THERE IS A STRONG FUEL SMELL IN THE PASSENGER CABIN. I HAVE TAKEN IT BACK TO THE DEALER, AND THE FUEL LINES HAVE BEEN REPLACED, BUT THE FUEL SMELL CONTINUES. IT HAPPENS ON START, WHEN STOPPING AFTER DRIVING, WHEN IDLING. IT HAS HAPPENED SINCE I HAVE OWNED THE VEHICLE FOR 3 YEARS. IT MAKES THE VEHICLE ALMOST UNDRIVABLE AND I AM GETTING SICK FROM IT BUT I CAN'T AFFORD TO GET ANOTHER VEHICLE WITHOUT SELLING THIS ONE AND I CAN'T SELL THIS ONE TO SOMEONE UNLESS THE GAS SMELL IS FIXED. I WANT IT FIXED OR MY MONEY BACK. I THINK IT SHOULD BE A DEALER REPAIR SINCE IT'S A SAFETY ISSUE AND SINCE IT'S BEEN DOING IT SINCE IT WAS UNDER WARRANTY.
NHTSA complaint #11287738 — an unverified report by a vehicle owner.
WHEN STARTING OUT IN MORNING THE MOTOR RUNS BUT DOESN'T SEEM TO HAVE ENOUGH FUEL PRESSURE TO RUN THE TRUCK BUT AFTER A FEW SECONDS IT SEEMS TO RECOVER AND TAKES OFF. DOESN'T SEEM SAFE WHEN PULLING ON TO STREET OR HIGHWAY. IT HAPPENS EVERY MORNING ON FIRST STARTUP.
NHTSA complaint #11120158 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2003 GMC SAVANA. THE CONTACT STATED WHILE DRIVING 30 MPH, THE CHECK ENGINE LIGHT ILLUMINATED. ALSO, THE CONTACT SMELLED FUEL INSIDE THE VEHICLE AND FUEL LEAKED OUT OF THE FUEL TANK WHILE THE VEHICLE WAS PARKED ON A HILL. THE CONTACT RECEIVED A RECALL NOTICE FOR CAMPAIGN NUMBER 06E043000 (FUEL SYSTEM, GASOLINE) AND TOOK THE VEHICLE TO THE DEALER. THE DEALER DID NOT HONOR THE RECALL AND WOULD NOT INSPECT THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO ANOTHER DEALER. THE DEALER STATED THERE WAS NO CORROSION ON THE FUEL FILLER PIPE BUT THE FUEL TANK HAD CORROSION AND NEEDED TO BE REPLACED, MAKING THE VEHICLE UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 159,000. THE VIN WAS NOT AVAILABLE.
NHTSA complaint #10504823 — an unverified report by a vehicle owner.
NO INCIDENT ...YET. NOTICED THE SMELL OF GAS AFTER REFUELING JUST BEFORE CHRISTMAS 2012. IT HAS BEEN GETTING WORSE EVER SINCE. CHECKED OUT RECALLS AND SAW THIS ONE, BUT NEVER RECEIVED A RECALL NOTICE. CALLED LOCAL DEALER AND TOLD ME THAT IT WAS NOT COVERED. SOMETHING IS WRONG HERE. THIS RECALL (LISTED BELOW) IS EXACTLY WHAT IS THE ISSUE WITH MY GMC VAN. IT SHOULD BE INCLUDED IN THIS RECALL BUT FOR SOME REASON IS NOT. I AM GOING TO FIX IT MYSELF (AT MY OWN EXPENSE), BECAUSE IT IS A SAFETY ISSUE AND I AM NOT GOING TO RISK THE SAFETY OF MY FAMILY. FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP RECALL NUMBER: 12V388000 RECALL DATE: 08/08/2012 PROBLEM SUMMARY: GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2003-2004 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES, EQUIPPED WITH A LEFT SIDE CARGO DOOR, AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. WATER AND ROAD CONTAMINANTS MAY BECOME TRAPPED IN THE PROTECTIVE CONDUIT THAT COVERS THE FUEL FILLER PIPE AND MAY CAUSE THE PIPE TO CORRODE. CONSEQUENCE: SIGNIFICANT CORROSION MAY ALLOW FUEL TO LEAK DURING REFUELING, AND IN THE PRESENCE OF AN IGNITION SOURCE; THERE IS AN INCREASED RISK OF FIRE. CORRECTIVE ACTION: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A NEW FUEL FILLER NECK, FREE OF CHARGE. GM HAS NOT PROVIDED A NOTIFICATION SCHEDULE. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546 AND GMC AT 1-866-996-9463. THIS RECALL AFFECTS VEHICLES MANUFACTURED BETWEEN 05/14/2003 AND 06/24/2003.
