139 of the
3,081 complaints filed about the Ford Thunderbird
are about the fuel system —
5% of everything owners reported.
The worst model year for it is 1992.
The contact owns a 2005 Ford Thunderbird. The contact stated that while driving at 30 MPH over a speed bump, the contact heard a loud grinding noise with no warning light illuminated. The contact stated while the vehicle was parked, the contact noticed fuel leaking from the fuel tank with no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the fuel pump failed and needed to be replaced. The vehicle was repaired. The contact stated while driving at an undisclosed speed, the vehicle stalled with no warning illuminated. The vehicle was towed to the dealer where it was diagnosed that the fuel tank failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 33,118.
NHTSA complaint #11620384 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2004 FORD THUNDERBIRD. THE CONTACT STATED THAT WHILE INSIDE THE VEHICLE, AN ABNORMAL ODOR APPEARED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO CHANGED THE OIL AND NOTICED FUEL LEAKING FROM THE FUEL TANK. THE CONTACT MENTIONED THAT THE FAILURE WAS CURRENTLY STILL BEING EXPERIENCED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 05V113000 (FUEL SYSTEM, GASOLINE) AS A POSSIBLE SOLUTION TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000.
NHTSA complaint #11351417 — an unverified report by a vehicle owner.
1ST HAD TO HAVE 8 COILS REPLACED ,2002 NOT COVERED ON RECALL, BUT 2003 AND AFTER WERE. YESTERDAY HAD TO HAVE IT TOWED TO A FORD DEALER, CAR WOULD NOT START. AFTER A DIAGNOSIS, FOUND THE FUEL PUMP NEEDED REPLACED AND FUEL FILTER. THE COST WAS $1500.00. THERE WERE 4 OTHER T-BIRDS THERE PLUS MINE WITH THE SAME PROBLEM. WHAT NEXT? DO I NEED A TOW TRUCK TO FOLLOW ME ALL THE TIME.
NHTSA complaint #11055850 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2005 FORD THUNDERBIRD. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE LOST POWER WITHOUT WARNING. THE VEHICLE WAS RESTARTED, BUT COMPLETELY SHUT DOWN. THE VEHICLE WAS TOWED TO A LOCAL DEALER, BUT THE EXACT CAUSE OF THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE FAILURE RECURRED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED AND THE FUEL PRESSURE WAS REPLACED. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE REAR MODULE AND FUEL PUMP WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 44,168. UPDATED 11/17/16*LJ
NHTSA complaint #10910504 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2005 FORD THUNDERBIRD. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS A CRACK IN THE FUEL SYSTEM AND A VAPOR FUEL LEAK. AS A RESULT, THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V113000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 11,000. UPDATED 08/22/16*LJ UPDATED 08/30/16*LJ
NHTSA complaint #10863376 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2005 FORD THUNDERBIRD. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT SMELLED "RAW" FUEL IN THE VEHICLE. THE CONTACT NOTICED FUEL LEAKED ALL OVER THE GARAGE AT HOME AND THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT FUEL WAS LEAKING AROUND THE SEAM OF THE FUEL TANK COVER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 91,000.
NHTSA complaint #10860518 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2005 FORD THUNDERBIRD. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE WARNING LIGHT ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL TANK WAS CRACKED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V113000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 24,000.
NHTSA complaint #10855559 — an unverified report by a vehicle owner.
WHILE DRIVING AT 35 MPH ON STATE ROUTE 179 MY VEHICLE STARTED RUNNING ROUGH THAN STALLED COMPLETELY MAKING IT DIFFICULT TO STEER AND STOP THE VEHICLE. I HAD IT TOWED TO A REPAIR SHOP WHERE THEY REPLACED THE FUEL PUMP. WHEN THE ENGINE STALLED, IT WAS IN A CURVE AND I BARELY WAS ABLE TO KEEP FROM GOING OFF THE ROADWAY. I SHUDDER TO THINK OF WHAT WOULD HAVE HAPPENED AT HIGHER SPEED.
NHTSA complaint #10818532 — an unverified report by a vehicle owner.
VEHICLE EXPERIENCES UNINTENDED ENGINE ACCELERATION WHEN STOPPING FOR A RED LIGHT OR PLACING THE CAR IN PARK. MOTOR HIT OVER 3500 RPM WHILE PARKING BEFORE I COULD SHUT DOWN THE IGNITION.
NHTSA complaint #10639514 — an unverified report by a vehicle owner.
