2009 Jeep Wrangler fuel system problems

FUEL/PROPULSION SYSTEM

When filling my tank, it spits gas back out of the nozzle. I’ve been told in several forums that this is a warranty issue and is to be replaced by a dealership for free. The item that needs to be repaired is a fuel filler tube. I don’t wanna spend the money on buying the part myself if this is something that is covered by the dealership through the factory. This happens every time I fill the tank and has been an ongoing problem for over a year almost 2 years. I have to fill it very slowly with gas as well. I cannot fill it fast as it will stop automatically. The part number is 52060489AH

NHTSA complaint #11632876 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Fuel overflow problem. It happens every time I fill up the gas tank.

NHTSA complaint #11514305 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Every time I fill the fuel tank it will overflow quite profusely. Not just a trickle, but more like a quart or more. Not only is this manufactured defect a COSTLY inconvenience, BUT A POSSIBLY DANGEROUS SITUATION. Not to mention stinking like gasoline when I arrive at my destination, which was Sunday church service the last time. Research has shown me there has been recalls for this issue on jeeps very near my vehicle's "birthday". I grew up pumping gas for my parents at the station, but now I have to be sure there is a "splash zone" of at least 5 feet of distance from the filler so innocent bystanders don't get splattered. I have been verbally attacked numerous times at the pump because of this manufacturer defect. Now I know perfection can be unattainable, lots of quirky parts in vehicles today, but i can honestly say this situation alone is keeping me from being an advocate of what i once thought was a great buy. I have replaced the steering damper that created the now legendary death wobble, and personally dealt with evap system part failures. Repairing those issues myself doesn't bother me, but the fuel tank is another story. This is something that should absolutely be addressed. If Im required by the government to pass an e-check so minimal fumes don't enter the atmosphere, then this needs to be replaced/corrected IMMEDIATELY because all these jeeps are dumping fuel on the ground all over the world! Also Ive learned about a mopar replacement filler tube with a check valve built in. I feel this issue should be recognized as a recall, or exposed for the environmental hypocrisy it creates.

NHTSA complaint #11492255 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN FILLING MY 2009 JEEP WRANGLER WITH GAS, THE FUEL OVERFLOWS - OFTEN SO MUCH THAT IT SPILLS ONTO THE GROUND. NO MATTER HOW SLOWLY OR CAUTIOUSLY I PUMP THE FUEL, IT STILL OVERFLOWS. THIS HAS HAPPENED ON MULTIPLE OCCASIONS. IT IS MY OPINION THAT THERE IS A MALFUNCTION IN THE VEHICLE. I HAVE RESEARCHED THE MATTER AND FOUND THAT APPARENTLY I AM NOT THE ONLY ONE HAVING THIS ISSUE. I ASK THAT THIS BE DEEMED A RECALL - AND THAT THE COMPANY PAYS TO FIX IT. THIS MALFUNCTION COULD CAUSE A FIRE AND OTHER ISSUES RELATED TO GASOLINE EXPOSURE.

NHTSA complaint #11466605 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Any time you fuel this vehicle the fuel gushes out of the filler neck. We have tried several different fueling stations . Different times of the day and night. Nothing changes , the fuel still blows out. Sometimes even if you pump slow it will still spew back out. Not every station has the rubber splash guards on their nozzles. The reason this is a danger is very obvious. Gasoline has a low flash point , not to mention the health risk of the vapors. One freak spark unrelated to me fueling could have deadly consequences. I spoke to jeep headquarters about this issue. They refused to give me the lot number for the faulty fuel tanks. The fuel tanks that had issues was on 2008 and earlier jeep Wranglers. Our jeep was manufactured in 2/2009 and from what I have gathered uses the exact same tank as the 2008 and earlier tanks back to a certain year. Is it to far fetched to believe that the tank installed could be faulty , just like the earlier ones. Just so we are clear this has been occuring since we purchased the jeep and continues to. I would like jeep to replace the tank or the valve in the tank. They could install the retro fit repair . I don't feel as an owner we should have the Burden of replacing the tank.

NHTSA complaint #11426341 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

THERE IS NO SAFETY STOP ON THE FUEL LINE. EVERY TIME THE TANK IS FILLED IT OVERFLOWS SPILLING GAS EVERYWHERE. THIS IS NOT NEW, BUT FINALLY REPORTING IT. THERE ARE TONS OF PEOPLE COMPLAINING ABOUT THIS ON THE INTERNET

NHTSA complaint #11404288 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHILE FUELING THE PUMP WILL AUTOMATICALLY CLICK OFF, BUT FUEL WILL SPILL OUT ONTO THE VEHICLE, MYSELF, AND THE GROUND, HUGE SAFETY AND ENVIRONMENTAL CONCERN.

