86 of the
1,559 complaints filed about the Hyundai Santa FE Sport
are about the fuel system —
6% of everything owners reported.
The worst model year for it is 2018.
On February 24, 2026, I had the 9C2 software update. My vehicle was being checked for oil consumption. Since then I have had issues with it hard shifting when first starting to drive and sometimes after I've been driving a while. This has continued miles down the road, sometimes over thirty minutes after driving. It also just feels continuously like it is not driving smooth. This only started after the update. I contacted HMA. The first person on my case (Gurvinder) told me I needed to return my car, not to drive it. I had bronchitis, so I did not immediately do that. The next person "Rainey" told me it is a KNOWN issue and they are telling people to warm their cars up for around 3 minutes, and it will be fine. I'd done that, and even driven longer than that. I told him that. I took my mother-in-law home from church miles from there after collecting her at the church door, etc... Getting to the hill at to her home, I didn't think it was going to get up it. Often I don't think I'm going to get out of my driveway, a dangerous driveway in a curve. He wanted Krause Hyundai to contact HMA Engineer. When I was at Krause, they didn't know how to get ahold of HMA Engineer. Dalton also said they can't back the update out. I'm on my third HMA Case Manager. She keeps changing what I've told her is wrong in the emails, I don't think she knows anything about cars. She won't listen when I say I spoke to Dalton at Krause; she keeps speaking to John. [XXX] said they can do diagnostic, but it will cost me. I refuse to pay as [XXX] and Gurvinder had months before wanted me to take it back to get fixed, and Rainey wanted Krause to contact the engineer. It is a known issue with a letter written by Hyundai. Getting a diagnostic code reading performed is not going to help. I'm afraid my vehicle will lose power on the road and I will be struck. I tried uploading both pdf and jpg, but it wouldn't let me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11754336 — an unverified report by a vehicle owner.
We have a 2017 Hyundai Santa Fe Sport with a refurbished engine due to a past class act settlement, we were notified by Hyundai to bring in the vehicle for Service campaign 9C2 to update the Engine Control Module (ECM) Software for vehicles equipped with the (2.4 GDI) Theta II refurbished engine, which we have. The morning after we updated the 9C2 software, after starting our car cold for the first time in the am, our car went into limp mode, shaking very badly, it would not accelerate above 20 MPH, it had a lot of trouble shifting from 1st to 3rd gear and acted like it was going to stall out and then die in the middle of the road while I was in the car with my 2 children. The dealership we took it to was not able to duplicate the limp mode, but has documented that they did witness hesitation and sluggishness while test driving it. I cannot validate that it was test driven cold immediately as requested as all their test drives were done without me. Due to the vehicle not accelerating as it should normally, I feel the vehicle is very unsafe and unreliable as well. I’m willing to provide more documentation, and our car is available for further inspection. I did request the help of a Hyundai customer relations case manager who stated Hyundai is aware of all of the drive-ability issues I have stated and he said they are hoping to provide another software update, but that time frame is unknown. Dealership mechanic stated the same thing and believes our issue is related to the 9C2 update. The manufacture has not inspected the vehicle, but we would absolutely love them to if they would. There have been no check engine lights come on before or after this update, only misfire codes came up after the update which dealership has those, and since the dealership was unable to witness it going into limp mode while driving it, they could not gain the much needed data that pinpoints the exact problem. We were advised to warm up car and rev up the RPM to above 2,000 before driving.
NHTSA complaint #11752266 — an unverified report by a vehicle owner.
After a recall repair (Campaign 9C2) was performed on my vehicle, it developed a hesitation and lack of acceleration issue that did not exist before the repair. The vehicle exhibits rough or delayed gear shifting, a noticeable lack of power/acceleration, and behavior that feels like the engine is not receiving adequate fuel. This occurs both during cold start and after the vehicle has been driven and is fully warm. I returned the vehicle to the dealership (Wallace Hyundai), where the service advisor personally test drove the car with me and confirmed he could feel the hesitation firsthand. Despite this, the dealership stated no issue was found and advised warming the car up for 1-3 minutes before driving as a workaround. I tested this exact recommendation, and the issue returned even after the vehicle was fully warmed and had already been driven. Hyundai Motor America's National Consumer Affairs department has stated this is "under review" but has also described the hesitation as "normal" cold-start behavior related to catalyst warm-up. This does not match what I am experiencing, since the issue also occurs when the vehicle is already warm, and their own dealership's advisor confirmed the problem exists. I have also noticed a decrease in fuel efficiency (MPG) since the software update associated with this recall. This issue directly affects the safe operation of the vehicle — specifically the ability to accelerate reliably, including in situations like merging onto highways or pulling into traffic, where a lack of power could result in a collision. I do not consider the vehicle safe to drive in its current condition.
