176 of the 1,136 complaints about the 2000 Ford Expedition are about the tires — 15% of everything reported for this model year. Half of the failures with a mileage on record happened before 52,000 miles.
176
Complaints
8
Crashes
2
Fires
5
Injuries
Filed with NHTSA, in their own words.
TIRES
THE TREAD IS SEPARATING FROM THE TIRE ON ALL FOUR TIRES. THERE IS ABOUT 30K ON THE TIRES WHICH HAVE A 70K MILE WARRANTY. THE SAME TIRE ALTHOUGH DIFFERENT SIZE ARE RECALLED FOR THE SAME ISSUE.
NHTSA complaint #10764017 — an unverified report by a vehicle owner.
TIRES
TL* THE CONTACT OWNS A 2000 FORD EXPEDITION EQUIPPED WITH GOOD YEAR TRACKER2 TIRES, SIZE: P265-70-R17 (SERIAL NUMBER: 48570555000). THE CONTACT STATED THAT ALL FOUR TIRES WOULD CONSTANTLY LOSE AIR, CAUSING THE TIRES TO BECOMES FLAT WITHOUT WARNING. THE TIRES WERE REPLACEMENT TIRES. THE VEHICLE WAS TAKEN TO A TIRE SHOP WHERE TWO TIRES WERE REPLACED, HOWEVER THE FAILURE ALSO OCCURRED WITH THE REPLACEMENT TIRES. THE TIRE FAILURE MILEAGE WAS 11,000 AND THE VEHICLE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 165,713. UPDATED 8/15/13 *CN THE CONSUMER STATED HE HAD TO REPLACE THE TIRES AFTER 1 1.2 YEARS. DURING THAT TIME PERIOD, SHE EXPERIENCED TEN TIRE INCIDENTS.
NHTSA complaint #10475023 — an unverified report by a vehicle owner.
TIRES
DRIVE A 2000 FORD EXPEDITION WITH YOKOHAMA GEOLANDER H/T S P265/70R17 AND HAD BLOWOUT OF ONE TIRE ON THE INSIDE SIDEWALL. EXTENDED OVER 15 INCHES AND WAS CLOSE TO THE RIM AS EVIDENCED IN MOST BLOWOUTS. THE CAR WAS PARKED FOR ABOUT 2 HOURS AFTER A TIRE ROTATION WHEN IT RUPTURED ABRUPTLY. RESULTED IN A TEAR OF ABOUT 12 INCHES AND THEN ENDED IN AN EXTENSION TO THE TREAD.
NHTSA complaint #10386094 — an unverified report by a vehicle owner.
TIRES
I WAS DRIVING 65 MPH ON THE FLORIDA TURNPIKE WHEN I HEARD A LOUD BANG FROM THE BACK OF MY 2000 FORD EXPEDITION. I LOOKED IN THE REARVIEW MIRROR TO SEE A TIRES ROLLING AND BEING TOSSED DOWN THE TURNPIKE WITH CARS TRYING TO DODGE THE TIRE. I THOUGHT I HAD JUST ROLLED OVER THE TIRE BUT WHEN I GOT HOME I LOOKED UNDER THE TRUCK AND NOTICED THE TIRE WAS GONE AND THE WINCH CABLE WAS BROKEN. LUCKILY NOBODY SEEMED TO GET HIT BY THE TIRE BUT I CAN'T BE SURE.
NHTSA complaint #10350254 — an unverified report by a vehicle owner.
TIRES
UNIT 1 WAS TRAVELING EASTBOUND ON THE OHIO TURNPIKE IN THE RIGHT LANE AT MILE POST 138. #1 WHILE SLOWING ITS SPEED CLAIMS THE RIGHT REAR TIRE BLEW OUT, CAUSING LOSS OF CONTROL, THE DRIVER STRUCK A CONCRETE DIVIDER.*CW LETTER UPDATED 03/18/10 *BF OHIO TRAFFIC CRASH REPORT # 10-0122-90.
NHTSA complaint #10319737 — an unverified report by a vehicle owner.
TIRES
WITH NO WARNING SPARE TIRE CABLE SNAPPED WHILE DRIVING DOWN ROAD CAUSING SPARE TIRE TO FALL OUT AND STRIKE REAR WHEEL OF VEHICLE, THEN FLEW OFF SIDE OF ROAD. DISCUSSION WITH FORD INDICATED THIS IS UNHEARD OF AND THEY WANTED $300+ TO REPAIR. DISCUSSIONS WITH MULTIPLE OTHER SHOPS (NOT FORD) INDICATE THIS DOES HAPPEN WITH THIS TYPE OF SPARE MOUNT. REPAIRS COMPLETED FOR UNDER $150. I AM CONCERNED THAT SPARE CAN COME OUT AND ONCE LOOSE HIT OTHER VEHICLES OR PROPERTY/PERSONS.
