PT Cruiser
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
09E012000
EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
08E033000
SUSPENSION
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
Risk: THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
07V149000
VISIBILITY:GLASS, SIDE/REAR
ON CERTAIN PASSENGER VEHICLES, THE REAR QUARTER GLASS ATTACHING FASTENERS MAY PULL THROUGH THEIR MOUNTS AND ALLOW THE GLASS TO SEPARATE FROM THE VEHICLE.
Risk: IF THE GLASS SEPARATES WHILE DRIVING, IT COULD STRIKE ANOTHER VEHICLE OR INJURE A PEDESTRIAN.
04V481000
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKING SYSTEM (ABS), 2.4L HIGH OUTPUT TURBOCHARGED ENGINE, AND 5-SPEED MANUAL TRANSAXLE, MAY EXHIBIT INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE TRANSAXLE HOUSING.
Risk: CONTACT BETWEEN THE BRAKE TUBE AND THE TRANSAXLE HOUSING OVER AN EXTENDED PERIOD OF TIME MAY EVENTUALLY LEAD TO PERFORATION OF THE BRAKE TUBE, WHICH COULD LEAD TO A LOSS OF BRAKING FORCE IN THE LEFT FRONT/RIGHT REAR CIRCUIT OF VEHICLE.
04V268000
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Risk: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20194205,327 units in Canada
Other
Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
Recall 20071112,689 units in Canada
Other
On certain vehicles, the rear quarter glass attaching fasteners may pull through their mounts and allow the glass to separate from the vehicle. If the glass separates while driving, it could strike another vehicle and cause a crash. Correction: Dealers will replace the rear quarter glass.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 78,000 milesDeltona, FLCrash1 injured
AIR BAGS
RECENTLY IN A ACCIDENT, TRAVELING AT SPEED THAT IMPACTED FOUR OTHER VEHICLES. THE AIRBAG S DID NOT GO OFF.*DT
NHTSA complaint #11270843 — an unverified report by a vehicle owner.
at 145,000 milesMansfield, OHFire
ELECTRICAL SYSTEM
TL-THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. STARTED THE VEHICLE AND THE VEHICLE STALLED. FUEL ODOR, VEHICLE WOULD NOT START FOR AN ADDITIONAL HOUR VEHICLE RESTARTED AND CAUGHT ON FIRE, FIRE DEPARTMENT STATED THAT THE FIRE STARTED ALONG THE FIREWALL MANUFACTURER NOT CONTACTED, FIRE REPORT FILED, FIRE EXTINGUISHED BY FIRE DEPARTMENT STATED THAT UPON START UP THE VEHICLE STALLED. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR. THE VEHICLE WAS THEN RESTARTED ALMOST AN HOUR LATER. THE CONTACT THEN NOTICED FIRE COMING FROM UNDER THE HOOD OF THE VEHICLE ON THE PASSENGER'S SIDE OF THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THE FIRE MARSHALL STATED THAT THE FIRE SEEMED TO HAVE ORIGINATED IN A WIRING HARNESS INSTALLED BEHIND THE FUEL LINES FOR THE FUEL INJECTORS. THERE WAS NO INJURIES SUSTAINED IN THE FIRE. THE VEHICLE REMAINED AT THE RESIDENCE. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. THE VIN WAS NOT AVAILABLE. PIIR = Y. AH *DT
NHTSA complaint #11207986 — an unverified report by a vehicle owner.
at 145,000 milesMansfield, OHFire
ENGINE
TL-THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. STARTED THE VEHICLE AND THE VEHICLE STALLED. FUEL ODOR, VEHICLE WOULD NOT START FOR AN ADDITIONAL HOUR VEHICLE RESTARTED AND CAUGHT ON FIRE, FIRE DEPARTMENT STATED THAT THE FIRE STARTED ALONG THE FIREWALL MANUFACTURER NOT CONTACTED, FIRE REPORT FILED, FIRE EXTINGUISHED BY FIRE DEPARTMENT STATED THAT UPON START UP THE VEHICLE STALLED. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR. THE VEHICLE WAS THEN RESTARTED ALMOST AN HOUR LATER. THE CONTACT THEN NOTICED FIRE COMING FROM UNDER THE HOOD OF THE VEHICLE ON THE PASSENGER'S SIDE OF THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THE FIRE MARSHALL STATED THAT THE FIRE SEEMED TO HAVE ORIGINATED IN A WIRING HARNESS INSTALLED BEHIND THE FUEL LINES FOR THE FUEL INJECTORS. THERE WAS NO INJURIES SUSTAINED IN THE FIRE. THE VEHICLE REMAINED AT THE RESIDENCE. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. THE VIN WAS NOT AVAILABLE. PIIR = Y. AH *DT
NHTSA complaint #11207986 — an unverified report by a vehicle owner.