NHTSA complaint #11749084 — an unverified report by a vehicle owner.
After the ECM recall for a software update the car would not run correctly. It jerks and and runs rough. It almost stalls when you put your foot on the gas. I took it back to the dealer and they can not get the problem to duplicate. Noone else has looked at the problem. There were never any problems with the care until the recall. The problem occurred the day I brought the car home from the ECM update.
NHTSA complaint #11740806 — an unverified report by a vehicle owner.
After my Hyundai dealership performed a recall on emissions my Santa Fe Sport started having problems on cold starts. After it has set for a few hours when I would put into gear and start to driving the car acted as though it was trying to flood out. I have to feather the accelerator and drive very carefully for at least 1/2 - 3/4 miles. This is very dangerous and make me very uncomfortable driving. I took my vehicle back to my Hyundai dealer and the mechanic told me they were waiting for a recall to the recall. How stupid!!! It has been over a month and nothing has been done to fix the problem. Please advise!
NHTSA complaint #11740351 — an unverified report by a vehicle owner.
2018 Hyundai Santa Fe Sport. Purchased January 2026 took to Oxmoor Hyundai Service Center March 2026. February 2026 began using oil at a measured rate of 700 miles per tank of oil. Used 3 full tanks of oil within the month of February. Oil lights and engine lights on and off and flashing during this time. March 8, 2026, engine light flashed and then stayed on continuously. Engine shook and stuttered and made a loud noise. Engine stalled while I was driving at 35-40 miles per hour. I was able to continue driving to my home with the stuttering and stalling. The next morning I drove it to the Oxmoor Hyundai Service Center. I told relayed the timeline of all symptoms I had experienced over the 2 month lifetime of my ownership. They did not attempt to reproduce the issue. They only entered "shakes in reverse" as the customer provided issue on the intake information. Service Center performed diagnostic, found cylinder misfires on cylinder 2 and cylinder 4. Replaced spark plugs to resolve Cylinder 2. Cylinder 4 continued to misfire. Used Borescope and found broken valve. They did not address the scoring on the cylinder of the valve. Recommended engine replacement. Advised it would not be covered under a warranty because the rod did not break. The oil consumption was proven with documentation from multiple Valvoline visits and the vertical scoring was present on the cylinder with the broken valve in the borescope photo. The Service Center refused to do a Boring Clearance Test or any other test that would prove the engine should be covered under an extended warranty or class action settlement. It wasn't until I reviewed HMA documents uploaded to the BBB Arbitration, that I realized that the information I initially gave to the Service Center of all the symptoms with timelines had not been entered into the system for diagnostic review by Techline. Arbitrator denied my claim under the theta settlement because the rod had not broken yet, BUT she said my engine was defective.
NHTSA complaint #11739906 — an unverified report by a vehicle owner.
NO power till car warms up for 5 minutes. It will be jerky on highway. The gas mileage is going down drastically, I was doing 32 miles to gallon and now it's 22mpg. All this is after the recall we just had performed. I have no power trying to avoid accidents, taking off from stopping. Car smells weird now.
NHTSA complaint #11739585 — an unverified report by a vehicle owner.
TOOK CAR TO DEALER TO HAVE OIL CHANGED ON APRIL 29, 2026 AND WAS TOLD THEY HAD ALSO PREFORMED A SOFTWARE UPDATE, SERVICE CAMPAIGN 9C2. EVERYTIME SINCE THAT DAY AFTER THE CAR HAS SET FOR A LITTLE WHILE AND THE CAR IS RESTARTED DRIVEN IT STALLS AND SURGES REALLY BAD SEVERAL TIMES LASTING FOR SEVERAL MINUTES. IT ALSO CAN DO THIS AT RANDOM AT ANYTIME BUT NOT CONSTANT LIKE IT DOES WHEN FIRST STARTED. THIS IS VERY DANGEREST FOR OBVIOUS RASONS AND NEEDS TO BE FIXED. ALTHOUGH THERE IS OTHERS REPORTING THE SAME PROBLEMS ON LINE AND A PERSON MAKING THE SAME COMPLAINT WHILE I WAS WATING AT THE DEALERSHIP. THEY SAY "THEY ARE UNAWARE OF THE PROBLEM AND I WILL HAVE TO LEAVE MY CAR FOR UP TO THREE DAYS OR MORE TO HAVE IT CHECKED OUT AND THEN THEY WILL LET ME KNOW WHAT NEEDS TO BE DONE” AND WHAT THE COST WILL BE. I ONLY HAVE THE ONE VEHICLE AND THEY WOULD NOT PROVIDE A LOANER VEHICLE SO NEEDING MY CAR EVERY DAY I CAN NOT DO WITHOUT IT. DUE TO THE FACT THAT HYUNDAI REFUSES TO ACKNOWLAGE THE PROBLEM. THERE REALLY NEEDS TO BE A RECALL TO HAVE THIS PROBLEM FIXED.