NHTSA complaint #10241991 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
WHILE TRAVELING SOUTH ON I-95 AT APPROX 65 MPH, THE PASSENGER RIGHT REAR TIRE FAILED. IT APPEARS THAT THE FAILURE MODE WAS TREAD SEPARATION/DETACHMENT. THE TREAD ENDED UP WRAPPED AROUND THE REAR AXLE. AT THE MOMENT OF THE FAILURE THE 2000 FORD EXPEDITION TORQUED HARD TO THE RIGHT, BUT CONTROL WAS MAINTAINED. FURTHER INFORMATION ON THIS INCIDENT IS THAT THE FAILED TIRE WAS A REPLACEMENT FOR A RECALL (NHTSA CAMPAIGN ID NUMBER: 02T012000) BY CONTINENTAL TIRE CO. AND REPLACED BY A FORD DEALERSHIP. THE FAILURE OF THE REPLACEMENT TIRE FITS THE EXACT DESCRIPTION AS STATED IN THE NHTSA INVESTIGATION REPORT.
NHTSA complaint #10208508 — an unverified report by a vehicle owner.
TIRES:SIDEWALL
TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. THE DRIVER FRONT, REAR AND THE PASSENGER SIDE FRONT AND REAR GOOD YEAR WRANGLER RTS TIRES HAD 2 INCH SPLITS IN THE SIDE WALL. THE DOT NUMBER WAS 4BCUC6WR0306. THEY WERE REPLACEMENT TIRES WITH APPROXIMATELY 35000 MILES ON THEM. THE TIRE SIZE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 95000.
NHTSA complaint #10205373 — an unverified report by a vehicle owner.
TIRES
4 NEW DUNLOP A/T RADIAL ROVER P255/70R16 109S M+S DOT PJCU 78HR TIRES BOUGHT FROM INTERNET SELLER DISCOUNT TIRE DIRECT INSTALLED ALSO BY DISCOUNT TIRE, HAMPTON, GEORGIA, SHIPPED FROM ARIZONA TO DISCOUNT TIRE IN HAMPTON, GEORGIA, ALL HAD DEFECT OF STEEL BELT INTERNAL SEPARATION (SOME CALLED TREAD SEPARATION) AFTER DRIVING ONLY ABOUT 30 MILES, ONE TIRE HAD SIDEWALL BLOW-OUT, PAPER THIN AT POINT OF DEFECT, RIDGE OF TREAD SEPARATION EASY TO SEE AND FEEL, OTHER 3 TIRES ALL HAD BELT SEPARATION, FELT AND SEEN BY A, B, J, L (DT EMPLOYEES) AND OTHERS, ALL AMAZED THAT ALL 4 TIRES HAD SAME DEFECT, OF DISCOUNT TIRE HAMPTON. DISCOUNT TIRE ADVISED BY ME TO NOTIFY DUNLOP, DUNLOP CALLED ONCE MONDAY BASICALLY ASKING FOR THE TIRE THAT BLEW OUT (DISCOUNT TIRE COULD NOT REACH ANYONE OVER WEEKEND AT DUNLOP). I HAVE THE TIRE THAT BLEW OUT AT MY HOME. I BELIEVE THESE TIRES SHOULD BE INVESTIGATED BY NHTSA IMMEDIATELY. DISCOUNT TIRE HAMPTON EMPLOYEES WERE GRACIOUS, RETAINED OTHER 3 TIRES, REPLACED WITH 4 KELLY TIRES.
NHTSA complaint #10176714 — an unverified report by a vehicle owner.
