2022 GMC Sierra 1500 problems

ENGINE

No warning. It’s been replaced by Gm and a week later now it’s in the shop again because it’s acting up.

NHTSA complaint #11763868 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I am filing this complaint regarding a potentially serious safety defect involving my 2022 GMC Sierra 1500 Denali four-wheel-drive with the V8 5.3 engine. The vehicle had approximately 28,786 miles at the time of the incident. While traveling on an interstate highway in heavy traffic, my truck suddenly lost engine power. I was extremely fortunate that I was able to maneuver through traffic and get the vehicle onto the shoulder without being struck by another vehicle. A sudden loss of engine power under these conditions could easily have resulted in a serious or fatal collision. Immediately follow the incident Onstar detected diagnostic trouble code P129F The vehicle was subsequently taken to an authorized GM dealership. The dealership diagnosed the problem and replaced the fuel pump power control module to repair the vehicle. I have since learned that General Motors issued service bulletin 24 –NA-139 concerning this condition. The bulletin specifically includes 2022 GMC Sierra 1500 vehicles and identifies loss of power stalling and DTC P129F among the possible symptoms. GM states the condition may be caused by an internal short in the K111 fuel pump driver control module/fuel pump, power control module. I am particularly concerned that GM has been aware of this potential failure condition since at least 2024. A failure capable of causing a vehicle to suddenly lose engine power while traveling at Internet speeds presents amsafety hazard not only to the occupants of the affected vehicle but also to surrounding motorist. I respectfully request that NHTSA review this issue including other owner complaints involving error code P129F, fuel pump power control, module failures, stalling, or sudden loss of power in affected GMC Sierra and related to GMC vehicles and determine whether a safety defect investigation or recall is warranted. Vehicle: 2022 GMC Sierra 1500 Denali four-wheel-drive Engine: 5.3 L V8

NHTSA complaint #11763825 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I was driving today with product resting on the tailgate and the tailgate dropped while turning a corner, spilling product on the street. It was a residential street, thankfully, but it has happened on the highway. Previously, I had bikes resting on the tailgate and the same thing happen. Tailgate will randomly drop while driving, especially with a little weight resting on it. I close it completely, but doesn't seem to matter. It has become a concern and safety issue.

NHTSA complaint #11763685 — an unverified report by a vehicle owner.

ENGINE

I purchased said vehicle with a little over 76,000 miles on XXX from NW Chevrolet, [XXX]. Dealership service the engine on XXX and remained on their lot until it was sold. While driving home, I smelled gas fumes coming into the cabin and the engine was misfiring causing slight hesitation in motor acceleration while adjusting to speed limits and climbing hills. I told management at the dealership about these issues on XXX. My vehicle is currently in the shop to fix the fuel injection system, spark plugs, grounding issues as of XXX to fix the dealerships mistake costing more out of pocket expense. Management will not do anything about it because it was sold (As Is) without a warranty which I refused to purchase through finance and interest charges on a car loan. I purchased a 4-year warranty through Endurance on XXX with a 30 day wait period before filing a claim. GM is letting their dealerships advertise and sell problem vehicles with known motor issues to consumers while marking up the sale price. Vehicles should never be sold until GM fixes all motor defects before advertising to the consumer. The consumer is at serious financial risk when getting an auto loan paying on a broken vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11763367 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP:CONTROL/DRIVE MODULE

The contact's son owns a 2022 GMC Sierra 1500. While the contact's son was driving at an undisclosed speed, the vehicle stalled and the engine seized. The driver attempted to restart the vehicle, but the vehicle failed to restart. The vehicle was towed to an independent mechanic, where it was diagnosed with a fuel pump drive module failure. The contact was informed that the fuel pump drive module needed to be replaced. The vehicle was repaired. The contact stated that the failure was a known failure with the vehicle. The manufacturer was contacted by phone, and a case was filed. The failure mileage was approximately 31,298.

