2012 GMC Sierra 1500 problems

ELECTRICAL SYSTEM

June 29, 2025, Driving on the St. Francis loop in Amarillo, TX, brake lights start flashing, the warning sounds happening, no brakes. I had already slowed down to 35-45 mph due to road construction ahead. I weaved through the cones and as soon as possible, hit the ditch and then coasted to a stop. (I didn’t think about the emergency brake, in my panic.) I turned the vehicle off and called my husband. I decided that I wasn’t pulled over far enough over in the ditch, so I started the pickup again. The lights and warning signals for the brakes were gone and when I pressed on the brake pedal, there were brakes again. I drove home at 35 mph, knowing I could use the emergency brake at that speed, if needed, and had brakes all the way home. GMC Bender repaired truck. After driving approximately 3 miles since repaired, our daughter took the truck to Grease Monkey. She was at the garage door; employee said the pickup didn't need an oil change. She backed out and didn’t have brakes (no warning lights or sounds) and as the truck continued backing, it hit the Grease Monkey sign at the east end of their lot and broke it, knocked the sign over. An employee walked over to see what happened, she told him that she didn’t have brakes. He sat in the pickup seat and pushed on the brakes and said, yes, you don’t have brakes! The police were called, and the officer who showed up took pictures, gave us his card, talked with my husband and talked to the Grease Monkey boss. August 6, 2025, I called GMC Bender Service Department (11 mins. 8 secs.) I told them what had happened. They sent a tow truck to bring the pickup back to their shop. September 16, 2025, my husband texted me saying GMC Bender said that the pickup shows another EBS Modulator Fault. No new parts… used one would be $1293 installed. A week to get it here, no guarantees. There's more details, but the vehicle cannot be repaired to guarantee brakes will work properly. Please help us know what to do next.

NHTSA complaint #11756257 — an unverified report by a vehicle owner.

SERVICE BRAKES

June 29, 2025, Driving on the St. Francis loop in Amarillo, TX, brake lights start flashing, the warning sounds happening, no brakes. I had already slowed down to 35-45 mph due to road construction ahead. I weaved through the cones and as soon as possible, hit the ditch and then coasted to a stop. (I didn’t think about the emergency brake, in my panic.) I turned the vehicle off and called my husband. I decided that I wasn’t pulled over far enough over in the ditch, so I started the pickup again. The lights and warning signals for the brakes were gone and when I pressed on the brake pedal, there were brakes again. I drove home at 35 mph, knowing I could use the emergency brake at that speed, if needed, and had brakes all the way home. GMC Bender repaired truck. After driving approximately 3 miles since repaired, our daughter took the truck to Grease Monkey. She was at the garage door; employee said the pickup didn't need an oil change. She backed out and didn’t have brakes (no warning lights or sounds) and as the truck continued backing, it hit the Grease Monkey sign at the east end of their lot and broke it, knocked the sign over. An employee walked over to see what happened, she told him that she didn’t have brakes. He sat in the pickup seat and pushed on the brakes and said, yes, you don’t have brakes! The police were called, and the officer who showed up took pictures, gave us his card, talked with my husband and talked to the Grease Monkey boss. August 6, 2025, I called GMC Bender Service Department (11 mins. 8 secs.) I told them what had happened. They sent a tow truck to bring the pickup back to their shop. September 16, 2025, my husband texted me saying GMC Bender said that the pickup shows another EBS Modulator Fault. No new parts… used one would be $1293 installed. A week to get it here, no guarantees. There's more details, but the vehicle cannot be repaired to guarantee brakes will work properly. Please help us know what to do next.

NHTSA complaint #11756257 — an unverified report by a vehicle owner.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

June 29, 2025, Driving on the St. Francis loop in Amarillo, TX, brake lights start flashing, the warning sounds happening, no brakes. I had already slowed down to 35-45 mph due to road construction ahead. I weaved through the cones and as soon as possible, hit the ditch and then coasted to a stop. (I didn’t think about the emergency brake, in my panic.) I turned the vehicle off and called my husband. I decided that I wasn’t pulled over far enough over in the ditch, so I started the pickup again. The lights and warning signals for the brakes were gone and when I pressed on the brake pedal, there were brakes again. I drove home at 35 mph, knowing I could use the emergency brake at that speed, if needed, and had brakes all the way home. GMC Bender repaired truck. After driving approximately 3 miles since repaired, our daughter took the truck to Grease Monkey. She was at the garage door; employee said the pickup didn't need an oil change. She backed out and didn’t have brakes (no warning lights or sounds) and as the truck continued backing, it hit the Grease Monkey sign at the east end of their lot and broke it, knocked the sign over. An employee walked over to see what happened, she told him that she didn’t have brakes. He sat in the pickup seat and pushed on the brakes and said, yes, you don’t have brakes! The police were called, and the officer who showed up took pictures, gave us his card, talked with my husband and talked to the Grease Monkey boss. August 6, 2025, I called GMC Bender Service Department (11 mins. 8 secs.) I told them what had happened. They sent a tow truck to bring the pickup back to their shop. September 16, 2025, my husband texted me saying GMC Bender said that the pickup shows another EBS Modulator Fault. No new parts… used one would be $1293 installed. A week to get it here, no guarantees. There's more details, but the vehicle cannot be repaired to guarantee brakes will work properly. Please help us know what to do next.