at 145,000 milesMansfield, OHFire
FUEL/PROPULSION SYSTEM
TL-THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. STARTED THE VEHICLE AND THE VEHICLE STALLED. FUEL ODOR, VEHICLE WOULD NOT START FOR AN ADDITIONAL HOUR VEHICLE RESTARTED AND CAUGHT ON FIRE, FIRE DEPARTMENT STATED THAT THE FIRE STARTED ALONG THE FIREWALL MANUFACTURER NOT CONTACTED, FIRE REPORT FILED, FIRE EXTINGUISHED BY FIRE DEPARTMENT STATED THAT UPON START UP THE VEHICLE STALLED. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR. THE VEHICLE WAS THEN RESTARTED ALMOST AN HOUR LATER. THE CONTACT THEN NOTICED FIRE COMING FROM UNDER THE HOOD OF THE VEHICLE ON THE PASSENGER'S SIDE OF THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THE FIRE MARSHALL STATED THAT THE FIRE SEEMED TO HAVE ORIGINATED IN A WIRING HARNESS INSTALLED BEHIND THE FUEL LINES FOR THE FUEL INJECTORS. THERE WAS NO INJURIES SUSTAINED IN THE FIRE. THE VEHICLE REMAINED AT THE RESIDENCE. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. THE VIN WAS NOT AVAILABLE. PIIR = Y. AH *DT
NHTSA complaint #11207986 — an unverified report by a vehicle owner.
Snyder, OKFire
ENGINE
TL* THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. APPROXIMATELY TEN MINUTES AFTER PARKING AND TURNING OFF THE VEHICLE, IT CAUGHT ON FIRE. THE CONTACT NOTICED SMOKE AND FLAMES UNDER THE FRONT DRIVER'S SIDE OF THE VEHICLE WHERE THE ENGINE WAS LOCATED. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED AT THE SCENE. THE VEHICLE WAS DESTROYED AND TOWED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS INVALID.
NHTSA complaint #11124347 — an unverified report by a vehicle owner.
at 106,000 milesCanton, MIFire
EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. WHILE THE VEHICLE WAS STATIONARY, THE CONTACT NOTICED SMOKE COMING FROM THE ROOT OF THE TURN SIGNAL SWITCH. THE CONTACT IMMEDIATELY PULLED THE FOG LAMP SWITCH, WHICH DIFFUSED THE SMOKE. A POLICE REPORT WAS NOT FILED. THE CONTACT STATED THAT THE FOG LIGHTS WERE ILLUMINATED AT THE TIME OF THE FAILURE. AN UNKNOWN CHRYSLER DEALER WAS MADE AWARE OF THE FAILURE, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 106,000.
NHTSA complaint #11114205 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 71,000 milesWheaton, IL
STEERING
The contact owns a 2005 Chrysler PT Cruiser. The contact stated that while the vehicle was at the dealer for a service appointment, the contact was informed that the power steering fluid hose was leaking. The contact stated that at that time, it was a small leak; however, the power steering fluid hose then developed a severe leak. The vehicle was taken to the dealer; however, the vehicle was not inspected. The contact was informed that a diagnostic test needed to be performed. The contact declined to pay for a diagnostic test. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The contact referenced an unknown recall with a similar failure however, the VIN was not under recall. The failure mileage was approximately 71,000.
NHTSA complaint #11719373 — an unverified report by a vehicle owner.