TIRES
I PURCHASED 4 GOODYEAR WRANGLER RT/S TIRES FROM DISCOUNT TIRE CO. ON 1/17/2005 THE TRUCK BEGAN TO SHAKE AND VIBRATE WHILE DRIVING AT HIGHWAY SPEED. I RETURNED THE TRUCK TO DISCOUNT THEY REBALANCED AND ROTATED THE TIRES AND INFORMED ME IF THE TRUCK CONTINUED TO VIBRATE TO TAKE IT TO THE DEALERSHIP BECAUSE IT MUST BE MECHANICAL. I RETURNED IT TO THE DEALERSHIP, THEY ALIGNED, AND ROADFORCE BALANCED THE TIRES. THEY FOUND THAT THEIR WAS A DEFECT IN THE TIRES BECAUSE TOO MUCH WEIGHT WAS NEEDED TO BALANCE THE TIRES. THEY RECOMMENDED THAT THE TIRES BE REPLACED. I RETURNED THE TRUCK TO DISCOUNT TIRE CO. THEY AGAIN DID NOT FIND A DEFECT IN THE TIRE. I THEN TOOK IT TO A THIRD PARTY BIG O TIRE CO. THEY INSPECTED THE TIRES AND FOUND A "HOP" IN THE REAR TIRES. IT WAS AGAIN RECOMMENDED TO REPLACE THE DEFECTED TIRES.
NHTSA complaint #10159381 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
OWN A 2000 FORD EXPEDITION (ORIGINAL OWNER) AND HAD TIRES REPLACED AS PART OF RECALL OF 2002. TIRES WERE REPLACED AT LOCAL FORD DEALERSHIP WITH GENERAL GRABBER AW P275/60/R17. RECENTLY I NOTICED "STEERING" AND "BUMPY" RIDE, SO I TOOK VEHICLE TO GET IT CHECKED OUT. MECHANIC SHOWED HOW ONE TIRE HAD "BOWED OUT" FEATURE AND EXPLAINED THAT THIS WAS A "TREAD SEPARATION" AND NEEDED TO BE REPLACED. REMEMBERING PRIOR RECALL FOR SAME REASON, WAS CONCERNED THIS WAS A POSSIBLE MANUFACTURER DEFECT. RESEARCHED ON INTERNET AND FOUND # TO CALL AT CONTINENTAL TO REPORT. CALLED AND SPOKE WITH "BILL" WHO RECORDED MY CONCERNS AND CREATED A FILE #22239. TOLD ME A COULD GO TO NATIONAL TIRE AND BATTERY AND HAVE IT CHECKED OUT. WENT TO NTB AND THE TECHNICIAN EXAMINED THE TIRE AND SAID HE COULD NOT PRORATE THE WARRANTY. I EXPLAINED THAT I JUST WANTED TO INFORM THE MANUFACTURER OF THE POSSIBILITY OF A MANUFACTURER DEFECT IN CASE THERE WERE OTHER COMPLAINTS FOR THE SAME TYPE OF TIRE. HE SAID THAT WITH THE APPARENT AGE OF THE TIRE IT COULD HAVE BEEN CAUSED BY A BUMP THAT HAD CAUSED THE WEAKNESS. MY EXPECTATIONS FOR A TIRE IS FOR THE TREAD TO WEAR OUT BEFORE ANY OTHER BREAKDOWN.
NHTSA complaint #10157833 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
2000 EXPEDITION TIRE TREAD SEPARATED. *TS
NHTSA complaint #10147591 — an unverified report by a vehicle owner.
TIRES
DT: 2000, FORD, EXPEDITION, VEHICLE WAS PARKED IN FRONT OF CONSUMER'S HOME WHEN IT CAUGHT ON FIRE, THE VEHICLE HAD NOT BEEN OPERATING SINCE THE PREVIOUS DAY, THE FIRE DEPARTMENT WAS NOTIFIED. FIRE INVESTIGATOR SAID THE CAUSE OF THE FIRE WAS CRUISE CONTROL DISCONNECT SWITCH, IN AUGUST OF 2004 CONSUMER TOOK THE VEHICLE TO THE FORD DEALER BECAUSE THE STEERING WHEEL WAS LOST WHICH CAUSED THE VEHICLE TO BE UNCONTROLLABLE, THE DEALER SAID IT WAS BECAUSE OF THE FRONT TIRES, THIS WAS THE ONLY PROBLEM CONSUMER HAD WITH THE VEHICLE UNTIL IT CAUGHT ON. FIRE, THE FIRE ALSO CAUSED DAMAGE TO CONSUMER' S HOME .
NHTSA complaint #10126224 — an unverified report by a vehicle owner.
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
SPARE TIRE EQUIPMENT FOR THE 2000 FORD EXPEDITION HAS A CUT IN THE SIDEWALL .*MR THE TIRE WAS NEW ORIGINAL EQUIPMENT AND WAS NEVER USED.
NHTSA complaint #10119146 — an unverified report by a vehicle owner.