NHTSA complaint #11763360 — an unverified report by a vehicle owner.

POWER TRAIN

After numerous attempts getting GM to finally look at why my vehicle because after the L87 engine swap, which failed after the Pico test and oil, oil filter, and oil cap change my truck has been dangerous to drive. It falls on its face when taking off or driving. It acts as if something is holding the truck back. It takes more throttle to get it moving. Then in traffic while moving it randomly lunges forward very quickly as if I have the gas pedal to the floor. I came very close to rear ending a Deer Park police vehicle. They told me to get my own alternate transportation and they would then look at it. I had to go out and get a rental car. I had no choice. I explained due to my HIGH medical bills following a cancer diagnosis, I could not afford a rental and my appointments. They basically told me come see them when i can make my arrangements. So, i rented a car, took the truck in, four days later i was told that the problem was my ADAS camera. I told them it worked fine before yall had it 3 months waiting on an engine. They told me I would have to pay around 1000 dollars to have my truck repaired. Even though it was clearly something they did. I made arrangements to pay them. I picked up my truck. That evening I was happy. Well, the next morning while going to get coffee the problem returned. I took it back to the dealer. I was again told, go get another rental and leave it here. I have done that. Well, that week went by. I had to borrow money to get the rental for another week. So, i could make it to my cardiologist today. I have to get cardiac clearance before i begin surgery Oct. 1st. Between now and then, i have an appt with pain mgmt., A PET scan, and an Echo/Doppler for cardiac clearance. Surgery begins Oct. 1st. This has been making it very difficult to manage appts. with Gastrointerology, Cardiology, Oncology, Infusion services, Pain mgmt., Therapy with a Psychiatrist, My new Esophogealist (for surgery). And follow-ups and blood tests. This is ongoing.

NHTSA complaint #11763190 — an unverified report by a vehicle owner.

FORWARD COLLISION AVOIDANCE: WARNINGS

After numerous attempts getting GM to finally look at why my vehicle because after the L87 engine swap, which failed after the Pico test and oil, oil filter, and oil cap change my truck has been dangerous to drive. It falls on its face when taking off or driving. It acts as if something is holding the truck back. It takes more throttle to get it moving. Then in traffic while moving it randomly lunges forward very quickly as if I have the gas pedal to the floor. I came very close to rear ending a Deer Park police vehicle. They told me to get my own alternate transportation and they would then look at it. I had to go out and get a rental car. I had no choice. I explained due to my HIGH medical bills following a cancer diagnosis, I could not afford a rental and my appointments. They basically told me come see them when i can make my arrangements. So, i rented a car, took the truck in, four days later i was told that the problem was my ADAS camera. I told them it worked fine before yall had it 3 months waiting on an engine. They told me I would have to pay around 1000 dollars to have my truck repaired. Even though it was clearly something they did. I made arrangements to pay them. I picked up my truck. That evening I was happy. Well, the next morning while going to get coffee the problem returned. I took it back to the dealer. I was again told, go get another rental and leave it here. I have done that. Well, that week went by. I had to borrow money to get the rental for another week. So, i could make it to my cardiologist today. I have to get cardiac clearance before i begin surgery Oct. 1st. Between now and then, i have an appt with pain mgmt., A PET scan, and an Echo/Doppler for cardiac clearance. Surgery begins Oct. 1st. This has been making it very difficult to manage appts. with Gastrointerology, Cardiology, Oncology, Infusion services, Pain mgmt., Therapy with a Psychiatrist, My new Esophogealist (for surgery). And follow-ups and blood tests. This is ongoing.

