33 of the
312 complaints filed about the Ford Focus Electric
are about the fuel system —
11% of everything owners reported.
The worst model year for it is 2013.
While driving around [XXX] PM on Thursday, [XXX], the Focus Electric displayed a "Stop Safely Now" message and proceeded to cut power going to the electric motor, allowing the car only to coast as if it was in neutral. Luckily no vehicles were around in my lanes, as that easily could've caused an accident. Electric steering, regen braking, and air conditioning were all disabled. I was able to coast it into a nearby FireHouse Subs parking lot, and directly into a parking spot. Had to disconnect the 12 Volt battery for 5 minutes and reconnect to hopefully reset the computers in the car. Still displayed SSN message after reconnection. I let the car sit for another 30 minutes and was able to start it up like nothing happened. Drove it home and read the stored DTCs, which were the following: ===BECM DTC P0AA2:00-08=== Code: P0AA2 - Hybrid/EV Battery Positive Contactor 'A' Stuck Open ===TCM DTC P0AF8:16-08=== Code: P0AF8 - Hybrid/EV Battery System Voltage ===GFM DTC U0111:00-08=== Code: U0111 - Lost Communication With Battery Energy Control Module A It will be going to Thomasville Ford on Wednesday [XXX]. That is the earliest they can accept it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11584198 — an unverified report by a vehicle owner.
When driving my car the first day I bought it, the wrench icon illuminated, telling me to check the manual. I figured I would do so after work, but as I tried to start the car to leave work, I received a "Stop Safely Now" message and could not start the car. It had at least 30% charge, being electric, so that had nothing to do with it not starting. I am glad this did not happen when I was driving, as I have seen other instances of earlier years of the Ford Focus electric with this same issue. In other cases, it came in while the owner was driving, causing all power to the accelerator to stop. It was recently serviced since I just bought it, so I know there shouldn't have been any outlying service to be done. I am calling a tow service in the morning to have it taken to a dealer, so hopefully they can figure out the issue. I just wanted to let others know that this item that has had a recall on earlier years still persists with the 2015 model.
NHTSA complaint #11493726 — an unverified report by a vehicle owner.
DRIVING MY VEHICLE IN NORMAL CONDITIONS WITH OVER 30 MILES LEFT TO A CHARGE ON A SUBURBAN STREET GOING APPROXIMATELY 45 MILES PER HOUR, SUDDENLY A RED TRIANGLE WARNING APPEARED ON THE DASH STATING STOP SAFELY NOW. 60 SECONDS LATER THE VEHICLE SHUT OFF AND I LOST ALL POWER LEAVING ME STRANDED IN THE DARK IN THE MIDDLE OF THE STREET. AFTER ABOUT 20 MINUTES I WAS ABLE TO RESTART THE VEHICLE AND PROCEED HOME. THERE IS NEVER ANY PRIOR WARNING TO THIS HAPPENING. THIS HAS HAPPENED 3 TIMES TO ME WITHIN A 2 MONTH PERIOD AND I HAVE TAKEN IT TO MY DEALERSHIP TWICE WITH NO RESULTS. I DRIVE 40 MILES TO WORK ONE WAY ON VERY BUSY PHOENIX FREEWAYS AND AM PETRIFIED THIS WILL HAPPEN IN THE HOV LANE AND I END UP IN A DANGEROUS SITUATION. I HAVE FOUND THIS TO BE AN ISSUE ON PREVIOUS YEARS MODEL RECALL NO 13V-523000. THE DEALERSHIP IS NO HELP AND TOLD ME THEY COULD FIND NO INFORMATION REGARDING IT EVEN THOUGH I DID.
NHTSA complaint #11181991 — an unverified report by a vehicle owner.
