Owners have filed 258 complaints
about the 2024 GMC Canyon with NHTSA between 2024 and 2026.
The largest single group is the lights.
Across this model's run it ranks 3 of 19 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the GMC Canyon. 50 means typical for this
model; 100 means roughly double.
Severity — 0
0% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
100% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
444.4%
1,000 – 9,999 miles
333.3%
10,000 – 24,999 miles
222.2%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 2024peak 121Aug 2026
NHTSA investigations into the 2024 GMC Canyon
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
1
investigation is
still open.
EA26006Opened 21 Aug 2026Still openSERVICE BRAKES
Electronic Brake Module Component Failure
On April 11, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24011 after receiving complaints concerning a loss of brake assist in 2023 MY Cadillac Lyriq vehicles. These complaints allege a hard brake pedal, followed by a “Brake System Failure” message at start up or while driving. GM shared records regarding several internal investigations for loss of brake assist due to alleged spindle fractures in the eBoost system. GM has stated that in the event of a spindle fracture, anti-lock brakes (ABS), stability control, and traction control remain functional until th...
Recalls on the 2024 GMC Canyon
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
25V856000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
General Motors, LLC (GM) is recalling certain 2024–2026 GMC Canyon AT4X AEV vehicles. Incorrect sensing and diagnostic module (SDM) software may cause a second stage passenger air bag deployment when only a first stage is intended. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 208, “Occupant Crash Protection."
Risk: An air bag that deploys improperly increases the risk of injury in a crash.
24V673000
EXTERIOR LIGHTING:HEADLIGHTS
General Motors, LLC (GM) is recalling certain 2024 GMC Canyon vehicles. The headlights may flicker while driving and while the vehicle is in park. As such, these vehicles fail to comply with the requirements of Federal Motor Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Headlights flickering can reduce visibility, increasing the risk of a crash.
24V491000
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
General Motors, LLC (GM) is recalling certain 2024 Chevrolet Colorado and GMC Canyon vehicles. The lock ring that secures the fuel pump to the fuel tank assembly may not have been fully locked during assembly, which can result in a fuel leak during a crash.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2025680177 units in Canada
Airbag
Issue: Under certain conditions, a software problem could cause the passenger-front airbag to deploy with too much force. Note: This recall only affects certain vehicles equipped with the AT4X AEV (American Expedition Vehicle) option. Safety Risk: An airbag that inflates with too much force could create an increased risk of injury in a crash. Corrective Actions: General Motors will notify owners by mail and advise you to take your vehicle to a dealership to update the airbag sensing and diagnostic module (SDM) software.
Recall 20245182,392 units in Canada
Lights And Instruments
Issue: Under certain conditions, a software problem could cause the headlamps to flicker. Safety Risk: Headlamps that flicker could cause reduced visibility and could create a distraction for oncoming drivers. Both issues could increase the risk of a crash. Corrective Actions: General Motors will notify owners by mail and advise you to take your vehicle to a dealership to replace a module in the headlamp that includes the correct software.
Recall 20243751,274 units in Canada
Fuel System
Issue: On certain vehicles, the lock ring that secures the fuel pump to the fuel tank may not have been locked properly. As a result, the lock ring could loosen and create a fuel leak. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: General Motors will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, lock the fuel tank lock ring.
In the owners' own words, exactly as filed with NHTSA.
Lewes, DE
ELECTRICAL SYSTEM
Vehicle alerted driver that ECS and. Rake assist was needed and disabled abs and forward collision while lighting up multiple warning lights on dashboard. Lights eventually turned off leaving a check engine light on. Multiple codes pulled from system using obd2 reader. Communication bus B offline and U0074, U0151, U0447,U0452 all at same time.
NHTSA complaint #11755424 — an unverified report by a vehicle owner.
Lewes, DE
SERVICE BRAKES
Vehicle alerted driver that ECS and. Rake assist was needed and disabled abs and forward collision while lighting up multiple warning lights on dashboard. Lights eventually turned off leaving a check engine light on. Multiple codes pulled from system using obd2 reader. Communication bus B offline and U0074, U0151, U0447,U0452 all at same time.
NHTSA complaint #11755424 — an unverified report by a vehicle owner.
Lewes, DE
FORWARD COLLISION AVOIDANCE: WARNINGS
Vehicle alerted driver that ECS and. Rake assist was needed and disabled abs and forward collision while lighting up multiple warning lights on dashboard. Lights eventually turned off leaving a check engine light on. Multiple codes pulled from system using obd2 reader. Communication bus B offline and U0074, U0151, U0447,U0452 all at same time.
