2003 Dodge RAM 1500 problems

AIR BAGS

The contact owns a 2003 Dodge Ram 1500. The contact stated that the vehicle was included in NHTSA Campaign Number: 15V312000 (Air Bags) however, the part to do the recall repair was unavailable. The vehicle was taken to the dealer to be repaired; however, the contact was informed that the part to do the recall repair was on back order. The contact stated that the New York State Department of Motor Vehicles(DMV) had placed a hold on the registration of the vehicle, preventing the contact from being able to operate the vehicle on public roadways. The contact stated that the manufacturer had failed to provide the remedy within a reasonable amount of time. The contact had not experienced a failure.

NHTSA complaint #11752418 — an unverified report by a vehicle owner.

SUSPENSION:REAR

The contact owns a 2003 Dodge Ram 1500. The contact stated that while the vehicle was being driven by a friend at 45 MPH, the rear axle detached. The driver was stranded by the roadside. The vehicle was towed to the driver's residence. There were no warning lights illuminated. An unknown local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 300,000.

NHTSA complaint #11716771 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2003 Dodge Ram 1500. The contact stated that the steering wheel and the front wheels were uncontrollable. While driving from Georgia to Memphis, there was an unknown object loose by the wheel. The ball joint suspension was replaced by an independent mechanic. The low tire pressure warning light was illuminated. The contact was unable to control the vehicle and had the vehicle towed to an unstated location. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 180,000.

NHTSA complaint #11704481 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2003 Dodge Ram 1500. The contact stated that the steering wheel and the front wheels were uncontrollable. While driving from Georgia to Memphis, there was an unknown object loose by the wheel. The ball joint suspension was replaced by an independent mechanic. The low tire pressure warning light was illuminated. The contact was unable to control the vehicle and had the vehicle towed to an unstated location. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 180,000.

NHTSA complaint #11704481 — an unverified report by a vehicle owner.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

The contact owns a 2003 Dodge Ram 1500. The contact stated that the steering wheel and the front wheels were uncontrollable. While driving from Georgia to Memphis, there was an unknown object loose by the wheel. The ball joint suspension was replaced by an independent mechanic. The low tire pressure warning light was illuminated. The contact was unable to control the vehicle and had the vehicle towed to an unstated location. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 180,000.

NHTSA complaint #11704481 — an unverified report by a vehicle owner.

SUSPENSION

Rear fenders are rusted such that wiring harness falls off from underside if fenders and rubs on tires. Middle of frame rusted through on right and left side and dealer's floor lift went about half-way through both sides when the technician. tried to raise truck to check wiring under truck. The lift only crunched about halfway through near the middle of the frame. That was the point when the technician noticed the truck was lifting unevenly and making a crunching sound when he started trying to lift it. He left the truck as it was - with two wheels on the floor and two wheels about an inch off the floor He hollered for th shop supervisor to look at, who came and got me in the waiting room to show me what happened. The dealership could not repair the frame, but said there was a welding shop a couple of miles away down a back road in Zachow, WI where I could safely drive to if I went really slow. I don't know when the frame started rusting or the date the dealer's hydraulic lift broke through the frame. The truck's rear fenders were starting to significantly rust when it was about 3-4 years old. It was purchased new. I don't know how badly the frame had rusted at that time. I'm fairly certain the truck had less that 100,000 miles on it when the dealer found that the frame was rusted through. It's 22 years old now and was bought new in 2003. It has 147,000 miles on it today. Assuming that the miles/year were roughly the same at 6,682, and the tail lights started acting "funny" (the reason we brought the truck to the dealership),happened the year after we bought our new 2013 Lund boat (2014), that would put the mileage on the truck at 73,502. This type of dangerous deterioration should not happen with a low-mileage vehicle like ours.

NHTSA complaint #11640702 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Rear fenders are rusted such that wiring harness falls off from underside if fenders and rubs on tires. Middle of frame rusted through on right and left side and dealer's floor lift went about half-way through both sides when the technician. tried to raise truck to check wiring under truck. The lift only crunched about halfway through near the middle of the frame. That was the point when the technician noticed the truck was lifting unevenly and making a crunching sound when he started trying to lift it. He left the truck as it was - with two wheels on the floor and two wheels about an inch off the floor He hollered for th shop supervisor to look at, who came and got me in the waiting room to show me what happened. The dealership could not repair the frame, but said there was a welding shop a couple of miles away down a back road in Zachow, WI where I could safely drive to if I went really slow. I don't know when the frame started rusting or the date the dealer's hydraulic lift broke through the frame. The truck's rear fenders were starting to significantly rust when it was about 3-4 years old. It was purchased new. I don't know how badly the frame had rusted at that time. I'm fairly certain the truck had less that 100,000 miles on it when the dealer found that the frame was rusted through. It's 22 years old now and was bought new in 2003. It has 147,000 miles on it today. Assuming that the miles/year were roughly the same at 6,682, and the tail lights started acting "funny" (the reason we brought the truck to the dealership),happened the year after we bought our new 2013 Lund boat (2014), that would put the mileage on the truck at 73,502. This type of dangerous deterioration should not happen with a low-mileage vehicle like ours.

