154 of the 2,018 complaints about the 2005 Ford Freestyle are about the fuel system — 8% of everything reported for this model year. Half of the failures with a mileage on record happened before 80,000 miles.
154
Complaints
1
Crashes
1
Fires
0
Injuries
Filed with NHTSA, in their own words.
FUEL/PROPULSION SYSTEM
Our 2005 Ford Freestyle often accelerates or surges forward on its own when applying the brake or parking. It is a very dangerous malfunction that looks to be a wide spread problem for this make and model (based on online reports).
NHTSA complaint #11747522 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
THE VEHICLE LUNGES FORWARD WHEN BACKING AND WHEN STOPPING GOING FORWARD. IT FEELS LIKE SEONE IS PUSHING THE ACCELERATOR EVEN THOUGH YOUR FOOT IS ON THE BRAKE.
NHTSA complaint #11233494 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL LINE JUST SNAPPED OFF THE CAR , ALSO THE TRANSMISSION LINE SNAPPED OFF AND THE TRANS SYSTEM SHUT DOWN, THE DOOR LOCKS SHUT DOWN AND STOPPED WORKING . THE TRANSMISSION AND FUEL LINE SNAPPED WHILE IN MOTION ON THE HIGHWAY.
NHTSA complaint #11232100 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
DASH CLUSTER DIED UNEXPECTEDLY WHILE DRIVING. FOUND PROBLEM TO BE SHODDY SOLDER WORK ON THE CIRCUIT BOARD CAUSING MULTIPLE FAILURES IN THE DASH CLUSTER AND FUEL SYSTEM. HAPPENED DURING HIGHWAY DRIVING AT 60 MPH.
NHTSA complaint #11230688 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
DRIVING DOWN THE ROAD AND LOST POWER THE CAR WAS STILL RUNNING. THE REAR WIPER DOESN'T WORK AND THE TRACTION CONTROL SYSTEM IS MALFUNCTIONING
NHTSA complaint #11208744 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
LA GUAGUA SE APAGA EN PLENA RUTA LUEGO DE HABERLE SUPLIDO DE GASOLINA. NO APAGA LA LUZ INTERIOR DEL TECHO Y TECHO FRENTE AL CONDUCTOR. ESTE AUTO LO ADQUIR HACE UN AO MS O MENOS A TRAVS DE VENTA DIRECTA DEL DUEO. SOLICITO ME REGISTREN PARA TODA CORRESPONDENCIA.
NHTSA complaint #11193987 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
IT LUNGES WHEN I'M TURNING FROM STOP ,TAPPING ON THE BRAKE,TURNING RIGHT CORNERS, BACKING UP WHEN CAR IS WARMED UP, IT LUNGES OUT OF NOWHERE.IM AFRAID I'M GOING TO HIT SOMEONE OR SOMETHING
NHTSA complaint #11166016 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHEN PULLING OUT OF PARKING LOT ONTO HIGHWAY, LOST ALL ACCELERATION AND CHECK ENGINE AND CHECK TRANSMISSION LIGHTS CAME ON, WAS LUCKY THE VEHICLES BEHIND ME WERE PAYING ATTENTION AND I WAS ABLE TO COAST TO SIDE OF ROAD. TURNED CAR OFF AND RESTARTED, WHEN SHIFTING INTO GEAR THERE WAS A LOUD CLUNK IN D AND R, WITH STILL NO RESPONSE FROM THE THROTTLE. AFTER HAVING TO HAVE VEHICLE TOWED HOME SO MY FAMILY AND I WERE OFF OF THE BUSY HIGHWAY, I TRIED TO DISCONNECT THE BATTERY TO TRY AND RESET THE SYSTEM, STILL NO LUCK. WE JUST HAD THE THROTTLE BODY REPLACED LAST YEAR AT A COST OF 700.00, SIMILAR TO SAME ISSUES WITH THROTTLE BUT NOTHING WITH TRANSMISSION AT THAT TIME. AFTER READING THROUGH MULTIPLE REVIEWS THERE ARE NUMEROUS COMPLAINTS OF THIS CVT TRANSMISSION AND THERE WAS ALSO A RECALL ON THE THROTTLE BODY NEEDING TO BE CLEANED. WHAT IS THE PROBLEM OF WHY A RECALL HAS NOT BEEN ISSUED, THESE VEHICLES ARE NOT ONLY FAMILY VEHICLES BUT DEATH TRAPS! SOMETHING NEEDS TO BE DONE BEFORE SOME FAMILY GETS KILLED FROM A FAULTY MISTAKE THAT FORD CO. IS WELL AWARE OF!
