2015 Ford F-250 SD steering problems

STEERING

We were on vacation driving from [XXX] to [XXX] and experienced the Death Wobble. I though we were going to die. We stopped in [XXX] and took to a dealership there and they replaced the track ball joint for $757.59. We left there and 25 miles down the road it happened again. Went to [XXX] and they kept the truck and we had to rent a truck to continue our vacation. We rent back on our way back to [XXX] and they had replaced the steering stabilizer shock for $733.53 but we were afraid to drive home so we paid for it to be transported back to [XXX]. We had to pay $1414.00 to have it transported back but at least we made it back safe. Experiencing this death wobble 11 times as a passenger has given me PTSD. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11752194 — an unverified report by a vehicle owner.

STEERING

Death wobble

NHTSA complaint #11679054 — an unverified report by a vehicle owner.

STEERING

Entire vehicle shakes/wobbles extremely uncontrollably going a speed around 65; have to slow to avoid an accident and put on hazards. Makes our heart stop not knowing what danger we have been put in when it occurs. Very scary and DANGEROUS to ourselves and others. Occurs with roadways involving dips, highways, ridges of bridges such as bumps or gaps, and/or differences in road, etc. This has occurred multiple times. ([XXX]) was another episode. This is SCARY DANGEROUS! No lights or indications go off. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11678110 — an unverified report by a vehicle owner.

STEERING

Steering wheel shakes violently when going between 55 to 75 mph after hitting bump in road. Commonly known as the “death wobble”. Total loss of control.

NHTSA complaint #11660067 — an unverified report by a vehicle owner.

STEERING

At about 65-70 MPH, upon hitting an mildly rough spot on highway, my 2015 F250 started shaking violently: i.e better known as the Ford "Death Wobble."

NHTSA complaint #11650725 — an unverified report by a vehicle owner.

STEERING

Death wobble - on numerous occasions we have experienced the death wobble on our vehicle. We have complained to several dealers and done their recommended repairs. We have even purchased new high end tires as recommended with no resolution. We are unable to haul our RV out of fear of an accident. It has occurred at high speeds on the highway and at lower speeds on roads. This is very scary when it occurs. Coming to a full stop in a one lane HOV lane is not only dangerous for us but also dangerous for those traveling behind us. This has been occurring for years with the most recent occurrence this week. After researching we discovered this route to file a complaint.

NHTSA complaint #11633830 — an unverified report by a vehicle owner.

STEERING

While driving on interstate highway I hit a bump and the front end began to wobble until I could brake and stop I took it to my front end shop and spent ~ $2K Next trip after repair had same problem when I hit a bump. After two more returns to the same shop and almost all parts replaced the truck did it again last week This continued wobble could be deadly and needs to be fixed. I plan to call ford but cannot believe this is not a recall issue

NHTSA complaint #11620907 — an unverified report by a vehicle owner.

STEERING

[XXX] . My truck has started the death wobble. Driving on interstate and if I hit uneven paving steering wheel and front of truck shakes extremely rough, causing me to hit the breaksand bring my speed down to 40mph or less, In traffic is dangerous INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11617266 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2015 Ford F-250. The contact stated while driving and exceeding 60 MPH, while driving over a bump or pothole in the roadway, the vehicle started shaking violently in the front end. The driver depressed the brake pedal, and the vehicle decelerated to 30 MPH. There were no warning lights illuminated. The contact stated that the failure was related to Customer Satisfaction Program: 20N04. The local dealer was contacted, and the vehicle was diagnosed, and it was determined that the steering damper rod needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and informed the contact that there was no recall for the failure. The failure mileage was approximately 150,000.

NHTSA complaint #11614807 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2015 Ford F-250. The contact stated while driving 65 MPH, the vehicle experienced the death wobble, causing the contact to lose control of the vehicle. There was no warning light illuminated. The contact was able to regain control of the vehicle once the vehicle had slowed down. The contact stated that the violent shaking also ceased after slowing down. The vehicle was taken to a dealer where the tie rods and all four tires were replaced; however, the failure returned approximately 30,000 miles later. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 70,000.

NHTSA complaint #11608951 — an unverified report by a vehicle owner.

STEERING

I experienced what I now have come to understand is called the death wobble. It was terrifying and I was going about 60 mph on an interstate that was under construction. I hit minor bumps and the whole truck began to wobble back-and-forth violently. it would not stop until I came down to about 15 miles an hour, after that steering felt loose. I thought I was going to die. The incident chewed up my tires with pock marks everywhere.

NHTSA complaint #11599834 — an unverified report by a vehicle owner.