NHTSA complaint #11755424 — an unverified report by a vehicle owner.
Woodbridge, VA
SERVICE BRAKES
I first noticed the brakes squealing in August 2025 at 15,000 miles. The dealership said I needed to resurface the front rotors. I mistook this a coating and brake debris, but it was actually the rotors warping. By 21,000 the vehicle is pulsing heavily when stopping. I went back to the dealer and this time they told me all 4 rotors are warped. GM denied coverage of the pads and rotors. Normal driving, no collisions or towing.
NHTSA complaint #11727764 — an unverified report by a vehicle owner.
Leesburg, VA
ENGINE
Coolant leak caused by known manufacture defect in upper hose assembly causes coolant to drain and engine to overheat. CEL only comes on when coolant is almost gone. GMC refuses to cover the known issue after 36k miles.
NHTSA complaint #11722976 — an unverified report by a vehicle owner.
Inman, SC
ENGINE
Coolant Leaking at 22K miles, smell of coolant, check engine light on and off 2X's. Coolant evidence on driveway and in engine cabin. Known condition for GM Model. No parts available for replacement. No recall for issue.
NHTSA complaint #11722659 — an unverified report by a vehicle owner.
San Diego, CA
UNKNOWN OR OTHER
Radiator Hose began to leak coolant. Faulty radiator hose. This could have caused engine failure and potentially caused an accident or may have put others at risk for hazards. No warning other strange sound. Inspected by authorized dealers service center.
NHTSA complaint #11722277 — an unverified report by a vehicle owner.
Glen Allen, VA
ENGINE
Upper radiator hose connection to radiator is faulty causing leak of coolant. Yes it is available for inspection upon request. Truck began to run cooling fan at full speed in the middle of winter with no warnings of high heat or low coolant. After two weeks, check engine light finally cut on to indicate low coolant flow. Coolant reservoir was subsequently checked and found to be completely empty. It is apparent this reservoir had been extremely low / empty for at least two weeks with no warnings. Without proper warning and leaking coolant, truck could have overheated. Should this had happened in dead of summer, truck could have very well overheated with no warning. The problem was investigated and confirmed by dealer as leaking coolant at the connection of the upper radiator hose to the radiator. Was quoted $983 to replace the hose. No warning lights appeared until issue had been ongoing for over two weeks. A quick search of "GMC Canyon Upper Radiator Hose" will reveal many identical occurrences of this issue. This is a safety hazard / design flaw that GM is not acknowledging and is putting the burden on the vehicle owners for their own issue.
NHTSA complaint #11721052 — an unverified report by a vehicle owner.
Kailua, HI
ELECTRICAL SYSTEM
On 2 occasions the battery was drained and a tow truck had to jump the battery. On one occasion after the battery was jump started it took several hours before the brakes were able to be used and the car driven safely. Had to drive very slowly (under 50 mph) per note that appeared on dashboard. After nearly an hour of waiting Engine light stayed on and dealership ran diagnostic and found nothing wrong with the battery nor anything else. Have to start and run engine everyday to keep battery from dying. If not started in 24 to 36 hours, battery will die.
NHTSA complaint #11718011 — an unverified report by a vehicle owner.
Kailua, HI
ENGINE
On 2 occasions the battery was drained and a tow truck had to jump the battery. On one occasion after the battery was jump started it took several hours before the brakes were able to be used and the car driven safely. Had to drive very slowly (under 50 mph) per note that appeared on dashboard. After nearly an hour of waiting Engine light stayed on and dealership ran diagnostic and found nothing wrong with the battery nor anything else. Have to start and run engine everyday to keep battery from dying. If not started in 24 to 36 hours, battery will die.
NHTSA complaint #11718011 — an unverified report by a vehicle owner.
Kailua, HI
SERVICE BRAKES
On 2 occasions the battery was drained and a tow truck had to jump the battery. On one occasion after the battery was jump started it took several hours before the brakes were able to be used and the car driven safely. Had to drive very slowly (under 50 mph) per note that appeared on dashboard. After nearly an hour of waiting Engine light stayed on and dealership ran diagnostic and found nothing wrong with the battery nor anything else. Have to start and run engine everyday to keep battery from dying. If not started in 24 to 36 hours, battery will die.