NHTSA complaint #11763190 — an unverified report by a vehicle owner.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

After numerous attempts getting GM to finally look at why my vehicle because after the L87 engine swap, which failed after the Pico test and oil, oil filter, and oil cap change my truck has been dangerous to drive. It falls on its face when taking off or driving. It acts as if something is holding the truck back. It takes more throttle to get it moving. Then in traffic while moving it randomly lunges forward very quickly as if I have the gas pedal to the floor. I came very close to rear ending a Deer Park police vehicle. They told me to get my own alternate transportation and they would then look at it. I had to go out and get a rental car. I had no choice. I explained due to my HIGH medical bills following a cancer diagnosis, I could not afford a rental and my appointments. They basically told me come see them when i can make my arrangements. So, i rented a car, took the truck in, four days later i was told that the problem was my ADAS camera. I told them it worked fine before yall had it 3 months waiting on an engine. They told me I would have to pay around 1000 dollars to have my truck repaired. Even though it was clearly something they did. I made arrangements to pay them. I picked up my truck. That evening I was happy. Well, the next morning while going to get coffee the problem returned. I took it back to the dealer. I was again told, go get another rental and leave it here. I have done that. Well, that week went by. I had to borrow money to get the rental for another week. So, i could make it to my cardiologist today. I have to get cardiac clearance before i begin surgery Oct. 1st. Between now and then, i have an appt with pain mgmt., A PET scan, and an Echo/Doppler for cardiac clearance. Surgery begins Oct. 1st. This has been making it very difficult to manage appts. with Gastrointerology, Cardiology, Oncology, Infusion services, Pain mgmt., Therapy with a Psychiatrist, My new Esophogealist (for surgery). And follow-ups and blood tests. This is ongoing.

NHTSA complaint #11763190 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

P2101 Reduced Engine Power Idle instabilitystruggling to idle correctly, hunting/surging slightly, and possibly going into reduced-power protection mode. While driving engine reducing power, struggles then surges forward. Ive taken it to GMC however the techs say they have to experience the situation themselves and are unable to diagnose

NHTSA complaint #11762547 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Upper grille flew off on interstate. Hit windshield and landed in median. I have the black grill not covered in the recall.

NHTSA complaint #11762560 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

P2101 Reduced Engine Power Idle instabilitystruggling to idle correctly, hunting/surging slightly, and possibly going into reduced-power protection mode. While driving engine reducing power, struggles then surges forward. Ive taken it to GMC however the techs say they have to experience the situation themselves and are unable to diagnose

NHTSA complaint #11762547 — an unverified report by a vehicle owner.

ENGINE

P2101 Reduced Engine Power Idle instabilitystruggling to idle correctly, hunting/surging slightly, and possibly going into reduced-power protection mode. While driving engine reducing power, struggles then surges forward. Ive taken it to GMC however the techs say they have to experience the situation themselves and are unable to diagnose

NHTSA complaint #11762547 — an unverified report by a vehicle owner.

STRUCTURE:BODY

My 2022 GMC Sierra 1500 was subject to GM safety recall N242490120 / NHTSA 25V060 for an upper grille deflector that could detach from the vehicle. The recall repair was completed by my GM dealership in June 2025. In late August 2026, while driving normally on the highway, the same upper grille deflector detached again in the exact manner described by the recall. There was no collision, impact, or other outside damage that caused the failure. I was able to retain the detached deflector due to my attentiveness however, it was close to detaching and either busting mine or someone else’s windshield. Upon inspection, the adhesive and retainers from the previous recall repair are still clearly visible, and the bonding appears to have separated. I have photographs documenting the failed attachment points and still possess the undamaged detached component for inspection. My GM dealership inspected the vehicle after this failure and determined that the front grille assembly should be replaced. However, because the recall is shown as previously completed, GM has stated that the recall cannot be reopened. GM Customer Assistance offered only $251 toward a $1,673.82 repair, leaving me responsible for $1,422.82 to correct the same safety defect that the recall was intended to remedy. I am filing this complaint because the recall remedy appears to have failed, allowing the recalled component to detach from the vehicle again. A grille component detaching at highway speed could strike another vehicle or create a roadway hazard. I am concerned that other vehicles repaired under this recall may experience the same post-recall failure. I request that NHTSA review the effectiveness and durability of the remedy used for recall N242490120 / 25V060.

