26 of the 104 complaints about the 2003 Ford F-350 are about the engine — 25% of everything reported for this model year. Half of the failures with a mileage on record happened before 23,000 miles.
26
Complaints
0
Crashes
1
Fires
0
Injuries
Filed with NHTSA, in their own words.
ENGINE
The wires for the camshaft position sensor are failing just like they have in others models of the f series and cause the truck to suddenly die while driving. There was already a recall in place but it doesn't cover this vin and so I would like to request the recall be extended to this trucks vin
NHTSA complaint #11433730 — an unverified report by a vehicle owner.
ENGINE
AS I AM SURE YOU MUST BE AWARE OF THIS ISSUE: I PURCHASED USED A 2003 FORD -F350. I HAD MANY ISSUES AND HAD WORKED MOST OF THEM OUT. THERE WERE MANY ISSUES THAT WERE POSSIBLE I WAS CLEARLY UNAWARE OF. ONE BEING OF UTMOST SAFETY TO MYSELF AND OTHERS. MY HIGH PRESSURE OIL PUMP LOCATED INSIDE THE ENGINE OF MY 2003 FORD F-350 6.0 DIESEL FAILED. WHEN THAT HAPPENS THE ENGINE STOPS. THE HIGH PRESSURE OIL PUMP PROVIDES NEEDED PRESSURE TO THE INJECTORS IN ORDER TO HAVE A RUNNING ENGINE. BEING PARKED AND THE HPOP FAILING IS ONE THING HOWEVER DRIVING 55MPH ON A 2 LANE HIGHWAY AGAINST ONCOMING TRAFFIC ON A TURN IS A VERY BAD SITUATION. I AM FORTUNATE THAT I AM STILL VERY STRONG AT THE AGE OF 54. MY HPOP FAILED GOING 55MPH ON A LONG LEFT HAND TURN. AS THE ENGINE SHUTS DOWN BY BRAKES ARE LIMITED TO A SMALL AMOUNT OF STORAGE AND THEN THEY FAIL. THE STEERING HOWEVER FAILS IMMEDIATELY. I WAS HEADING STRAIT HEAD ON I TO A TRACKTOR TRAILER RIG. IT TOOK EVERY OUNCE OF STRENGTH TO ATTEMPT TO STEER THIS VEHICLE OUT OF THE OTHER LAND AND BRAKE GETTING IT OFF THE ROAD ASAP. IF THE BIG RIG HAD NOT MADE AN ATTEMPT TO MISS ME, I WOULDNT BE SENDING THIS LETTER. I WONDER HOW MANY OTHER PEOPLE HAD NOT THE STRENGTH TO STEER OUT OF A SITUATION OR HAVE TIME TO STOP AND WERE KILLED. THE REPORT MOST LIKELY SAID" DRIVER FELL ASLEEP." OR SOMETHING TO THAT AFFECT. THERE IS NO WAY THIS ENGINE SHOULD BE ALLOWED TO CONTINUE OPERATION ON THE ROAD PERIOD. FORD SHOULD HONOR ALL CURRENT OWNERS OF THIS VEHICLE WITH A VERY REASONABLE SETTLEMENT NOT TO MENTION HAVING A FORMAL INVESTIGATION INTO THIS MATTER. I KNOW OF NO OTHER VEHICLES ON THE ROAD THAT HAVE SUCH AN ISSUE. COMPLETE FAILURE OF STEERING AND BRAKES DUE TO AN UNFORESEEN INTERNAL MECHANICAL ISSUE IS A VERY POOR DESIGN. RUNNING OUT OF FUEL IS ONE THING, HOWEVER RUNNING OUT OF CONTROL IS ABSURD. HAD I KNOW WHO TO WRITE TOO SOONER I WOULD HAVE.
NHTSA complaint #11386656 — an unverified report by a vehicle owner.