NHTSA complaint #10995759 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
CAR WILL STALL OUT WHILE IDLING, ACCELERATING OR DECELERATING (APPARENTLY FAIL SAFE MODE). MAY OR MAY NOT START AGAIN AFTER SHUTTING OFF AND RESTARTING. ALTERNATIVELY, ENGINE WILL ROAR WHEN APPLYING GAS PEDAL, WITH NO ACCELERATION; OR WILL JOLT/SHUDDER WHILE MOVING FROM SECOND TO THIRD GEAR. NEW FUEL PUMP ALREADY INSTALLED. ALL ELECTRICAL CONNECTORS ALREADY GONE OVER AT DEALER. TWICE NEW INERTIA SHUTOFF VALVES INSTALLED. ($800) IF THIS IS RELATED TO THE THROTTLE BODY, I WANT TO BE INCLUDED IN THE CLASS ACTION.
NHTSA complaint #10956858 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
CVT FAIL, THROTTLE BODY ISSUE, STARTED IN SEPTEMBER 2016. CAR NOW HAS 135,030 MILES. HAPPENS CONTINUOUSLY, WHEN IDLE AND MOVING DOWN THE ROAD. I SENT A LETTER TO FORD AND THEY RESPONDED WITH A "SORRY...WE CAN'T HELP YOU". MAKING HELICOPTER NOISE. LOSES POWER AND GOES INTO FAILSAFE MODE. I WILL ATTACH BOTH LETTERS.
NHTSA complaint #10939023 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
DOOR LATCHES FREEZING EVERY WINTER AND DOORS WILL NOT LATCH AND STAY SHUT. ALSO WENT TO FORD WEBSITE AND REALIZED THERE WAS A RECALL FOR FSA TITLE: ENGINE IDLE RPM SURGE EXTENDED WARRANTY FIELD SERVICE ACTION NUMBER: 12N03. I WAS UNAWARE OF THIS RECALL AND MY CAR DOES THIS QUITE FREQUENTLY AND I AM AFRAID THE TENS YEARS IS UP FOR THIS TO BE TAKEN CARE OF. WHEN PULL UP TO A STOP SIGN OR RED LIGHT, SOMETIMES THE ENGINE WILL REV REALLY HIGH AND LURCH FORWARD CAUSING ME TO STOMP ON BRAKE PEDAL REALLY HARD.
NHTSA complaint #10935411 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
1. DRIVING CAR AT 45MPH..CAME TO RED LIGHT. WHEN PUSHING A CELERATOR TO FLOOR , CAR SUDDENLY DOES NOT RESPOND TO PRESSURE ON GAS PEDAL. WILL NOT PICK UP SPEED. NOTICE CHECK E GINE ON DISPLAY PANEL AND WRENCH SYMBOL CAME ON AND WORDS "ENGINE IN FAILSAFE MODE" DISPLAY. 2. WHEN STANDING STILL, ENGINE YRUNNING... FOOT ON BRAKE . ENGINE IDLING. ..CAR BEGINS TO LUNGE FORWARD, ENGINE REVS UP WHEN LUNGING. 3. DURING 90 DEGREE WEATHER, DRIVING AT 55 MPH, TURNED ON AC. CAR IMMEDIATELY LOST POWER AND FAILSAFE MODE LIGHT CAME ON.
NHTSA complaint #10765288 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
TRAVELING ON HWY AT APPROX 60 MPH, WRENCH LIGHT CAME ON, "FAILSAFE ENGINE MODE" MESSAGE APPEARED AND CAR POWERED DOWN. PULLED OVER, TURNED CAR OFF, WAITED 1 MIN, RESTARTED CAR. MESSAGE WAS CLEARED AND CAR DROVE AS NORMAL. ABOUT 20 MILES LATER, SAME PROBLEM, EXCEPT CHECK ENGINE LIGHT AND MESSAGE APPEARED. PULLED OVER, TURNED OFF CAR, RESTARTED. CHECK ENGINE LIGHT AND MESSAGE REMAINED. VERY LOW POWER UPON ACCELERATION. PROBLEM CONTINUED INTERMITTENTLY. RECEIVED ENGINE CODE P2111, P2112 RELATING TO THROTTLE BODY PROBLEM. ETB HAD BEEN CLEANED 11/13 BY DEALER PER TECHNICAL SERVICE BULLETIN ISSUED BY FORD. NO PROBLEMS UNTIL 12/14. SERVICE PERFORMED TO REPROGRAM ETB, NO CLEANING WAS NEEDED. PROBLEM RECURRED 12/23/14. CHECK ENGINE LIGHT IS ON AND NO POWER UPON ACCELERATION PERSISTS. CODES INDICATE ETB NEEDS TO BE REPLACED.