Dallas, TX
UNKNOWN OR OTHER
Unknown went to get an inspection and I got a paper with information for how to search up if there was any recalls with my car and it has 5 recalls it said
NHTSA complaint #11674679 — an unverified report by a vehicle owner.
Rosendale,, NY
STEERING
The contact owns a 2005 Chrysler PT Cruiser. The contact stated while driving 30 MPH, the vehicle started shaking with and an abnormal odor emanating through the vents. Additionally, the steering wheel became firm. The vehicle was steered to the side of the road. The vehicle was towed to an independent mechanic where it was diagnosed that the power steering system needed to be repaired because the hose was disconnected. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage unknown.
NHTSA complaint #11620679 — an unverified report by a vehicle owner.
at 194,000 milesRosendale, NY
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
The contact owns a 2005 Chrysler PT Cruiser. The contact stated that while the A/C defroster was activated, there was no air blowing through the vents. The vehicle was taken to an independent mechanic where it was diagnosed that the blower motor needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 194,000.
NHTSA complaint #11620681 — an unverified report by a vehicle owner.
Chicago, IL
UNKNOWN OR OTHER
The car (manual 5-speed) has issues going into reverse and hits hard shifting into other gears. I see where online it shows this issue happened quite a bit with the 2002 PT Cruiser. I don't drive my care every day and I keep it maintained very well. I have not had any accidents in it so I believe this may also be a recall issue.
NHTSA complaint #11476715 — an unverified report by a vehicle owner.
Tacoma, WA
STEERING
I bought this car and seen online there was a safety recall for the power steering/hoses malfunctioning. This cars power steering is non-existent and WILL NOT HOLD any power steering fluid. I'd like to file for the recall. This makes my car dangerous to drive. It's my only transportation. Thanks! [XXX] [XXX] [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11422896 — an unverified report by a vehicle owner.
at 78,000 milesDeltona, FLCrash1 injured
AIR BAGS
RECENTLY IN A ACCIDENT, TRAVELING AT SPEED THAT IMPACTED FOUR OTHER VEHICLES. THE AIRBAG S DID NOT GO OFF.*DT
NHTSA complaint #11270843 — an unverified report by a vehicle owner.
at 100,000 milesLAS Vegas, NV
AIR BAGS
WHETHER IN MOTION OR STANDING STILL, TILT STEERING WHEEL CLAMPING MECHANISM HAS WORN THROUGH WIRES CONNECTED TO THE AIR BAG AND ITS WARNING SYSTEM, CREATING INTERMITTENT (SHORT?) FAILURE OF AIR BAG WARNING LIGHT, PRESENTING POSSIBILITY OF SUDDEN AIRBAG DEPLOYMENT WITHOUT WARNING. WHEN AIR BAG WARNING LIGHT IS OFF, HORN WILL NOT SOUND BUT VENTILATION FAN RUNS. WITH AIRBAG LIGHT ON, HORN WILL SOUND, BUT IF ACTIVATED, VENTILATION FAN STOPS RUNNING. MUST CONSTANTLY ADJUST STEERING WHEEEL TILT TO MAKE FAN RUN OR HONK HORN - CREATING A DISTRACTED DRIVING HAZARD.
NHTSA complaint #11267038 — an unverified report by a vehicle owner.
at 100,000 milesLAS Vegas, NV
STEERING
WHETHER IN MOTION OR STANDING STILL, TILT STEERING WHEEL CLAMPING MECHANISM HAS WORN THROUGH WIRES CONNECTED TO THE AIR BAG AND ITS WARNING SYSTEM, CREATING INTERMITTENT (SHORT?) FAILURE OF AIR BAG WARNING LIGHT, PRESENTING POSSIBILITY OF SUDDEN AIRBAG DEPLOYMENT WITHOUT WARNING. WHEN AIR BAG WARNING LIGHT IS OFF, HORN WILL NOT SOUND BUT VENTILATION FAN RUNS. WITH AIRBAG LIGHT ON, HORN WILL SOUND, BUT IF ACTIVATED, VENTILATION FAN STOPS RUNNING. MUST CONSTANTLY ADJUST STEERING WHEEEL TILT TO MAKE FAN RUN OR HONK HORN - CREATING A DISTRACTED DRIVING HAZARD.
