2018 Honda Cr-V fuel system problems

FUEL/PROPULSION SYSTEM

Every warning light possible randomly came on a few months ago. The lights stay on for about a week, then go off for about two weeks. Took to Honda, first time they said nothing was wrong and preformed a relearn. Lights were all off for 300 miles, then came back on. Took back to Honda and they diagnosed as fuel injector misfire and quoted me $1800 for replacement. I was doing research and found that premature fuel injector failure with the 2018 CRV is a known issue. My local mechanic tells me it's a safety issue to drive around with misfired cylinders and can damage the engine. When the lights are on, none of my car's sensors work and I cannot use cruise control. I do not have $1800 to spend on something that should be a recall. I have only had the car 2 years. Thank you so much for your time and assistance.

NHTSA complaint #11758906 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda CR-V. The contact stated that while driving 60 MPH, several unknown warning lights illuminated, and the vehicle stalled. The failure was a recurring failure. The contact associated the failure with Technical Service Bulletins: 19-032 and 19-037. The dealer was contacted and diagnosed the vehicle with fuel injector failure. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 49,000.

NHTSA complaint #11757722 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Before the recall repairs, I did not experience any loss of acceleration, hesitation, jerking, or flashing warning lights. These symptoms began only after the recall service was completed. 1. What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle experienced a loss of acceleration while driving. The vehicle also began to jerk or stumble, and multiple warning lights flashed on the dashboard. The vehicle is currently at the Honda dealership and is available for inspection. 2. How was your safety or the safety of others put at risk? The loss of acceleration created a potentially dangerous situation because the vehicle would not respond as expected while driving. I did not feel safe operating the vehicle, especially in traffic, because the vehicle hesitated and lost power. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The vehicle was inspected by a Honda dealership. The dealership initially diagnosed a shutter grille issue (code P16E8). After that repair did not resolve the problem, the dealership later indicated that the fuel injectors might be the cause. The symptoms persisted after the initial repair. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected by an authorized Honda dealership. It has not been inspected by police or insurance representatives. 5. Were there any warning lamps, messages, or other symptoms before the failure, and when did they first appear? Multiple warning lights began flashing after the recall service was completed. The symptoms, including loss of acceleration and vehicle hesitation, first appeared after the recall repairs were performed.

NHTSA complaint #11756620 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

In Feb-2020 While driving on [XXX] just south of Altoona, PA experienced sudden loss of power with multiple warning lights on in the dashboard along with engine light. Safely maneuvered the vehicle to the shoulder. Turned it off, waited some minutes and then tried restarting it. To my surprise vehicle started with normal power but lights still present. I continued my driving and after few miles later even the lights went off. Then covid pandemic happened. Did not drove this car much that spring and summer and ultimately took the car to Autozone to read the stored DTC codes on Nov 19 2020. Autozone read the Error codes as P0303, P0304 and P0300 as part of Autozone paperwork Report ID# [XXX] Called American Honda and registered complaint case # [XXX]. Honda advised to take it to the nearest Honda dealership to read the codes again but Honda dealership said there are no codes those they were able to read on 11/23/2020. Updated Honda with dealership findings on 12/15/2020. American Honda assured me that vehicle is still under warranty and they will do the right thing if problem resurfaced. 09/26/2025 - Once I got this problem again around 73k miles on odometer, I Called Honda again to make the things right with their July 2019 advisory and emissions warranty extension to me under Service bulletin #19-032. 11/06/2025 - American Honda tried to resolve the issue as per advisory to me under Service bulletin #19-032 at 80K on the odometer. 02/11/2026 - Experienced the same Engine misfire codes again in January 2026 and called American honda to reopen the case# [XXX] and took the car to local honda dealership again where the warranty work as per Service bulletin #19-032 was performed in Nov 2025. 03/04/2026 - Upon dealership's further diagnosis talked to Dominique at American honda and he refused to stand behind their product and refused any fix. To me Honda failed to address oil dilution issue for my 2018 CRV EXL AWD. See attachments INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 55

NHTSA complaint #11756292 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda CR-V. The contact stated that while driving 53 MPH with the cruise control feature engaged, the vehicle started losing motive power with several unknown warning lights illuminated. The contact pulled over to the shoulder of the highway and had the vehicle towed to an independent mechanic. The mechanic performed a diagnostic test and discovered that the fuel pump was inoperable and needed to be replaced. Upon investigation, the contact discovered NHTSA Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The vehicle was repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was 78,176.