STEERING

Truck violently shakes (wobbles) when you go over 50 mph.

NHTSA complaint #11597331 — an unverified report by a vehicle owner.

STEERING

Today my 2015 Ford F250 SD experienced the aptly named Ford “Death Wobble”. It occurred twice today after just having the whole front end rebuilt for the same issue just weeks ago. My truck shakes so violently I am concerned for my safety and that of my wife. To stop the shaking I have to slow to 30 mph or less, typically on the highway where all other vehicles are traveling at 65+. The truck now sits at a dealership waiting for repair. The service writer states parts that were replaced two - three weeks ago are “shot”. How can this be? Ford F250’s have this as a known problem with no real fix. Just keep throwing parts at it with no resolve. I had the truck worked on in July ‘23, May ‘24 and now. I am invested heavily in this truck and have now had to replace parts multiple times because some design flaw keeps wearing them out. I’d love to see some sort of recall that forces some sort of redesign and real repair.

NHTSA complaint #11591670 — an unverified report by a vehicle owner.

STEERING

I experienced the “Ford Death Wobble” when on the highway at 70 MPH. It has happened three times now. It didn’t stop until I pulled off the road and stopped. It was an unsafe situation trying to get across three lanes of traffic and stop in the shoulder of the road. I did not loose control of the truck but it was close to being uncontrollable. From what I’ve read, this needs to be a Recalled item!!

NHTSA complaint #11580144 — an unverified report by a vehicle owner.

STEERING

On multiple occasions I have experienced the “F250 death wobble”. When reaching speeds of over 60 mph my front end and steering wheel start shaking violently. The entire truck is uncontrollable. It feels like the vehicle is going to shake apart. It is difficult to even hold onto the steering wheel and keep the vehicle going in a straight line. I have to slow down to about 30 mph on an interstate to make it stop, creating a dangerous situation. Sometimes I have to pull off the road. Often, when hitting a bump in the road it gets triggered. I’ve had it looked at multiple times at ford dealerships and nothing is ever found that is the cause of it. It’s extremely dangerous and there is no recall for this problem. Thankfully I have managed to keep control of the vehicle. I’ve experienced this problem for going on 3-5 years. I have replaced the front tires numerous times as that seems to help, though not eliminate the problem. Ford needs to do something about this with a recall or educating their service departments. There are tons of complaints online

NHTSA complaint #11579495 — an unverified report by a vehicle owner.

STEERING

While merging onto an interstate the truck began to violently shake causing me to begin to lose control. I was able to brake hard and pull off the road before I lost complete control. I was extremely upset after this event. After regaining composure on the side of an interstate I pulled back onto the interstate. Within the next 10 min I hit a bump in the middle of the interstate and the truck again began to shake violently. I thought I was going to lose control and crash. We immediately had the vehicle taken to a mechanic. The work they did cost 1300$. Approximately 2 weeks after getting the vehicle back I was driving over a bridge and the seam in the road again caused the truck to violently shake. Again feeling like I was going to lose control. I was able to brake hard and pull over on the side of a bridge. This caused significant trauma to myself and my young son. Since then the truck continues to violently shake anytime it’s driven over a bump or seam in the road even at slow rates of speed. We have taken the vehicle to the mechanic again and they have been unable to solve the issue

NHTSA complaint #11579241 — an unverified report by a vehicle owner.

STEERING

The truck experienced excessive shaking when it hit a bump in the road while driving on the interstate. The steering wheel rattled so badly that the truck was difficult to control or steer. The shaking was so severe, that it felt like we had been hit by another car or had a blown tire. The violent shaking occurred when driving at speeds over 50 miles per hour.

NHTSA complaint #11571086 — an unverified report by a vehicle owner.

STEERING

Since June of 2023 I have had instances of excessive wobbling of the front end of my truck. Severe to the point that I've almost lost control. Took it into the Ford dealership in July of 2023. Determined to be consistant with "Death Wobble." Extensive work done and then again in September of 2023. Took it in again. Additional work done by Ford. On October 31,2023 a reoccurance of wobble and taken into Ford. Today, 11/13/2023 Ford could not find any issues and told me to drive it and when it does it again, bring it back in. This is an accident waiting to happen and I'm at a loss.

NHTSA complaint #11554847 — an unverified report by a vehicle owner.

STEERING

The truck started jerking back and forth(left and right) while driving down the hwy at 70 mph, continued to do so at lower speeds as well. Safety was at risk as it was dark and the truck was jerking back and forth with passengers inside. It has not been inspected yet, it's Saturday night 9/16/2023 at 10:00 pm. No warning lights or alert sounds were activated. This has happened before but did not last as long and not near as violent. The problem seems to resolve it's self then occurs spontaneously days, sometimes minutes later.