ENGINE
JUST DRIVING ON HIGHWAY 41 AND IT JUST STOPPED. ENGINE WENT DEAD. PULLED OVER TO SIDE OF ROAD AND TRIED STARTING AGAIN AND IT WOULDNT START. HAD TO GET IT TOWED. ITS BEEN IN SHOP FOR 20 DAYS. NEEDS A NEW FUEL TANK BECAUSE THE INNER LINING IS PEELING AND PARTICLES ARE GOING THROUGH ENGINE! NEED HELP I PURCHASED THIS TRUCK IN 2015 AND ITS BEEN IN SHOP 7 DIFFERENT TIMES.
NHTSA complaint #11279677 — an unverified report by a vehicle owner.
ENGINE
DRIVING ALONG LOUD NOISE PULLED OVER TO FIND A SPARK PLUG BLEW OUT OF THE ENGINE BLOCK TAKING THE THREADS WITH IT. NO FIRE THANK GOODNESS!
NHTSA complaint #10909834 — an unverified report by a vehicle owner.
ENGINE
I WAS DRIVING DOWN THE ROAD AND I HEARD A LOUD POP. THE ENGINE HAD A VERY ABRUPT LOSS IN POWER AND BEGAN SHAKING AS I TRIED TO ACCELERATE. I WAS ON A 2 LANE ROAD AND HAD NO CHOICE BUT TO TRY AND MAINTAIN MY SPEED TO PREVENT CAUSING AN ACCIDENT FROM BEING REAR ENDED. AFTER DRIVING SEVERAL MILES TO A PLACE I COULD SAFELY STOP, I CHECKED UNDER THE HOOD AN A SPARK PLUG HAD BEEN SHOT FROM THE ENGINE. AFTER REVIEWING THIS ON THE WEB, THERE ARE MANY COMPLAINTS LIKE MINE WHERE SPARK PLUGS WERE SHOT OUT OF ENGINES. NHTSA NEEDS TO EVALUATE THIS AS REVIEW. HAD THE ENGINE CAUGHT FIRE I WOULD NOT HAVE KNOWN AND I HAD NO WHERE TO PULL OFF THE ROAD. THIS IS A RESULT OF AN CYLINDER HEAD WITH INADEQUATE THREADS FOR SPARK PLUGS TO THREAD INTO AND TAKE HOLD OVER TIME THE ALUMINUM WEAKENS AND THIS HAPPENS. IF THIS WASN'T A PROBLEM WHY DID FORD REDESIGN CYLINDER HEADS AFTER THESE MODEL ENGINES TO ACCOMMODATE MORE THREADING TO HOLD THE SPARK PLUGS IN THE ENGINE?
NHTSA complaint #10721515 — an unverified report by a vehicle owner.
ENGINE
I CALLED FORD MOTOR COMPANY MY 2003 FORD F350 SD. SC. 4X4 5.4 ENG. WITH THE PROBLEM WITH BOTH EXHAUST MANIFOLDS ROTTING AWAY & THE STUDS & NUTS THAT HOLD THE EXHAUST MANIFOLDS TO ENGINE HEADS THAT THEY WERE ALL ROTTING AWAY , THEY TOLD ME WE WON'T FIX THE PROBLEMS FOR FREE . I WOULD LIKE FOR TO INVESTIGATE THIS PROBLEM BEFORE MANY PEOPLE WILL GET INJURY OR MANY FATALITY WILL HAPPEN WHEN THE EXHAUST MANIFOLDS FALL OFF AND CATCH ON FIRE & BURN UP BECAUSE FIRE COMES OUT OF THE ENGINE TO THE EXHAUST MANIFOLDS . I TALKED TO MANY FORD DEALERS THEY TOLD ME THAT THEY HAVE REPLACED MANY OF THESE EXHAUST MANIFOLDS WITH THE SAME PROBLEMS I HAVE & HAD TO CHARGE THE OWNER OF THESE TRUCKS & MANY OTHER YEARS OF THESE FORD TRUCKS . PLEASE HELP ME & MANY OTHER OWNERS OF THESE FORD TRUCKS TO MAKE FORD MOTOR COMPANY RECALL THIS PROBLEMS BEFORE PEOPLE WILL DIE & FIX THIS PROBLEM FOR FREE . THANKS
NHTSA complaint #10607928 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