NHTSA complaint #11754391 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My car started experiencing a loss of power and began to shake a lot when I was parked. When they put the scanner on it, it said that cylinders number 2 and 3 had faults, so they replaced them.But after a few days the same message returned, so they think it's the injectors. In addition to all that, the problem started after the fuel pump was replaced at the Honda dealership in Lancaster, MA.

NHTSA complaint #11753887 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Have replaced the fuel injectors twice after completing the recalled fuel pump and now getting P0172 code with another bad injector!!! This is a piece of shit and I’m going to trade it in on a Toyota.

NHTSA complaint #11753645 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda CR-V. The contact stated that while driving on several occasions at various speeds, the vehicle went into LIMP Mode. The vehicle was taken to the residence while driving approximately 30 MPH. The vehicle was then taken to a dealer where it was diagnosed and determined that there was a misfire in cylinder #3, and that the head gasket and fuel injectors needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 153,500.

NHTSA complaint #11753230 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Honda CR-V. The contact stated that the vehicle failed to immediately start. After the vehicle was started, there were several unknown warning lights illuminated. The vehicle was taken to the local mechanic, who diagnosed the vehicle and determined that the fuel rail pressure was low. The cause of the failure was not yet determined, and the vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in NHTSA Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE). The contact stated that the vehicle had experienced the failure listed in the recall. The local dealer was not contacted. The failure mileage was 133,000.

NHTSA complaint #11746686 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Honda 2018 CRV VIN [XXX]. Car was brought to Honda dealer due to smoking issue from exhaust directly after fuel pump recall. Work was done at Napleton Honda that was under direction from America Honda to replace the head gasket for no engine codes were found and engine light was not on. CRV head gasket was replaced for $6,000 and still smoke was coming from exhaust. Returned the vehicle to Napleton Honda dealer and America Honda then claims issue is a Turbo issue and that is what is causing the smoking for another $5,500 they can swap that part too. I expect America Honda will recommend next the rear-view mirror will need to be replaced for that is how we are seeing the smoke from the exhaust. The Dealer is under direction from America Honda on what to replace and they have failed to fix the issue. Multiple websites reference that the recalled fuel pump is causing engine trouble like fuel gasket and turbo which America Honda knows for that is what they are recommend being replaced so far. If you do some discovery on this, you will also see there are several class-action lawsuits on this same issue in the US and several other countries. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11745231 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My fuel pump went out and car stopped working in middle of road and caused the timing chain to come off. My 2018 Honda CRV isn’t on the recall list but other 2018 Honda CRVs have been recalled for faulty fuel pumps. I think my car should be included in recall.

NHTSA complaint #11744649 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

The systems affected with failure notifications were Electric Parking Brake, TPMS, Emissions, Brake, Brake Hold, Power Steering, Vehicle Stability Assist, Hill Start Assist, Adaptive Cruise (including regular cruise), Collision Mitigation/Avoidance, Road Departure Mitigation. The stored codes in the vehicle that I was able to read were P0300, P0303, P0304. This failure bears a striking resemblance to that of TSB 21-010, directed at Keihin manufactured fuel injectors, PN: 16010-RLV-315, which was later replaced with updated ...-305 after the failure was determined, and the vehicles were given a 10 year 150,000 mile warranty. The CRV had injector PN: 16010-5PA-305, also manufactured by Keihin, which was also later revised to 06160-..., but the CRV was not given the same warranty extension, suggesting Honda acknowledged the same defect pattern across both injector families but chose not to extend equivalent coverage to the CRV. 21-010 also details that debris from the high pressure pump may contribute, and the CRV experienced the same fuel pump recall for low density impellers that these vehicles did. Honda is also obligated under TSB 98-081 to perform emissions services due to OBD inadequacy, which this vehicle experienced. Misfires were felt for months with no CEL. The Norm Reeves Honda parts catalog classifies injectors as emissions components, implying they should be covered. However, a Honda dealer in CA, mandated by CARB and EPA, refused to do the repairs or make any goodwill attempt on my behalf. I then reached out to American Honda, who delayed assigning a case manager as long as possible, then required phone contact after initially accepting alternate communication methods, then assigned a case manager whose hours conflicted with my stated availability, then assigned a second who has not answered the phone. I am still awaiting a callback. The vehicle has been immobile and in limp mode for the past two weeks while Honda's callback process remains unresolved.