NHTSA complaint #10497641 — an unverified report by a vehicle owner.
NO INCIDENT ...YET. NOTICED THE SMELL OF GAS AFTER REFUELING JUST BEFORE CHRISTMAS 2012. IT HAS BEEN GETTING WORSE EVER SINCE. CHECKED OUT RECALLS AND SAW THIS ONE, BUT NEVER RECEIVED A RECALL NOTICE. CALLED LOCAL DEALER AND TOLD ME THAT IT WAS NOT COVERED. SOMETHING IS WRONG HERE. THIS RECALL (LISTED BELOW) IS EXACTLY WHAT IS THE ISSUE WITH MY GMC VAN. IT SHOULD BE INCLUDED IN THIS RECALL BUT FOR SOME REASON IS NOT. I AM GOING TO FIX IT MYSELF (AT MY OWN EXPENSE), BECAUSE IT IS A SAFETY ISSUE AND I AM NOT GOING TO RISK THE SAFETY OF MY FAMILY. FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP RECALL NUMBER: 12V388000 RECALL DATE: 08/08/2012 PROBLEM SUMMARY: GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2003-2004 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES, EQUIPPED WITH A LEFT SIDE CARGO DOOR, AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. WATER AND ROAD CONTAMINANTS MAY BECOME TRAPPED IN THE PROTECTIVE CONDUIT THAT COVERS THE FUEL FILLER PIPE AND MAY CAUSE THE PIPE TO CORRODE. CONSEQUENCE: SIGNIFICANT CORROSION MAY ALLOW FUEL TO LEAK DURING REFUELING, AND IN THE PRESENCE OF AN IGNITION SOURCE; THERE IS AN INCREASED RISK OF FIRE. CORRECTIVE ACTION: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A NEW FUEL FILLER NECK, FREE OF CHARGE. GM HAS NOT PROVIDED A NOTIFICATION SCHEDULE. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546 AND GMC AT 1-866-996-9463. THIS RECALL AFFECTS VEHICLES MANUFACTURED BETWEEN 05/14/2003 AND 06/24/2003.
NHTSA complaint #10497641 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2003 GMC SAVANA. THE CONTACT STATED THAT FUEL LEAKED TO THE GROUND WHILE REFUELING THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 109,000.
NHTSA complaint #10463398 — an unverified report by a vehicle owner.
TL*THE CONTACT OWNS A 2000 GMC SAVANA. THE CONTACT STATED THAT THE FUEL GAUGE WAS DEFECTIVE. THE CONTACT MENTIONED THAT HE HAD TO WATCH THE MILEAGE ON THE VEHICLE IN ORDER TO KNOW THE FUEL LEVEL INSTEAD OF RELYING ON THE FUEL GAUGE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND CURRENT MILEAGE WAS 135,000.
NHTSA complaint #10398503 — an unverified report by a vehicle owner.