NHTSA complaint #11718011 — an unverified report by a vehicle owner.
Maryville, MO
SERVICE BRAKES
Upon starting the vehicle, I got multiple warning lights. The most important was brake failure. I had no brake function. I took it to the dealer and they replaced the brake module after 3 days.
NHTSA complaint #11713383 — an unverified report by a vehicle owner.
Victoria, VA
ENGINE
There are widespread reports of the O ring seals on the radiator and heater hoses failing and causing coolant leaks. These leaks are significant enough to render the vehicle inoperable and with no cabin heating or cooling. This could lead to life-threatening situations in adverse weather conditions. It could also create dangerous roadside failure situation in heavy traffic, particularly on interstate highways. Dealers are aware of the issue and are currently repairing vehicles under warranty. However some dealers are telling owners that the cooling system is not part of the engine and drivetrain, and therefor is not covered under the original factory warranty if the vehicle has exceeded the initial bumper to bumper warranty limits. Dealers are also telling owners that parts are on backorder due to high demand, and that repair wait times could take weeks. The vehicle is unsafe to operate with a known coolant leak. Video of leak (another owner) here. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11711833 — an unverified report by a vehicle owner.
Richland, IN
ENGINE
Upper radiator hose attachment is leaking due to faulty rubber gasket. This comes up across GMC Canyon groups on Facebook 10 times a day. It is happening to ALL of them mainly pre 2025 on 3rd gens. Part is on back order at all GMC dealers due to so much volume of issue. Happening as early as 10k-20k miles on brand new trucks causing over heating issues due to coolant leaking out. Hopefully a recall for the part is done before engines start blowing.
NHTSA complaint #11711886 — an unverified report by a vehicle owner.
Burleson, TX
POWER TRAIN
Truck began idling very rough. Went straight to the dealership. They shut the truck off and it would not restart. No CEL or messages on the dash. Tear down reveled a failed exhaust valve in cylinder #4. Truck has 10,000 miles. A replacement engine has been ordered under warranty. Luckily, we happened to only be a few miles from a dealership when the failure happened. There was no warning, no prior symptoms what so ever.
NHTSA complaint #11710979 — an unverified report by a vehicle owner.
Burleson, TX
ENGINE
Truck began idling very rough. Went straight to the dealership. They shut the truck off and it would not restart. No CEL or messages on the dash. Tear down reveled a failed exhaust valve in cylinder #4. Truck has 10,000 miles. A replacement engine has been ordered under warranty. Luckily, we happened to only be a few miles from a dealership when the failure happened. There was no warning, no prior symptoms what so ever.
NHTSA complaint #11710979 — an unverified report by a vehicle owner.
Chicago, IL
TIRES
The contact owns a 2024 GMC Canyon equipped with Goodyear Tires, Tire Line: Wrangler Territory, Tire Size: 265/65/R18, DOT number: 1M6C8JT1R. The contact stated that while her husband was driving at an undisclosed speed, the TPMS indicated a low tire pressure. The driver pulled over and noticed that the passenger’s side rear tire was low. The vehicle was taken to a tire shop, and it was determined that the tire damaged and the lock was missing. The mechanic located a pair of pliers between the rim and tire. The tire was replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The tire and vehicle failure mileages were unknown.
NHTSA complaint #11709841 — an unverified report by a vehicle owner.
Chicago, IL
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
The contact owns a 2024 GMC Canyon equipped with Goodyear Tires, Tire Line: Wrangler Territory, Tire Size: 265/65/R18, DOT number: 1M6C8JT1R. The contact stated that while her husband was driving at an undisclosed speed, the TPMS indicated a low tire pressure. The driver pulled over and noticed that the passenger’s side rear tire was low. The vehicle was taken to a tire shop, and it was determined that the tire damaged and the lock was missing. The mechanic located a pair of pliers between the rim and tire. The tire was replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The tire and vehicle failure mileages were unknown.
NHTSA complaint #11709841 — an unverified report by a vehicle owner.
Kansas City, MO
ENGINE
Upper radiator hose leaks where it connects to radiator. 40k miles and my truck has no coolant
NHTSA complaint #11707894 — an unverified report by a vehicle owner.