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
I HAD PULLED UP IN MY DRIVEWAY AND THE SPARE TIRE JUST DROPPED OUT ON THE DRIVEWAY. I WAS CONCERNED WHAT MAY HAVE HAPPEND IF THIS WOULD HAVE HAPPEN WHILE DRIVING OUT ON THE HIGHWAY AND MY SPARE TIRE AND DROPPED OUT ON THE HIGHWAY, WHAT DAMAGE, INJURY OR EVEN DEATH THAT IT COULD HAVE CAUSED. I REPORTED THIS TO MY DEALERSHIP, AND THEY WAS NOT TO CONCERNED, THEY JUST TOLD ME WHAT IT WOULD COST TO REPLACE THE CABLE FOR THE SPARE TIRE HOLDER. I BELIEVE THIS IS REALLY A SAFETY FACTOR THAT SHOULD BE CORRECTED BY FORD.
NHTSA complaint #10117997 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
'RECALL CAMPAIGN' TREAD SEPARATION. CONSUMER CONTACTED THE DEALER WHO SOLD HIM THE TIRES. FOUND THAT THERE WAS A RECALL FOR CONTINENTAL, P275/60R17 0051612.*AK *BF WHILE DRIVING THE CONSUMER NOTICED A VIBRATION. THE VEHICLE WAS TAKEN TO HAVE AN ALIGNMENT WHEN HE WAS INFORMED THAT THE PASSENGER SIDE FRONT TIRE TREAD HAD SEPARATED AND THAT A SECOND TIRE WAS HAVING A SIMILAR PROBLEM. THE CONSUMER REPLACED THE TIRES AND LATER FOUND OUT THAT THEY WERE RECALLED. THE CONSUMER REQUEST REIMBURSEMENT FOR THE FAULTY TIRES.
NHTSA complaint #10113458 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
WHILE TRAVELING ON THE INTERSTATE AT 55 MPH, THE CONSUMER HEARD A NOISE, THEN SAW SMOKE COMING FROM THE REAR OF THE VEHICLE. SUDDENLY THE VEHICLE STARTED TO SHAKE, THE CONSUMER LOST CONTROL, VEERED OUT OF HIS LANE AND WENT TOWARDS A SERVICE STATION. TO KEEP FROM ENTERING THE STATION HE ROLLED OVER. THE CONSUMER SUSTAINED NECK AND MOUTH INJURIES. IT WAS DISCOVERED THAT THE TREAD HAD SEPARATED FROM THE TIRE. *AK *SC
NHTSA complaint #10113259 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
WHILE DRIVING 65 MPH CONSUMER HEARD A LOUD KNOCKING NOISE COMING FROM THE REAR. CONSUMER PULLED OVER, AND NOTICED THAT THE PASSENGER'S REAR TIRE TREAD WAS SEPARATING. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE TIRE NEEDED TO BE REPLACED.
NHTSA complaint #10105159 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
THE CONSUMER WAS DENIED REIMBURSEMENT FOR FAULTY TIRES BECAUSE THE PURCHASE DATE OF THE TIRES DID NOT FALL WITH THE PURCHASED DATE ALLOWED (CONTINENTAL TIRES).
NHTSA complaint #10009311 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
CONTINENTAL TIRE REIMBURSEMENT. THE CONSUMER EXPERIENCED TREAD SEPARATION ON THE RIGHT REAR TIRE. THE CONUMER PURCHASED HIS TIRES PRIOR TO THE RECALL.
NHTSA complaint #10009622 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
NAR 1/29/2003. THE CONSUMER REPLACED ALL 4 TIRES PRIOR TO THE RECALL DUE TO POOR TREAD WEAR. THE CONSUMER SUBMITTED ALL THE NECESSARY PAPERWORK AND WAS TOLD HE WOULD BE REIMBURSED, HOWEVER THERE HAS BEEN NO REFUND. 8JB
NHTSA complaint #10006039 — an unverified report by a vehicle owner.
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
DRIVING THRU A PARKING LOT WHILE GOING OVER A SPEED BUMP MY SPARE TIRE FELL OUT FROM UNDER MY FORD 2000 EXPEDITION CABLE BROKE ON WENCH. I AM NOW TALKING WITH DEALER FOR REPLACEMENT.I AM WORRIED THAT SAME THING CAN HAPPEN WITH NEW WENCH POSSIBLE ON FREEWAY.
NHTSA complaint #10098434 — an unverified report by a vehicle owner.
