86 of the
1,559 complaints filed about the Hyundai Santa FE Sport
are about the electrical system —
6% of everything owners reported.
The worst model year for it is 2014.
In October/November of 2023, while Hyundai was actively initiating Safety Recall 251 (NHTSA Campaign 23V-651), my vehicle's ABS Control Unit suffered an internal fluid leak that resulted in an electrical short-circuit. The failure caused major electronic communication errors, illuminated dashboard warning lights, and placed the vehicle into Limp Mode, rendering it unsafe to drive. Because the failure occurred prior to receiving a formal owner notification in the mail and the vehicle was un-drivable, I paid $1,300.54 out-of-pocket on November 17th 2023 to replace the failed ABS module. Hyundai Corporate has twice denied reimbursement, arguing that Recall 251 only covers a multi-fuse replacement and claiming internal fluid leaks are not covered. This contradicts NHTSA 23V-651 documentation, which explicitly identifies internal ABS module fluid leaks and electrical shorts as the core safety defect. Installing a fuse current-limiter cannot repair an already-ruined ABS circuit board or resolve a safety-mandated Limp Mode. I am reporting this to document on the official public record that Hyundai is actively denying reimbursement for the exact root-cause failure identified in NHTSA Campaign 23V-651. PLEASE NOTE: This report is submitted solely to document Hyundai Motor America's non-compliance and improper reimbursement denial for official record-keeping under Campaign 23V-651. I do not require follow-up contact from NHTSA regarding this submission.
NHTSA complaint #11757483 — an unverified report by a vehicle owner.
The vehicle suffered a severe engine overheating failure that created an immediate fire risk and electrical safety signaling failure. A brand-new replacement engine was installed by an authorized dealership in April 2026 under a goodwill warranty and had only been driven ~ 3,100 miles since installation. While operating the vehicle, the air conditioning suddenly stopped functioning. Upon restarting, the check engine light illuminated; however, there was never any dashboard temperature warning indicator, notification, or chime to alert the driver to an active overheating situation. Shortly after, the engine completely disabled itself and died while in transit in a parking lot. AAA was contacted to tow the vehicle. Smoke was visible coming out of the engine's oil dipstick and oil intake spout before being towed. After being towed home, an overwhelming chemical burning odor was noted and continued to get worse. A physical check revealed that the oil level on the dipstick was critically overfilled a full inch above the maximum fill line. The local fire department responded to the scene to mitigate the thermal risk, ordered the battery disconnected due to safety hazards, and deemed the vehicle entirely unsafe to operate or connect to power. This represents a catastrophic failure of critical safety equipment and onboard driver warning networks on a newly installed engine assembly, presenting an active safety and fire hazard to passengers. An official corporate safety case has been opened with Hyundai Motor America under Case Number: 43112676.
NHTSA complaint #11756640 — an unverified report by a vehicle owner.
In June 2026 I took my vehicle to Hyundai for a recall to the ECM module. After that my vehicle would lose power and hesitate to shift gears, and overall does not feel safe. Took vehicle back to dealer and they have told me that I have to wait for them to issue a recall fix for this now .
NHTSA complaint #11755929 — an unverified report by a vehicle owner.
On June 20, 2026, while the 2014 Hyundai Santa Fe Sport was being driven on Richardson Highway near Mile 155 in Alaska, smoke and flames developed from the engine compartment without any collision. The driver stopped and both occupants exited before the vehicle became fully engulfed. The fire created an immediate risk of serious injury or death and blocked the northbound lane. There were no known prior drivability problems, warning lamps, or other symptoms before the incident. The exact failed component is UNKNOWN. Potential areas requiring investigation include the engine, electrical system, ABS/HECU brake module, multi-fuse, fuel system, and other engine-compartment components. Alaska Department of Public Safety responded. Its report states that there was no obvious cause, but that the fire appeared to have originated in the engine compartment. The vehicle was towed and preserved for the manufacturer. Hyundai inspected the vehicle and confirmed that the inspection was completed on July 11, 2026. Hyundai later stated orally that it did not find an engine defect, but it has not provided the complete inspection report, testing methods, photographs, technical findings, or a written origin-and-cause determination. Hyundai has not explained whether the ABS/HECU, electrical system, multi-fuse, fuel system, or other potential fire sources were separately examined. The vehicle sustained catastrophic damage and was a total loss. Both occupants escaped, but experienced severe ongoing psychological distress after the fire. I request that NHTSA evaluate whether the fire involved an engine, electrical, ABS/HECU, fuel-system, recall-remedy, or other safety defect. The vehicle was available for Hyundai's inspection. Its current availability for further inspection is UNKNOWN. The vehicle remains preserved and is currently available for further inspection upon request.