NHTSA complaint #10670132 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
A LITTLE OVER 3 YEARS AGO, I FILED A COMPLAINT REGARDING A SURGING WITH MY FORD FREESTYLE. WE HAD OUR VEHICLE SERVICED AND THE THROTTLE BODY CLEANED. THE PROBLEM WAS RESOLVED FOR A WHILE, BUT WE RECENTLY STARTED EXPERIENCING ISSUES AGAIN. THIS TIME THE FREESTYLE WOULD LOSE ACCELERATION, THE RPMS DROPPED, AND A WRENCH-SHAPED WARNING LIGHT ACTIVATED. AT FIRST IT SEEMED TO BE AN ISSUE ONLY WHEN CRUISE CONTROL WAS ACTIVATED, BUT HAS SINCE HAPPENED DURING NORMAL DRIVING. WE TOOK OUR CAR INTO THE DEALER, AND THEY COMPLETELY REPLACED THE THROTTLE BODY FOR A TOTAL OF $900, BUT WE ARE STILL HAVING ISSUES.
NHTSA complaint #10662974 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WE WERE PULLING OUT OF A PARKING LOT INTO TRAFFIC ON A HIGHWAY AND THE WRENCH LIGHT CAME ON AND WE LOST ALL POWER TO THE VEHICLE. THE VEHICLE HAD TO BE SHUT OFF AND THEN STARTED BACK UP IN THE MIDDLE OF THE ROAD. ANOTHER INCIDENT HAPPENED ON MY WAY TO WORK AND THERE WERE CARS BEHIND ME. I WAS ABLE TO MAKE IT TO THE SIDE OF THE ROAD TO START IT BACK UP. THE THIRD INCIDENT HAPPENED AGAIN ON MY WAY TO WORK AND THEN THE ENGINE LIGHT ILLUMINATED AND WHEN I HAD IT CHECKED THE CODES P2104 AND P2111 CAME UP. THE THROTTLE BODY WAS STUCK OPENED AND IN A BIND. I WAS ALMOST HIT DURING THE SECOND INCIDENT AND FEEL THAT THIS IS A SERIOUS SAFETY ISSUE. I AM GLAD THAT I WASN'T ON THE INTERSTATE GOING 65 OR 70 MPH. THE CAR ALMOST CAME TO A COMPLETE STOP ON ITS OWN IN THE MATTER OF A FEW YARDS.
NHTSA complaint #10655276 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
THE CAR STALLED WHILE I WAS IN LAS VEGAS. I WAS DRIVING ON THE STREET AND ALL OF THE SUDDEN THE SPEED WENT DOWN AND I COULD CONTROL THE SPEED ("FAILED ENGINE SAFE MODE" APPEARED IN THE PANEL). I PARKED THE VEHICLE, TURNED IT OFF AND RE-STARTED IT. THE PROBLEM DIDN'T HAPPEN AGAIN. ON MY WAY BACK, TOOK IT TO FAIRWAY FORD IN PLACENTIA, CALIFORNIA. THEY REPLACED THE THROTTLE BODY, AIR INTAKE AND ENGINE ROLL RESTRICTOR. CAR WAS OK UNTIL 6/6/14 WITH 65,330 MILES WHEN THE SAME THING HAPPENED WHILE DRIVING AROUND MY HOUSE, TOOK IT TO FAIRWAY FORD AND IT WAS RECALL 12N03 ON THE VEHICLE (NEVER RECEIVED A NOTICE FROM FORD), THEY CLEANED THE THROTTLE BODY AND RE-PROGRAMMED THE PCM. 2 MOS. LATER, 8/28/14 SAME THING HAPPENED, AND FAIRWAY FORD TOLD ME THEY HAVE TO REPLACE THE THROTTLE BODY ASSEMBLY AGAIN AND I HAVE TO PAY $860. CALLED FORD CUSTOMER SERVICE AT 800-392-3673, TALKED TO [XXX] AND SHE SAID I COULD GET ANY FINANCIAL ASSISTANCE BECAUSE THE RECALL HAD EXPIRED. I ESCALATED THE SITUATION, AND A SUPERVISOR WILL CALL ME BACK ON TUESDAY 9/2/14. IF THIS HAPPENED ON THE FREEWAY I COULD GET REAR ENDED AND BE KILLED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #10629456 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 FORD FREESTYLE. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE WENT OVER A BUMP IN THE ROAD AND THREE MINUTES LATER THE VEHICLE STALLED. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSE THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA complaint #10628374 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
THE PROBLEM WITH THIS CAR AND THE THROTTLE BODY HAS BEEN GOING ON FOR A WHILE. I TOOK THE CAR TO THE FORD DEALER BUT THEY ONLY CLEANED THE THROTTLE BODY WHEN IT NEEDED REPLACEMENT. THE LAST EVENT WAS IN AUGUST 1 WHEN WHILE I WAS DRIVING THE FAIL SAFE MODE CAME UP AND THE CAR SUDDENLY LOST THE POWER AND WOULDN'T RUN FASTER THAN PROBABLY 0.1 MILE PER HOUR. THIS WAS THE SECOND TIME THIS HAPPENED THE FIRST TIME I WAS WITH MY KIDS IN A MAJOR HIGHWAY AND THE CAR SUDDENLY STOP RUNNING. THANK GOD I HAD A CHANCE TO STEER TO THE EMERGENCY LANE. MANY PEOPLE ARE HAVING THE SAME ISSUE WITH THE 2005-2007 FREESTYLE, THIS IS A SUPER SAFETY ISSUE AND NOBODY IS DOING ANYTHING ABOUT IT. WHEN MY CAR STOPPED I COULD HAVE BEEN HIT ON THE BACK WITH A WORST OUTCOME. I GOT A TOW TRUCK AND THEY TOOK THE CAR TO THE FORD DEALER. THOSE PEOPLE ARE NOT HELPFUL AT ALL AND TREATED ME WITH A BAD ATTITUDE. VERY EXPENSIVE TO CHANGE THAT'S WHY FORD IS NOT GETTING INVOLVED AND ONLY OFFERED TO CLEAN THE PART IN THE EXTENDED WARRANTY, KNOWING THAT WOULDN'T FIX THE PROBLEM. FORD SHOULD HAVE A RECALL FOR THE THROTTLE BODY PART BEFORE SOMEBODY GETS KILLED IN A VERY SERIOUS ACCIDENT THAT THIS PROBLEM COULD CAUSE.
NHTSA complaint #10618367 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I WAS DRIVING ON THE FREEWAY ROUGHLY 65-70 MPH AND THE FAILSAFE ENGINE MODE CAME ON, WHICH DISABLED MY GAS PEDAL. I COULD NOT ACCELERATE. I WAS IN THE FAR LEFT LANE, AND HAD TO "COAST" WITH MY HAZARD LIGHTS ON SO I COULD TURN THE CAR OFF WHILE IN PARK ON THE SHOULDER. I RESTARTED THE CAR AND IT WENT AWAY. THANKFULLY TRAFFIC WAS LIGHT! EARLIER IN THE WEEK THIS SAME THINGHAPPENED ON MY WAY TO WORK I WAS ON A 35 MPH RD, AND IT DID THIS, LOST ALL USE OF THE GAS. HAD TO KILL THE CAR AND RESTART BUT THAT TIME THE CHECK ENGINE CODES P2106 AND P061B WERE DRAWN.(NOT THE FIRST TIME I'VE HAD THESE CODES I KNOW THEY MEAN THROTTLE BODY'SBAD) I'VE KEPT MY OBDII SCANNER IN THE CAR CUZ THESE CODES COME UP ONCE A WEEK AT LEAST. I JUST KEEP ERASING THEM, RESTARTING THE CAR, AND DRIVES FINE TILL IT RANDOMLY GOES OFF AGAIN. THUS WAS THE FIRST TIME IT HAS HAPPENED TO ME ON THE HIGHWAY. IT SCARED ME TO DEATH THAT I WOULD HAVE BEEN REAR ENDED ON A HIGHWAY. THESE SHOULD BE RECALLED. FORD CLAIMS THERE'S NO SAFETY ISSUE. I BARELY AVOIDED A POTENTIAL FATAL CRASH!