NHTSA complaint #11761833 — an unverified report by a vehicle owner.

STRUCTURE:BODY

The piece in front of the hood detached and flew off while riding down the highway.

NHTSA complaint #11761682 — an unverified report by a vehicle owner.

ENGINE

engine failure

NHTSA complaint #11761681 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2022 GMC Sierra 1500. The contact stated that while driving approximately 65 MPH, the transmission shifted to neutral(N), and the contact was unable to control the vehicle. The vehicle was coasted to the side of the road, and the transmission failed shift into park(P), reverse(R), or drive(D). The message "Conditions no Longer Exist for Driving," was displayed on the screen. The vehicle was towed to the dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The contact was informed that the nuts were welded to the engine, causing a failure with the engine overheating. The failure also occurred while driving 65 MPH, and the transmission shifted into neutral with the same message displayed on the screen. The vehicle was towed back to the dealer, and it was diagnosed with engine failure. The contact stated that the engine was replaced. The dealer informed the manufacturer of the failure. The failure mileage was approximately 34,000.

NHTSA complaint #11761210 — an unverified report by a vehicle owner.

POWER TRAIN

My 2022 GMC Sierra started hesitating two weeks ago between the speeds of 17-35 mph. It also hesitates going downhill. When I try to accelerate it hesitates causing a serious safety issue for me driving. I cant trust to move when I need to move across a busy intersection with semi tractor trailers coming at me. I can trust it to tow or haul anything anymore. This is well known and documented problem General Motors has and the company deems it "Normal Operations" which is totally not normal.

NHTSA complaint #11760937 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2022 GMC Sierra 1500. The contact had experienced several catastrophic failures with the engine and transmission. The contact stated that while driving 40 MPH, the vehicle shut off without warning, and lost power. The vehicle was towed to a dealer for an engine replacement. On another occasion while driving 65 MPH, the vehicle shut off without warning and the wheels locked up. The vehicle was towed to GMC of Rochester (4646 E Frontage Rd, Rochester, MN 55901), where a second engine failure was diagnosed and the vehicle was repaired under an extended warranty. Upon retrieving the vehicle, the vehicle was hesitating while depressing the accelerator pedal, with the messages "Reduced Engine Power" and "Check Engine" displayed. While attempting to reverse(R) into a driveway, the vehicle became immobile. The vehicle was towed to Red Wing Chevrolet (2500 US-61, Red Wing, MN 55066), and the technician diagnosed the vehicle with total transmission failure. The contact was informed that there was heavy metal debris inside the transmission pan. The manufacturer was notified of the failure but declined to assist. The vehicle remained with the dealer. The failure mileage was 12,000.

NHTSA complaint #11760940 — an unverified report by a vehicle owner.

STRUCTURE:BODY

On August 22, 2026, while driving my 2022 GMC Sierra westbound on State Route 84 at highway speed, with strong westerly winds of approximately 35 knots, the front passenger-side wheel-opening molding/fender flare completely detached from the vehicle without warning. The detached molding struck the passenger-side exterior mirror and narrowly missed a motorcyclist traveling behind me. This created a serious safety risk because a substantial exterior component became a projectile at highway speed and could have struck the motorcyclist or another vehicle. There were no warning lights, messages, unusual noises, or other symptoms before the failure, and there was no known collision or impact preceding the incident. I did not initially know what had detached. After arriving home and inspecting the vehicle, I discovered the entire passenger-side front wheel-opening molding was missing. The detached component was not recovered. I reported the incident to my GMC dealer, which performs my regular service and warranty work. The vehicle was inspected on August 31, 2026. The dealer declined warranty coverage but, to my knowledge, did not determine why the component detached. Afterward, I inspected the corresponding driver's-side molding and found a substantial visible gap at its leading edge between the molding and vehicle body. Comparison with other GMC Sierra vehicles of the same model showed their moldings appeared to sit substantially more flush. The vehicle and remaining molding are available for inspection, and I have photographs documenting the condition. The cause of the failure is currently UNKNOWN. I have escalated the incident to GMC Customer Assistance under Case #109189284 and requested a product-safety review. I am concerned there may be an installation, attachment, or component-retention issue that could allow these moldings to detach while driving.