NHTSA complaint #11753388 — an unverified report by a vehicle owner.
my BSD sensor would go on and off for the last several months when no one was around me. I work early and even when I was alone on the road the BSD would flash for 2-3 mins and go off.. then my fan for my air conditioner stopped. When I removed the glove compartment to see the wire connecting to the fan is "melted". When i called bob king hyundai, I was informed there was no recall. So, I attempted to fix the issue myself only to find the fuses (under the hood) are almost all bad. The tips of the fuses will not pull out. only the body of the fuse. With all this happening over the last several days and by the way, the vehicle passed inspection. I wanted to reach out as this is definitely a fire hazard and a huge concern.
NHTSA complaint #11753163 — an unverified report by a vehicle owner.
Odometer Fraud. The contact purchased a 2017 Hyundai Santa Fe Sport. The vehicle was a dealer sale. The contact stated that while attempting to trade the vehicle, the contact was informed by the dealer that the odometer had been rolled back prior to the purchase. The contact had purchased the vehicle in March 2022. A Carfax report indicated that the odometer was reported at approximately 75,585 miles on January 28th, 2022, and 55,710 miles on February 11, 2022, reflecting a 20,000 miles difference. The contact stated that the mileage at the time of purchase was unknown. The vehicle currently had approximately 132,064 miles. The issue was reported to the Pennsylvania State Police and the Pennsylvania Attorney General.
NHTSA complaint #11752626 — an unverified report by a vehicle owner.
*"I am filing a complaint against Hallmark Hyundai in [XXX] regarding an active safety recall on my vehicle's ABS (Anti-lock Braking System) module.My vehicle was brought to the dealership on XXX. As of today, XXX, the dealership has held my car for 27 days without completing the safety remedy. The dealership continues to give me conflicting stories, refuses to provide an expected repair date, and is denying me manufacturer-funded alternative transportation while my vehicle is grounded for this safety defect.I am reporting this because the dealership is failing to provide a timely remedy for a critical braking safety hazard, leaving me without a safe vehicle." The warning lights came on on XXX every light on my dash is flashing. Hallmark Hyundai inspected my vehicle and said it was the abs module I have been without transportation for a whole month with no answers on when my car will be ready for pick. The advisor Devita keep telling me lie after lie I need my car immediately no way it takes a whole month to fix a recall repair I need my car I have lost my job due to this I’ve missed important dr appointments do to my car being held for a month with no answers INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11751694 — an unverified report by a vehicle owner.
For a few months- the ABS light, Downhill assist light, and Slippery road light have all been on. Read it could be due to a bad sensor. Then on Saturday July 4th, I turned the car on and the Ebrake light was on but my ebrake was NOT initiated. Car was making a low humming noise on front passenger side of vehicle as well. I read the ebrake light could come on due to low brake fluid, so I wanted to drive it around the block to further try and diagnose the issue. My car then made a pop noise and started smoking from where the ABS pump is located and my tail lights all started flickering like Christmas lights. I instantly turned the car off and disconnected the battery to prevent an electrical fire. UPON researching- there is a recall for 2015 Santa Fe’s for this exact issue except mine isn’t on the list. I need to talk to someone who has seniority upon this situation because I have called Hyundai Customer service and my local dealership and nothing is being done or nobody cares to resolve this situation. My car is currently at a trusted local garage awaiting repair- I can not tow it back and forth between the garage and a dealership. I rely on my car for my children and work.. I can’t play around waiting for them to inspect it weeks from now. This is a serious issue as my children were also in the car. Everything is VERY similar to the recall on other 2015 Santa Fe’s..
NHTSA complaint #11749067 — an unverified report by a vehicle owner.