NHTSA complaint #11267038 — an unverified report by a vehicle owner.
at 100,000 milesLAS Vegas, NV
ELECTRICAL SYSTEM
WHETHER IN MOTION OR STANDING STILL, TILT STEERING WHEEL CLAMPING MECHANISM HAS WORN THROUGH WIRES CONNECTED TO THE AIR BAG AND ITS WARNING SYSTEM, CREATING INTERMITTENT (SHORT?) FAILURE OF AIR BAG WARNING LIGHT, PRESENTING POSSIBILITY OF SUDDEN AIRBAG DEPLOYMENT WITHOUT WARNING. WHEN AIR BAG WARNING LIGHT IS OFF, HORN WILL NOT SOUND BUT VENTILATION FAN RUNS. WITH AIRBAG LIGHT ON, HORN WILL SOUND, BUT IF ACTIVATED, VENTILATION FAN STOPS RUNNING. MUST CONSTANTLY ADJUST STEERING WHEEEL TILT TO MAKE FAN RUN OR HONK HORN - CREATING A DISTRACTED DRIVING HAZARD.
NHTSA complaint #11267038 — an unverified report by a vehicle owner.
at 145,000 milesMansfield, OHFire
ELECTRICAL SYSTEM
TL-THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. STARTED THE VEHICLE AND THE VEHICLE STALLED. FUEL ODOR, VEHICLE WOULD NOT START FOR AN ADDITIONAL HOUR VEHICLE RESTARTED AND CAUGHT ON FIRE, FIRE DEPARTMENT STATED THAT THE FIRE STARTED ALONG THE FIREWALL MANUFACTURER NOT CONTACTED, FIRE REPORT FILED, FIRE EXTINGUISHED BY FIRE DEPARTMENT STATED THAT UPON START UP THE VEHICLE STALLED. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR. THE VEHICLE WAS THEN RESTARTED ALMOST AN HOUR LATER. THE CONTACT THEN NOTICED FIRE COMING FROM UNDER THE HOOD OF THE VEHICLE ON THE PASSENGER'S SIDE OF THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THE FIRE MARSHALL STATED THAT THE FIRE SEEMED TO HAVE ORIGINATED IN A WIRING HARNESS INSTALLED BEHIND THE FUEL LINES FOR THE FUEL INJECTORS. THERE WAS NO INJURIES SUSTAINED IN THE FIRE. THE VEHICLE REMAINED AT THE RESIDENCE. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. THE VIN WAS NOT AVAILABLE. PIIR = Y. AH *DT
NHTSA complaint #11207986 — an unverified report by a vehicle owner.
at 145,000 milesMansfield, OHFire
ENGINE
TL-THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. STARTED THE VEHICLE AND THE VEHICLE STALLED. FUEL ODOR, VEHICLE WOULD NOT START FOR AN ADDITIONAL HOUR VEHICLE RESTARTED AND CAUGHT ON FIRE, FIRE DEPARTMENT STATED THAT THE FIRE STARTED ALONG THE FIREWALL MANUFACTURER NOT CONTACTED, FIRE REPORT FILED, FIRE EXTINGUISHED BY FIRE DEPARTMENT STATED THAT UPON START UP THE VEHICLE STALLED. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR. THE VEHICLE WAS THEN RESTARTED ALMOST AN HOUR LATER. THE CONTACT THEN NOTICED FIRE COMING FROM UNDER THE HOOD OF THE VEHICLE ON THE PASSENGER'S SIDE OF THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THE FIRE MARSHALL STATED THAT THE FIRE SEEMED TO HAVE ORIGINATED IN A WIRING HARNESS INSTALLED BEHIND THE FUEL LINES FOR THE FUEL INJECTORS. THERE WAS NO INJURIES SUSTAINED IN THE FIRE. THE VEHICLE REMAINED AT THE RESIDENCE. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. THE VIN WAS NOT AVAILABLE. PIIR = Y. AH *DT
NHTSA complaint #11207986 — an unverified report by a vehicle owner.