I WAS ACCELERATING TO MERGE ONTO THE HIGHWAY AT FULL THROTTLE AND THE ENGINE SHUT ITSELF OFF. I PULLED OVER TO THE SHOULDER AND TURNED THE IGNITION OFF AND RESTARTED IT AND CONTINUED TO MY DESTINATION. THIS HAS OCCURRED SEVERAL TIMES OVER THE LAST FEW YEARS, AND IT IS ONLY GETTING WORSE AND MORE FREQUENT. SOMETIMES THE LIMP HOME LIGHT (WRENCH) COMES ON. I MUST TURN THE IGNITION OFF AND BACK ON TO MAKE THE CAR WORK. I HAVE HAD ALL 8 COILS REPLACED AND THIS DID NOT FIX THE PROBLEM AND IT STILL OCCURS TODAY. I CHECKED THE CODES AND IT DID SAY IT WAS A FORCED SHUT DOWN. I UNFORTUNATELY DO NOT REMEMBER THE CODE NUMBER.
NHTSA complaint #10598417 — an unverified report by a vehicle owner.
I SMELL GAS WHEN DRIVING AT HIGH SPEED OF 60 AND ABOVE ON FREEWAY MOSTLY. ONCE IN A WHILE I CAN SMELL IT WHEN DRIVING AT LOWER SPEEDS OF 25 -30MPH. I USED TO THINK THAT I HAD SPILLED GAS ON THE OUTSIDE OF CAR WHEN IT FIRST STARTED HAPPENING, BUT NOW A YEAR LATER, I STILL SMELL GAS AND I DO SMOKE IN MY CAR, BUT WHEN I SMELL THE GAS, I WILL PUT THE CIGARETTE OUT. IS THERE SOME KIND OF RECALL ON THIS PROBLEM, THAT CAN REPAIR IT. I HAVE PUT $4000.00 INTO RESTORING THE CAR AND I AND PUTTING ANOTHER $800.00 INTO IT NEXT WEEK, NOVEMBER 2013, TO REPLACE ALL OF THE BELTS AROUND THE ENGINE. I HAVE ALREADY REBUILT THE TRANSMISSION FOR $1800.00 AT AAMCO, AND PUT A $2200.00 PAINT JOB ON IT, BEFORE I KNEW OF THE GAS SMELL. I HAVE ALSO REPLACED ALTERNATOR AND BATTERY. AM I FIGHTING A LOSING BATTLE WITH THIS CAR?
NHTSA complaint #10550111 — an unverified report by a vehicle owner.
VEHICLE STALLS AND WONT RESTART UNLESS YOU PUT IN A NEW 15 AMP FUSE FOR THE FUEL PUMP CIRCUIT. FUEL PUMP IS FAILING. THIS IS A KNOWN PRODUCT PROBLEM ON THE FORUMS AND FORD HAS NOT ANNOUNCED A RECALL. I CALLED FORD AND THEY SAID SORRY NOTHING WE CAN DO.
NHTSA complaint #10461858 — an unverified report by a vehicle owner.
DRIVING ON A 1,850 MILE TRIP. CAR ENGINE REPEATEDLY SHUT OFF ON LIGHT ACCELERATION FROM COMPLETE STOP. MOTOR LIGHT AND WRENCH LIGHT ILLUMINATED. PUT CAN IN NEUTRAL AND RE-STARTED. WRENCH LIGHT DE-ILLUMINATED, MOTOR LIGHT STAYED ON. ACCELERATION COULD BARELY BE ATTAINED TO KEEP ENGINE RUNNING UP TO 45 MPH. AFTER THAT SPEED, CAN RAN SOMEWHAT NORMALLY,. ENTERING AN EXPRESSWAY AT VERY LOW SPEED WITH MINIMUM ACCELERATION BECAME THE ONLY WAY TO CONTINUE THE TRIP. VERY DANGEROUS. WENT TO A FORD DEALER ON ROUTE. BECAUSE I WAS FROM OUT OF STATE HE AGREED TO WORK ME IN FOR SERVICE THAT DAY. HOWEVER, AFTER I DESCRIBED THE PROBLEM, SERVICE WRITER REFUSED MY REQUEST TO PUT CAR ON THEIR DIAGNOSTIC MACHINE. HE AGREED TO CHANGE THE FUEL FILTER ONLY. DEALER WOULD DO NO OTHER WORK. TOLD ME I WOULD HAVE TO LEAVE IT SEVERAL DAYS. I TRIED TWO TANKS OF FUEL WITH A STODDARD SOLVENT INJECTOR CLEANER. AT HOME. I RESEARCHED THE PROBLEM. THE IGNITION COILS AND THROTTLE BODY ARE INDICATED. I HAVE HAD BOTH IGNITION COILS REPLACED.18,000 MILES AGO. REPLACEMENT FOR BOTH WAS NOT FREE. THIS CONDITION IS ABSOLUTELY DANGEROUS AND HAS NO LEAD UP SYMPTOMS TO WARN YOU. I HAVE BARELY AVOIDED BEING REAR-ENDED SEVERAL TIMES AS I TRIED TO MAKE IT OFF THE EXPRESSWAY. LOCAL FORD DEALER IS TRYING TO AVOID SCHEDULING MY THUNDERBIRD FOR REPAIRS. A RECALL OF THE DEFECTIVE COMPONENTS IS NECESSARY. A CHECK OF THE INTERNET WEB SITES INDICATE THIS IS PREDOMINANT WITH ALL THUNDERBIRDS OF THIS VINTAGE.