I GOT A LOAN ON THE CAR LAST YEAR OF 2017 AND THE CAR HAD ISSUES ACCELERATING. I DO NOT RECALL THE DATE BUT MY HUSBAND AND WAS ON THE HILL AND I AND IT STATED TRANSMISSION DEFAULT. I TOOK THE CAR TO FORD AND THEY REPLACED THE CLUTCH. FOR ABOUT 2MTHS IT WAS FINE. THEN IT WOULDN'T ACCELERATE PROBABLY. THE CAR THEN STARTS TURNING OFF IN TRAFFIC AND I ALMOST WAS IN A CAR ACCIDENT. I THEN REPLACED THE BATTERY. THEN I FINALLY DECIDED TO TAKE IT TO FORD AND THAT'S WHEN THEY TOLD ME I NEEDED MY ENTIRE FUEL SYSTEM REPLACED. I CAN NOT AFFORD THAT AND I AM UNABLE TO PURCHASE AN EXTENDED WARRANTY WHICH WILL NOT EVEN COVER THE EXISTING ISSUES EVEN IF I DID PURCHASE IT. I CONTINUE TO DRIVE THE CAR BECAUSE MY CREDIT ISN'T GOOD ENOUGH TO OBTAIN ANOTHER CAR. I PAY A MORE EVERY MONTH AND I NEED SOME HELP.
NHTSA complaint #11099831 — an unverified report by a vehicle owner.
I BOUGHT THIS CAR AT HONDA IN ARLINGTON OFF OF 20 HWY IN 2013 I TOOK IT BACK WHEN I BOUGHT IT THAT WAS PRE USED , AND THEN IT SEEM LIKE THEY DID NOT WANT IT BACK AND NEVER WANT TO FIX IT . AND THE TRANS MISSION IS NOT WANT TO PUT DUE TO A LOUD NOISE, AND THEN THE TRUCK WANT OPEN AND THE LIGHT WANTED GO OFF AND THE ALARM WANT COME ON, TAKEN TO DON DAVIS AND THEY WANT TO CHARGE ME AND I AM DISABLE, AND I HAVE MY LITTLE GRANDCHILD THAT IS 6 MONTHS OLD AND SHE RIDE EVERYDAY AND I HOPE WE DON'T GET IN THIS CAR. PLEASE HELP US I HAVE PUT THIS ON MANY TIMES. THE DOOR WAS A RECALL AND WHEN TO DON DAVIS AND THEY ARE HAVE WAY FIX. PLEASE HELP!!!!!!!!
NHTSA complaint #11051123 — an unverified report by a vehicle owner.
VEHICLE SUBJECT TO CUSTOMER SATISFACTION PROGRAM 15N03 AND 16B02. AFTER TWO REPAIRS FOR RANDOM LOSS OF MOTIVE POWER, WITH TWO REPLACEMENTS OF HIGH-VOLTAGE WIRE HARNESS, CAR CONTINUES TO DISPLAY "STOP SAFELY NOW" WARNING ON DASH AND LOSS OF MOTIVE POWER. OBVIOUSLY A SAFETY HAZARD AS CAR HAS LOSS POWER IN TRAFFIC SEVERAL TIMES, FORTUNATELY WITHOUT INJURIES OR DAMGE. I AM RETURNING VEHICLE TO DEALERSHIP FOR THIRD TIME TODAY FOR SAME ISSUE. FIRST REPAIR WAS IN BEGINNING OF NOVEMBER, 2015 AND SECOND REPAIR WAS DONE AT THE END OF APRIL 2016.
NHTSA complaint #10870561 — an unverified report by a vehicle owner.
"STOP SAFELY NOW". WHILE DRIVING, POWER TO THE CAR COMPLETELY STOPPED MULTIPLE TIMES. "STOP SAFELY NOW" MESSAGE SHOWS ON INSTRUMENT PANEL. THIS HAS HAPPENED AT LEAST 7 TIMES. THE FIRST WHILE DRIVING 65 MPH ON THE FREEWAY IN FEBRUARY. LUCKILY I WAS ABLE TO GET OUT OF WAY OF TRAFFIC BEFORE IT CAME TO COMPLETE STOP. I TOOK IT TO FORD ON 2/24/16 AND THEY STATED THERE WAS A RECALL TO FIX THIS (I NEVER RECEIVED NOTICE OF RECALL). THEY MADE THE REPAIRS AND SAID IT WAS SAFE TO DRIVE. ON 