NHTSA complaint #11640702 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

A few years ago, while driving down a rural road, I saw a tire rolling behind my truck. I stopped to remove it from the road and it turned out to be my spare tire.. The cross brace that is connected to the support cable rusted and folded to allow the tire to drop free. I replaced the cross brace and added heavy duty straps to be a backup support so as to assure this incident would not happen again. Last month my friend's son was injured due to an accident involving what appears to be a Pick-Up truck spare tire lost on a state highway. The tire size and a rusted cross brace led the responding police officer to conclude that it came from a Pick-up truck. Perhaps, pick up truck manufacturers should inspect and install a secondary/back up safety strap?

NHTSA complaint #11631953 — an unverified report by a vehicle owner.

STRUCTURE:BODY

The frame/chasis rusted through and dealer could not raise truck because lift went through frame. If it had not been noticed at dealership, we and others could have been killed if the frame had broken through on the highway. The dealership and repair shop can confirm. The box and other body components are severely rusted. The body around the gas filler cap is so rusty that I have to hold the gas dispenser just so as to prevent gas leakage from the filler apparatus going into the gas tank. The gas tank fell off the truck twice and the truck was towed into the dealer to be fixed. The truck has less than 150,000 miles, and was purchased new. The incidents occurred between 2004 and 2020 - approx. No police reports or injuries, but no help from dealer.

NHTSA complaint #11617781 — an unverified report by a vehicle owner.

TIRES:TEMPORARY/EMERGENCY SPARE TIRE

The contact owns a 2003 Dodge Ram 1500. The contact stated while driving 30 MPH, there was an abnormal thump, prompting the contact to look through the review mirror, where he observed that the spare tire was on the roadway. After a visual inspection, the contact observed that the spare tire hoist cable had detached, allowing the spare tire to fall from the spare tire compartment. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 99,600. The VIN was not available.

NHTSA complaint #11552042 — an unverified report by a vehicle owner.

AIR BAGS

The contact owns a 2003 Dodge Ram 1500. The contact stated that while driving at slow speeds, the driveshaft detached. Due to the failure, the gear oil and rear differential fluid leaked out of the vehicle. The contact was able to temporarily repair the driveshaft. The dealer and the manufacturer were notified of the failure but offered no assistance. Additionally, the VIN was included in NHTSA Campaign Number: 15V312000 (Air Bags) however, the contact was informed that due to a crack in the dashboard, he would be charged for the repair. The vehicle was not repaired. The failure mileage was approximately 230,000.

NHTSA complaint #11551048 — an unverified report by a vehicle owner.

POWER TRAIN:DRIVELINE:DRIVESHAFT

The contact owns a 2003 Dodge Ram 1500. The contact stated that while driving at slow speeds, the driveshaft detached. Due to the failure, the gear oil and rear differential fluid leaked out of the vehicle. The contact was able to temporarily repair the driveshaft. The dealer and the manufacturer were notified of the failure but offered no assistance. Additionally, the VIN was included in NHTSA Campaign Number: 15V312000 (Air Bags) however, the contact was informed that due to a crack in the dashboard, he would be charged for the repair. The vehicle was not repaired. The failure mileage was approximately 230,000.

NHTSA complaint #11551048 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

UNKNOWN Everything will stop operating as I'm driving and after coming to a stop will start Right back up. I had one repair shop tell me that it has something to do with the fuel but the problem continue, the second repair shop said it was a brain box issue, if this was safety issue or problem can I get reimbursed.

NHTSA complaint #11533960 — an unverified report by a vehicle owner.

POWER TRAIN

The driveshaft to pinion gear at the differential comes loose during normal driving. I have replaced the bit numerous times, but it keeps coming loose. There is a recall on same truck but different years. The exact problem the other Rams have is exact issue with mine. When it comes loose, the car grinds to a halt.