NHTSA complaint #11761056 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2022 GMC Sierra 1500. The contact stated that the vehicle was serviced under NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); the vehicle was inspected, and the engine oil was replaced with a higher viscosity oil. The contact stated that later while operating the vehicle, the engine was knocking, and the vehicle was taken back to the dealer to be diagnosed. The contact was informed that there were metal shavings inside the engine oil, and the engine was replaced. The manufacturer was notified of the failure. The failure mileage was 22,700.

NHTSA complaint #11760944 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2022 GMC Sierra 1500. The contact had experienced several catastrophic failures with the engine and transmission. The contact stated that while driving 40 MPH, the vehicle shut off without warning, and lost power. The vehicle was towed to a dealer for an engine replacement. On another occasion while driving 65 MPH, the vehicle shut off without warning and the wheels locked up. The vehicle was towed to GMC of Rochester (4646 E Frontage Rd, Rochester, MN 55901), where a second engine failure was diagnosed and the vehicle was repaired under an extended warranty. Upon retrieving the vehicle, the vehicle was hesitating while depressing the accelerator pedal, with the messages "Reduced Engine Power" and "Check Engine" displayed. While attempting to reverse(R) into a driveway, the vehicle became immobile. The vehicle was towed to Red Wing Chevrolet (2500 US-61, Red Wing, MN 55066), and the technician diagnosed the vehicle with total transmission failure. The contact was informed that there was heavy metal debris inside the transmission pan. The manufacturer was notified of the failure but declined to assist. The vehicle remained with the dealer. The failure mileage was 12,000.

NHTSA complaint #11760940 — an unverified report by a vehicle owner.

ENGINE

I just had to put my 4th engine in my 22 Sierra at4 with the 6.2 V8. I currently have 103k miles

NHTSA complaint #11761156 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My 2022 GMC Sierra started hesitating two weeks ago between the speeds of 17-35 mph. It also hesitates going downhill. When I try to accelerate it hesitates causing a serious safety issue for me driving. I cant trust to move when I need to move across a busy intersection with semi tractor trailers coming at me. I can trust it to tow or haul anything anymore. This is well known and documented problem General Motors has and the company deems it "Normal Operations" which is totally not normal.

NHTSA complaint #11760937 — an unverified report by a vehicle owner.

POWER TRAIN

Truck died while driving on a major highway due to a faulty fuel pump module. The vehicle was blocking an intersection. The vehicle could not be put into neutral without the engine running because of the electronic transmission. Could not move the vehicle out of the intersection and out of traffic. I found out later that to put the truck in neutral requires a special tool, and going under the truck to engage the bypass, which is very difficult and unsafe on a major roadway.

NHTSA complaint #11760717 — an unverified report by a vehicle owner.

POWER TRAIN

My truck has the same issues for the transmission and engine problems I have taken it to 4 dealerships and they all say the same thing. The first one I spent about 3 hours there and they changed the 20 oil to the 40 oil and said that will fix the issues but it hasn't i called GMC to report this and they sent me to the others but they said it's been looked at and I know one of them didn't do anything to see the issue.Gmc called the other day and I told them I will let the engine locked up or the transmission keep doing the same thing and they'll have to fix the issue then.I do have 109000 miles on it but thus issue has been going on for 4 years they said I have 150000 miles for the issue but I do t think that is right.I paid them cash money for the truck when I bought it

NHTSA complaint #11760765 — an unverified report by a vehicle owner.