NHTSA complaint #11742846 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

While getting the cr-v fuel pump mtr saf recall fixed on my vehicle, the dealership found a crack in the fuel pump module. They also said there is a leak in the head gasket and a purge flow malfunction. They stopped any work on my vehicle and said I needed to replace my vehicle with a new vehicle. If a Honda dealership is not willing to work on my vehicle, what am I supposed to do with it?

NHTSA complaint #11741278 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

A franchised dealership has actively undermined a federal safety mandate, creating an immediate vehicle fire hazard. On [XXX], I took my 2018 Honda CR-V to Bedard Bros Honda in Cheshire, MA, for NHTSA Safety Recall Campaign 23V-858 (Fuel Pump Module). During the service, the dealer identified a cracked fuel pump housing and attempted to charge me a $390 fee to replace it. When I declined this commercial upcharge on a safety recall, the technician reassembled the pressurized fuel system using the broken housing and released the vehicle to me. Prior to this appointment, the vehicle had no fuel leaks or odors. Immediately upon driving the vehicle home and parking it, the vehicle began actively leaking raw gasoline, filling the cabin with toxic, flammable vapors. The dealership’s decision to perform a federal safety recall inside a known broken component, and subsequently release a vehicle with a compromised fuel system to avoid completing a free repair, has created an active fire emergency. The dealer invoice explicitly documents the crack and their attempted charge. I am requesting a formal investigation into this dealership's handling of Campaign 23V-858. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11741036 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

While driving home during rush hour traffic on the highway with my children in the vehicle, without warning it stopped accelerating when I passed the gas pedal and started slowing down. When I let go of the gas pedal it would speed back up. I couldn't safely merge over to the right with heavy traffic and ended up on the left shoulder. I turned the vehicle off and tried to restart it, it struggled to start, but when I let go of the key it would turn over. The brake system lights and check engine light were illuminated after the incident, but not during. The code was for p0087 and honda service confirmed it's a failed high pressure fuel pump, but it's not under the recall so the repair isn't covered. I'm extremely lucky to have gotten to the side of the road without causing an accident. I was not driving my normal route that day, but if i had been this would have happened on a stretch of the highway that's under construction where there was no shoulder to pull onto. So if I'd have gone a different way home that day, we'd have most certainly been involved in a collision. They've anyway Texans the low pressure fuel pump but these high pressure ones are just as dangerous when they fail, even more so!

NHTSA complaint #11738956 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

After the low-pressure fuel pump recall repair was performed on my 2018 Honda CR-V at Doggett Honda Med Center on March 6, 2026, the vehicle began experiencing a serious and repeated loss-of-power condition. The vehicle suddenly loses power without warning. This happens with no clear pattern, at highway speeds and also at low speeds. The engine does not shut off, but the vehicle loses the ability to accelerate normally. In some situations, it does not have enough power to safely reach the shoulder, leaving me exposed in traffic. This has now happened multiple times and has become more frequent. I have already narrowly avoided at least three serious rear-end collisions while trying to move the vehicle out of traffic. Yesterday, the vehicle lost power again and a police unit had to escort me so I could safely move the vehicle to the side. When I turn the vehicle off and restart it, it temporarily returns to normal, but the problem keeps coming back. This makes the vehicle unsafe and unreliable for normal use. The vehicle is my work vehicle, and I depend on it for transportation. I am now unable to work normally or travel safely because I do not know when the vehicle will suddenly lose power again. This condition places my life and the lives of my passengers at risk. I contacted both the dealership and American Honda Corporate. However, my safety concern has been minimized, and I was told that I would have to pay for diagnosis, even though this problem began after Honda performed recall work on the fuel system. I am reporting this because this is a serious safety issue. A vehicle that suddenly loses power in traffic, without warning, creates a real risk of collision, injury, or death. Honda should properly investigate whether the recall repair, fuel pump system, connectors, wiring, or related fuel delivery components caused or contributed to this dangerous condition.