NHTSA complaint #11532408 — an unverified report by a vehicle owner.

AIR BAGS

The reason the owners of these Dodges is that the dealers break the already brittle dash boards and REFUSE to repair or replace the dashboard. So most wont have the recall performed. So until the dealers are forced to repair/replace the brittle dashes when they perform these recalls then people will not have it addressed. Also i have owned my Dodge since October 2022. Truck is registered with dodge on the website and yet to receive a recall notice in the mail. Now if i go and look it shows the recall on my truck but many do not register their vehicles with the manufacturers website. All in all the EXPENSIVE dashboards being broke by dealerships performing the recall is why owners wont go thru it. Many have paid thousands in getting the dashes fixed. Also id think brittle dashboards that turn sharp daggers would be a safety hazard as well but yet no recall. My dash is missing HUGE pieces. Leaving sharp jagged edges that will be knives in an accident. I mean if the dashes bust just by replacing an airbag inflator or just sun exposure. Imagine being in an accident.

NHTSA complaint #11531739 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The reason the owners of these Dodges is that the dealers break the already brittle dash boards and REFUSE to repair or replace the dashboard. So most wont have the recall performed. So until the dealers are forced to repair/replace the brittle dashes when they perform these recalls then people will not have it addressed. Also i have owned my Dodge since October 2022. Truck is registered with dodge on the website and yet to receive a recall notice in the mail. Now if i go and look it shows the recall on my truck but many do not register their vehicles with the manufacturers website. All in all the EXPENSIVE dashboards being broke by dealerships performing the recall is why owners wont go thru it. Many have paid thousands in getting the dashes fixed. Also id think brittle dashboards that turn sharp daggers would be a safety hazard as well but yet no recall. My dash is missing HUGE pieces. Leaving sharp jagged edges that will be knives in an accident. I mean if the dashes bust just by replacing an airbag inflator or just sun exposure. Imagine being in an accident.

NHTSA complaint #11531739 — an unverified report by a vehicle owner.

POWER TRAIN

Rear end of my ram 1500 pickup model year 2003 locked up doing 60 MPH on the interstate broke the drive shaft and the front of the rear end and yoke off. This is the third rear end I have put in this truck. This has been reported all over the internet thousands and thousands of times over about these Dodge ram 1500 pickup truck rear ends having catastrophic failure causing injury and near fatalities yet Chrysler Dodge Jeep still has not issued a recall for the 2003 model year ram 1500 rear end. It is the same exact rear end as the model year 2005 which has the same recall and other years that they have issued recalls for. I cannot understand how this has gone on for years with so many reports and incidences of this happening and still nothing being done of it. Again this is the third rear end I have put in my truck. My truck only has 120,000 miles on it first rear end went out well under 100,000 mi. It was also brought to the dealership to have pinion seal and nut fixed under warranty at 30,000 miles. I have paperwork proving that there was an issue starting at 30,000 miles with this truck. I really hope somebody will finally do something about this issue that has plagued hundreds of thousands of people and their trucks. A simple internet search will show thousands and thousands of people all having the same issues with their 2003 Dodge ram 1500 pickup trucks. You can see in two of the pictures the skid marks from the rear end locking up on the road and I buy a miracle manage to keep the truck from sliding into the guardrail next to it. The vehicle is currently on a car trailer at my house and can be inspected at any time as I do not have the money to put a fourth rear end to this vehicle at this time.

NHTSA complaint #11524773 — an unverified report by a vehicle owner.

AIR BAGS

The contact owned a 2003 Dodge Ram 1500. The contact received notification of NHTSA Campaign Number: 15V312000 (Air Bags) and requested to be removed from the recall distribution list as she no longer owns the vehicle. The local dealer and manufacturer were not contacted.

NHTSA complaint #11504037 — an unverified report by a vehicle owner.

AIR BAGS

THE PASSENGER AIRBAG INFLATOR HOUSING MAY RUPTURE, DUE TO EXCESSIVE INTERNAL PRESSURE, DURING NORMAL AIRBAG DEPLOYMENT EVENTS. THIS CONDITION IS MORE LIKELY TO OCCUR IF YOUR VEHICLE HAS BEEN EXPOSED TO HIGH LEVELS OF ABSOLUTE HUMIDITY FOR EXTENDED PERIODS OF TIME.

NHTSA complaint #11496490 — an unverified report by a vehicle owner.

AIR BAGS

Frame damage where steering box separates

NHTSA complaint #11476656 — an unverified report by a vehicle owner.