CRACKED "Y" PIPE IS LEAKING DIESEL EXHAUST FUMES INTO CAB OF TRUCK. THIS OCCURRED PREVIOUSLY WHEN THE TRUCK WAS UNDER WARRANTY BACK IN 2004 BUT NOW IT IS NOT UNDER WARRANTY NOR IS THERE A RECALL. I HAVE BROUGHT THIS UP TO SEVERAL DEALERS IN THE AREA BUT UNLESS IT IS UNDER WARRANTY THEY WON'T COVER THE REPAIR. HOWEVER, I FEEL IT IS A MAJOR SAFETY HAZARD WHICH I FEEL SHOULD BE ADDRESSED IMMEDIATELY, AS DIESEL FUMES ARE LINKED TO CANCER OR COULD LEAK TO AN ACCIDENT IF SOMEONE IS OVERCOME BY THE FUMES, WHICH COULD LEAD TO A DEATH. PLEASE LOOK INTO THIS HAZARD AND LET ME KNOW IF YOU HAVE ANY QUESTIONS, I WOULD BE HAPPY TO ANSWER. I DO KNOW FROM TALKING TO MECHANICS THAT THIS DOES OCCUR OFTEN IN THESE TRUCKS.
NHTSA complaint #10567257 — an unverified report by a vehicle owner.
ENGINE
TL* THE CONTACT OWNS A 2003 FORD F-350. THE CONTACT STATED THAT THE ENGINE COOLANT LEVEL WAS FOUND TO BE PREMATURELY LOW. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, WHO ADVISED THE CONTACT THAT THE HEAD GASKET HEAD BOLTS WERE DEFECTIVE. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 130,000.
NHTSA complaint #10546769 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
TL* THE CONTACT OWNS A 2003 FORD F350 DIESEL. THE CONTACT STATED THAT THE VEHICLE COULD NOT BE STARTED IN COLD WEATHER. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE DEALER PERFORMED A DIAGNOSTIC WHICH LOCATED THE FAILURE AT THE EGR EXHAUST SYSTEM VALVE BUT THE DEALER DID NOT REPLACE THE EGR VALVE. THE VEHICLE WAS THEN TAKEN TO A LOCAL MECHANIC FOR A SECOND DIAGNOSTIC WHICH LOCATED THE FAILURE AT THE FUEL INJECTION CONTROL MODULE BOX AND THE GLOW PLUGS MODULE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND DENIED ASSISTANCE WITH THE REPAIRS DUE TO THE AGE OF THE VEHICLE. THE FAILURE MILEAGE WAS 10,000 AND THE CURRENT MILEAGE WAS 111,000. UPDATED 03/05/12*LJ THE ENGINE GLOW PLUG WAS REPLACED. UPDATED 03/08/12
NHTSA complaint #10445916 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2003 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, A SPARK PLUG FLEW OUT OF THE ENGINE COMPARTMENT AND HIT THE HOOD OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE A COIL AND THE SPARK PLUG WERE REPLACED. THE FAILURE OCCURRED TWO ADDITIONAL TIMES AFTER. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 98,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 101,000.
NHTSA complaint #10361439 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
DT*: THE CONTACT STATED WHILE DRIVING THE VEHICLE STALLED AND LOST POWER. THIS OCCURRED AT VARIOUS SPEEDS, AND IN ALL INCIDENTS THE VEHICLE RESTARTED. THE VEHICLE WAS LATER DRIVEN TO THE DEALER, WHO REPLACED AND REPROGRAMMED THE TURBO-CHARGER. HOWEVER THIS DID NOT REMEDY THE PROBLEM. ON THE MOST RECENT VISIT TO THE DEALER THE TURBO CHARGER WAS REPLACED, BUT THE PROBLEM STILL OCCURRED. UPDATED 05/30/06.