NHTSA complaint #11360587 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

CRACKED FUEL TANK, FOUND THROUGH A SMOKE TEST

NHTSA complaint #11344131 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN GASSING UP AND THE TANK IS FULL, FUEL FREQUENTLY SQUIRTS OUT AND RUNS DOWN THE SIDE OF MY VEHICLE ONTO THE GROUND. SEVERAL TIMES IT HAS SPLASHED ON MY CLOTHES, SHOES, AND SKIN. THIS IS A SAFETY HAZARD. THIS STARTED IN ABOUT 2011 AND HAS CONTINUED OFF AND ON SINCE. IT IS MORE PREVALENT IN COLD WEATHER.

NHTSA complaint #11288741 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2009 JEEP WRANGLER. WHILE FUELING THE VEHICLE, FUEL SPILLED ONTO THE GROUND. THE VEHICLE WAS TAKEN TO WALKER CHRYSLER DODGE JEEP AND RAM (5757 COLISEUM BOULEVARD, ALEXANDRIA, LA 71301, (318) 618-0103) WHERE IT WAS DIAGNOSED THAT THE FUEL FILLER NECK AND FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE 2007 AND 2008 JEEP WRANGLERS RECEIVED THE MANUFACTURER WARRANTED REPLACEMENT FOR THE FUEL NECK AND THE FUEL TANK; HOWEVER, THE 2009 WRANGLER WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000.

NHTSA complaint #11242678 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

FUEL RUNS OUT WHEN FILLING UP JEEP AT THE GAS PUMP HAPPENS EVERY TIME I FILL UP

NHTSA complaint #11217766 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN FILLING MY JEEP WRANGLER JK 2009 GAS TANK IT OVER FILLS WHEN PUMP SHUTS OFF THE SPILLING GAS ALL OVER MY 2009 JEEP WRANGLER JK AND GROUND.

NHTSA complaint #11202702 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

GAS TANK SKID PLA RUSTED THROUGH. GAS TANK READY TO FALL OFF 2009 JEEP. 88K MILES AND PARKED IN GARAGE. PIECES MISSING AND CRACKED LENGTHWISE AND WIDTHWISE

NHTSA complaint #11132789 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN REFUELING THE PUMP ALWAYS STOPS EVEN IF EMPTY, THIS MAKES IT VERY HARD TO KNOW IF IT'S ALREADY FULL OR IF IT'S JUST ACTING UP. THIS HAS BEEN HAPPENING FOR A COUPLE YEARS NOW, AND IT HAPPENS 100% OF THE TIMES I REFUEL. I HAVE READ IN FORUMS THIS IS A VERY COMMON ISSUE AND SOME YEARS HAVE BEEN FIXED. THIS IS A POTENTIAL FIRE HAZARD SINCE FUEL SPILLS ARE VERY COMMON WITH THIS PROBLEM.

NHTSA complaint #11083574 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN USING A GAS PUMP TO AUTO-FILL THE TANK, THE PUMP SHUTS OFF AND THE TANK OVERFLOWS SOME OF THE FUEL ONTO THE PAINT ON THE OUTSIDE OF THE 2009 JEEP WRANGLER. DOESN'T MATTER WHAT GAS STATION I GO TO, THE STYLE OF NOZZLE, OR THE ANGLE THE NOZZLE IS USED AT. IT OVER FILLS EVERY TIME. THIS JEEP WRANGLER X WAS RECENTLY PURCHASED IN NOVEMBER 2017 WITH 90, 961 MILES. STARTED EARLY NOVEMBER. I RECENTLY SOLD MY 1997 JEEP WRANGLER WHICH I HAD DRIVEN OVER 178,523 MILES IN THE 18 YEARS OF OWNERSHIP NEVER EXPERIENCED THIS PROBLEM NOT EVEN ONCE. INITIALLY I THOUGHT IT WAS OPERATOR ERROR UNTIL I READ THE COMPLIANTS ON THE INTERNET FROM OTHER JEEP OWNERS AND THE NHTSA WEBSITE.

