92 of the 350 complaints about the 2019 Ford Ranger are about the transmission — 26% of everything reported for this model year. Half of the failures with a mileage on record happened before 50,000 miles.
92
Complaints
3
Crashes
0
Fires
1
Injuries
Filed with NHTSA, in their own words.
POWER TRAIN
Auto transmission is failing to shift when taking off from a stop or hesitating to shift to next year causing traffic behind me to get close to rear bumper.
NHTSA complaint #11755076 — an unverified report by a vehicle owner.
POWER TRAIN
1st I reported to Ford that when my truck was in park and off, it started rolling down a hill. I jumped in and stopped it. Ford said they see nothing and everything looks fine. Since then I use the emergency break every time. 2nd, you feel the transmission shifting hard. Jerks truck. Also, if you drive around 25 mph, the truck starts jerking like it cant make up its mind what gear to be in.
NHTSA complaint #11752783 — an unverified report by a vehicle owner.
POWER TRAIN
The Ford 10R60 and 10R80 transmission has become a hazard on the road. Please see TSB 23-2250. My Ranger only has 43,000 miles on it and is dangerous to drive because of the stuttering and lunging of the transmission. Ford is perfectly aware of this situation but won't fix vehicles that are out of the 5 year warranty at no cost to the owner. No transmission should be faulty after only 43,000 miles. I am requesting that you please investigate this situation as I believe it should be a recall. - Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11747616 — an unverified report by a vehicle owner.
POWER TRAIN
The transmission has issues not shifting gears and having loss of power when pulling out into intersections that are getting worse with time.
NHTSA complaint #11746830 — an unverified report by a vehicle owner.
POWER TRAIN
Hash Shifting and at times kicks into gear hard at a stop light nearly hitting vehicle in front of me
NHTSA complaint #11743330 — an unverified report by a vehicle owner.
POWER TRAIN
My 2019 Ford Ranger is equipped with the 10R80 10-speed automatic transmission that experiences hard/erratic shifting (as if it can't decide what gear it wants to be in), jerking/lunging especially in 1-2 gear when making a brief stop-and-go (stop sign or a crosswalk). The first couple time it happened, it felt like I got rearended or hit a curb.
NHTSA complaint #11736221 — an unverified report by a vehicle owner.
POWER TRAIN
Mileage is at 86980. I have been having issues for a good 10k miles that are slowly getting worse. Transmission is slamming into reverse from park. Shifting is slow from 1st to 2nd gear. Has begun revving engine but not engaging. I have had the transmission fluid changed 3x and flushed and changed the last time. No leakage or overheating. I do not drive her hard, off road or tow. She always gets warmed up before driving. My mechanic believes it is the PCM.
NHTSA complaint #11734116 — an unverified report by a vehicle owner.
POWER TRAIN
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle hesitated, and the transmission was shifting hard. Additionally, the vehicle vibrated abnormally while shifting from 1st to 3rd gear. The vehicle was taken to the dealer, where the TCM was reprogrammed, and various fluids were replaced; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 951.
NHTSA complaint #11731902 — an unverified report by a vehicle owner.
POWER TRAIN
The transmission failed prematurely (my point-of-view) at around 115,000 miles. A Ford dealer diagnosed and determined the transmission needed replaced. The vehicle was a 2019 Ford Ranger XL with a 10-speed automatic transmission. The transmission would get stuck in 2 gear, sometimes upshifting and sometimes downshifting. Driving highway speeds the speed needle would also drop to zero even though I was moving. They noted that solenoids were bad but replacement was needed. I had the transmission replaced with a new warrantied transmission but it was very expensive at $9,650. It did come with a 2-year warranty. That is half the value of the truck! This is the fourth Ford truck I have owned. I do use it as a truck and haul a few things around as projects dictate but do little towing, drive it reasonably, and do not take it off-roading. I have never had a transmission fail before. The Ford dealer, and three area shops, noted they see "a lot of 10-speeds" come in for transmission rebuild or replacement. As a now review many Ford forums I see many people with issues surrounding the durability of the 10-speed transmission.
NHTSA complaint #11724978 — an unverified report by a vehicle owner.