NHTSA complaint #10610244 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
IN DRIVE AT 40 MPH TO 55 MPH THE CAR ALMOST STALLS AND GOES I TO FAIL SAFE MODE. IN FAIL SAFE MODE THE CAR RUNS AT 15 MPH. THE DEALER SAYS THEY CAN NOT DUPLICATE THE PROBLEM.
NHTSA complaint #10564917 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
ME AND MY WIFE CARPOOL ON THIRD SHIFT TO OUR JOBS. UPON BACKING OUT OF THE DRIVEWAY IN REVERSE, THE WRENCH LIGHT CAME ON, AND AN ERROR READING" FAILSAFE ENGINE MODE". I WAS ABLE TO MAKE IT TO WORK, HOWEVER I COULDN'T GO FAST AT ALL NO MORE THAN MAYBE 40. I'M SEEING ONLINE MANY WITH THIS YEAR AND MODEL NEED OR HAVE HAD NEW THROTTLE BODY'S PUT IN WITH NO LUCK COMING FROM IT. I'M HOPING THERE'S A RECALL BECAUSE I HAVE TWO CHILDREN AND A WIFE TO GET AROUND IN THIS ONE CAR.I WANNA KNOW WHAT THE RECALL IS ON IT IF ONE AT ALL IS AVAILABLE. WHY HAVEN'T THEY CORRECTED IT YET AFTER ALL THESE YEARS OF PROBLEMS AND SO MANY COMPLAINTS?
NHTSA complaint #10561116 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
IN 2011 THE THROTTLE BODY FAILED ON MY 2005 FORD FREESTYLE. FORD RECOMMENDED CLEANING THE THROTTLE BODY AND I HAD THIS DONE AT A FORD DEALER. FORD LATER EXTENDED THE WARRANTY ON THIS PART AND REIMBURSED ME. FOLLOWING THIS, I FOUND THAT THE CAR OCCASIONALLY LUNGED AND THE RPMS WOULD RACE. ON NOVEMBER 3, 2013 THE VEHICLE WENT INTO FAIL SAFE MODE WHILE DRIVING AT 45 MPH. I WAS IN HEAVY TRAFFIC AND THE ENTIRE ENGINE STOPPED ACCELERATING. I IMMEDIATELY HIT MY BRAKES AND BEGAN TO PULL OVER. I RESTARTED THE VEHICLE AND TRIED TO MAKE MY WAY HOME AT 15 MPH. ON MONDAY I MADE AN APPOINTMENT TO HAVE MY CAR SEEN. I WAS TOLD IT WAS STILL COVERED BY THE EXTENDED WARRANTY. ON TUESDAY THE CAR AGAIN WENT INTO FAIL SAFE MODE AND SHUT DOWN WHILE DRIVING. I WAS ALMOST REAR ENDED. ON INSPECTION, THE DEALER FOUND THAT THE THROTTLE BODY WAS AT FAULT. THE PART WAS FAULTY, AND COULD NOT BE CLEANED TO FIX. IT WOULD HAVE TO BE REPLACED, BUT FORD WOULD NOT COVER THE COST (OVER $900) EVEN THOUGH THEY KNOW THERE IS A PROBLEM WITH THIS PART. WHEN CALLING, I WAS TOLD THAT THEY WOULD ONLY COVER A ONE TIME CLEANING. THE CLEANING DID NOT FIX THE PROBLEM, AND THIS IS A MASSIVE SAFETY ISSUE. THE CAR SHUTS DOWN IN TRAFFIC, LEAVING YOU VULNERABLE.
NHTSA complaint #10551035 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WE HAVE HAD THIS CAR FOR OVER TWO YEARS NOW. IN THOSE TWO YEARS OUR INSTRUMENT CLUSTER HAS BEEN REPLACED BY THE FORD DEALER 4 TIMES NOW. WHEN DRIVING THE INSTRUMENT CLUSTER GOES OFF AND SENDS FUEL SHUTOFF CODES TO THE FUEL SYSTEM WHICH CAUSES THE VEHICLE TO SHAKE. OTHER ITEMS REPLACED WERE THE ONBOARD COMPUTER AND ALTERNATOR. THE COMPUTER HAS BEEN REPROGRAMMED ONCE, BUT NO HELP. I HAVE SEEN THE TECHNICAL RELEASE FOR THIS ISSUE, BUT THIS HAS BEEN A HUGE SAFETY CONCERN FOR MY FAMILY. WHEN THE CAR STARTS TO SHAKE AND YOU ARE DOING 65/70 MPH IT COULD CAUSE AN ACCIDENT.