NHTSA complaint #11737439 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

A known common issues that Honda are not addressing: car going limp randomly, oil dilution, head gasket failure causing fuel injector issues, dashboard lighting up which causes the safety features to also cease from operating. I have multiple times now with my 4 year old in the car been in traffic and my car has just stopped going unprovoked. This limp mode issue a huge safety issue and has almost caused me to wreck multiple times. This started around 70k miles.

NHTSA complaint #11735679 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Failed Head Gasket in the engin affected fuel injectors and spark plugs to fail or not perform normally and started misfiring in the engin. My 24 year old son drives this car and the problem happened at night when he was driving home at night on 3/4/2026 flashing all waring signs on the screen. The car's speed was abruptly reduced to very low and he was not able to drive the car . I put the car to repair shop and replaced the fuel injecton kit and spark plugs and paid $1650 for that and the problem happed again with same kind of signs and drop the car to dealership for detailed diagnostic analysis and they came with the conclusion that the engin has a failed head gasket which causes the engin coolent to enter into cumbustion chamber and mix with the oil/gas affecting fuel injectors and spark plugs. Upon extensive search on internet and social media , it has been found that there are hundreds of victims who own the same year vehicle & model ( or same engine types ) and faced same issues and paid too much money to repair even though the Honda is aware of the issue and not taking care of it. Honda is playing with american people's life when they know the issue very well and haven't done anything yet to recall the vehicles to resolve this issue . This need to be investigated thoroughly to save life of innocent people.

NHTSA complaint #11735293 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

The fuel injection system failed, specifically causing a cylinder 1 misfire (DTC P0301). The component is currently installed in the vehicle and available for inspection. The vehicle experienced a sudden loss of power and violent shaking while driving in traffic, creating a high risk of a rear-end collision or being stranded in a dangerous intersection. Multiple safety systems (VSA, Braking Assist, Power Steering) were disabled simultaneously. The problem was officially confirmed and diagnosed by Saccucci Honda [XXX] ) on Invoice #XXX. The vehicle has been inspected by the dealer (Saccucci Honda), who confirmed the failure is internal to the fuel injectors. There were NO warning symptoms prior to the failure. All warning lamps and messages appeared suddenly on 04/20/2026 exactly 3 days after the official Honda Fuel Pump Safety Recall was performed at a different dealership of Honda . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11734936 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

"fuel pump issues directly cause injector system failures". Today Honda assured me than the fuel pump recall could not interfere in the injector system, that's totally false Now I have to changed injector system and spark plugs to my own expense. On Monday 6th of April 2026 showrd engine light as well as stalling when driving On Monday 30th of March AC COMPRRSSOR SMOKED, ALSO NEED TO BE REPLACED

NHTSA complaint #11730083 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My 2018 CRV was taken to Dick Ide Honda for a recall on my fuel pump. The next day I was driving my car and it just stopped running and I drifted off to the side of the road. It would not start up but had power in the car. No warning signs or lights. I had it towed back to dealer that just worked on it and they stated that they did nothing wrong and and now they need to do a system check / diagnosis at $185.00 an hour to see what is wrong with it. My car worked fine before the dealer had it and now it doesn't work. And they are going to charge me for diagnosing it. I don't feel comfortable or trust that they have checked my car for whatever mistakes or faulty parts they may have used and my safety is in jeopardy

NHTSA complaint #11729526 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My 2018 Honda CR-V (1.5L Turbo) has a confirmed fuel leak dripping directly onto the starter motor, creating an immediate fire hazard. A Honda dealer (Inv #XXX) diagnosed codes P219C and P219D, which are explicitly covered under Honda Service Bulletin 20-038 for a 150,000-mile warranty extension. Despite the vehicle having 131,528 miles, Honda Corporate is refusing to honor the warranty extension, claiming my VIN is not affected, while ignoring the documented failure and the dangerous safety risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11729311 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