NHTSA complaint #11073893 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

CONSTANT OVERFLOW WHILE FUELING (~80% OF TIME). I DO NOT USE ANYTHING BUT REG GRADE FUEL. I DO NOT HOLD THE FUELING HOSE. IT DOES NOT MATTER IF I PUT THE HOSE IN ALL THE WAY OR SLIGHTLY OUT. IT TYPICALLY OVERFLOWS ABOUT 1/2 TO 1 PINT CREATING A FIRE HAZARD AND AN ENVIRONMENTAL ISSUE

NHTSA complaint #11072161 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHENEVER I FILL MY TANK UP, THE GAS SPILLS OVER ONTO THE CAR, THE GROUND, AND MYSELF. ABOUT A QUART SPILLS OVER SO COULD BE POTENTIALLY VERY DANGEROUS.

NHTSA complaint #11056344 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

EACH TIME I FILL MY JEEP WITH GAS THERE IS A GUSHING OF GAS AT THE END OF FILL UP. EACH TIME I FILL IT UP THE JEEP DOESNT WANT TO TAKE THE GAS EITHER. IT WAS WHEN THE VEHICLE IS STATIONARY AT A GAS STATION.

NHTSA complaint #11052297 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN FILLING TANK, FUEL OVERFLOWS EVERY TIME. HAVE TRIED TO DECREASE FLOW TOWARDS THE END, BUT NOTHING SEEMS TO WORK. SEEMS LIKE A HUGE SAFETY ISSUE WITH FUEL SPILLING ON EVERY FILL UP.

NHTSA complaint #10995554 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

SAME ISSUE AS WITH 2007-2008 JEEP JK FUEL SPITS OUT WHEN DONE FUELING, NO CHANGES TO FUEL SYSTEM SO WHY ONLY HAVE A RECALL ON 07-08 AND NOT ALL JEEP JK?

NHTSA complaint #10978609 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2009 JEEP WRANGLER. WHILE FUELING THE VEHICLE, THE CONTACT NOTICED FUEL SPRAYING OUT OF THE OPENING INTO THE FUEL PUMP. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL TANK FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 128,000.

NHTSA complaint #10968149 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN FILLING THE GAS TANK, FUEL SHOOTS OUT OF THE FILLER OPENING WHEN THE TANK IS FULL AND GOES ON THE VEHICLE AND ON THE GROUND.

NHTSA complaint #10958804 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2009 JEEP WRANGLER. WHILE REFUELING THE VEHICLE, IT EXPERIENCED AN OVERFLOW OF FUEL. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL TUBE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 131,000. UPDATED 03/07/17*LJ

NHTSA complaint #10944394 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

FUEL OVERFLOWS WHEN FILLING UP VEHICLE.

NHTSA complaint #10854309 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

FUEL SPITS BACK WHEN FUELING. THIS HAPPENS EVERYTHING WE FUEL UP AND IS CREATING A DANGEROUS SITUATION. THE LOCAL JEEP DEALER TELLS ME THERE WAS AN EXTENDED WARRANTY OFFERED FOR 2007 AND 2008 JEEP WRANGLERS BUT MY 2009 WAS NOT INCLUDED IN THE EXTENDED WARRANTY.

NHTSA complaint #10852538 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

ALMOST EVERY TIME I FILL UP MY JEEP AND USE THE AUTOMATIC SHUT-OFF ON THE PUMP, IT WILL SHUT OFF AND THEN PUKE SOME GAS OUT THE FILLER HOLE AND DOWN THE SIDE OF THE JEEP. JEEP WON'T COVER IT BECAUSE IT WASNT A 2007 OR 2008 MY WITH SAME KNOWN ISSUE.

NHTSA complaint #10838634 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN FILLING UP GAS TAKE, IT DOES NOT STOP AUTOMATICALLY WHEN FULL LIKE IT USED TO. GAS OVERFLOWS OUT OF FILLER TUBE DOWN THE SIDE OF THE 2009 JEEP WRANGLER. ISSUE DID NOT START UNTIL VEHICLE HAD 65K MILES ON IT.

NHTSA complaint #10694970 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

GAS TANK OVER FLOWS EVERYTIME I FILL GAS TANK, GOES ALL OVER THE SIDE OF THE CAR, ALL OVER THE GROUND AND GETS ON ME . IT'S DANGEROUS, WASTEFUL AND IS DAMAGING THE FINISH ON THE OUTSIDE OF VEHICLE. MFG SAYS IT'S NOT COVERED UNDER ANY RECALLS. NOTE: HAPPENS REGARDLESS OF WHICH GAS STATION , WHICH SETTING ON THE PUMP HANDLE OR HOW FAR THE GAS NOZZLE IS INSERTED INTO FILLER TUBE. INTERNET SEARCH SHOWS OTHER YEARS HAVE BEEN RECALLED FOR CONDITION.

NHTSA complaint #10679644 — an unverified report by a vehicle owner.