NHTSA complaint #10548683 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
VEHICLE WOULD SURGE AND LOOSE POWER AT ALL SPEEDS. AT TIMES WHEN PRESSING THE ACCELERATOR THE CAR WOULD NOT RESPOND, THEN ALL OF THE SUDDEN WOULD SURGE, THEN WOULD LOSE POWER. TOOK IT TO THE DEALER RECENTLY AS THEY TOLD ME THAT THERE WAS A RECALL. DEALER CLEANED THE THROTTLE BODY ONLY. NOW IT'S WORSE. I WAS DRIVING BACK FROM THE DEALER AND THE CAR LOST POWER, WRENCH LIGHT ON, AND LEFT ME IN THE MIDDLE LANE OF THE HIGHWAY. SHUT THE CAR OFF AND ON AGAIN AND CONTINUE BUT WITH MINIMAL POWER. TOOK IT TO A MECHANIC WHO TOLD ME THAT THE THROTTLE BODY IS GETTING STUCK. I SEE THIS IS HAPPENED TO A LOT OF FREESTYLE OWNER, ESPECIALLY FROM 2005-2007. CAR IS DANGEROUS TO DRIVE AS IT'S UNPREDICTABLE WHEN SURGES WILL HAPPEN.
NHTSA complaint #10546015 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
I PURCHASED MY FORD FREESTYLE IN JUNE 2011 AND SHORTLY AFTER MY CAR BEGAN LUNGING FORWARD WHEN THE AIR CONDITIONER WAS ON. MY CAR BEGAN DOING IT IN FORWARD AND REVERSE GEAR. I HAVE TAKEN MY CAR TO THE DEALER TWICE BEFORE. THEY REPLACED THE AIR COMPRESSOR, CLEANED THE THROTTLE BODY, AND RESET THE COMPUTER. THIS WILL TREAT THE PROBLEM FOR AWHILE BUT IT WILL ALWAYS COME BACK. LAST WEEK I NEARLY HIT A PEDESTRIAN IN A CROSS WALK WHEN MY CAR DECIDED TO LUNGE FORWARD AT A RED LIGHT WITH MY FOOT ON THE BRAKE. MY WIFE HAS NEARLY HIT CARS IN DRIVE THROUGH LINES. AGAIN I PUT MY CAR IN THE SHOP AND THEY ARE DOING THE SAME WORK AS BEFORE. I HAVE BEEN PUSHED INTO INTERSECTIONS AND NEARLY T-BONED. I HAVE ALMOST HIT CARS WHEN TRYING TO BACK UP. THIS CAR IS NOT SAFE BECAUSE EVEN WITH MY FOOT ON THE BRAKE THE CAR CAN MOVE 5-8 FEET. WHEN THE CAR LUNGES FORWARD OR BACKWARD IT WILL MOST OF THE TIME RUMBLE THEN DIE, WHICH IS DANGEROUS WHEN I AM SENT INTO AN INTERSECTION WITH CARS COMING AT ME. SOMETIMES I AM ABLE TO DEPRESS THE GAS PEDAL ALL THE WAY, DRIVING AT 4000 RPMS AND SLOWLY MOVE OUT OF THE WAY. I WORRY ABOUT MY FAMILY OF SIX SAFETY AS WELL AS ANY INNOCENT THAT MAY GET HURT BECAUSE OF FORDS INCAPABILITY TO FIX THE PROBLEM THEY HAVE CREATED.