4/18/16, THE CAR AGAIN COMPLETELY STOPPED AS I ENTERED AN INTERSECTION AND "STOP SAFELY NOW" MESSAGE APPEARED AGAIN. A SEMI-TRUCK BEHIND ME CAME TO A SKIDDING STOP, A FEW FEET FROM MY BUMPER. I WAS VERY LUCKY ONCE AGAIN TO AVOID AN ACCIDENT. I TOOK THE CAR TO NEWARK FORD AGAIN ON 4/18/16 AND THEY SAID THEY HAD TO UPGRADE THE SOFTWARE. I ASKED IF WAS SAFE TO DRIVE AND THEY SAID "ABSOLUTELY", THEY DON'T SEE ANY PROBLEM WITH THE CAR. ON 4/21, THE CAR AGAIN SUDDENLY STOPPED WHILE DRIVING 50MPH. THE SAME MESSAGE"STOP SAFELY NOW" APPEARED. PLEASE SEE ATTACHED PHOTOS OF THE LAST TWO TIMES THIS HAPPENED. I CALLED FORD CORPORATE OFFICE AND THEY SAID IF THE MECHANICS SAID THE CAR WAS SAFE TO DRIVE, IT WAS SAFE TO DRIVE. I SAID I DON'T FEEL SAFE SINCE THIS KEEPS HAPPENING AND THEY OBVIOUSLY DON'T KNOW WHAT IS WRONG. HE SAID IF YOU DON'T FEEL SAFE, YOU DON'T HAVE TO DRIVE THE CAR. I TOLD HIM THAT IS NOT A GOOD SOLUTION AS I AM PAYING FORD TO LEASE THE CAR AND NEED TRANSPORTATION. HE SAID THERE IS NOTHING FORD CAN DO, IT HAS TO GO THROUGH THE STATE, FORD IS NOT GOING TO DO ANYTHING FOR ME. HOW CAN I FEEL SAFE DRIVING A CAR THAT MIGHT SUDDENLY STOP AT ANY TIME?? I DRIVE 50 MILES EACH WAY TO WORK ON THE FREEWAY. I AM EXTREMELY SCARED THAT THIS PROBLEM IS GOING TO CAUSE ME TO GET IN A BAD ACCIDENT. WHY DOESN'T FORD ACCEPT RESPONSIBILITY FOR THIS CAR AND THE EXTREMELY UNSAFE ISSUES?
NHTSA complaint #10861105 — an unverified report by a vehicle owner.
THE VEHICLE WAS STATIONARY WITH NO POWER. THE VEHICLE WOULD NOT START AND DISPLAYED A YELLOW TOOL WRENCH THAT READ 'SEE MANUAL' AND THEN WOULD CHANGE TO A YELLOW TRIANGLE WITH A RED EXCLAMATION MARK THAT READ 'STOP VEHICLE SAFELY.' HAD THE VEHICLE TOWED TO AV FORD AND THEY HAVE BEEN NOTHING BUT UNHELPFUL. THEY STATE IT'S WATER INTRUSION TO THE CONNECTORS AND IS NOT COVERED UNDER THE MANUFACTURE WARRANTY AND TO FILE A CLAIM WITH MY AUTO INSURANCE COMPANY. THEY CANNOT PROVIDE ANY DIAGNOSTIC TESTING TO CONCLUDE THEIR WATER INTRUSION TO THE CONNECTOR'S THEORY. WE HAD A RAINSTORM THE DAY BEFORE I BROUGHT THE VEHICLE IN TO THEM. THEY ARE USING WATER INTRUSION DAMAGE AS A SCAPEGOAT TO FIXING THE REAL ISSUE WHICH IS A DEFECT TO THE POWERTRAIN CONTROL MODULE. FORD DID HOWEVER PROVIDE ME A WRITTEN ESTIMATE OF REPAIR FOR $33,160.42. THIS IS ABSURD AND IS MORE THAN THE CAR IS EVEN WORTH. THESE CARS CONTINUE TO HAVE THIS ISSUE DESPITE OF THE RECALL THEY HAD FOR THIS PROBLEM. FORD FOCUS ELECTRIC VEHICLES THAT WERE NOT PART OF THE ORIGINAL RECALL IN NOVEMBER 2013 ARE EXPERIENCING THE SAME COMPLETE LOSS OF POWER BECAUSE THE ISSUE HAS NOT BEEN FIXED.
NHTSA complaint #10786040 — an unverified report by a vehicle owner.
