Ford Focus Electric transmission problems

POWER TRAIN

MY SHOCKS AND MY TRANSMISSION I BELIEVE

NHTSA complaint #11405962 — an unverified report by a vehicle owner.

POWER TRAIN

TRANSMISSION WOULD NOT GO AFTER SITTING AT RED LIGHT A LIGHT CAME ON SAYING TRANSMISSION DEFAULT

NHTSA complaint #11232695 — an unverified report by a vehicle owner.

POWER TRAIN

CAR STOPPED ON MOTION WITH AN ALARM STOP SAFELY NOW, WHEELS LOST POWER, STEERING WHEEL WAS ABLE TO FUNCTION SO CAR HAD TO BE PUSHED TO THE SIDE OF THE ROAD.

NHTSA complaint #11231056 — an unverified report by a vehicle owner.

POWER TRAIN:CLUTCH ASSEMBLY

TL* THE CONTACT OWNS A 2012 FORD FOCUS ELECTRIC. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE HESITATED TO SWITCH GEARS. THE VEHICLE WAS DRIVEN TO MAHWAH FORD (55 FRANKLIN TPK, MAHWAH, NJ 07430) WHERE IT WAS DIAGNOSED THAT THE CLUTCH ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 26,000.

NHTSA complaint #11222637 — an unverified report by a vehicle owner.

POWER TRAIN

SO I WAS DRIVING HOME LAST NIGHT IN THE RAIN AND THE SPEEDOMETER WAS JUMPING AROUND A LITTLE AND THE TRACTION CONTROL FLASHED A COUPLE TIMES AND I THOUGHT 'OH IT'S JUST CAUSE THE RAIN' WELL TODAY THE SAME THING WAS HAPPENING WHILE I WAS DRIVING. THEN I GOT A WARNING LIGHT SAYING 'LOW BRAKE FLUID' AND THE BRAKES LOCKED UP WHILE I WAS DOING 30MPH. IT WENT AWAY AND DROVE FINE BUT IT WILL POP UP EVERY 4 MILES OR SO SAYING LOW BRAKE FLUID

NHTSA complaint #11193717 — an unverified report by a vehicle owner.

POWER TRAIN

CAR HAS ABOUT 13,000 MILES. SUDDENLY LOST POWER WHILE STOPPED AT A TRAFFIC LIGHT. 'STOP SAFELY NOW' WARNING SHOWED ON DASHBOARD. TRIED FOR 10-15 MINUTES TO RESTART, FINALLY RESTARTED AND COMPLETED COMMUTE TO WORK. DROVE THE CAR TO THE DEALER SAME DAY. AFTER ONE WEEK, DEALER HAS NO DIAGNOSIS AND HAS MADE NO REPAIR. I CANNOT DRIVE AN UNSAFE CAR ON MY DAILY COMMUTE, WHICH INCLUDES HIGHWAY DRIVING. FORD IS OBVIOUSLY ON NOTICE THAT THIS IS A SERIOUS SAFETY PROBLEM AND THEY HAVEN'T FIXED IT.

NHTSA complaint #11156675 — an unverified report by a vehicle owner.

POWER TRAIN

THE VEHICLE KICKS FORWARD DURING BRAKING. IT FEELS LIKE THIS HAPPENS AFTER A FULL CHARGE THE FIRST TIME THAT THE REGENERATIVE BRAKING MECHANISM TURNS ON. I HAVE ALSO EXPERIENCED A STRONG KICK WHEN BRAKING AND GOING OVER A BUMPS, SUCH AS THE BUMPS THAT ARE ON LANE DIVIDERS.

NHTSA complaint #11090914 — an unverified report by a vehicle owner.

POWER TRAIN

THIS CAR, I HAVE BEEN TRYING TO GET HELP FOR A LONG TIME AND IT SEEM LIKE NOT ONE HAS HEARD ME , NOT EVEN THE DEALER, AND NOW HEAR IT IS MY CAR IS HAVING TROUBLE LIKE THE TRUNK WONT OPEN AND WE TIDE A STREAM ON IT AND THE LIGHTS STAY ON OVER A HOUR. AND CAR JERK WHEN TAKEING OFF IN SPEED WHEN CHANGE GEARS.

NHTSA complaint #11053394 — an unverified report by a vehicle owner.