NHTSA complaint #10157067 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
CONSUMER REQUEST FOR REIMBURSEMENT FOR ENGINE REPLACEMENT IN THE 2003 FORD F350.*MR THE CONSUMER HAD A MULTITUDE OF PROBLEMS WITH THE VEHICLE LACKING POWER AND BLOWING OUT WHITE SMOKE, AT TIMES THE VEHICLE WOULD HESITATE ON START UP, IT JERKED WHEN THE CONSUMER ATTEMPTED TO ACCELERATE, THERE WAS A RATTLING NOISE WHEN THE CONSUMERS FOOT WAS RELEASED FROM THE ACCELERATOR. THE INTAKE MANIFOLD HAD POPPED LOSE. THE CONSUMER WAS TOLD BECAUSE AN AFTER MARKET CHIP WAS INSTALLED IN THE VEHICLE, THE ENGINE WOULD NOT BE COVERED UNDER WARRANTY.
NHTSA complaint #10135610 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
TURBO CHARGER IS ON IT'S THIRD FAILURE AND INSTALATION. I ONLY HAVE 11,000 MILES ON THE FORD F-350, THE WASTED TIME ON MY END IS REDICULOUS. FROM WHAT I HEARD FORD AND THE DEALERSHIPS ARE INDUNDATED WITH THIS PROBLEM, BUT THEY ARE REFUSING TO RECALL.
NHTSA complaint #10128428 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
2ND REQUEST FAX RE CONSUMER'S CONCERNS RE HIS 2003 FORD F-350 6.0 L DIESEL TRUCK DUE TO LOSS OF POWER/IRREPARABLE TURBO LAG.*MR THE VEHICLE HAS BEEN TAKEN TO THE DEALER SEVERAL TIMES BUT THEY HAVE BEEN UNABLE TO CORRECT THE PROBLEM. THE PROBLEM HAS PROGRESSED TO THE POINT THAT THE VEHICLE HAS COMPLETE LOSS OF POWER AT STOP, PARTICULARLY WHEN IN REVERSE. ON TWO SEPARATE OCCASIONS THE CONSUMER WAS UNABLE TO BACKUP AN INCLINE. LOTS OF EXHAUST SMOKE CAME FROM THE TAIL PIPE BUT THERE WAS NO POWER.
NHTSA complaint #10118938 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
THE CONSUMER IS EXPERIENCING TREMENDOUS COOLANT LEAKAGE, WHICH IS CAUSING EXTREME OVER HEATING. THE VEHICLE DOES NOT HAVE ANY HEAT.
NHTSA complaint #10107420 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
THE CONSUMER TRIED TO START THE VEHICLE, BUT IT WOULD NOT START. THE CONSUMER WAITED A COUPLE OF HOURS, WENT OUT AND THE VEHICLE STARTED. THE VEHICLE WAS TAKEN TO A MECHANIC AND THE WIRING HARNESS WAS REPLACED. FOUR DAYS LATER THE VEHICLE WOULD NOT START AGAIN, LATER ON, THE CONSUMER WAS INFORMED THAT THE VEHICLE WAS ON FIRE. THE VEHICLE WAS TOTALED. *JB
NHTSA complaint #10105392 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
WHILE DRIVING VEHICLE WOULD LOST POWER STEERING AND BRAKES. VEHICLE WAS TAKEN TO DEALER FOR CHECKUP, AND RESULTS SHOWED THAT OIL WAS LEAKING INSIDE THE ENGINE CAUSING THE PROBLEM.
NHTSA complaint #10103855 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
WHILE DRIVING THE TURBO HOSE TO THE TURBO CHARGER CONTINUOUSLY BLEW OFF. CONSUMER EXPERIENCED THIS PROBLEM SEVERAL TIMES. TOOK VEHICLE TO DEALER TO BE REPAIRED. HOWEVER, PROBLEM RECURRED.