ON TUESDAY, SEPTEMBER 22, 2015, WHILE MY SON WAS DRIVING ON THE FREEWAY AT 65 MPH IN THE CARPOOL LANE, THE CAR SUDDENLY STALLED ON HIM AND LOSS ALL POWER TO THE CAR. A MESSAGE POPPED UP ON THE DASH IN AN ORANGE TRIANGLE STATED "STOP SAFELY NOW". SINCE HE WAS IN THE CARPOOL LANE, HE DID NOT HAVE ENOUGH TIME TO GET THE CAR OFF TO THE SIDE. HE WAS STRANDED IN A BUSY CARPOOL LANE AND ALMOST GOT REAR END FROM BEHIND WHEN THE CAR SUDDENLY CUT OFF ALL POWER AND CAME TO A STOP. THIS HAS PUT MY SON IN A GREAT DANGER SITUATION!!! HE COULD HAVE GOT REAR ENDED AND THE STALLING OF THE CAR COULD HAVE CAUSED A MULTI-CARS ACCIDENT IN THE CARPOOL LANE ON THE FREEWAY. SOMEHOW HE MANAGED TO ABLE TO RESTART THE CAR AFTER TURNING THE CAR ON, OFF AND OPENING THE DRIVER SIDE DOOR AND CLOSING IT SEVERAL TIME. THE CAR CONTINUE TO HAVE THE SAME PROBLEM ON AND OFF FOR THE NEXT COUPLE OF DAYS. WE FINALLY GOT THE CAR INTO FORD DEALERSHIP SEPTEMBER 24, 2015. AT THE TIME OF THIS REPORT, FORD DEALERSHIP HAS NOT CALL ME WITH A CAUSE FOR THE ISSUE. I ALSO NOTED THAT THERE WAS A RECALL FOR A SIMILAR ISSUE THAT WAS ISSUED FROM FORD FOR THE ELECTRIC VEHICLE FOR MODEL 2012 TO 2014. THE SERVICEMAN AT FORD DEALERSHIP TOLD ME THAT MY VIN NUMBER WAS NOT ON THAT RECALL LIST YET MY SON STILL ENCOUNTERED THE SAME ISSUE THAT WAS DESCRIBED IN THE NHTSA INVESTIGATION REPORT A COUPLE OF YEARS AGO. I DONT THINK FORD HAS DONE ENOUGH TO CORRECT THIS DANGEROUS PROBLEM.
NHTSA complaint #10776444 — an unverified report by a vehicle owner.
"STOP SAFELY NOW" WARNING LIGHT CAME ON AT ~18K MILES, 17 MONTHS INTO OWNERSHIP, WHILE DRIVING ON EXPRESS WAY AT ~35 MPH. CAR POWERED OFF AFTER COMING TO A COMPLETE STOP AT NEXT STOPLIGHT, WAS STRANDED BEFORE INTERSECTION. CAR DID POWER UP AGAIN AND WAS DRIVEABLE AFTER OPENING AND CLOSING DRIVER DOOR, WAITING SEVERAL MINUTES, AND TURNED POWER OFF AND ON.
NHTSA complaint #10763941 — an unverified report by a vehicle owner.
WHILE DRIVING THE VEHICLE, A LOUD CHIME SOUNDED, WITH A RED TRIANGLE SAYING, "STOP SAFELY NOW" AS WELL AS A YELLOW "SEE MANUAL" INDICATION. THIS WAS VERY DANGEROUS BECAUSE IT WAS SUDDEN AND WHILE DRIVING. THE CAR LOST ALL POWER AND I HAD TO ATTEMPT TO PULL OF THE STREET SO I WOULDN'T CAUSE AN ACCIDENT. I SHIFTED TO PARK AND TURNED THE CAR OFF AND BACK ON AND IT RESOLVED THE ISSUE. HOWEVER, 2 DAYS LATER THE SAME PROBLEM OCCURRED BUT THIS TIME I WAS UNABLE TO RESTART THE VEHICLE AND NEEDED TO TOW THE CAR TO THE DEALERSHIP.
NHTSA complaint #10750116 — an unverified report by a vehicle owner.