NHTSA complaint #11756257 — an unverified report by a vehicle owner.

POWER TRAIN

They should be responsible for repairs or replacement of the cheap made frames that rust away so fast so u ain’t gotta worry about your truck fallling apart going down the rd and the lower control arms made of cast that rust from inside out and you don’t know until breaks while driving along with camber adjustments where they can throw alignment out with a single bump. Mostly the frame replacement is major always having to plate frame or check to make sure it will be able travel long trips or haul stuff in bed or a trailer with breaking or falling off truck causing wreck frame repair is major and time consuming if you don’t have proper stuff and definitely expensive and lower control arms that’ll make a wheel come real fast and it’s time consuming and expensive too but very dangerous and breaks and causes damage right then and there at high or low speed on highways or interstates

NHTSA complaint #11739589 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

They should be responsible for repairs or replacement of the cheap made frames that rust away so fast so u ain’t gotta worry about your truck fallling apart going down the rd and the lower control arms made of cast that rust from inside out and you don’t know until breaks while driving along with camber adjustments where they can throw alignment out with a single bump. Mostly the frame replacement is major always having to plate frame or check to make sure it will be able travel long trips or haul stuff in bed or a trailer with breaking or falling off truck causing wreck frame repair is major and time consuming if you don’t have proper stuff and definitely expensive and lower control arms that’ll make a wheel come real fast and it’s time consuming and expensive too but very dangerous and breaks and causes damage right then and there at high or low speed on highways or interstates

NHTSA complaint #11739589 — an unverified report by a vehicle owner.

SUSPENSION

They should be responsible for repairs or replacement of the cheap made frames that rust away so fast so u ain’t gotta worry about your truck fallling apart going down the rd and the lower control arms made of cast that rust from inside out and you don’t know until breaks while driving along with camber adjustments where they can throw alignment out with a single bump. Mostly the frame replacement is major always having to plate frame or check to make sure it will be able travel long trips or haul stuff in bed or a trailer with breaking or falling off truck causing wreck frame repair is major and time consuming if you don’t have proper stuff and definitely expensive and lower control arms that’ll make a wheel come real fast and it’s time consuming and expensive too but very dangerous and breaks and causes damage right then and there at high or low speed on highways or interstates

NHTSA complaint #11739589 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2012 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted, especially between second and third gears. The check engine warning light was intermittently illuminated. In addition, the contact stated that the engine felt as though the engine mounts were inoperable. The contact pulled over to the side of the road and turned off the vehicle. The vehicle was restarted, and the vehicle resumed normal driving. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was made aware of the failure, but no assistance was offered. The failure mileage was approximately 20,000.

NHTSA complaint #11711216 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Odometer Fraud. The contact purchased a 2012 GMC Sierra 1500. The contact stated that it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the mileage was 111,000, and at the time of registration, it was discovered that the mileage was 243,000. The Carfax Report indicated that the vehicle was serviced at 149,000 and 179,000 miles, then registered at 149,000 and 179,000 miles on August 8, 2024. The contact had filed a police report with the Dillon Police Department -Special Ops Police Department.

NHTSA complaint #11682085 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

P0521 has been addressed/replaced almost nine (9) times. “Low Oil Pressure-Stop Engine” is another one that is not completely functional. The truck is using oil but we cant find evidence of leakage. Services performed at dealership or certified shop. Troubleshooting was performed, Im told. I cant vouch for the quality of the workmanship. This should not be an issue at this mileage 100,100 ohe hundred thousand miles and oil components going bad is not good. GMC has sold me a truck that needs a new engine component. Please help. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11652682 — an unverified report by a vehicle owner.

ENGINE

P0521 has been addressed/replaced almost nine (9) times. “Low Oil Pressure-Stop Engine” is another one that is not completely functional. The truck is using oil but we cant find evidence of leakage. Services performed at dealership or certified shop. Troubleshooting was performed, Im told. I cant vouch for the quality of the workmanship. This should not be an issue at this mileage 100,100 ohe hundred thousand miles and oil components going bad is not good. GMC has sold me a truck that needs a new engine component. Please help. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11652682 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

P0521 has been addressed/replaced almost nine (9) times. “Low Oil Pressure-Stop Engine” is another one that is not completely functional. The truck is using oil but we cant find evidence of leakage. Services performed at dealership or certified shop. Troubleshooting was performed, Im told. I cant vouch for the quality of the workmanship. This should not be an issue at this mileage 100,100 ohe hundred thousand miles and oil components going bad is not good. GMC has sold me a truck that needs a new engine component. Please help. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11652682 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

Faulty Tire Pressure Management system. Looking for recalls or service bulletins.