POWER TRAIN

ON 4 SEPARATE OCCASIONS SINCE PURCHASING THIS VEHICLE ON 9/22/2017, THE CAR WHILE IN MOTION HAS ABRUPTLY AND UNEXPECTEDLY LOST ALL POWER AND ROLLED TO A COMPLETE STOP. WHEN THIS HAPPENS A WARNING INDICATOR ON THE DASH READS "STOP SAFELY NOW"! ONCE STOPPED, THE CAR IS UNRESPONSIVE AND CANNOT BE TURNED OFF OR RESTARTED. ONLY AFTER SEVERAL MINUTES OF WAITING (5+ MINS), THE CAR RESPONDS AGAIN, ALLOWING A RESTART. THANKFULLY, IN ALL FOUR INSTANCES, I HAVE BEEN TRAVELING ON CITY STREETS AND HAVE BEEN ABLE TO PULL TO THE SIDE OF THE ROAD SAFELY, BUT THIS IS A VERY DANGEROUS SITUATION, AS THE CAR LOSES ALL POWER AND ONCE STOPPED IT WILL NOT RESPOND.

NHTSA complaint #11032927 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2014 FORD FOCUS ELECTRIC. THE CONTACT STATED THAT THE VEHICLE SHUTTERED AND SHOOK WITHOUT WARNING. THE VEHICLE WAS TAKEN TO WILLOW BOOK FORD (7301 KINGERY HIGHWAY, WILLOWBROOK, IL) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION WAS DEFECTIVE AND THE CLUTCH ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 73,744.

NHTSA complaint #11016540 — an unverified report by a vehicle owner.

POWER TRAIN

BRAND NEW FOCUS ELECTRIC, LESS THAN 3 DAYS OLD FROM DEALER ON 8/17/2017. FOR THE LAST TWO DAYS, I HAVE DRIVEN LESS THAN 100 MILES. CAR WAS CHARGED OVERNIGHT AND SHOWS FULL CHARGE THIS MORNING. I DROVE THE CAR LESS THAN 30 MILES TODAY. IN THE EVENING, WHEN I WAS DRIVING, THE CAR SUDDENLY LOST POWER AND THE ENGINE STOPPED SUDDENLY ON THE ROAD. THE CAR WAS IN STEADY SPEED ON A CITY STREET IN A STRAIGHT LINE. I WAS NOT ACCELERATING. I WAS NOT BRAKING. ALMOST GOT HIT BY A CAR BEHIND ME. I WAS UNABLE TO RESTART THE CAR. BATTERY STILL SHOW 80 MILES CHARGE. INDICATOR WARNING SHOWS: "STOP SAFELY WARNING LAMP" AND "ELECTRIC MOTOR WARNING LAMP". ALL INTERIOR LIGHTS ARE BRIGHT WHEN THE CAR DOOR IS OPENED, IT DOES NOT APPEAR THAT THE BATTERY CHARGE IS LOW. ALSO THERE IS NO WARNING OF "LOW BATTERY" BEFORE THE CAR SUDDENLY LOST POWER. I ALSO NOTICED WHEN I TURN OFF THE "POWER/START BUTTON", THE "INFORMATION AND ENTERTAINMENT DISPLAY/GPS" STAYED ON. EVEN AFTER I HAVE CLICKED THE "LOCK" BUTTON ON THE REMOTE CONTROL KEY. AFTER PRESSING THE "POWER/START/STOP" QUITE A NUMBER OF TIME AND SWITCHING BETWEEN THE TWO KEYS, THEN THE "DISPLAY CENTER" FINALLY TURN OFF. WE HAD TO CALL ROADSIDE ASSISTANCE TO HAVE CAR TOWED.

NHTSA complaint #11016442 — an unverified report by a vehicle owner.