THIS MODEL HAS A "STICKY" STEERING WHEEL THAT WILL NOT ALWAYS RETURN TO THE NEUTRAL POSITION WITH OUT DRIVER ASSISTANCE AND NEEDS TO BE CONSTANTLY ADJUSTED TO KEEP THE VEHICLE DRIVING IN A STRAIGHT LINE. YOU CAN ACTUALLY LET GO OF THE STEERING WHEEL WHILE GOING AROUND A GRADUAL CURVE IN THE ROAD AND THE CAR WILL FOLLOW THE CURVE THE WHOLE WAY WITHOUT BREAKING ITS ARCH. IT ALSO SUFFERS FROM DANGEROUS "TORQUE STEERING" WHICH CAUSES THE VEHICLE STEERING TO LOSE CONTROL WHEN YOU ACCELERATE AGGRESSIVELY. IN ADDITION, THE ELECTRIC STEERING REACTS POORLY WITH THE REGENERATIVE BREAKING. IF YOU NEED TO BREAK HARD, THE STEERING WILL SWERVE DANGEROUSLY AND INHIBIT DRIVER CONTROL. I'VE APPROACHED FORD ABOUT THIS AND TAKEN TO THE DEALER SEVERAL TIMES AND THEY SAY THAT'S JUST THE WAY THE CAR IS. I'VE TALKED TO OTHER OWNERS OF THIS TYPE OF CAR AND NOT ALL BUT A GOOD PORTION HAVE HAD SIMILAR PROBLEMS. ONE MAN EVEN SAID HE'S AFRAID TO DRIVE THE CAR 1. FOR SAFETY, BUT 2. BECAUSE IT LOOKS LIKE YOU'RE DRIVING DRUNK BECAUSE YOU HAVE TO CONSTANTLY ADJUST THE STEERING JUST TO KEEP THE CAR IN LINE - LOOKS LIKE YOU'RE SWERVING. LASTLY, THE MILEAGE THEY SAY YOU CAN GET FROM A CHARGE ISN'T ACCURATE AND THEIR APP DOESN'T WORK IN ALL LOCATIONS. NEITHER OF WHICH THEY DISCLOSED BEFORE I LEASED THIS CAR. PLEASE CHECK INTO THIS AS FORD DOESN'T CARE. I'M HAPPY TO ASSIST YOUR INVESTIGATION IN ANY WAY. THANKS!
NHTSA complaint #10705700 — an unverified report by a vehicle owner.
WHILE TRAVELING DOWN THE FREEWAY, DECELERATING TO CHANGE LANES THE STOP SAFELY NOW MESSAGE APPEARED AND THE CAR LOST POWER. THIS IS A RE-OCCURRENCE AND THE DEALER IS WORKING TO RESOLVE IT.
NHTSA complaint #10678151 — an unverified report by a vehicle owner.
STOP SAFELY NOW ERROR MESSAGE DISPLAYED ALONG WITH MULTIPLE OTHER ERROR MESSAGES (TIRE FAULT, ENGINE COOLANT ERROR, REAR PARKING SENSOR ERROR, ETC). CAR IS BRAND NEW AND UNABLE TO DRIVE.
NHTSA complaint #10667889 — an unverified report by a vehicle owner.
THREE SEPARATE TIMES WHILE BACKING UP FROM PARKING SPACES AND WHILE PULLING FORWARD, THE STOP SAFELY NOW LIGHT CAME ON AND THE CAR LOST ALL POWER. I WAS ABLE TO RESTART AND DRIVE NORMALLY BUT HAVE HEARD OF THIS CONDITION HAPPENING WHILE AT SPEED. CAR IS IN DEALERSHIP FOR REPLACEMENT OF HIGH VOLTAGE WIRING HARNESS.
NHTSA complaint #10662049 — an unverified report by a vehicle owner.
WAS DRIVING AT 25 MPH IN A RESIDENTIAL ZONE, WITH 48 MILES ON THE BATTERY WHEN AN ALERT DINGED AND THE MESSAGE ON THE SCREEN SAID "PULL OVER TO SAFETY NOW." I IMMEDIATELY PULLED OUT OF TRAFFIC INTO A PARKING SPACE AS THE POWER STEERING STOPPED WORKING, THEN STEERING THEN COMPLETELY LOCKED, COULDN'T TURN THE WHEEL. THE CAR WOULD NO LONGER GO FORWARD / HAD LOST POWER. AND THE POWER BREAKS DIDN'T SEEM TO BE FUNCTIONING. THANKFULLY I HAD ALREADY COME TO A COMPLETE STOP. THE NEXT MORNING WE HAD IT TOWED TO AN AUTHORIZED FORD SERVICE CENTER THAT SAID THERE WAS A RECALL FOR THIS ISSUE. THEY APPLIED THE SOFTWARE FIX AND TEST DROVE THE CAR ONLY TO HAVE THE PROBLEM REOCCUR. THEREFORE THEY SAID THE FIX FOR THE RECALL DIDN'T ACTUALLY FIX THE PROBLEM AND THAT THEY WOULD HAVE TO ORDER A REPLACEMENT FOR THE TRANSMISSION CONTROL MODULE, AS THAT WAS THE PART FORD SAID WAS FAULTY / FAILED.