FUEL LINE FROM GAS TANK TO "QUICK CONNECT" SPLIT NEAR THE MUFFLER. WITH THE PRESSURE OF THE FUEL PUMP, GASOLINE WAS SPEWING OUT OF THE LINE UNDER THE TRUCK NEAR THE MUFFLER. IT HAD HAPPENED TWO WEEKS OR SO EARLIER BUT I DIDN'T NOTICE IT BECAUSE I'D HAD A GAS SPILL FROM A LEAF BLOWER IN THE BACK OF THE VAN AND THOUGHT THAT WAS THE SMELL (EVEN THOUGH I'D WIPED IT UP). I WENT TO MY MECHANIC TO SEE IF HE COULD CLEAN THE SPILL. HE FOUND THE SPLIT THAT WAS CAUSING THE ODOR. IT WOULD SEEM TO BE A REAL FIRE HAZARD. THE FUEL LINE IS PLASTIC, MY MECHANIC SAYS, AND THERE ARE VERY FEW AVAILABLE (NONE AT FACTORY WAREHOUSES).
NHTSA complaint #10195969 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
DT*: THE CONTACT STATED THERE IS A STRONG ODOR OF GASOLINE. THERE IS A NHTSA RECALL, # 00V110000, REGARDING THE FUEL SYSTEM GASOLINE DELIVERY HOSES, LINES/PIPING AND FITTINGS. THE VIN WAS NOT INCLUDED IN THE RECALL. UPDATE 05/30/2006. *AK
NHTSA complaint #10156325 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
PLASTIC PRESSURE FUEL LINE ON MY GMC 1997 SAVANNAH G150 DEVELOPED A PUNCTURE SPRAYING GASOLINE NEAR EXHAUST PIPE HAD TO REPLACE SEND DEFECTIVE LINE TO GM THEY SAID THEY HAD NO WAY TO TEST IT.
NHTSA complaint #10152204 — an unverified report by a vehicle owner.
DT: THE CONSUMER STATED THAT THE FUEL PUMP LOCATED INSIDE THE FUEL TANK, BASICALLY BURNED OUT. CONSUMER SAID THE ONLY THING THAT SAVED VEHICLE WAS THAT THE HILL HE WAS TRAVELING ON WAS NOT STEEP. CONSUMER LOST POWER FUNCTION IN 2000 GMC SAVANNAH 2500. THERE WERE SO SIGNS OF ANY TROUBLE BEFORE THIS HAPPENED. OWNER CONTACTED THE DEALERSHIP, THERE WAS NOTHING THEY COULD DO BECAUSE IT WAS OUT OF WARRANTY. MANUFACTURER SAID THE SAME THING, THEY COULD NOT HELP . THE FUEL PUMP WAS REPLACED ALREADY, AND THE PROBLEM SEEMED TO CORRECT ITSELF. THE INFORMATION GIVEN IS WHAT THE CONSUMER PROVIDED AT THIS TIME.
NHTSA complaint #10130069 — an unverified report by a vehicle owner.
FUEL INJECTORS CLOGGING VERY OFTEN CAUSING VEHICLE TO RUN ROUGH AND SHAKE. DEALER REPAIRED FIRST TIME WITH ONLY 11,000 ON VEHICLE. BUT STATED THAT IT WAS NOT WARRANTY. INJECTORS ARE CONTINUING TO CLOG EVERY 6,000-7,000 MILES EVEN WHEN CHANGING FUEL FILTER AND HAVING INJECTORS SERVICED. AND USING QUALITY FUEL AND INJECTOR CLEANER EVERY 3,000 MILES.
NHTSA complaint #10112603 — an unverified report by a vehicle owner.