Katy, TX
UNKNOWN OR OTHER
I am reporting a driver distraction safety issue involving the infotainment system in my 2024 GMC Canyon. The vehicle displays a mandatory “Focus your attention on driving” warning every time the vehicle is started, requiring user acknowledgment. When using the built-in Google Maps navigation without subscribing to GM’s paid Connected Services plan (while tethering to a personal cellphone hotspot instead), the system displays a modal warning stating that a connected services subscription is required. This warning appears whenever cellular connectivity is briefly interrupted, even for a few seconds (such as when driving through a known cellular dead spot). The warning overlays the navigation screen and requires the driver to manually press a “Dismiss” button to continue, even while the vehicle is in motion, requiring the driver to take their eyes off the road to focus on pressing the dismiss button. This behavior creates a safety contradiction: The system warns drivers to focus on driving, then forces manual interaction with the touchscreen during active driving. The interruption is triggered by transient network conditions, not driver action. The behavior does not occur if the driver pays for GM’s subscription service, indicating it is a business-rule enforcement rather than a technical or safety requirement. The repeated appearance of this warning during normal driving conditions constitutes an unnecessary and avoidable distraction. It diverts attention from the road and navigation, increasing risk rather than reducing it. I believe this design violates established human-factors safety principles by introducing nonessential driver interaction during vehicle operation and should be reviewed as a potential safety defect related to driver distraction. We just got home from a trip to West Texas and had to press the dismiss button no less than 100 times while driving through areas with marginal/intermittent cell service. It's a huge driver distraction.
NHTSA complaint #11706486 — an unverified report by a vehicle owner.
Yorba Linda, CA
VEHICLE SPEED CONTROL
I've noticed an issue since I picked up my vehicle from its last service where the RPMs stay around 1,000 when I let off the gas and should be coasting. The vehicle will continue to accelerate at 11 to 13 mph, and I really have to mash the brake pedal to stop. There is an update notice that popped up starting yesterday, but it will not install. Looks like the update is for the issue I am having. The update was supposed to be installed already per the service bulletin. Update number is N242452130
NHTSA complaint #11698266 — an unverified report by a vehicle owner.
Yorba Linda, CA
ENGINE
I've noticed an issue since I picked up my vehicle from its last service where the RPMs stay around 1,000 when I let off the gas and should be coasting. The vehicle will continue to accelerate at 11 to 13 mph, and I really have to mash the brake pedal to stop. There is an update notice that popped up starting yesterday, but it will not install. Looks like the update is for the issue I am having. The update was supposed to be installed already per the service bulletin. Update number is N242452130
NHTSA complaint #11698266 — an unverified report by a vehicle owner.
Yorba Linda, CA
FUEL/PROPULSION SYSTEM
I've noticed an issue since I picked up my vehicle from its last service where the RPMs stay around 1,000 when I let off the gas and should be coasting. The vehicle will continue to accelerate at 11 to 13 mph, and I really have to mash the brake pedal to stop. There is an update notice that popped up starting yesterday, but it will not install. Looks like the update is for the issue I am having. The update was supposed to be installed already per the service bulletin. Update number is N242452130
NHTSA complaint #11698266 — an unverified report by a vehicle owner.
at 4,491 milesOcala, FL
ENGINE
The contact owns a 2024 GMC Canyon. The contact stated that while driving at various speeds, the steering wheel was rattling abnormally. The check engine warning light was briefly illuminated. The vehicle was taken to a local dealer, where the vehicle was test-driven; however, the failure was not identified. The failure reoccurred, and the vehicle was taken back to the same local dealer, where it was diagnosed as needing a rear intermediate steering shaft, and a retest was performed. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same local dealer, where the vehicle remained under investigation. The manufacturer was made aware of the failure. The failure mileage was approximately 4,491.
NHTSA complaint #11693569 — an unverified report by a vehicle owner.
Portsmouth, VA
ENGINE
2024 GMC Canyon Elevation trim 4x4 with 31,000 miles on it always had maintenance every 5k interval. I noticed an upper radiator hose leak significant enough to require a decent amount of coolant and decided to take it in to GMC to get it repaired. Mind you this repair is almost $1,000 to get repaired with the hose itself only costing $148. It's disappointing to have such a new truck and have these kinds of problems and upon research there seems to be several others with the same problem relating to an O ring in the upper radiator hose. Considering the truck is routinely serviced more frequently than required I see this as an issue for someone to run out of coolant and possibly be stranded on the side of the road if gone unnoticed and needs to be properly addressed asap.
NHTSA complaint #11693216 — an unverified report by a vehicle owner.