NHTSA complaint #10430381 — an unverified report by a vehicle owner.
IN THE MIDDLE OF AUGUST I SMELT GAS WHEN I DROVE. AND THE SMELL HAS BECOME STRONGER AND STRONGER. TODAY (10/10/2011) I WENT TO A VEHICLE REPAIR SHOP AND WAS TOLD THE LEAKING IS ON THE TOP OF FUEL TANK AND COULD NOT BE REPAIRED IN THE SHOP. I CHECKED ONLINE AND FOUND MANY PEOPLE HAVE EXPERIENCED THIS VERY DANGEROUS LEAK. PLEASE CLICK THE LINK: HTTP://WWW.CARGURUS.COM/CARS/DISCUSSION-T872_DS478881. THIS CAR MUST BE RECALLED FOR FUEL LEAKING.
NHTSA complaint #10429371 — an unverified report by a vehicle owner.
TL*THE CONTACT OWNS A 2002 FORD THUNDERBIRD. THE CONTACT STATED WHILE DRIVING 70 MPH, THE VEHICLE SUDDENLY SHUT OFF. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO STATED THAT THE FUEL PUMP CAUSED THE FAILURE TO OCCUR. THE FUEL PUMP WAS REPLACED. THE FAILURE OCCURRED AGAIN AFTER DRIVING APPROXIMATELY 400 MILES. THE FUEL PUMP WAS REPLACED A SECOND TIME. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THE PARTS WERE UNAVAILABLE. THE CURRENT MILEAGE WAS 28,079. THE FAILURE MILEAGE WAS 27,676. UPDATED 07/08/11 *BF UPDATED 09/19/11
NHTSA complaint #10404034 — an unverified report by a vehicle owner.
FUEL LEAK FROM FUEL TANK WHEN FULL . DANGEROUS , COULD CAUSE A FIRE . AUTO IS PARKED IN A GARAGE INSIDE OF MY HOUSE . UNABLE TO FILL TANK BECAUSE OF CONDITION . FORD WILL NOT REPAIR . AROUND 45,000 MILES , NEVER IN ACCIDENT & FUEL SYSTEM NEVER WORKED ON . I THINK THIS IS VERY NEGLIGENT ON FORD'S PART .
NHTSA complaint #10114317 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
1)1992 FORD THUNDERBIRD VIN [XXX], FUEL LINE CHAFFED AGAINST FLOOR PAN CAUSING A PIN HOLE RESULTING IN FUEL LEAKAGE (EXACTLY AS IN NHSA ID: 97V159000 ISSUED 09/17/1997). 2) FUEL LINE LEAKED STRONG ODOR AND EXTEAM FIRE DANGER. 3)JOHN'S REPAIR 189 E. 2ND S. SODA SPRINGS, ID REPLACED FUEL LINE 10/20/03 $292.66. CONTACTED FORD AT 800-392-3673, 07/28/2004, THEY STATED THIS VIN HAD NO OUTSTANDING RECALLS, THEY COULDN'T CROSS CHECK NHTSA ID # TO FORD'S RECALL NUMBER AND FORD WOULDN'T REIMBURSE ME FOR REPAIR.*AK UPDATED 07/25/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #10082845 — an unverified report by a vehicle owner.
CAR STALLS AFTER IT WARMS UP.RUNS WELL WHILE DRIVING WHEN CAMING TO A STOP CALL STALLS AND CAUSES CAR TO NOT HAVE POWER BRAKES OR POWER STEERING WITCH MAY CAUSE A VERY BAD ACCIDENT.
NHTSA complaint #10069318 — an unverified report by a vehicle owner.
FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
A LEAKING FUEL LINE ON MY 1997 FORD THUNDERBIRD, (V6 ENGINE), WITH 113000 MILES ON THE CAR. I HAD THE CAR TOWED TO A FORD DEALER WHO SUGGESTED REPLACING COMPLETELY BOTH FUEL LINES, BECAUSE THERE SEEMED TO BE CORROSION, SO THAT WAS DONE AT A COST TO ME OF $548. AS FAR AS I KNOW THIS CAR HAS NEVER BEEN IN ANY ACCIDENTS, ALTHOUGH I BOUGHT THE CAR USED A FEW YEARS AGO. LUCKILY I NOTICED FUEL LEAKING FROM THE FUEL LINE, AND THEN HAD THE CAR TOWED BY AAA TO THE FORD DEALER. SO NO FIRE OCCURRED. THE CAR BEING JUST 6 YEARS OLD, I AM SURPRISED THAT THERE WOULD BE A LEAKING FUEL LINE. APPARENTLY CORROSION RESULTED IN THE FUEL LINE LEAKING UNDERNEATH THE CAR NEAR THE GAS TANK.
NHTSA complaint #10048871 — an unverified report by a vehicle owner.