I am reporting a severe safety failure on my 2014 Hyundai Santa Fe Sport that perfectly matches the safety defect described in Recall 21V-303 / Campaign 205. This happened even though I had the dealer perform the official recall fuse fix back in 2024. The problem started after I left the car parked for about 3 to 4 hours. When I came back, I heard a motor (not the motor) loudly running under the hood even though the ignition was completely off. It stayed on even after starting and turning the car off. The battery in the vehicle had drained so bad it was deemed bad when hooked up to a tester at the auto parts store. After getting a new battery and trying to drive the car, the electrical system went haywire. The dashboard lit up with every brake warning light on, the speedometer stopped working, miles to empty being erratic, and the exterior rear brake lights kept flickering erratically after the car was turned off. The steering was acting abnormal and unnatural, not crisp and easy to turn as usual. There were absolutely no warning lights or symptoms before I parked the vehicle. I had it towed to my local Hyundai dealership, and their diagnostic scan confirmed major brake and chassis issues, specifically code C2402 for an ABS Pump Motor Circuit Malfunction and codes C1200, C1203, and C1206 for a loss of wheel speed data. The vehicle has not been inspected by police or insurance representatives, but it is currently sitting at the dealership waiting for a resolution from a Hyundai customer care case manager. The 2024 recall remedy only involved dropping the fuse amperage to mitigate fire intensity; it did not replace the module housing or prevent the internal brake fluid leak from eventually destroying the system. The defect has seemingly now fully manifested, knocking out primary braking indicators and power steering assist, presenting an ongoing safety and fire hazard while driving and parked.
NHTSA complaint #11749195 — an unverified report by a vehicle owner.
FHW Garage used car dealer [XXX], sold this Hyundai Santa fe 2015 knowing the vehicle is defective. It Stalls and stops in the middle of the road in High Traffic. This Hyundai Santa Fe 2015 Lock up the Steering Wheel, Lock up the breaks, Lock up the gas. it Stalls and stops without Warning then after it freeze and stop it flashes all of the Warning Lights on the dash board. FHW Garage is Falsely Advertising this vehicle in Excellent Condition. Its Advertised on Craigs List, and [XXX]. I was almost in a Serious Accident. [XXX] keeps getting his people in the workshop to Machanically Rig the Vehicle to run and drive until someone gets killed when this vehicle is in a terrible Accident. The Gas Cap dont screw on properly. Fhw Garage [XXX] sold me this Vehicle with full knowlege of the Mechanical Defects, and refuses to give my money back. I paid $5,400 Cash plus traded my car. The Hyundai Santa fe was $6,900. Deceptive Practices Fraud, and Title Jumping. FHW still have the two cars after I purchased them. I would like to see FHW Dealer License Suspended or Revoked. Give my money back and return my car. I will be filing a complaint Affidavit with the FLHSMV. [XXX] lied on the Bill of Sales how much I paid and he put $900 in his pocket. I will also file a complaint to FHW [XXX]. For defrauding me, Misrepresentation saying the Vehicle is in Excellent Condition when its Mechanically Defective, and Dangerous should not be on the road to kill someone. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11747002 — an unverified report by a vehicle owner.
Engine code p1326. The engine went into limp mode it was only able to drive about 15 miles then check engine light came popped on and the vehicle stopped and I had the get the vehicle towed. Yes Route 60 of Hyundai in Vero Beach was aware of the issue and also I took the vehicle to Hyundai in Fort pierce where they also was well aware of the engine issue. When I received a recall letter in the mail and brought my vehicle into Route 60 Hyundai of Vero Beach. My vehicle was also apart of the Theta 2 issue class act litigation.
NHTSA complaint #11738905 — an unverified report by a vehicle owner.
As I would be driving down the road, most of the time when getting up to speeds of either 25-30mph or 55-60mph is when the dash board lights up check BSD detection system failure, then it will rev out rpm’s to 5,000-6,000 then lose power to accelerator. I also notice on the dash board where the panel for your selected gear displays is blank and doesn’t show whether you are in park,drive neutral, ECT. After this occurs I can not drive it any longer until I safely stop the car (most of the time on a busy highway or country road Highway where once this happens it becomes dangerous due to the power loss in the accelerator) and put it in park, I’ve tried to put the vehicle in park, once fully stopped, and try to put it back into drive but the shifter is locked into park and will not let me shift the vehicle, I then have to shut the vehicle completely off and open the driver door to get the backup power cut off as-well to have zero power to the vehicle. Once that is completed I then Re-Start the vehicle where it operates normally again, this situation happens at least twice a week if not 3-4. It sometimes has put my passengers and myself at risk of getting into accidents or struck by other vehicle on the road. my vehicle is still under a warranty through the dealership I purchased it from, but when I ask them about it they say that because there is no prompt on the dash once I get there that they cannot do anything about it, nor do they allegedly know why it’s happening, I’ve asked a few other mechanics I know and they say that they have seen this malfunction before with this vehicle and usually it is a transmission sensor? Or a transmission speed sensor issue? I then relay this message back to the dealer ship and they still act like they don’t know what it is, I truly believe that the dealership just doesn’t want to deal with the issue and I only have 2-3000 miles left under their warranty, I do enjoy the vehicle and respect Hyundai for their great customer service.