NHTSA complaint #11590951 — an unverified report by a vehicle owner.

WHEELS

Faulty Tire Pressure Management system. Looking for recalls or service bulletins.

NHTSA complaint #11590951 — an unverified report by a vehicle owner.

SERVICE BRAKES

Faulty Tire Pressure Management system. Looking for recalls or service bulletins.

NHTSA complaint #11590951 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Manufacturer interior defect - Crack on dash w/potential to crumble all the way in Diminishes vehicle

NHTSA complaint #11578132 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Frame rot behind gas tank truck doesn't even have 90000 Miles on it unsave to drive poor frame quality

NHTSA complaint #11576679 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Major major frame and wheel well rust , ever one I see is exactly the same , I live in upstate ny and yes we use salt but I've done a lot of research and the problem is country wide , please do some things this isn't right , I'm not trying to get a new free truck , just not get screwed out of the one I have cause it will fail inspection soon

NHTSA complaint #11560212 — an unverified report by a vehicle owner.

SUSPENSION

I went to get the vehicle inspected today and was told it failed due to the chassis frame in the rear being rusted thru. This could cause the suspension to collapse any time. I see on the internet that multiple others have and are experiencing the same with the Sierra and Silverado. My vehicle has unlimited washes and has been washed 40 times a year and looks new from the outside.

NHTSA complaint #11559780 — an unverified report by a vehicle owner.

STRUCTURE:BODY

I went to get the vehicle inspected today and was told it failed due to the chassis frame in the rear being rusted thru. This could cause the suspension to collapse any time. I see on the internet that multiple others have and are experiencing the same with the Sierra and Silverado. My vehicle has unlimited washes and has been washed 40 times a year and looks new from the outside.

NHTSA complaint #11559780 — an unverified report by a vehicle owner.

ENGINE

Lifter Failure: I was traveling to a State Park in Northern Michigan when my engine starting running very rough with major power loss. My check engine light activated, and I pulled over as soon as I could. It was dangerous because I was pulling a camper and I had to drive well under the speed limit. The Certified Chevy Dealership discovered a collapsed lifter and Cam damage. They considered this as catastrophic engine failure, and I was completely shocked as the vehicle had roughly 129k miles on it. There was no indication of failure prior to this incident as the vehicle ran perfect. I am very disappointed in GM as I have a co-worker with the same year truck that had the exact same issue shortly after I did. A friend of mine also had this happen with a 2014 vehicle of same make and model. It appears that this is a common issue with GM's newer 5.3 engines which used to be extremely reliable (99-07). GM needs to fix these lifter issues because a newer technology engine should last much longer.

NHTSA complaint #11558123 — an unverified report by a vehicle owner.

STRUCTURE:FRAME AND MEMBERS

The contact owns a 2012 GMC Sierra 1500. The contact stated that during a vehicle inspection, the contact was informed that the sub frame was severely corroded with holes. The vehicle was taken to an independent mechanic, who determined that the sub frame needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

NHTSA complaint #11555714 — an unverified report by a vehicle owner.

STRUCTURE:BODY

I took My 2012 GMC Sierra with 112,410 miles in for annual safety inspection and was told that my frame has a hole in it and is cracked, hence un-inspectable in the state of Vermont. I then took it to a welding shop to get an estimate on repair and the tech told me he sees this all the time on this era GM/Chevy trucks. This is clearly a widespread incident and GM should be held accountable like Toyota was years ago with its bad frames.O

NHTSA complaint #11526416 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Vehicle has just over 113,000 miles and the frame is already severely compromised due to rust. Nearly all factory coating is gone. I believe the sub par wax like coating that GM used from the factory was never intended to last anywhere near or over 100,000 miles. I have personally inspected numerous 2007-2013 GMT900 trucks in or around ohio and have found similar severe rust issues. All vehicles inspected were between 60,000 and 120,000 miles. The rust issues are the worst in the areas directly in front of the rear axle where the frame drops. Nearly every vehicle inspected has structure compromising rust in this area. GMT900 platform vehicles with rust issues in this area are unsafe to be on the road, yet they remain popular in multiple service industries and are frequently seen pulling trailers. GM has done a great disservice to their customers by using a sub par coating on the most important structural component in a vehicle. These trucks should easily last well over 250,000 miles but due to poor coatings they have a hard time breaking 100,000 miles.

NHTSA complaint #11518357 — an unverified report by a vehicle owner.

AIR BAGS

Cracked interior plastic dash, multiple places, potential safety hazard if airbag deploys and shatters it even more, also will be exposed wires once the cracks breaks all the way

NHTSA complaint #11518000 — an unverified report by a vehicle owner.