POWER TRAIN

I PURCHASED THE VEHICLE NEW ON 3/17/17. A SAFTEY RECALL (16V479) HAD PREVIOUSLY BEEN ISSUED FOR THE VEHICLE BACK IN JUNE 2016. THE DEALER SOLD ME THE VEHICLE EVEN THOUGH IT WAS UNDER A STOP-SALE RECALL IN VIOLATION OF THE MOTOR VEHICLE SAFETY ACT. A FEW DAYS AFTER PURCHASING THE VEHICLE, THE DEALER ASKED ME TO TAKE IT IN FOR WARRANTY WORK. I HAVE NOT HAD USE OF THE VEHICLE FOR THE WEEK SINCE AND AM BEING TOLD THAT IT MAY TAKE 2 MORE WEEKS FOR THE REPAIR WORK TO BE COMPLETED. THE DEALER VIOLATED THE LAW AND THE STOP-SALE RECALL ORDER ON THE VIN BY SELLING ME THE VEHICLE BEFORE THIS REPAIR WORK WAS DONE. I PAID FOR THE VEHICLE, BUT WILL HAVE ONLY BEEN ABLE TO USE IT FOR ABOUT 1 WEEK OVER THE COURSE OF THE FIRST MONTH. NEWS REPORTS INDICATE THAT THE NHTSA HAS FINED DEALERS IN THE PAST FOR THIS.

NHTSA complaint #10970548 — an unverified report by a vehicle owner.

POWER TRAIN

STOP SAFELY NOW WARNING ON DASH. CAR WILL NOT MOVE. HAD TO BE TOWED TO DEALER AGAIN. THIS IS THE FOURTH TIME TO OCCUR IN 7 WEEKS. BEEN AT THE DEALER MOST OF THE TIME SINCE BUYING IT ON 12/16/2016. FORD NEEDS TO SEND AN ENGINEER TO RECTIFY THE ISSUE BEFORE SOMEONE IS INJURED OR KILLED DUE TO THIS SAFETY DEFECT.

NHTSA complaint #10949758 — an unverified report by a vehicle owner.

POWER TRAIN

OVER THE LAST 3 YEARS, THE VEHICLE DISPLAYS "STOP SAFELY NOW" AND ALL ELECTRICAL SYSTEMS SHUT OFF IMMEDIATELY AFTER OR SOON AFTER THE MESSAGE IS DISPLAYED AND THE CAR HAS COME TO A COMPLETE STOP. THIS OCCURS AT LOW CITY SPEEDS (20-30 MPH) AS WELL AS HIGHWAY SPEEDS (60-70 MPH) LEAVING THE DRIVER AND IT'S OCCUPANTS SITTING VULNERABLE TO BEING HIT BY MOVING TRAFFIC. THIS USUALLY OCCURS WHILE BRAKING TO SLOW OR STOP. THIS HAS HAPPENED 15-20 TIMES OVER THE LAST THREE YEARS. WE HAVE BROUGHT IN THE CAR FOR SERVICE FOR THIS SAME PROBLEM 3-4 TIMES EACH TIME BEING TOLD THAT THIS IS DUE TO VARIOUS REASONS (HARNESS, LOOSE CONNECTIONS, FAULTY CIRCUITS, ETC.). NO FIXES TO DATE HAVE PERMANENTLY FIXED THE PROBLEM. USUALLY, THE PROBLEM IS TEMPORARILY RESOLVED WHEN THE VEHICLE COMES TO STOP, IT'S PLACED IN "PARK" AND THE CAR TURNED OFF. AFTER A MINUTE OR TWO, IT CAN BE RESTARTED AS NORMAL. HOWEVER, SEEING AS THOUGH THIS HAPPENS RANDOMLY AT ANY SPEED, TAKING THE WORKAROUND STEPS DESCRIBED IS UNACCEPTABLE ON THE HIGHWAY OR AT INTERSECTIONS WHERE CAR OCCUPANTS CAN BE STRUCK AT ANY MOMENT BY ONCOMING TRAFFIC GIVEN THE FREQUENCY OF THE ISSUE.

NHTSA complaint #10949932 — an unverified report by a vehicle owner.

POWER TRAIN

WHILE BRAKING, THE "STOP SAFELY NOW" MESSAGE APPEARS AND ONCE STOPPED, THE CAR LOSES ALL MOTIVE POWER. OCCURRED FIRST IN NOV 2015 AND DEALER REPLACED WIRING HARNESS. PROBLEM RECURRED IN OCT. 2016 AND DEALER PERFORMED RECALL TSB. PROBLEM RECURRED A 3RD TIME IN NOV 2016 AND DEALER WAS ABLE TO REPLICATE FAILURE WHILE IN FOR SERVICE. "REPAIR" IMPLEMENTED DID NOT RESOLVE THE PROBLEM AS THE CAR HAD 4TH INCIDENT WHILE DRIVING OFF THE DEALER LOT. DEALER CURRENTLY HAS THE CAR AND IS IN COMMUNICATION WITH FORD.