NO WARNING FAILURE OF STANADYNE PN [XXX] (GM NUMBER) OR MFG #[XXX]. VEHICLE IS 2001 GMC VAN [XXX]. THE FUEL SOLENOID DRIVER (FSD) IS LOCATED ON THE INJECTOR PUMP AND IS USED TO DRIVE THE FUEL SYSTEM. ITS FAILURE IS CAUSE BY HEAT OR LACK OF COOLING OF THE TWO 500 WATT TRANSISTORS. FAILURE IS ABRUPT WITH OUT WARNING AND CAUSES LOSS OF VEHICLE CONTROL DUE TO STALLING. AFTER COOL DOWN VEHICLE CAN BE RESTARTED. FIRST FAILURE OCCURRED 5/22/2003 AT 39630 MILES AND WAS REPAIRED UNDER CLAIM NUMBER 1-105619528. THE SECOND FAILURE (OF THE REPLACED PART) OCCURRED AT 65779 MILES AND WAS NOTED IN REPAIR TICKET 1-273605803. THE UNIT WAS NOT REPAIRED BY GM BUT WAS REPLACED BY THE OWNER (ME). THE PART DID NOT FAIL AT DEALER WHO ONLY DROVE THE VEHICLE 8 MILES. STALLING OF VEHICLE CAUSES LOSS OF CONTROL SINCE THE DIESEL MOTOR DRIVES THE POWER STEERING AND BRAKES. VERY DANGEROUS TO DRIVE. PART FAILURE DOES NOT SET ANY COMPUTER CODES READABLE AT DTC11 CONNECTOR. BASED ON INTERNET INVESTIGATION USING FSD FAILURE AND GM IN THE GOOGLE SEARCH ENGINE, MANY REPAIR SOLUTIONS ARE RECOMMENDED. THIS IS A KNOWN PROBLEM SINCE GM ISSUED A WARRANTY EXTENSION, G00064D IN MAY 2003. ORIGINAL PART IS AVAILABLE. REPLACEMENT PART (THE SECOND FAILURE) IS AVAILABLE. *JB UPDATED 07/24/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #10098751 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
CONSUMER WAS UNABLE TO FILL THE FUEL TANK WITH FUEL BECAUSE THE FUEL TANK SENSOR MALFUNCTIONED. THIS RESULTED IN THE GASOLINE PUMP NOZZLE CLICKING OFF BEFORE THE TANK WAS FULL. DEALERSHIP IN AN ATTEMPT TO CORRECT THE PROBLEM CHANGED THE FILLER NECK, ITS VALVE AND OTHER FUEL TANK COMPONENTS, BUT THE PROBLEM STILL EXISTS.
NHTSA complaint #10061057 — an unverified report by a vehicle owner.
1996 GMC SAVANA VAN- FUEL PUMP FAILURES AT 40,000 MILES AND 75,000 MILES. $600 REPAIR EACH TIME. HIGH FAILURE ITEM LASTING LESS THAN A SET OF TIRES, MAJOR REPAIRS NEEDED. THIS *HAS* TO BE A MANUFACTURING DEFECT. THIS IS A COMMON FAILURE PER THE GM DEALER.
NHTSA complaint #10049234 — an unverified report by a vehicle owner.
MANUFACTURER DECLINED TO PROVIDE ASSISTANCE IN REPAIR/REPLACEMENT OF PUMP. *PH *NLM **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT OVER TO ARTEMIS**768169
NHTSA complaint #10007463 — an unverified report by a vehicle owner.
SINCE VEHICLE WAS PURCHASED THERE HAS BEEN A GAS LEAK. CONSUMER STATES' HE CONSTANTLY BREATHING FUMES. CAUSE IS UNKNOWN. PLEASE PROVIDE ANY FURTHER INFORMATION. TS
NHTSA complaint #8023000 — an unverified report by a vehicle owner.
CONSUMER STATES THAT AFTER THE RECALL #00V110000 FUEL ODOR LEAKAGE WAS REPAIR ON THE VEHICLE THE SENDING UNIT FAILS TO OPERATE WITHIN A WEEK. DEALER NOTIFIED AND STATED THAT THE REPAIR HAS NOTHING TO DO WITH THE SENDING UNIT. PLEASE PROVIDE THAT DEALER NAME ADDRESS AND NUMBER. TS
NHTSA complaint #8021886 — an unverified report by a vehicle owner.