NHTSA complaint #10537275 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WE WERE DRIVING ON THE FREEWAY (HWY 350) AND THE CAR JUST STALLED OUT, AGAIN IN TRAFFIC ON TAKE OFF THE CAR STALLED IN THE MIDDLE OF TRAFFIC, ONCE GETTING ON I-70 IT JUST STALLED,. WE TOOK IT TO DICK SMITH FORD HERE IN RAYTOWN, MISSOURI , [XXX] THE SERVICE PERSON SAID IT WAS COVERED UNDER EXTENDED WARRANTY. SO I LEFT THE CAR WITH THEM , AND ABOUT 3:00 PM I GOT A CALL, [XXX] SAID THE CAR WAS READY, HE SAID THEY FIXED THE PROBLEM, BUT IT IS DOING THE SAME THING. THIS TIME IT STOPPED WITH MY WIFE IN THE HEAT OF TRAFFIC, WELL I CALLED [XXX] AT THE DEALERSHIP AGAIN AND HE SAID IT MUST BE SOMETHING ELSE, WELL I HAD A TEST DONE, THE TEST INDICATED IT IS THE SAME PROBLEM THE THROTTLE BODY. I KNOW THE PROBLEM COULD NOT BE A TUNE-UP BECAUSE I JUST SPENT $ 900.00 FOR THAT AT THE SAME FORD PLACE, YES OVER NINE HUNDRED DOLLARS. PLEASE ADVISE WHAT TO DO. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #10533378 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
CAR SUDDENLY SLOWED TO APPROXIMATELY 5 MPH AND THEN STOPPED. ACCELERATOR STOPPED FUNCTIONING. I WAITED FOR TEN MINUTES, TURNED THE ENGINE ON AND LIMPED HOME AT 5 MPH. THIS BREAKDOWN OCCURRED AFTER WORKED WAS PERFORMED AT VARSITY FORD IN ANN ARBOR, MICHIGAN FOR THIS SAME PROBLEM. DEALER ADVISED THAT THE WORKED PERFORMED (CLEANING THE THROTTLE BODY AND REPROGRAMMING THE POWERTRAIN TRAIN MODULE) DID NOT WORK. AFTER DETAILED DISCUSSIONS WITH THE DEALERSHIP, I WAS ADVISED THAT I NEEDED A COMPLETE REPLACEMENT OF THE THROTTLE BODY MODULE AT MY EXPENSE. WHY SHOULD I BE HELD LIABLE FOR THE REPAIR WHEN FORD HAD ALREADY ADMITTED THAT THIS WAS A KNOWN PROBLEM BY CALLING IT IN FOR CLEANING. THIS IS CERTAINLY AN ISSUE FOR THE NHTSA TO ACT ON. I THINK THAT THE $882.73 REPAIR BILL SHOULD BE FORD'S BURDEN, NOT MINE.
NHTSA complaint #10531960 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
HAD RECALL 12N03 PERFORMED DUE TO SURGING, AFTER REPAIR CAR CONTINUED TO SURGE WHEN COLD. WHEN APPROACHING STOP CAR WOULD NOT WANT TO SLOW DOWN, WOULD PUT GEAR IN NEUTRAL AND TACH WOULD SURGE OVER 2000 RPM'S, DOES THIS ON A CONSISTENT BASIS. CONTINUED TO DRIVE UNTIL CAR DIED WHILE DRIVING, GOT MESSAGE FOR THROTTLE BODY ERROR, TOOK TO DEALERSHIP AND WAS INFORMED THAT THROTTLE BODY NEEDS TO BE REPLACED AT OVER $600. RECALL REPAIR DONE IN APRIL AND CAR FAILED IN JULY.
NHTSA complaint #10531566 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
THE VEHICLE BEGAN TO SURGE ON THE HWY. THE RPMS WOULD SURGE FORWARD AND RELAX TO NORMAL RPM SPEED. I RECEIVED A RECALL LETTER A FEW DAY'S AGO. MY WORRY IS THAT I HAVE TAKEN IT TO REPAIR FACILITIES AND THEY FOUND NOTHING WRONG. I AM WORRIED THAT I WILL HAVE TRANSMISSION PROBLEMS BECAUSE OF THE RECALL DEFECT. I HAVE READ MANY POSTS ABOUT CVT TRANSMISSION FAILURE, IT WOULD APPEAR THAT FORD IS DOING NOTHING ABOUT THE TRANSMISSION PROBLEMS. I HAVE OWNED FORDS FOR OVER THIRTY YEARS AND IF THE CVT PROBLEMS ARE NOT ADDRESSED. I WILL NOT BUY ANOTHER, MY FAMILY WILL NOT BUY AGAIN EITHER.
NHTSA complaint #10490047 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
VEHICLE LUNGES OR SURGES WHEN AT IDLE OR LOW SPEEDS IN FORWARD AND REVERSE.
NHTSA complaint #10486748 — an unverified report by a vehicle owner.