NHTSA complaint #10934479 — an unverified report by a vehicle owner.

POWER TRAIN

I DID THE UPDATE TO THE TCM BUT DID NOT FIX NOTHING MY TRANS STILL MESSES UP AND AROUND SAME TIME IT STARTED STEERING IS GETTING STUCK MAY BE STEARING PUMP FORD WILL NOT HELP AT ALL IV ONLY OWNED CAR FOR A YEAR SOON AS I GOT TO 60000 MILES IT STARED HESITATE JERKING I DID UPDATE LIKE IT SAID 2 DO IT WORKED FOR LIKE A HOUR THEN SAME PROBLEMS BUT IT GOT WORSE IT'S UNSAFE TO DRIVE AND FORD WANTS ALOT OF MONEY JUST TO CHECK IT OUT AGAIN THEN I CAN BARRELY CONTROLE MY CAR WITH THE STEARING WHEEL GETTING STUCK AND NO 1 CAN FIGURE OUT WHAT'S WRONG

NHTSA complaint #10894268 — an unverified report by a vehicle owner.

POWER TRAIN

I HAD YET ANOTHER "STOP SAFELY NOW" WARNING IN WHICH THE CAR COMPLETELY LOST POWER TO THE DRIVETRAIN WHILE IN MOTION. I HAD PREVIOUSLY TAKEN IN THE CAR FOR THE RECALL IN JANUARY AND WAS TOLD THAT WOULD RESOLVE THE ISSUE, BUT THE PROBLEM HAS POPPED UP AGAIN. THIS IS A VERY DANGEROUS THING TO HAPPEN TO HAVE A CAR SUDDENLY LOSE ALL POWER WHILE DRIVING IN THE MIDDLE OF THE ROAD. FORD HAS CLEARLY NOT FIXED THIS PROBLEM YET.

NHTSA complaint #10888834 — an unverified report by a vehicle owner.

POWER TRAIN

TL* THE CONTACT OWNS A 2013 FORD FOCUS ELECTRIC. WHILE DRIVING APPROXIMATELY 20 MPH, THE ENGINE STALLED. AFTER RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THE FAILURE RECURRED THREE TIMES. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V523000 (POWER TRAIN). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20,900.

NHTSA complaint #10884762 — an unverified report by a vehicle owner.

POWER TRAIN

I POWERED ON THE CAR, SELECTED DRIVE OR REVERSE, AND PRESSED THE ACCELERATOR BUT THE CAR DID NOT MOVE. THE GREEN CAR WITH THE ARROWS INDICATING THAT THE CAR IS READY WAS ILLUMINATED AND THE HANDBRAKE WAS RELEASED. THE LIGHT IN THE INSTRUMENT CLUSTER CORRECTLY SHOWED THE GEAR THAT THE LEVER WAS IN, AND WHEN IN REVERSE THE BACKUP CAMERA CAME ON AS USUAL. THERE HAVE BEEN THREE INSTANCES OF THIS MALFUNCTION HAPPENING IN THE PAST TWO WEEKS. WHICH PROMPTED ME TO TAKE IT INTO THE LOCAL FORD SERVICE SHOP. FORD ENGINEERING HAS KNOWN ABOUT THE ISSUE SINCE OCTOBER OF 2015, AND HAS NO ESTIMATION OF A SCHEDULED FIX. THEY HAVE GIVEN INSTRUCTIONS TO TURN OFF AND ON THE CAR UNTIL IT IS ABLE TO DRIVE (USUALLY TAKES 3 OR 4 CYCLES). WHEN PARKED ON A SLOPE IT ACTS LIKE THE TRANSMISSION IS IN NEUTRAL (WHEN IN DRIVE OR REVERSE) SO THE CAR WILL ROLL UNINTENTIONALLY. THIS IS A SAFETY CONCERN BECAUSE THERE IS NO INDICATION THAT THE CAR IS MALFUNCTIONING UNTIL IT DOESN'T MOVE OR IT ROLLS UNINTENTIONALLY. ALSO THE RANDOMNESS OF THE MALFUNCTIONS DOES NOT GIVE ME PEACE IN MIND, AS IT IS MY PRIMARY TRANSPORTATION AND ONLY CAR I OWN.

NHTSA complaint #10871723 — an unverified report by a vehicle owner.