NHTSA complaint #11737802 — an unverified report by a vehicle owner.
My 2018 Hyundai Santa Fe Sport equipped with a Theta II GDI engine began exhibiting excessive oil consumption, engine knocking, and cylinder misfires consistent with the known Theta II engine defect covered under the Hyundai class action settlement. Prior to the failure, the check engine light illuminated and I experienced repeated misfires and audible engine knocking. The vehicle required frequent oil additions between oil changes due to excessive consumption. The vehicle was taken to an authorized Hyundai dealership where a diagnosis confirmed a burnt valve inside the cylinder head. The dealership recommends replacement of the cylinder head or complete engine replacement to correct the issue. The dealership performed a bearing failure test and attributed the burnt valve to carbon buildup. However, excessive oil consumption in a GDI engine directly accelerates carbon buildup on intake valves, as burning oil deposits carbon on valve surfaces preventing proper seating and causing overheating and valve failure. The carbon buildup is therefore a consequential result of the Theta II oil consumption defect, not an independent cause. The safety risk is significant as engine misfires and knocking while driving create unpredictable loss of power and potential for stalling in traffic. The vehicle is currently not reliably operable. The manufacturer has been contacted regarding coverage under the Theta II settlement. The component is available for inspection upon request at the servicing dealership
NHTSA complaint #11729615 — an unverified report by a vehicle owner.
I bought a 2018 Hyundai Santa Fe from a dealership in May of 2023. Ever since then I have paid around $8,000 in repairs for this car. These repairs have been so expensive and time consuming that last year I wasn’t able to drive it for 6 months because it was in the shop for most of the year. I had to fix the Fuel pump, the Battery, timing chain valve TWICE, O2 sensor , Catalytic Converter, Engine valve, cylinder 1 & 3 and NOW I have to fix cylinder 2 & 4 & that cost again around $2,000 to fix. I am constantly stressed out, crying and becoming broke because I have to keep on repairing this car. I use up all of my tows every year because my car always shuts off on me while I am driving. I am at the point where I want a refund on the car and I want to get rid of this vehicle. I do not feel safe driving on the highway or driving with my two kids and I am currently pregnant again and this car isn’t safe for a family. I am constantly feeling broken down and worthless because I can’t even keep this car a float.
NHTSA complaint #11727837 — an unverified report by a vehicle owner.
I was driving on March 20, 2026 at about 12:00 PM when I suddenly noticed smoke, a strong gasoline smell, an oil smell, and a burning odor coming from the vehicle. I pulled over immediately because I believed the vehicle was unsafe and at risk of fire. The vehicle had to be towed. An independent repair shop later found a fuel leak at the high-pressure fuel line / fuel pump area, a loose ground wire on the right-hand side of the engine, a valve cover gasket leak, and engine timing chain noise. I was informed that gasoline had sprayed throughout the engine bay. This created an immediate fire hazard even though no actual fire occurred. This problem was especially concerning because the vehicle had been inspected and serviced by an authorized Hyundai dealer in December 2025, less than about 3,000 miles earlier. The loose engine ground wire and fuel leak raise serious concerns about vehicle safety and the adequacy of the prior inspection. I contacted Hyundai the same day and reported this as a fire-risk safety issue, but I did not receive timely assistance. Because immediate dealer service was not available, I had to authorize emergency repairs at a local shop for safety reasons. No warning lights were noted before the incident. The failure was confirmed by the repair shop.
NHTSA complaint #11726301 — an unverified report by a vehicle owner.
While driving the vehicle at approximately at 55 MPH on a the 826, the engine suffered a sudden and catastrophic mechanical failure without warning. The vehicle lost all motive power in active traffic, creating an immediate safety hazard and nearly resulting in a rear-end collision. Upon inspection, it was determined that the engine assembly, which is a replacement unit provided by Hyundai under the Theta II Settlement, with less than 12,000 miles, suffered an internal breach. This breach allowed coolant to contaminate the lubrication system sort of a milky oil, which led to a connecting rod bearing seizure. Despite this being a repeat failure of a safety-recall component and the vehicle being covered under the Theta II Settlement Lifetime Warranty, Hyundai Motor America has denied the repair claim. I am reporting this as a safety defect because the sudden engine stall resulted in a loss of power-assisted steering and braking while the vehicle was in motion.