at 145,000 milesMansfield, OHFire
FUEL/PROPULSION SYSTEM
TL-THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. STARTED THE VEHICLE AND THE VEHICLE STALLED. FUEL ODOR, VEHICLE WOULD NOT START FOR AN ADDITIONAL HOUR VEHICLE RESTARTED AND CAUGHT ON FIRE, FIRE DEPARTMENT STATED THAT THE FIRE STARTED ALONG THE FIREWALL MANUFACTURER NOT CONTACTED, FIRE REPORT FILED, FIRE EXTINGUISHED BY FIRE DEPARTMENT STATED THAT UPON START UP THE VEHICLE STALLED. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR. THE VEHICLE WAS THEN RESTARTED ALMOST AN HOUR LATER. THE CONTACT THEN NOTICED FIRE COMING FROM UNDER THE HOOD OF THE VEHICLE ON THE PASSENGER'S SIDE OF THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THE FIRE MARSHALL STATED THAT THE FIRE SEEMED TO HAVE ORIGINATED IN A WIRING HARNESS INSTALLED BEHIND THE FUEL LINES FOR THE FUEL INJECTORS. THERE WAS NO INJURIES SUSTAINED IN THE FIRE. THE VEHICLE REMAINED AT THE RESIDENCE. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. THE VIN WAS NOT AVAILABLE. PIIR = Y. AH *DT
NHTSA complaint #11207986 — an unverified report by a vehicle owner.
Snyder, OKFire
ENGINE
TL* THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. APPROXIMATELY TEN MINUTES AFTER PARKING AND TURNING OFF THE VEHICLE, IT CAUGHT ON FIRE. THE CONTACT NOTICED SMOKE AND FLAMES UNDER THE FRONT DRIVER'S SIDE OF THE VEHICLE WHERE THE ENGINE WAS LOCATED. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED AT THE SCENE. THE VEHICLE WAS DESTROYED AND TOWED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS INVALID.
NHTSA complaint #11124347 — an unverified report by a vehicle owner.
at 106,000 milesCanton, MIFire
EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. WHILE THE VEHICLE WAS STATIONARY, THE CONTACT NOTICED SMOKE COMING FROM THE ROOT OF THE TURN SIGNAL SWITCH. THE CONTACT IMMEDIATELY PULLED THE FOG LAMP SWITCH, WHICH DIFFUSED THE SMOKE. A POLICE REPORT WAS NOT FILED. THE CONTACT STATED THAT THE FOG LIGHTS WERE ILLUMINATED AT THE TIME OF THE FAILURE. AN UNKNOWN CHRYSLER DEALER WAS MADE AWARE OF THE FAILURE, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 106,000.
NHTSA complaint #11114205 — an unverified report by a vehicle owner.
at 106,000 milesCanton, MIFire
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. WHILE THE VEHICLE WAS STATIONARY, THE CONTACT NOTICED SMOKE COMING FROM THE ROOT OF THE TURN SIGNAL SWITCH. THE CONTACT IMMEDIATELY PULLED THE FOG LAMP SWITCH, WHICH DIFFUSED THE SMOKE. A POLICE REPORT WAS NOT FILED. THE CONTACT STATED THAT THE FOG LIGHTS WERE ILLUMINATED AT THE TIME OF THE FAILURE. AN UNKNOWN CHRYSLER DEALER WAS MADE AWARE OF THE FAILURE, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 106,000.
NHTSA complaint #11114205 — an unverified report by a vehicle owner.
at 85,000 milesFlagler Beach, FL
ELECTRICAL SYSTEM
CAR STALLS WHILE DRIVING. SOMETIMES WONT START.
NHTSA complaint #11102983 — an unverified report by a vehicle owner.
at 39,000 milesFort Lauderdale, FL
SUSPENSION
2005 CHRYSLER PT CRUISER. CONSUMER WRITES IN REGARDS TO THE FUEL LEAK LOCATION ON THE INLET NOZZLE FUEL TANK. *SMD THE DEALER STATED CHECK ENGINE LIGHT ON, CRACKED TRIM AROUND A/C UNIT, TRUNK WILL NOT STAY OPEN, FRONT BRAKES NEED REPLACING, AND REAR SHOCK NEED TO BE REPLACED.