POWER TRAIN
Since owning the vehicle, I have experienced a range of serious transmission issues. These include harsh or delayed gear shifts, inconsistent downshifts, and transmission slipping. The vehicle also frequently jerks or lurches during gear changes. Of particular concern is the vehicle’s behavior during downshifting. At times, the transmission downshifts abruptly and causes the vehicle to lunge forward unexpectedly. This unpredictable behavior presents a significant safety concern, particularly in traffic situations where smooth and predictable vehicle response is essential. These transmission issues negatively affect the safety, drivability, and reliability of the vehicle and are not consistent with normal operation.
NHTSA complaint #11724320 — an unverified report by a vehicle owner.
POWER TRAIN
My transmission has failed at 131,000 miles on my vehicle. It roughly shifts into reverse and harshly shifts while in drive and the vehicle is in motion. My truck shakes while the transmission searches for gears and shifts slowly requiring extra power to move in normal operating conditions.
NHTSA complaint #11724035 — an unverified report by a vehicle owner.
POWER TRAIN
10th gear, gear ratio incorrect. CDF drum failure. Rough shifts from 3-4 struggles to shifts into park and reverse.
NHTSA complaint #11723225 — an unverified report by a vehicle owner.
POWER TRAIN
My truck experienced a P0302 misfire on the freeway, which caused it to shake immediately and made it very difficult to drive. I had it towed to the dealership, and they told me there was water in the spark‑plug wells, which was surprising since I live in Las Vegas, NV, where it rarely rains. My spark plugs were rusted as well as the cylinder head. After looking into it online, I discovered that Ford issued TSB‑23‑2011 for the Ford Ranger due to a windshield cowl leak that allows water to drip directly onto the engine. Their proposed fix is to install an engine cover, but that clearly doesn’t solve the issue since my truck already has the engine cover installed. Now I’m stuck paying for repairs caused by a design flaw that Ford never properly addressed.
NHTSA complaint #11720076 — an unverified report by a vehicle owner.
POWER TRAIN
The vehicle is experiencing a severe power train failure involving erratic and violent gear selection. The transmission unexpectedly jumps from 2nd, 3rd, or 4th gear directly up to 7th or 8th gear, resulting in a total loss of acceleration. This is immediately followed by the transmission "slamming" down into lower gears, usually 1st or 2nd gear without driver input. This behavior is accompanied by a strong burning smell and a dashboard "wrench" warning light. The symptoms match the manufacturing defect documented in Ford TSB 24-2101 (CDF clutch drum). Diagnosis & Manufacturer Response: The issue began in October 2025 with a noticeable transmission shudder. I paid for two transmission flushes at Big O Tires to attempt to resolve the issue, but the mechanical failure has since escalated. When the "wrench" light appeared, an independent diagnostic computer was unable to retrieve an error code, as the light is a proprietary Ford powertrain indicator. Furthermore, the wrench light clears upon restarting the vehicle, despite the violent shifting and burning smell remaining. Ford Corporate agents claim there are "no known issues" and have refused to assist with towing, despite an active NHTSA Engineering Analysis (PE 24-001) regarding this exact 10R80 transmission. Safety Risk: This defect creates an extreme safety hazard. Violent downshifting into low gears at highway speeds can cause a loss of vehicle control or a rear-end collision. The burning smell indicates internal friction and fluid oxidation, posing an immediate fire risk or the potential for a catastrophic mechanical lock-up.
NHTSA complaint #11713793 — an unverified report by a vehicle owner.
POWER TRAIN
The transmission stutters at sustained modest speed (25-45 mph). It was taken to the dealer, who determined it was affected by tsb 25-2134. This is a widely known issue and the dealer refused any servicing without payment. This should have been a recall, since hundreds of known issues in and out of warranty have occurred.
NHTSA complaint #11709896 — an unverified report by a vehicle owner.