TIRES
NAR 05/21/2003. *MR` NEGLIGENT SERVICE ON RECALL TIRES. GENERAL GRABBER TIRES AW DOT ADT0044T109 THROUGH ADT044T4400 BEING RECALLED.
NHTSA complaint #10021566 — an unverified report by a vehicle owner.
TIRES
CONSUMER STATED THAT AFTER TAKING A TRIP VEHICLE VIBRATED AT HIGH SPEED. IT WAS DISCOVERED THAT ALL FOUR TIRES HAD CRACKS. THESE TIRES WERE PLACED ON THE VEHICLE AFTER THE FIRESTONE RECALL. THE DEALER STATED THAT THEY COULD NOT REPLACE THE TIRES.
NHTSA complaint #10087724 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
I HAD A TIRE SEPARATION WHILE DRIVING 70 MPH. PLEASE SEE TIRE RECALL CAMPAIGN NUMBER BELOW. TIRE RECALL CAMPAIGN ID NUMBER 02T012000 I HAVE 5 OF THESE TIRE ON MY 2000 EXPEDITION. ACCORDING TO FORD CUSTOMER RELATIONSHIP, MY VIN WAS NOT A PART OF A RECALL. THE TIRES, HOWEVER WERE. DOT NUMBERS WERE VERIFIED WITH CONTINENTAL. THERE WERE 596610 UNITS AFFECTED, YET FORD ONLY IS SHOWING APPROXIMATELY 500 VEHICLES WITH ONLY 300 ACTUALY QUALIFYING. THIS SEEMS LIKE A GAME TO ME AS THES FIVE TIRE WERE ORIGINALLY ON MY VEHICLE.
NHTSA complaint #10078281 — an unverified report by a vehicle owner.
TIRES
SINCE OWNING FIVE CONTINENTAL CONTI-TRAC TIRES, CONSUMER WAS SUBJECTED TO REPEATED FAILURE, UNSAFE TRAVELING CONDITION AND EXCESSIVE BURDEN DUE TO REPLACEMENT COSTS. *PH THERE WAS A REPEATED "TREAD SEPARATED" WITH THE NEW TIRES THAT WERE PLACED ON THE VEHICLE. FAILURE OCCURRED AGAIN IN MARCH 2004, TREAD SEPARATION. CONSUMER REQUEST A REFUND FOR THE REPLACEMENT COST OF FIVE TIRES.
NHTSA complaint #10071876 — an unverified report by a vehicle owner.
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
SPARE TIRE ASSEMBLY FAILED, CAUSING THE SPARE TIRE TO COME UNATTACHED.
NHTSA complaint #10061216 — an unverified report by a vehicle owner.
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
WITHOUT WARNING SPARE TIRE ASSEMBLY FAILED, CAUSING THE SPARE TIRE TO COME UNATTACHED FROM THE ASSEMBLY. DRIVER PULLED THE VEHICLE OVER TO GET THE SPARE TIRE FROM OUT OF THE STREET.
NHTSA complaint #10052004 — an unverified report by a vehicle owner.
TIRES:SIDEWALL
THE REPLACEMENT GOODYEAR TIRE ON THE PASSENGER REAR SIDE SIDEWALL BLEW OUT ON THE HIGHWAY .
NHTSA complaint #10047742 — an unverified report by a vehicle owner.
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
THE SPARE TIRE WHICH IS MOUNTED UNDER THE BODY OF MY 2000 FORD EXPEDITION FELL OFF WHILE I WAS ON AN ENTRANCE RAMP OF AN EXPRESSWAY. FORTUNATELY, THE ERRANT SPARE TIRE DID NOT HIT THE CARS BEHIND ME. THE TIRE WAS HELD BY A STEEL CABLE THAT BROKE. THIS IS A VERY SERIOUS SAFETY ISSUE THAT NEEDS TO BE ADDRESSED, AND NOT SWEPT UNDER THE RUG. THE LOCAL FORD DEALERSHIP WOULD NOT FIX IT WITHOUT PAYMENT. I NOTIFIED THE CORP CUSTOMER SERVICE DEPARTMENT FOR FORD. GOT THE RUNAROUND, AND WAS TOLD THAT THEY WOULD FORWARD TO THE ENGINEERING DEPT. I KNOW THAT THIS SAME ISSUE HAPPENED TO A FRIEND OF MINE. THIS IS A REAL SAFETY ISSUE.
NHTSA complaint #10047169 — an unverified report by a vehicle owner.