NHTSA complaint #11726371 — an unverified report by a vehicle owner.
Enterprise car sales sold me this vehicle when it had 3 open recalls on it. The vehicle itself was a problem from the beginning. When I took it in for it's first oil change the mechanic told me it had no oil in it. He said they sold me a car that is notorious for consuming oil and or seizing or blowing up. I had the engine replaced on this car already and I just took it in for it's first oil change and it was already consuming oil. I want a new car but enterprise is telling me this is my problem
NHTSA complaint #11726332 — an unverified report by a vehicle owner.
Circuit board inside the fuse box stopped working and there was no speed indicator, no cruise control, no odometer registering while driving. Also the mechanical fuel pump started leaking fuel at 148,000 miles and now at 156,000 miles it is burning through oil and no oil light came on and the engine went into limp mode and is also now going through coolant too.
NHTSA complaint #11725066 — an unverified report by a vehicle owner.
While traveling at approximately 80 mph on the highway, my vehicle suddenly lost all response to the accelerator pedal. Despite continued pressure on the gas, the vehicle rapidly decelerated to approximately 40 mph on its own. There were no warning lights, unusual noises, or physical indicators of a problem before, during, or after the event. I was able to safely navigate the vehicle off the highway. The vehicle appeared to operate normally afterward. The following day, I brought the vehicle to a mechanic who was unable to replicate the issue and found no stored fault codes. No repairs were made. Given the known concerns surrounding the Theta II engine in this model year, I am submitting this incident for documentation purposes and to contribute to any ongoing or future investigation into sudden acceleration loss in 2013 Hyundai Santa Fe vehicles.
NHTSA complaint #11724727 — an unverified report by a vehicle owner.
The contact owns a 2016 Hyundai Santa Fe Sport. The contact stated that while the vehicle was parked and running, there was an abnormal fuel odor inside the vehicle. The contact exited the vehicle and inspected it. The hood was opened, and the engine cover was removed, and there was condensation dripping from the fuel pump. The contact’s brother inspected the vehicle and became aware of the strong fuel odor and the condensation dripping from the high-pressure fuel pump. The vehicle was then taken to a dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11723852 — an unverified report by a vehicle owner.
Component: Engine (Theta II 2.4L GDI) / connecting rod bearing-related failure risk with abnormal internal oil loss. The vehicle is available for inspection upon request (engine, oil level condition, diagnostic history, and dealer records). Safety risk: While driving on the highway (approx. 70 mph), the vehicle displayed a low oil warning, and I experienced concern for potential engine seizure/stalling and sudden loss of power, which could cause a crash. I reduced speed and sought service. This condition presents an ongoing safety risk because sudden engine failure can occur without adequate warning. Dealer confirmation: The problem was confirmed by a Hyundai dealer. After a routine oil change, the low oil warning appeared within ~1,700 miles. A Hyundai service center inspected the vehicle and documented the engine was approximately 3 quarts low with no external leaks, indicating internal loss/engine deterioration rather than a leak. Hyundai then required additional steps (combustion chamber cleaning and monitored mileage), and the abnormal internal oil loss condition persisted. Manufacturer inspection: The vehicle has been inspected by Hyundai dealerships, and Hyundai performed campaign-related actions, including KSDS/ECM update (T3G) and later knock sensor replacement. No police or insurance inspection. No crash or injury occurred. Warning lamps/symptoms prior to failure: Prior symptoms included a Check Engine Lamp with DTC P1326 (KSDS-related) documented by Hyundai service in 2025, followed by continued abnormal internal engine condition. The low oil warning occurred while the vehicle was in motion (highway speed). The issue remains unresolved, and I do not feel the vehicle is safe to operate due to seizure/stall risk. Additional: I reported this as a safety defect because similar Theta II engine issues are widely reported and can result in stalling, seizure, or engine fire. Hyundai denied engine replacement assistance despite the documented condition.
NHTSA complaint #11708993 — an unverified report by a vehicle owner.
This engine is burning oil. Its mixing oil with gasoline in the cylinders. Its fouling spark plugs and consuming large amounts of oil with absolutely no visible oil leaks. The exhaust is black. PCV valve is clean. Engine is misfiring due to spark plug fouling. New spark plugs and coils. Multiple dealers have stated this is a KNOWN defect with this particular GDI engine but Hyundai refuses to issue a recall.
NHTSA complaint #11697278 — an unverified report by a vehicle owner.