POWER TRAIN
The automatic transmission and related transmission control system malfunctioned. The vehicle experienced improper shifting and loss of gears, including a condition in which 4th gear is disabled due to a failsafe logic triggered by the transmission control module. The vehicle and all affected components are currently available for inspection upon request and are at a Ford-authorized dealership. This malfunction posed a safety risk because the vehicle was unable to shift normally or maintain consistent acceleration. The unpredictable shifting and loss of gears could create hazardous situations when merging, accelerating, or driving at highway speeds, potentially endangering the driver and others. The problem has been reproduced and confirmed by a Ford dealership. After inspection and diagnostic testing, the dealership advised that the transmission requires replacement. The vehicle has been inspected by a Ford-authorized dealer. It has not been inspected by the manufacturer directly, police, or insurance representatives (UNKNOWN). Prior to the failure, warning messages and drivability symptoms were present. Specifically, the transmission control module detected an issue when attempting to shift into 4th gear, triggering a failsafe mode that disabled 4th gear for the remainder of the key cycle. These symptoms appeared before the full transmission failure and progressively worsened over time.
NHTSA complaint #11708360 — an unverified report by a vehicle owner.
POWER TRAIN
Transmission shifting issues. Will shift out of gear or delay shifting several seconds and sometimes limited power. The 1080r 10 speed transmission has a know design flaw that was finally fixed in 2023. My 2019 is now having the issue and is $8000 to fix for a bushing that moves out of place
NHTSA complaint #11704620 — an unverified report by a vehicle owner.
POWER TRAIN
Truck looses gear when pulling into traffic. It will shift out of gear and only allow coasting. At speeds of 40 MPH and higher it will down shift causing dramatic reduced speed with no brake warning to other drivers behind. It will also randomly loose power. It will have delayed shifts squealing tires upon shifting and excessive jerking that is uncontrollable.
NHTSA complaint #11704234 — an unverified report by a vehicle owner.
POWER TRAIN
I have had my 2019 Ford Ranger in for service to address issues with the transmission on 3 different occasions starting in Fall of 2023. Each time paying $106 for the deductible on the warranty to service a "Technical Service Bulletin" (TSB). Each time, being told of a different TSB that they would be addressing. Never addressing them all at the same time. In May of 2025, still experiencing the same/similar issues, I brought in in again only to be told that there was a TSB that they did not service, that my warranty had expired. Upon searching the internet, there are many people reporting similar issues with a similar response from Ford. I have spoken to multiple dealerships as well as reached out to Ford car with little to no response.
NHTSA complaint #11703457 — an unverified report by a vehicle owner.
POWER TRAIN
I’ve been noticing a delay in shit out of 1st, 3rd, 6th, and 9th gear. Sometimes it slams but most of the time not. Anyways, this morning on my way to work I passed a slow driver on 2 lane road. After I merged back into the lane, I resumed cruise control and basically lost all power to the wheels. The vehicle I passed about slammed into the back of me. I canceled cruise control to give gas and the transmission was fighting me to stay in a gear. It finally caught and I drove it the rest of the way to work with the “normal” 1,3,6,and 9 being weird. My safety and the other vehicles safety was definitely at risk. The was no warning lights that came on. I haven’t had it checked out yet because this is same day
NHTSA complaint #11701697 — an unverified report by a vehicle owner.
POWER TRAIN
My 2019 Ford Ranger 4x4 was bought new in April of 2019 and has approxiamatly 73,400 miles. Over time a slight glitch in the transission got to be more frequent. When first starting out within the first mile of operation, the vehicle would hang between gears and act like it ran out of fuel for a few seconds at low speed, as in pulling out from a stop sign or accelerating from a dead stop. My guess is inbetween first and second or second and third gear. It just wouldn'd go. Fortunatley I was not involved in any accidents. I can see where this could easily cause a mjor accident. There are several TSB's for this transmission and I believe Ford and General Motors use this same transmission. I have had my truck at the dealer for almost a month after it got scary to drive it got scary to drive. They are repairing this and contributing to the cost. I feel ike they no there is a problem and probably should have done a recall before someone gets killed.
NHTSA complaint #11693113 — an unverified report by a vehicle owner.
POWER TRAIN
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission shuddered abnormally. In addition, while driving approximately 45 MPH, the vehicle drove without issues. No warning light was illuminated. The vehicle was taken to the dealer, and the failure was diagnosed as an internal transmission pump failure. The contact was informed that the transmission pump needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the manufacturer was aware of the failure; however, the repair was not covered under the recall. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 78,000.