NHTSA complaint #11738419 — an unverified report by a vehicle owner.
THIS IS AN UPDATE TO EXISTING NHTSA ODI COMPLAINT #11735718 2017 Hyundai Santa Fe Sport, TXXI Theta II engine defect. UPDATE: On May 7, 2026, Hyundai Case Manager acknowledged in writing "Your case is important to us" and "2.4L THETA concerns" for Case #42623761. This is written admission the vehicle has the TXXI defect covered by warranty extension to 120,000 miles. I gave Hyundai 48 hours to provide written authorization for oil consumption test per their TSB 22-EM-003H. After 3 days they are silent. They refuse email communication despite documented language barrier. Current Vehicle Status: - Active DTC P0010 causing loss of power and stalling risk - Oil Consumption: 1 liter per 600km, which is 3x Hyundai failure threshold in TSB 22-EM-003H - 95,772 miles, under TXXI 120,000 mile warranty limit - U.S. Spec vehicle covered by TXXI Warranty Extension Hyundai is violating Magnuson-Moss Warranty Act by refusing to honor written warranty for known safety defect. The P0010 defect causes sudden loss of power while driving. Requesting immediate NHTSA intervention to compel Hyundai to perform warranty repair.
NHTSA complaint #11736898 — an unverified report by a vehicle owner.
The passenger-side doors do not latch properly and may open after closing. This creates a safety risk while driving. The issue occurs continually and has worsened over time. Vehicle has approximately 106,265 miles. this causes the auto door locks no to work.
NHTSA complaint #11728573 — an unverified report by a vehicle owner.
I was driving on March 20, 2026 at about 12:00 PM when I suddenly noticed smoke, a strong gasoline smell, an oil smell, and a burning odor coming from the vehicle. I pulled over immediately because I believed the vehicle was unsafe and at risk of fire. The vehicle had to be towed. An independent repair shop later found a fuel leak at the high-pressure fuel line / fuel pump area, a loose ground wire on the right-hand side of the engine, a valve cover gasket leak, and engine timing chain noise. I was informed that gasoline had sprayed throughout the engine bay. This created an immediate fire hazard even though no actual fire occurred. This problem was especially concerning because the vehicle had been inspected and serviced by an authorized Hyundai dealer in December 2025, less than about 3,000 miles earlier. The loose engine ground wire and fuel leak raise serious concerns about vehicle safety and the adequacy of the prior inspection. I contacted Hyundai the same day and reported this as a fire-risk safety issue, but I did not receive timely assistance. Because immediate dealer service was not available, I had to authorize emergency repairs at a local shop for safety reasons. No warning lights were noted before the incident. The failure was confirmed by the repair shop.
NHTSA complaint #11726301 — an unverified report by a vehicle owner.
I turned off the car and went inside the house. I was outside and could smell smoke. I walked to the front of the house and saw my neighbor who was calling 911 due to flames from my engine. The flames reached the yard and my garage where minor damage occurred. The vehicle was completely engulfed in flames before the fire department extinguished it.
NHTSA complaint #11716330 — an unverified report by a vehicle owner.
My starter failed while out shopping. No issues starting the car departing from my home, but would not start in the store parking lot. My mechanic did not provide the broken part for inspection however everyone commented that is was very unusual for it to fail as I only have roughly 25,000 miles on it. My mechanic also mentioned that this was 2nd 2018 hyundai sante fe in the past week he had to replace the starter on that vehicle had 60,000 miles. There were no warning lights prior to the event, I suspected it was the starter after having a new battery installed and no success starting because of the lights that remained on on the instrument panel.
NHTSA complaint #11715566 — an unverified report by a vehicle owner.
The contact owns a 2018 Hyundai Santa Fe Sport. The contact stated that the headlights suddenly illuminated without the vehicle being turned on, causing the battery to be drained. The contact recharged the battery to start the vehicle. The contact stated that the light switch failed to turn off the high beam headlights; however, the headlights and the indicators were no longer illuminated. The vehicle was towed to the dealer, who stated that the junction block had failed and needed to be replaced; however, the contact was not sure of the cause of the failure and needed to repair the vehicle. The dealer diagnosed the vehicle that an interlock casing, fuse, and relay that had melted, and that the switches were not responding, but could not confirm what caused the failure. The contact learned that the vehicle was previously included in a recall for another junction box that had been repaired. The contact was unable to provide the recall campaign. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was approximately 18,000.
NHTSA complaint #11710589 — an unverified report by a vehicle owner.