NHTSA complaint #10919533 — an unverified report by a vehicle owner.
at 39,000 milesFort Lauderdale, FL
FUEL SYSTEM, GASOLINE
2005 CHRYSLER PT CRUISER. CONSUMER WRITES IN REGARDS TO THE FUEL LEAK LOCATION ON THE INLET NOZZLE FUEL TANK. *SMD THE DEALER STATED CHECK ENGINE LIGHT ON, CRACKED TRIM AROUND A/C UNIT, TRUNK WILL NOT STAY OPEN, FRONT BRAKES NEED REPLACING, AND REAR SHOCK NEED TO BE REPLACED.
NHTSA complaint #10919533 — an unverified report by a vehicle owner.
at 39,000 milesFort Lauderdale, FL
STRUCTURE:BODY:TRUNK LID
2005 CHRYSLER PT CRUISER. CONSUMER WRITES IN REGARDS TO THE FUEL LEAK LOCATION ON THE INLET NOZZLE FUEL TANK. *SMD THE DEALER STATED CHECK ENGINE LIGHT ON, CRACKED TRIM AROUND A/C UNIT, TRUNK WILL NOT STAY OPEN, FRONT BRAKES NEED REPLACING, AND REAR SHOCK NEED TO BE REPLACED.
NHTSA complaint #10919533 — an unverified report by a vehicle owner.
at 39,000 milesFort Lauderdale, FL
ENGINE AND ENGINE COOLING
2005 CHRYSLER PT CRUISER. CONSUMER WRITES IN REGARDS TO THE FUEL LEAK LOCATION ON THE INLET NOZZLE FUEL TANK. *SMD THE DEALER STATED CHECK ENGINE LIGHT ON, CRACKED TRIM AROUND A/C UNIT, TRUNK WILL NOT STAY OPEN, FRONT BRAKES NEED REPLACING, AND REAR SHOCK NEED TO BE REPLACED.
NHTSA complaint #10919533 — an unverified report by a vehicle owner.
at 39,000 milesFort Lauderdale, FL
STRUCTURE
2005 CHRYSLER PT CRUISER. CONSUMER WRITES IN REGARDS TO THE FUEL LEAK LOCATION ON THE INLET NOZZLE FUEL TANK. *SMD THE DEALER STATED CHECK ENGINE LIGHT ON, CRACKED TRIM AROUND A/C UNIT, TRUNK WILL NOT STAY OPEN, FRONT BRAKES NEED REPLACING, AND REAR SHOCK NEED TO BE REPLACED.
NHTSA complaint #10919533 — an unverified report by a vehicle owner.
at 39,000 milesFort Lauderdale, FL
SERVICE BRAKES
2005 CHRYSLER PT CRUISER. CONSUMER WRITES IN REGARDS TO THE FUEL LEAK LOCATION ON THE INLET NOZZLE FUEL TANK. *SMD THE DEALER STATED CHECK ENGINE LIGHT ON, CRACKED TRIM AROUND A/C UNIT, TRUNK WILL NOT STAY OPEN, FRONT BRAKES NEED REPLACING, AND REAR SHOCK NEED TO BE REPLACED.
NHTSA complaint #10919533 — an unverified report by a vehicle owner.
at 200,000 milesKennewick, WA
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. WHILE DRIVING 40 MPH, THE BRAKES FAILED AND THE BRAKE PEDAL BECAME STIFF. AFTER REMOVING PRESSURE FROM THE BRAKE PEDAL, THE VEHICLE ACCELERATED RAPIDLY WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. THE VIN WAS NOT AVAILABLE.
NHTSA complaint #11075818 — an unverified report by a vehicle owner.
at 200,000 milesKennewick, WA
SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. WHILE DRIVING 40 MPH, THE BRAKES FAILED AND THE BRAKE PEDAL BECAME STIFF. AFTER REMOVING PRESSURE FROM THE BRAKE PEDAL, THE VEHICLE ACCELERATED RAPIDLY WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. THE VIN WAS NOT AVAILABLE.
NHTSA complaint #11075818 — an unverified report by a vehicle owner.