After we had our car serviced for the two recalls on the car, all of the check engine lights came back on again a little over one week later. We took it back to the dealership today and were told the fuel injectors need to be replaced, and they said this is a "common problem." We have been researching this issue and it is a common problem, so why isn't there a fuel injector recall? Our car has less than 54,000 miles on it but Honda is saying we will need to pay over $1700 for new fuel injectors, despite that this is a known problem.

NHTSA complaint #11728625 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Multiple warning lights were turning on then turning off in their own, typically 2-3 days later. However while on, all ADAS showed errors and did not work. Most recent time, had an elevation changed (over 6000 ft), lights came cascading on parked safely. Next morning, car would not accelerate/was extremely jerky. Turned off waited turned back on, while lights were on car felt to be running fine. Slightly off sounding idle. DTC showed multiple misfires and error codes with a recommendation to replace fuel injectors. Dealer was surprised given relatively low milage (109000 miles) for this issue to occur.

NHTSA complaint #11727725 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Head gasket failure diagnosed by Wittmeier Honda in February of 2026 Chico Ca. Car was initially throwing misfire codes, battery, fuel pump, then fuel injectors were replaced. Took it back to the dealer because car would sputter, dash is blacking out and I'm unable to indicate the speed at which I'm traveling, white smoke from exhaust, misfire, poor gas mileage, car nearly stalling in intersection. Car has been having this issue or possibly other issues contributing to this for nearly 25-30k miles. It is important to note that fuel pump was recalled in this model, car performance has significantly declined over the last 25k miles. This car is well maintained as in; regular oil, changes, transmission flushes, rear differential fluid change, tire rotation every 5-7k miles, brakes and rotors changed nearly every 30k front and back, fixing all issues as they arise. I say all of this so that there is a clear picture of the car maintenance and the issues it is having despite the proper care. This car has had several issues from about 150k miles. In my opinion this is premature for a car this well maintained. Though this car has had several issues over that past year I will put the most pressing and scariest date, the time it almost stalled in an intersection.

NHTSA complaint #11727137 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

The contact owns a 2018 Honda CR-V. The contact stated that while his wife was driving approximately 55-60 MPH, the cruise control mode and the lane mitigation systems became inoperable. Several unknown warning lights were illuminated. The Parking Brake, Hill Assist, Traction Control, TPMS, and the Electronic Stability Control were illuminated, and other unknown systems inoperable messages were displayed. The vehicle was taken to an independent mechanic, where it was reset, and the contact was informed that the failure might be caused by a misfire. The contact stated that the failure had become more frequent while driving. The vehicle was taken to the dealer, where it was diagnosed, and it was determined that 4 fuel injectors had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 74,410. The VIN was not available.

NHTSA complaint #11723029 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I went out to the garage for something and heard what sounded like the fuel pump running. I know there was a recall with the fuel pump relay/module and I'm concerned it was either not repaired correctly or there is still an issue.

NHTSA complaint #11722566 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

"While driving my 2018 Honda CR-V (Mileage: 58,800), the vehicle experienced a sudden and total loss of power/stalling due to a fuel injector failure. This failure caused the vehicle to enter 'Limp Mode' on a high-speed roadway, creating an immediate risk of a rear-end collision as the vehicle could not maintain flow-of-traffic speeds. My Wife and I was just getting on the highway when this occurred. Research indicates this is a recurring manufacturing defect in the 1.5L Turbo engine (referenced in Honda TSB #22-002 and similar internal communications). This is a critical safety issue as the fuel system failure is unpredictable and occurs without prior warning, leaving the driver stranded in dangerous traffic conditions. Honda has not yet issued a safety recall for this VIN despite the widespread nature of the injector defects."

NHTSA complaint #11716219 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Steering pulls and clicks at highway speeds. Engine misfire due to faulty fuel injection issues.

NHTSA complaint #11714450 — an unverified report by a vehicle owner.