NHTSA complaint #10655138 — an unverified report by a vehicle owner.
3 MILES AFTER LEAVING THE PARKING LOT WITH MY MOM AND 2 KIDS IN THE CAR THE "STOP SAFELY NOW" WARNING FLASHED AND THE CAR LOST POWER. I FOUND SIMILAR COMPLAINT 10512459. I HAD TO PULL OVER IN THE BIKE LANE, TURN OFF THE CAR AND RESTART IT UNTIL POWER WAR RESTORED. SAME THING HAPPENED NEXT DAY RIGHT AFTER LEAVING HOME. NOW I AM AFRAID TO GO OUT ON THE HIGHWAY OR ON NARROW COUNTRY ROADS WITH THIS CAR.
NHTSA complaint #10610951 — an unverified report by a vehicle owner.
CAR WAS IN THE GARAGE WITH FULLY CHARGED. I TRIED TO START CAR AND I GOT MESSAGE "SAFE MODE SHUTDOWN" ON THE RIGHT SCREEN AND "STOP SAFELY NOW" ON THE LEFT SCREEN. CAR LIGHTS START BLINKING AND AFTER A WHILE WHOLE CAR SHUTDOWN AND DISABLED. CAR IS NOT RESPONDING REMOTE KEY. BACK DOOR IS LOCKED AND CAN'T OPEN. I TRIED TO PUT BACK TO CHARGED AND NOTHING CHANGED AT ALL. I CALLED FORD ROAD SIDE ASSISTANCE AND TAKING CAR TO SERVICE TOMORROW.
NHTSA complaint #10604902 — an unverified report by a vehicle owner.
THE PRODUCT IS BOSCH POWER XPRESS 240 VOLT CHARGER COUPLED TO MY 2012 FORD FOCUS ELECTRIC. IT IS SET TO 30 AMPS FOR MY VEHICLE....UPDATED 12/17/14 *BF THIS CHARGER WAS PUT IN SERVICE ON 7/22/2013. I NOTICED IN FEBRUARY THAT THERE WAS A NOTICEABLE ELECTRICAL SMELL OF MELTED PLASTIC AFTER CHARGING THE CAR, BUT THERE WAS NO DAMAGE. I FIGURED THAT WITH THE VERY COLD AIR IN MY GARAGE THAT MY SENSE OF SMELL MAY BE OFF. I CHARGE AT HOME AND AT WORK. THE WORK CHARGER IS MADE BY PEP. I HAVE ALSO OCCASIONALLY USED CHARGEPOINT CHARGERS. DURING THE WINTER I ALSO PRE-CONDITION THE VEHICLE TO 85 DEGREES. ON 3/27/14 I NOTICED FIRSTHAND THE ISSUE WHILE GETTING IN THE CAR IN THE MORNING. THE VEHICLE WAS STILL PRE-CONDITIONING WHEN I UNPLUGGED IT. THE CHARGER WAS MELTED AT THE CHARGING STATION COUPLER END AND THE VEHICLE CHARGE INLET PORT WAS ALSO MELTED. I TOUCHED THE CHARGING STATION COUPLER AFTER UNPLUGGING IT FROM MAIN POWER AND THE TIPS OF THE CONTACTS WERE BASICALLY MOLTEN PLASTIC THAT BURNT THE TIP OF MY FINGER. I DECIDED TO SCHEDULE A WARRANTY REPAIR WITH FORD. ON 3/28/2014 I TOOK THE VEHICLE IN FOR WARRANTY SERVICE WITH FORD MOTOR COMPANY AND THEY REPLACED THE CHARGE PORT UNDER WARRANTY. ON 4/8/2014 I CALLED BOSCH ABOUT THE CHARGER AND THEY OPENED A CASE TO REPLACE THE CHARGER UNDER WARRANTY. THE CLAIM WAS ACCEPTED AND PROCESSED ON 4/11/2014. MY CONCERN IS OF POSSIBLE FIRE OR INJURY FROM AN OVERHEATED AND/OR IMPROPERLY INSULATED CONNECTION BETWEEN THE CHARGING STATION AND THE VEHICLE. *TR UPDATED 9/29/2015
NHTSA complaint #10586711 — an unverified report by a vehicle owner.