NHTSA complaint #11544981 — an unverified report by a vehicle owner.

STEERING

When driving (Once going downhill 6% grade, several times driving level on the freeway and once on a 45 MPH road with ruts), the front end began shaking violently to the point I was losing control of the vehicle until I slowed down. The vehicle would be available for inspection upon request. Safety was impacted by the loss of control resulting from the vehicle violently shaking. I took the truck to a mechanic and he could not see any problems. Other than my mechanic, no one has inspected the vehicle. There were no warning lamps, messages, or symptoms prior to the event. I have dash cam video of the event.

NHTSA complaint #11542311 — an unverified report by a vehicle owner.

STEERING

Truck started to wobble/shake aggressively. Did some research and read about this situation called the “death wobble”. This is the second time it’s happened

NHTSA complaint #11542186 — an unverified report by a vehicle owner.

STEERING

My truck has what is known as the death wobble. I am having it repaired again because if I hit a bump while I'm driving down the road, it'll jerk over into other people's lanes almost hitting other cars. It's horrible this is the second or third time I've had to repair this and is a well-known issue between 2007 and 2019. Can something please be done about this? This is starting to get a little ridiculous that there's so many cars out there that are this unsaved over the fact that a company doesn't want to pay to fix them

NHTSA complaint #11524201 — an unverified report by a vehicle owner.

STEERING

This vehicle, like many others has a severe death wobble. I almost lost complete control of the vehicle on the freeway at 75MPH after hitting a pothole! I replaced tie rod ends and took it to the Ford dealer to have it aligned and had them check all other steering components. They only recommended new tires and said everything was tight and didn't need replacement. The tires have over 3/32's wear on them so they could have made it another summer before replacing them. It is at the dealer right now getting new tires but I am afraid this will not fix the actual problem. The problem had been reproduced at the dealer and the mechanic told me it was the worst one he has ever driven. This is a known vehicle defect and Ford will still not do anything to fix the issue since it has not been reported in new vehicles that are exactly the same. There were no messages or symptoms before this occurred and it was the scariest thing I have ever experienced. I am only a 118lb Female and it was almost impossible to control the vehicle

NHTSA complaint #11521568 — an unverified report by a vehicle owner.

STEERING

I drove thru a groove in the pavement at bridge at 60 MPH and it started shaking violently, I almost lost control of the truck.

NHTSA complaint #11515396 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2015 Ford F-250. The contact stated while driving 50-65 MPH, the vehicle experienced the death wobble, almost causing the contact to lose control of the vehicle. There was no warning light illuminated. The contact depressed the brake pedal and came a complete stop. The contact was able to continue driving; however, the failure reoccurred several times while driving. An unknown dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 92,000.

NHTSA complaint #11510996 — an unverified report by a vehicle owner.

STEERING

Truck will begin doing the Death Wobble on the highway with speeds around 60-65 mph. Cab and steering vibrate vigorously causing loss of steering control.

NHTSA complaint #11509295 — an unverified report by a vehicle owner.

STEERING

While driving between 50 and 60 mph the steering wheel begins to violently shake until you slow below 50 MPH. This is known as the Death Wobble.

NHTSA complaint #11499198 — an unverified report by a vehicle owner.

STEERING

I have experienced a "death wobble" on 2 occasions in 4 weeks. The truck's front end uncontrollably bounces when driving on the freeway causing me to have to immediately let off the gas and gently brake causing a dangerous situation not only for me and my family but potentially for others on the road.

NHTSA complaint #11496979 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2015 Ford F-250. The contact stated while driving approximately 65 MPH, the vehicle drove over a slight bump on the roadway and the steering wheel began to move left to right and the vehicle was shaking and unable to maintain a straight line in the lane. The contact stated he was not aware of any warning lights being illuminated. The contact pulled off the road and placed the vehicle in park(P) and waited with the engine running. The contact was able to drive the vehicle to a dealer. The dealer diagnosed the vehicle and determined that the ball joints and the steering dampener needed to be replaced. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 144,000.

NHTSA complaint #11496285 — an unverified report by a vehicle owner.

STEERING

When driving over speeds of 50mph or after driving over bumpy/ wavy roads, the truck starts shaking violently. It was bouncing so hard it almost shook the steering wheel out of my hands. I had to completely stop and pull over off the left side of the interstate. This has happened multiple times.

NHTSA complaint #11495868 — an unverified report by a vehicle owner.