NHTSA complaint #11684393 — an unverified report by a vehicle owner.
POWER TRAIN
Air bag malfunctions and not active passanger and driver side, hvac malfunction replaced twice, power train shifting out of gears, PCM malfunctions and triggering failures to sensors. Passanger seat belt not working. Collision sensor malfunction and not working.
NHTSA complaint #11684152 — an unverified report by a vehicle owner.
POWER TRAIN
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was an abnormal sound coming from the vehicle. The contact stated that the check engine and the service warning lights then became illuminated. The vehicle was driven to a nearby Ford dealer. The vehicle was diagnosed with internal failure of the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact referenced an unknown recall with a similar description of the failure; however, the VIN was not associated with the recall. The failure mileage was approximately 73,000.
NHTSA complaint #11678319 — an unverified report by a vehicle owner.
POWER TRAIN
My transmission failed on the highway. I was merging on the highway one day and all of a sudden I felt a sudden reduction in power which was dangerous for the people behind me, and heard an awful grinding/whining noise. I immediately limped it to the dealership and was told several days later the transmission (Ford 10R80) had a catastrophic failure and was lucky to get it to the dealership. This is unacceptable and I know I’m not the only one with issues with these transmissions. The dealership told me it happens all the time. This is a safety issue and unacceptable for the truck that is 5 years old.
NHTSA complaint #11675449 — an unverified report by a vehicle owner.
POWER TRAIN
Own a 2019 Ford Ranger, which is experiencing severe transmission issues including harsh and delayed shifting. A diagnostic scan revealed code P07F7-00, which matches Ford's TSB 24-2046 / 25-2024, related to known defects in the 10R80 10-speed transmission. Despite this being a documented issue, authorized Ford dealerships have refused to properly diagnose the TSB entirely and claiming it was no longer valid. This unresolved defect affects the safety and reliability of my vehicle. I am filing a complaint to request that the NHTSA investigate this widespread problem and consider issuing a recall to address the transmission defect affecting many Ford Rangers (and other vehicles with this transmission). Thank you for your attention to this serious safety concern.
NHTSA complaint #11673464 — an unverified report by a vehicle owner.
POWER TRAIN
Vehicle lurching and loosing power, almost caused accident. Determined DPFE sensor had water in it, replaced sensor. Problem continued with slipping gears and mis-shift. Transmission fluid was burnt and had metal shavings. Repair was complete transmission replacement. Vehicle has 94000 miles.
NHTSA complaint #11672614 — an unverified report by a vehicle owner.
POWER TRAIN
The contact owns a 2019 Ford Ranger. The contact stated that while driving 65 MPH, the vehicle decelerated to 35 MPH. The contact stated that while driving at various speeds, the transmission was skipping gear, slipping, and shifting hard. The check engine warning light was briefly illuminated. The vehicle was taken to the dealer, who diagnosed that the head gasket was failing. The dealer stated that coolant was intruding into the engine, and there was engine oil was entering into the spark plugs, causing engine failure. The dealer also diagnosed the vehicle with transmission failure. The head gasket and the transmission were replaced; however, the failure persisted. The dealer informed the contact that the vehicle needed to be drive more often for the vehicle to run properly. The dealer was unable to duplicate the failure. The vehicle was taken to another dealer, Mountain Grove Ford (11311 Bus Dr #60, Mountain Grove, MO 65711); and the vehicle was diagnosed with a transmission fluid leak and fractured head gasket. The head gasket was replaced; however, the failure persisted. The transmission jerked abnormally when the vehicle was shifted into park on an incline. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer opened a case regarding the failures and extended the warranty for the transmission. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 65,000.
NHTSA complaint #11668851 — an unverified report by a vehicle owner.
POWER TRAIN
10R80 Transmission delays Shifts and slams into gear when it does shift extremely hard.Has caused my back pain. This is a known defect caused by the CD&F drum bushing. This problem has almost caused me and my family to be killed at an Intersection since the vehicle will not accelerate while waiting for gear selection.
NHTSA complaint #11663707 — an unverified report by a vehicle owner.
POWER TRAIN
Transmission failer. Lurches at start up even in park refuses to shift gears
NHTSA complaint #11661686 — an unverified report by a vehicle owner.