NHTSA complaint #10101769 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
WHILE DRIVING 70 MPH, THE VEHICLE SHUT OFF. *AK THE REAR DIFFERENTAIL MADE A GRINDING SOUND AND SHUDDERED WHEN A TURN WAS MADE.
NHTSA complaint #10094664 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
VEHICLE HESITATE WHEN TRYING TO ACCELERATE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM.
NHTSA complaint #10089815 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
WHILE DRIVING VEHICLE STALLED. DEALERSHIP INDICATED THAT THIS WAS DUE TO A MALFUNCTION IN THE FUEL INJECTORS. THE FUEL INJECTORS WERE REPLACED 8 TIMES, AND THE EGR VALVE WAS REPLACED TWICE.
NHTSA complaint #10061373 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
WHILE WARMING UP THE VEHICLE FOR MORE THAN FIFTEEN MINUTES AN EXHAUST SMELL CAME INSIDE OF VEHICLE, CAUSING CONSUMER TO BECOME ILL. DRIVER WAS CONCERNED THAT CARBON DIOXIDE POISON GAS WAS ESCAPING INSIDE OF VEHICLE AS WELL. VEHICLE WAS TOWED TO THE DEALER FOR ANALYSIS. DEALERSHIP MECHANIC COULD NOT DUPLICATE THE PROBLEM.
NHTSA complaint #10042024 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
A BAD ODOR WAS COMING FROM INSIDE OF THE VEHICLE THROUGH THE VENTS. EXHAUST SYSTEM WAS CAUSING THE SMELL. ON ONE OCCASION, CONSUMER HAD TO PULL OVER TO THE SHOULDER BECAUSE HE BECAME VERY ILL. DEALER WAS AWARE OF THE PROBLEM.
NHTSA complaint #10039996 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE
CONSUMER STATED WHILE DRIVING AT 60 MPH, THE VEHICLE STARTED SMOKING AND RATTLING. AFTER PULLING OVER TO THE SHOULDER TO INVESTIGATE THE PROBLEM, THE VEHICLE FAILED TO RESTART. AFTER TAKING THE VEHICLE TO THE DEALER, IT WAS FOUND THE FUEL INJECTOR WAS FAULTY AND THE ENGINE FAILED. THERE WERE NO INDICATION LIGHT ON AT ALL. *PH ALL ACCOUNTS TOOK PLACE APPROX. 11:30 P.M. ON AN EXTREMELY BUSY FREEWAY. AS OF 08/20/03, FORD HAD NOT COMPLIED WITH EITHER REPLACING THE ENGINE OR VEHICLE. *PH ALSO THE CONSUMER STATED THE COOLANT WAS LOW, AND THERE WAS STEAM COMING FROM UNDER THE HOOD.
NHTSA complaint #10032438 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
VEHICLE WONT MOVE, WHEN TEMPERATURE IS BELOW O DEGREE. HAS TO WAIT ABOUT A MINUTE TO WARM-UP. DEALER HAS INSPECTED THE VEHICLE AND COULD NOT DUPLICATE OR CORRECT THE PROBLEM. (DIESEL ENGINE)
NHTSA complaint #10018158 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE
WHILE DRIVING APPROXIMATELY 70 MPH ON HIGHWAY, THE VEHICLE STALLED 4 SEPARATE TIMES, WHICH RESULTED IN LOSS OF POWER STEERING AND BRAKE CONTROL. DEALER ADVISED THE PROBLEM WAS CORRECTED, BUT WAS UNABLE TO GUARANTEE THE VEHICLE WOULD NOT STALL AGAIN. *JB AFTER THE VEHICLE WAS PICKED UP IT STALLED 15 TIMES. *SCC
NHTSA complaint #10017516 — an unverified report by a vehicle owner.